Actuator SUBARU TRIBECA 2009 1.G Service Repair Manual

GD(H6DO)-203
Diagnostic Trouble Code (DTC) Detecting Criteria
GENERAL DESCRIPTION
ED:DTC P2102 THROTTLE ACTUATOR CONTROL MOTOR CIRCUIT LOW
1. OUTLINE OF DIAGNOSIS
Judge as NG when the electronic throttle control power is not supplied even when ECM sets the electric con-
trol throttle relay to ON.
2. COMPONENT DESCRIPTION
3. ENABLE CONDITIONS
4. GENERAL DRIVING CYCLE
Always perform the diagnosis continuously.
5. DIAGNOSTIC METHOD
Judge as OK and clear the NG when the malfunction criteria below are met.
Time Needed for Diagnosis:
•400 milliseconds (For NG)
•2000 milliseconds (For OK)
Malfunction Indicator Light: Illuminates as soon as a malfunction occurs.
(1) Engine control module (ECM) (3) Drive circuit (5) Motor
(2) Voltage detection circuit (4) Electronic throttle control relay
Secondary Parameters Enable Conditions
Electronic control throttle relay output ON
Judgment Value
Malfunction Criteria Threshold Value
Motor power voltage≥ 5 V
EN-01868
(2)
(3)
(1)
(4)
(5)
12V 12V

GD(H6DO)-205
Diagnostic Trouble Code (DTC) Detecting Criteria
GENERAL DESCRIPTION
EE:DTC P2103 THROTTLE ACTUATOR CONTROL MOTOR CIRCUIT HIGH
1. OUTLINE OF DIAGNOSIS
Judge as NG when the electronic throttle control power is not supplied even when ECM sets the electric throt-
tle control relay to OFF.
2. COMPONENT DESCRIPTION
3. ENABLE CONDITIONS
4. GENERAL DRIVING CYCLE
•When ignition switch ON → OFF
•Ignition switch OFF → ON (Only after clearing memory)
5. DIAGNOSTIC METHOD
Judge as OK and clear the NG when the malfunction criteria below are met.
(1) Engine control module (ECM) (3) Drive circuit (5) Motor
(2) Voltage detection circuit (4) Electronic throttle control relay
Secondary Parameters Enable Conditions
Electronic control throttle relay output OFF
Judgment Value
Malfunction Criteria Threshold Value
Motor power voltage≤ 5 V
EN-01868
(2)
(3)
(1)
(4)
(5)
12V 12V

5AT-14
General Description
AUTOMATIC TRANSMISSION
10.TRANSMISSION CONTROL DEVICE & PARKING SUPPORT
(1) Bracket (9) Parking support actuator (16) Reduction driven gear
(2) Floating bracket (10) Parking pawl shaft (17) Ball bearing
(3) AT main case (11) Return spring
(4) Range select lever (12) Parking pawlTightening torque: N·m (kgf-m, ft-lb)
(5) Straight pin (13) Ball bearingT1: 6 (0.6, 4.4)
(6) Detent spring (14) Snap ringT2: 25 (2.5, 18)
(7) Manual plate (15) Parking gearT3: <Ref. to 5AT-73, Parking Pawl.>
(8) Parking rod
T2
T2
T3
T1
T1
(1)
(2)
(3)
(10)
(11)
(8)
(7)
(5)(4)
(6)
(12)
(13)
(14)
(15)
(16)
(17)
(9)
AT-03248

5AT-73
Parking Pawl
AUTOMATIC TRANSMISSION
29.Parking Pawl
A: REMOVAL
1) Remove the transmission assembly from vehicle
body. <Ref. to 5AT-34, REMOVAL, Automatic
Transmission Assembly.>
2) Remove the extension case. <Ref. to 5AT-63,
REMOVAL, Extension Case.>
3) Remove the center differential carrier. <Ref. to
5AT-71, REMOVAL, Center Differential Carrier.>
4) Remove the front vehicle speed sensor. <Ref. to
5AT-47, REMOVAL, Front Vehicle Speed Sensor.>
5) Remove the parking support actuator.
6) Remove the parking pawl, parking pawl shaft
and return spring.
B: INSTALLATION
1) Set the transmission to the “N” range.
2) Install the parking pawl, parking pawl shaft and
return spring.
3) Install the parking support actuator.
Tightening torque:
10±2 N·m (1.0±0.2 kgf-m, 7.4±1.5 ft-lb)
4) Using the ST, tighten the bolts which tightened in
step 4) with specified angle.
Tightening angle:
17°±2°
ST 18854AA000 ANGLE GAUGE
NOTE:
Do not use extension as much as possible.
AT-03236
AT-03272
AT-03272
AT-03236
AT-02071ST
AT-02072
ST

WI-21
Power Supply Circuit
WIRING SYSTEM
FB-37 Body integrated unit
FB-38 ECM
TCM
Fuel pump relay
FB-39 Airbag control module
FB-41 Airbag control module
FB-42 Power window relay
FB-44 VDC control module
Steering angle sensor
Ya w r a t e s e n s o r
FB-45 A/C control panel
Rear cooler relay
FB-46 A/C relay
FRESH/RECIRC actuator
Auto A/C control module
Pressure switch
Blower fan relay
FB-47 Occupant detection control module
FB-48 TPM control module
FB-49 Impact sensor
TV monitor
ACC -1 Front washer motor
ST-1 ECM
Starter relay
No. Load

WI-27
Ground Circuit
WIRING SYSTEM
WI-08035
GND-06GND-06
D140B A16
REAR GATE RELEASE
ACTUATOR
GND-05G
GND-05H
BB
GB-12
BBY
GB-13
BBY
GB-15GB-14
D35
12345678910
D139B2
1
B2B4
TAIL LIGHT RH
D134B2
1
TAIL LIGHT LH
D137B2
1
LICENSE PLATE LIGHT RH
D44B2
1
LICENSE PLATE LIGHT LH
D37B2
1
LUGGAGE ROOM LIGHT
D39B
HIGH-MOUNTED STOP LIGHT
D87B2
1
BACK UP LIGHT RH
D91B2
1
BACK UP LIGHT LH
D43B2
3
REAR WIPER MOTOR
D135B2
1
REAR GATE LATCH SWITCH
D89B2
2
REAR DEFOGGER
R79B
TRAILER CONNECTOR
D34
R37
B
2
B
26
R26B3
REAR COMBINATION LIGHT RH
R28B3
REAR COMBINATIONLIGHT LH
2
BB8
D35R39
BB12
R215R247
D39
12D139
D134D44
D91
D135
D87D137D140
D43
121234
D34
D89
121
R215
12
10115634897131412
12
D37
123
R26
R28
4321
R79
123456

WI-64
Air Conditioning System
WIRING SYSTEM
WI-08070
F-A/C-02F-A/C-02
(GREEN)
WLYR
B282A:B:B283AUTO A/C CONTROL MODULE
A2B10
LgWYRVY
B16B23B6
PWGW
B3B2
LYBL
TO POWER SUPPLY CIRCUIT
FB-29F/B FUSE NO. 31(ACC)
FB-18F/B FUSE NO. 7 (B)
RW
MB-32(B)
BLOWERFANRELAY
VY
GOr
LgWBL
3
BR
5
B419
BLOWERFAN MOTOR
B87
FRESH/RECIRCACTUATOR
B91
2
GOrWL
1
BY 1
BR
213
7
BY
LYB
BLOWER FANCONTROLLER
B863
GW
52
1
B
A1
WL
PW
ECM
C:B136
C24
A-A/C-01A
B87
12
B91
1234567
REF. TO GROUNDCIRCUIT [GND-03]
B432
SBF HOLDER30A
12
B432
2
1
4
36
5
8
7
B283A:
345678910
16 17 18 19 20
121112132425262122231415
B282B:
12345678
910 1112 1314 1516
B419
76
2435
1
B86
12345
C: B136
16101112131415252430
9871718192028212223293231
123456
2726333435

WI-66
Air Conditioning System
WIRING SYSTEM
WI-08072
F-A/C-04F-A/C-04A5
WR
A3
BrW
A13
LR
A15
BW
B24
B
B26A8
AUTO A/C CONTROL MODULE
53B77B390
MODE ACTUATOR
A:B282B:B283
WR
6
LW
1
LR
7
RBW
WG
(GREEN)
B
A16
YB
A6
RB
B7
LWLGGRB
B20B9B22A12
PG
B8
BL
A4
Br
B21
53B235
AIR MIX ACTUATOR(PASSENGER SIDE)
BL
7
PG
1
LR
6
BrW
12B88
EVAPORATIONTHERMO SWITCH
BrWLR
21B413
IN-VEHICLESENSOR
WGLR
21i51
SUNLOADSENSOR
YBWR
YB
3
W
2
YBWR
B38
i3
67
LG
5
RB
1
W
3
LRG
B88
121
B235(GREEN)B77
1234567
(GREEN)B390
B413
i51
12
B38
1234 5678910 11 12 13 14 15 16 17 18 19 20
AIR MIX ACTUATOR(DRIVER SIDE)
B
REF. TO GROUNDCIRCUIT [GND-03]
B283
A:
345678910
16 17 18 19 20
121112132425262122231415
B282
B:
12345678
910 1112 1314 1516

WI-140
Keyless Entry System
WIRING SYSTEM
50.Keyless Entry System
A: WIRING DIAGRAM
K/L-01K/L-01
WI-08142
i96
123456781234
D72
56782194310242223 25111213141526 27 281617181920 21
B281C:A:i84
1234567891011121415161718192021222324252627282930313233343513
BY
LR
LR
i99
i99
7
BY
43
YGLR
i96
LRLRWLGR
BY
BY
GRWL
C8
BY
B22
BY
C9
Y
B12
LR
A1C2
A:i84B:B280C:B281
WG
D84
567821943
10
2422 23 25
11121314151617181920 21
YG
A9
BY
A21
WG
A34B7
5467821931022 23111213141524 25 26 2716171828 29192021 30
B280B:
GLgY
56
24
RLLgYD72
G
A23
LgY
A7
B90
R50
43
89
BrWBrB
BrWBrB
BrW
A15
BrB
A29
5
BD7
2
B
BB1
BBr
BrB
R52
71
Br
B3
i76
D84
R50
123456789101112
R52
321
K/L-02C
K/L-02B
K/L-02A
K/L-02D
FB-10M/B FUSE NO. 8(B)
JOINTCONNECTOR(ILLUMINATION& BACK-UPLIGHT)
KEYLESSENTRYCONTROLMODULE
FB-6F/B FUSE NO. 3(B)
MB-29M/B FUSE NO. 8(B)
FB-18F/B FUSE NO. 7(B)
FB-37F/B FUSE NO. 12(IG)
TO POWER SUPPLY CIRCUIT
BODY INTEGRATED UNIT
REF. TO TURN SIGNAL LIGHTAND HAZARD LIGHT SYSTEM[TURN-01]
REF. TO GROUNDCIRCUIT [GND-02]REF. TO GROUNDCIRCUIT [GND-04-05]FRONTDOOR LOCKACTUATOR LH
REF. TO GROUNDCIRCUIT [GND-04]REF. TO GROUNDCIRCUIT [GND-01]
POWER WINDOWMAIN SWITCH(DOOR LOCK SWITCH)
ROOMLIGHT
i126
i127
JOINTCON-NECTOR
2*
3*
R241
JOINTCON-NECTOR
1*
1*
3*
3*
: TERMINAL NO. OPTIONAL ARRANGEMENT : TERMINAL NO. OPTIONAL ARRANGEMENT AMONG 10, 11 AND 12
1*
2*
: TERMINAL NO. OPTIONAL ARRANGEMENT AMONG 7, 8 AND 9
3*
D7
12345689101112131514716123456789101112
i127(BLACK)
(GRAY)
i126(BLACK)
i99R241(BLACK)
1234
UNLOCK
LOCK
OFF
DOOR
2

WI-142
Keyless Entry System
WIRING SYSTEM
SEC-03K/L-03
WI-08144
VG
VG
i102
R167
B
1
16
5
2
V
R39
D35
D34
R37
VG
R215
R247
2
B
B
D26
D18
D140
D32
i114
i113
D83
567821943
10
2422 23 25
1112131415161718192021
LgY
A7A8
1
LgY
RGLgY 5
R13
D281
LgY
RGLgY
5R10
D22
4
RLLgY
2D184
RGLgY
2D264
RGLgY
2D32
D140
A: i84
LgY
5
RL
LgYRG
6i101
D83
RGRG
RGK/L-03A22
FRONT DOOR LOCKACTUATOR RHREAR DOOR LOCKACTUATOR LHREAR DOOR LOCKACTUATOR RH
BODY INTEGRATED UNIT
REF. TO GROUNDCIRCUIT [GND-06]
REAR GATERELEASEACTUATOR
A:i84
1234567891011121415161718192021222324252627282930313233343513
i127
i127
i126
JOINTCONNECTOR
LgY
LgY
LgYLgY
3*
2*2*3*i113
i114
i114
JOINTCONNECTOR
RG
RG
RGRG
1*
1*1*1*
LgY
RGLgY
i102
R167
LgY
RGLgY
i53
R98
RGRG
: TERMINAL NO. OPTIONAL ARRANGEMENT BETWEEN 3 AND 4
: TERMINAL NO. OPTIONAL ARRANGEMENT AMONG 7, 8 AND 9
1*
2*
: TERMINAL NO. OPTIONAL ARRANGEMENT AMONG 10, 11 AND 12
3*
123456789101112
i127(BLACK)
(GRAY)
i126(BLACK)
123456789101234
R10
D35R13D34
1211234567891413121110151617181920
i102(BLUE)
123 8910411 12 13 14 15 16567171819202122
i53(BLUE)R215
12
10115634897131412
2
17181617