NISSAN PATHFINDER 2004 R50 / 2.G Owners Manual

ment, toll-free, at 1-800-NISSAN-1
(1-800-647-7261). In Hawaii call
(808) 836-0888.
Due to legal requirements in some states/
areas, your vehicle may be required to be in what
is called the ready condition for an
Inspection/Maintenance (I/M) test of the emis-
sion control system.
The vehicle is set to the ready condition when it
is driven through certain driving patterns. Usu-
ally, the ready condition can be obtained by
ordinary usage of the vehicle.
If a powertrain system component is repaired or
the battery is disconnected, the vehicle may be
reset to a not ready condition. Before taking the
I/M test, drive the vehicle through the following
pattern to set the vehicle to the ready condition.
If you cannot or do not want to perform the
driving pattern, a NISSAN dealer can conduct it
for you.
WARNING
Always drive the vehicle in a safe and
prudent manner according to traffic
conditions, and obey all traffic laws.
1. Start the engine. Allow the engine to idle until
the engine coolant temperature gauge needle
points between the C and H (normal operat-
ing temperature).2. Accelerate the vehicle to 55 MPH (88 km/h),
then quickly release the accelerator pedal
completely and keep it released for at least 6
seconds.
3. Quickly depress the accelerator pedal for a
moment, then drive the vehicle at a speed of
53 to 60 MPH (86 to 96 km/h) for at least 5
minutes.
4. Stop the vehicle. Leave the engine running.
5. Accelerate the vehicle to 35 MPH (55 km/h)
and maintain the speed for 20 seconds.
6. Repeat steps 4 and 5 at least 3 times.
7. Accelerate the vehicle to 55 MPH (88 km/h)
and maintain the speed for at least 3 minutes.
8. Stop the vehicle. Place the transmission gear
shift lever in the “P” or “N” position.
9. Turn the engine off.
10.Repeat steps 1 through 8 at least one more
time.
If step 1 through 7 is interrupted, repeat the
preceding step. Any safe driving mode is ac-
ceptable between steps. Do not stop the engine
until step 7 is completed.READINESS FOR INSPECTION/
MAINTENANCE (I/M) TEST (US
only)
Technical and consumer information
9-25


04.3.9/R50-D/V5


Dynamometer testing for Inspection/
Maintenance (I/M) test (US only)Due to legal requirements in some states/areas,
your vehicle may be tested for emissions on a
dynamometer. The transfer control lever (if so
equipped) MUST be in the 2H position for I/M
testing on a two wheel dynamometer.
WARNING

If the transfer control lever is not in
the 2H position during the dynamom-
eter I/M testing, the vehicle could
come off the dynamometer and
cause serious personal injury and/or
body damage to the vehicle.

Serious damage will occur to the
4WD system if the transfer control
lever is not in the 2H position.Your vehicle is equipped with a variety of com-
puters that monitor and control a number of
systems to optimize performance and help ser-
vice technicians with diagnosis and repair. De-
pending on the equipment on your vehicle, some
of the computers monitor emission control sys-
tems, braking systems and air bag systems, just
to name a few. Some data about vehicle opera-
tion may be stored in the computers for use
during servicing. Other data may be stored if a
crash event occurs. For example, air bag readi-
ness, air bag performance, and seat belt use by
the driver or passenger may be recorded, de-
pending on vehicle equipment. These types of
systems are sometimes called Event Data Re-
corders.
Special equipment can be used to access the
electronic data that may be stored in the vehi-
cle’s computers (sounds are not recorded).
NISSAN and NISSAN dealers have equipment
to access some of this data; others may also
have this equipment. The data may be retrieved
during routine vehicle servicing or for special
research. It might also be accessed with the
consent of the vehicle owner or lessee, in re-
sponse to a request by law enforcement, or as
otherwise required or permitted by law.
EVENT DATA RECORDERS
9-26
Technical and consumer information


04.3.9/R50-D/V5


A genuine NISSAN Service Manual is the best
source of service and repair information for your
vehicle. Filled with wiring diagrams, illustrations
and step-by-step diagnostic and adjustment
procedures, this manual is the same one used by
the factory trained technicians working at autho-
rized NISSAN dealerships. Also available are
genuine NISSAN Owner’s Manuals, and genu-
ine NISSAN Service and Owner’s Manuals for
older NISSAN models.In the USA:
For current pricing and availability of genuine
NISSAN Service Manualsfor the 2000 model
year and later, contact:
Tweddle Litho Company
1-800-639-8841
www.nissan-techinfo.com
For current pricing and availability of genuine
NISSAN Service Manualsfor the 1999 model
year and prior, see an authorized NISSAN
dealer, or contact:
DDS Distribution Services, Ltd.
20770 Westwood Dr.
Strongsville OH 44136
1-800-247-5321For current pricing and availability of genuine
NISSAN Owner’s Manualsfor the 2002
model year and prior, see an authorized NISSAN
dealer, or contact:
DDS Distribution Services, Ltd.
20770 Westwood Dr.
Strongsville OH 44136
1-800-247-5321
In Canada:
To purchase a copy of a genuine NISSAN
Service Manual or Owner’s Manual please con-
tact your nearest NISSAN dealer. For the phone
number and location of a NISSAN Dealer in your
area call the NISSAN Satisfaction Center at
1-800-387-0122 and a bilingual
NISSAN representative will assist you.
Also available are Genuine NISSAN Service and
Owner’s Manuals for older NISSAN models.
IN THE EVENT OF A COLLISIONUnfortunately, accidents do occur. In this unlikely
event, there is some important information you
should know. Many insurance companies rou-
tinely authorize the use of non-genuine collision
parts in order to cut costs, among other reasons.
OWNER’S MANUAL/SERVICE
MANUAL ORDER INFORMATION
Technical and consumer information
9-27


04.3.9/R50-D/V5


Insist on the use of Genuine Nissan
Collision Parts!If you want your vehicle to be restored using
parts made to NISSAN’s original exacting speci-
fications — if you want to help it to last and hold
its resale value, the solution is simple.Tell your
insurance agent and your repair shop to
only use Genuine Nissan Collision Parts.
NISSAN does not warrant non-Nissan parts, nor
does NISSAN’s warranty apply to damage
caused by a non-genuine part.
Using Genuine Nissan Parts can help protect
your personal safety, preserve your warranty
protection and maintain the resale value of your
vehicle. And if your vehicle was leased, using
Genuine Nissan Parts may prevent or limit un-
necessary excess wear and tear expenses at the
end of your lease.
NISSAN designs its hoods with crumple zones
to minimize the risk that the hood will penetrate
the windshield of your vehicle in an accident.
Non-genuine (imitation) parts may not provide
such built in safeguards. Also, non-genuine
parts often show premature wear, rust and cor-
rosion.
Why should you take a chance?In over 40 states, the law says you must be
advised if non-genuine parts are used to repair
your vehicle. And some states and provinces
have enacted laws that restrict insurance com-
panies from authorizing the use of non-genuine
collision parts during the new vehicle warranty.
These laws help protect you, so you can take
action to protect yourself.It’s your right!If you should need further information visit us at:
www.nissanusa.com.
9-28
Technical and consumer information


04.3.9/R50-D/V5


MEMO
Technical and consumer information
9-29


04.3.9/R50-D/V5


MEMO9-30
Technical and consumer information


04.3.9/R50-D/V5


10 Index
A
ABS (Anti-lock brake system)................................ 5-34
Air bag warning labels ............................................. 1-21
Air bag warning light .................................... 1-21, 2-13
Air cleaner housing filter.......................................... 8-20
Air conditioner
Air conditioner operation ..................................... 4-2
Air conditioner service ............................. 4-2, 4-12
Air conditioner specification label .................. 9-14
Air conditioning system refrigerant and lubricant
recommendations ...................................... 4-12, 9-7
Heater and air conditioner controls.................. 4-2
Servicing air conditioner...................................... 4-2
Air flow charts............................................................... 4-5
Alcohol, drugs and driving......................................... 5-5
Anchor point locations, Top tether strap ............ 1-43
Antenna ........................................................................ 4-29
Anti-lock Brake System (ABS) .............................. 5-34
Anti-lock brake warning light .................................... 2-9
Appearance care
Exterior appearance care .................................... 7-2
Interior appearance care ..................................... 7-3
Armrest ........................................................................... 1-9
Ashtray (See cigarette lighter and ashtray) ........ 2-29
ATP warning light ...................................................... 2-10
Audible reminders ..................................................... 2-16
Audio operation precautions .................................. 4-14
Audio system .............................................................. 4-13Steering wheel audio controls ........................ 4-28
Autochanger, Compact Disc (CD) ....................... 4-26
Automatic
Automatic transmission fluid (ATF) ................ 8-14
Drive positioner ................................................... 3-17
Driving with automatic transmission ..... 5-7, 5-11
Seat positioner, seat .......................................... 3-17
Transmission park warning light ..................... 2-10
Transmission selector lever lock release ...... 5-14
Avoiding collision and rollover .................................. 5-5
B
Back door.................................................................... 3-10
Battery .......................................................................... 8-18
Battery saver system ......................................... 2-22
Battery replacement
Intelligent Key system .......................................... 3-8
Remote keyless entry system............................. 3-8
Before starting the engine ...................................... 5-10
Belts (See drive belts) ............................................. 8-19
Brake
Anti-lock brake system (ABS) ......................... 5-34
Brake and clutch fluid ....................................... 8-16
Brake booster ...................................................... 8-23
Brake fluid............................................................. 8-16
Brake pedal .......................................................... 8-22
Brake pedal check ............................................. 8-23
Brake system ....................................................... 5-34Parking brake check............................... 5-17, 8-22
Parking brake operation .................................... 5-17
Warning light ....................................................... 2-11
Break-in schedule ..................................................... 5-20
Brightness control, Instrument panel ................... 2-23
Bulbcheck/instrument panel .................................... 2-9
Bulbreplacement ............................................. 8-3, 8-27
C
Capacities and recommended fuel/lubricants...... 9-2
Car phone or CB radio............................................ 4-31
Cargo (See vehicle loading information)............. 2-37
Cargo net .................................................................... 2-37
Cassette player (See audio system) ........ 4-18, 4-25
Catalytic converter, Three way catalyst ................. 5-3
CD care and cleaning .............................................. 4-28
Child restraints ........................................................... 1-32
Installation on front passenger seat............... 1-44
Installation on rear seat center position........ 1-34
Installation on rear seat outboard
positions ................................................................ 1-36
Precautions on child restraints........................ 1-32
Top tether strap anchor point locations ....... 1-43
With top tether strap ......................................... 1-42
Child safety ................................................................. 1-25
Child safety rear door lock ........................................ 3-4
Chimes
Audible reminders............................................... 2-16


04.3.9/R50-D/V5


Seat belt warning light and chime ................. 2-13
Cigarette lighter and ashtray .................................. 2-29
Circuit breaker, Fusible link .................................... 8-24
Cleaning exterior and interior .......................... 7-2, 7-3
Clock ............................................................................ 2-28
Clutch fluid.................................................................. 8-16
Coin box ...................................................................... 2-30
Cold weather driving ................................................ 5-37
Compact Disc (CD) changer operation .............. 4-26
Compact Disc (CD) player (See audio
system) ......................................................................... 4-19
Compact spare tire ................................................... 8-39
Compass display ......................................................... 2-7
Console box................................................................ 2-34
Controls
Heater and air conditioner controls.................. 4-2
Steering wheel audio controls ........................ 4-28
Coolant
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Changing engine coolant .................................... 8-9
Checking engine coolant level........................... 8-8
Corrosion protection ................................................... 7-4
Cover, Tonneau cover .............................................. 2-37
Cruise control............................................................. 5-18
Cup holders ................................................................ 2-32
CVT, Transmission selector lever lock
release .......................................................................... 5-14
D
Daytime running light system ................................. 2-24
Dimensions and weights ......................................... 9-11
Door open warning light .......................................... 2-11Drive belts ................................................................... 8-19
Drive positioner, Automatic..................................... 3-17
Driving
All-mode four wheel drive (4WD) .................. 5-25
Cold weather driving ......................................... 5-37
Driving with automatic transmission ..... 5-7, 5-11
Driving with manual transmission .......... 5-8, 5-16
On-pavement and offroad driving ..................... 5-4
Part time four wheel drive (4WD) .................. 5-21
Precautions when starting and driving ............ 5-2
Safety precautions ................................................ 5-5
E
Economy, Fuel............................................................ 5-20
Electric sunroof .......................................................... 2-40
Emission control information label ........................ 9-13
Emission control system warranty......................... 9-24
Engine
Before starting the engine................................ 5-10
Break-in schedule............................................... 5-20
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Changing engine coolant .................................... 8-9
Changing engine oil ........................................... 8-12
Changing engine oil filter ................................. 8-13
Checking engine coolant level........................... 8-8
Checking engine oil level ................................. 8-11
Coolant temperature gauge ............................... 2-4
Engine block heater ........................................... 5-39
Engine compartment check locations.............. 8-7
Engine cooling system ......................................... 8-8
Engine oil .............................................................. 8-11
Engine oil and oil filter recommendation......... 9-6Engine oil viscosity ............................................... 9-6
Engine serial number ......................................... 9-13
Engine specifications ........................................... 9-9
If your vehicle overheats ................................... 6-11
Starting the engine............................................. 5-10
Event data recorders ................................................ 9-26
Exhaust gas (Carbon monoxide).............................. 5-2
F
F.M.V.S.S. certification label................................... 9-13
Filter
Air cleaner housing filter ................................... 8-20
Changing engine oil filter ................................. 8-13
Flashers (See hazard warning flasher switch) ... 2-25
Flat tire............................................................................ 6-2
Flat tire, Low tire pressure warning system .......... 5-3
Flat towing .................................................................. 9-22
Floor mat cleaning ....................................................... 7-4
Fluid
Automatic transmission fluid (ATF) ................ 8-14
Brake and clutch fluid ....................................... 8-16
Brake fluid............................................................. 8-16
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Engine coolant ....................................................... 8-8
Engine oil .............................................................. 8-11
Power steering fluid ........................................... 8-15
Window washer fluid ......................................... 8-17
FM-AM radio with cassette player and Compact
Disc (CD) player........................................................ 4-16
FM-AM-SATELLITE radio with cassette
player and Compact Disc (CD) player/CD
changer ........................................................................ 4-23


04.3.9/R50-D/V5

10-2

Fog light switch ......................................................... 2-25
Four wheel drive (4WD), 4WD shift switch
operations.................................................................... 5-28
Four wheel drive (4WD), All-mode 4WD ........... 5-25
Four wheel drive (4WD), Part time 4WD ........... 5-21
Front manual seat adjustment .................................. 1-2
Front fog light switch ............................................... 2-25
Front power seat adjustment .................................... 1-4
Fuel
Capacities and recommended fuel/
lubricants ................................................................. 9-2
filler cap................................................................. 3-13
filler lid ................................................................... 3-13
Fuel economy ...................................................... 5-20
Fuel octane rating ................................................. 9-4
Fuel recommendation ........................................... 9-4
Gauge ...................................................................... 2-5
Fuses ............................................................................ 8-24
Fusible links ................................................................ 8-24
G
Garage door opener, HomeLink
Universal
Transceiver .................................................................. 2-44
Gas cap ....................................................................... 3-13
Gauge ............................................................................. 2-3
Engine coolant temperature gauge .................. 2-4
Fuel gauge .............................................................. 2-5
Odometer ................................................................ 2-3
Speedometer .......................................................... 2-3
Tachometer ............................................................. 2-4
General maintenance .................................................. 8-2
Glass hatch and outside mirror defogger........... 2-21
Glass hatch lock........................................................ 3-11Glass hatch opener .................................................. 3-11
Glove box .................................................................... 2-33
Glove box lock ........................................................... 2-33
H
Hazard warning flasher switch............................... 2-25
Head restraints ............................................................. 1-9
Headlights
Bulbreplacement ............................................... 8-28
Headlight switch ................................................. 2-22
Heated seats .............................................................. 2-26
Heater
Engine coolant heater ....................................... 5-39
Heater and air conditioner controls.................. 4-2
Heater operation.................................................... 4-2
Heater and air conditioner (Type A) ....................... 4-8
Heater and air conditioner (Type B) .................... 4-10
HomeLink
Universal Transceiver ......................... 2-44
Hood release ................................................................ 3-9
Hook, Luggage hook ................................................ 2-35
Horn .............................................................................. 2-26
I
Ignition switch ............................................................... 5-7
Automatic transmission models ............. 5-7, 5-11
Key positions .......................................................... 5-9
Manual transmission models .................. 5-8, 5-16
Immobilizer system .................................................... 2-18
Indicator lights............................................................ 2-14
Inside mirror ................................................................ 3-16
Inspection/maintenance (I/M) test ........................ 9-25Instrument brightness control ................................ 2-23
Instrument panel........................................................... 2-2
Interior lights ............................................................... 2-42
ISOFIX child restraint ............................................... 1-41
J
Jump starting................................................................. 6-9
K
Keyless entry (See remote keyless entry
system) ........................................................................... 3-5
Keys................................................................................. 3-2
L
Label, Air conditioner specification label ............ 9-14
Label, Emission control information label............ 9-13
Label, F.M.V.S.S. certification label ...................... 9-13
Labels
Air bag warning labels ...................................... 1-21
Engine serial number ......................................... 9-13
Vehicle identification number (VIN)................ 9-12
LATCH system ........................................................... 1-41
Light
Air bag warning light ......................................... 1-21
Bulbreplacement ...................................... 8-3, 8-27
Fog light switch................................................... 2-25
Headlight switch ................................................. 2-22
Headlights bulb replacement........................... 8-28
Interior lights ........................................................ 2-42
Personal lights ..................................................... 2-43


04.3.9/R50-D/V5

10-3

Replacement ............................................... 8-3, 8-27
Vanity mirror light ................................................ 2-44
Warning/indicator lights and audible
reminders ..................................................... 2-9, 2-14
Loading information (See vehicle loading
information) ................................................................. 9-14
Lock
Back door lock .................................................... 3-10
Door locks ............................................................... 3-2
Glass hatch lock ................................................. 3-11
Glove box lock..................................................... 2-33
Power door lock .................................................... 3-2
Lockout protection....................................................... 3-4
Low fuel warning light .............................................. 2-12
Low tire pressure warning light ............................. 2-12
Low tire pressure warning system ................. 5-3, 6-2
Luggage hooks .......................................................... 2-35
Luggage rack ............................................................. 2-38
Luggage side console box...................................... 2-34
M
Maintenance
Battery ................................................................... 8-18
General maintenance ........................................... 8-2
Inside the vehicle................................................... 8-3
Maintenance precautions .................................... 8-5
Maintenance requirements.................................. 8-2
Outside the vehicle............................................... 8-2
Seat belt maintenance ...................................... 1-32
Malfunction indicator lamp (MIL) ........................... 2-14
Manual front seat adjustment ................................... 1-2
Meters and gauges ..................................................... 2-3Meters and gauges, Instrument brightness
control .......................................................................... 2-23
Mirror
Inside mirror ......................................................... 3-16
Outside mirror control ....................................... 3-16
Outside mirrors ................................................... 3-16
N
Net, Cargo net ........................................................... 2-37
New vehicle break-in ................................................ 5-20
Nissan Vehicle Immobilizer System ...................... 2-17
Engine start............................................................. 5-9
O
Odometer ....................................................................... 2-3
Oil
Capacities and recommended fuel/
lubricants ................................................................. 9-2
Changing engine oil ........................................... 8-12
Checking engine oil level ................................. 8-11
Engine oil .............................................................. 8-11
Engine oil viscosity ............................................... 9-6
Outside mirror control .............................................. 3-16
Outside mirrors .......................................................... 3-16
Outside temperature display..................................... 2-6
Overdrive switch........................................................ 5-15
Overheat, If your vehicle overheats ...................... 6-11
Owner’s Manual/Service Manual order
information................................................................... 9-27P
Parking
Brake check ......................................................... 8-22
Parking brake check .......................................... 5-17
Parking brake operation .................................... 5-17
Parking on hills .................................................... 5-17
Parking/parking on hills ........................................... 5-32
Personal lights............................................................ 2-43
Phone, Car phone or CB radio ............................. 4-31
Power
Front seat adjustment .......................................... 1-4
Power door lock .................................................... 3-2
Power outlet ......................................................... 2-28
Power steering fluid ........................................... 8-15
Power steering system ...................................... 5-33
Power windows................................................... 2-39
Pre-tensioner seat belt system .............................. 1-20
Precautions
Audio operation ................................................... 4-14
Braking precautions ........................................... 5-34
Child restraints .................................................... 1-32
Cruise control ...................................................... 5-18
Cruise control operations ................................. 5-20
Driving safety .......................................................... 5-5
Maintenance ........................................................... 8-5
On-pavement and offroad driving ..................... 5-4
Seat belt usage ................................................... 1-24
Supplemental restraint system ........................ 1-10
When starting and driving .................................. 5-2
Push starting .............................................................. 6-11


04.3.9/R50-D/V5

10-4