TOYOTA LAND CRUISER 1998 Factory Repair Manual

R04447
D01633
SPIDER GREASE FITTING ASSEMBLY DIRECTION
Front propeller shaft
Rear propeller shaftThe figure at left shows the locations
of the grease fittings as seen from the
rear. No. 1
Sleeve Yoke
No. 2
No. 1No. 2
Sleeve Yoke
No. 2
No. 1 Sleeve Yoke
- PROPELLER SHAFTSPIDER BEARING
PR-1 1
1950 Author
: Date
:
2004 LAND CRUISER (RM1071U)
10. CHECK SPIDER BEARING (See page PR-5)
(a) Check that the spider bearing moves smoothly.
(b) Check the spider bearing axial play.
Maximum bearing axial play: 0 mm (0 in.)
HINT:
When replacing the spider bearing, be sure that the grease fit-
ting assembly hole is facing to the direction shown in the illustra-
tion.

PR03H-02
- PROPELLER SHAFTTROUBLESHOOTING
PR-1
1940 Author
: Date
:
2004 LAND CRUISER (RM1071U)
TROUBLESHOOTING
PROBLEM SYMPTOMS TABLE
Use the table below to help you find the cause of the problem. The numbers indicate the priority of the likely
cause of the problem. Check each part in order. If necessary, replace these parts.
SymptomsSuspect AreaSee page
Noise1. Sleeve yoke spline (Worn)
2. Spider bearing (Worn or stuck)PR-5
PR-5
Vibration
1. Sleeve yoke spline (Stuck)
2. Propeller shaft (Runout)
3. Propeller shaft (Imbalance)PR-5
PR-5
-

SS0O3-03
SS-52
- SERVICE SPECIFICATIONSAIR CONDITIONING
192 Author
: Date
:
2004 LAND CRUISER (RM1071U)
AIR CONDITIONING
SERVICE DATA
Refrigerant charge volume Single A/C
Dual A/C650 ± 50 g (22.93 ± 1.76 oz.)
1,050 ± 50 g (37.03 ± 1.76 oz.)
Idle speed Magnetic clutch not engaged700 ± 50 rpmIdle s eed Magnetic clutch not engaged
Magnetic clutch engaged780 ± 50 rpm
Magnetic clutch clearance0.5 ± 0.15 mm (0.020 ± 0.0059 in.)

SS0O4-04
- SERVICE SPECIFICATIONSAIR CONDITIONING
SS-53
193 Author
: Date
:
2004 LAND CRUISER (RM1071U)
TORQUE SPECIFICATION
Part tightenedN´mkgf´cmft´lbf
Condenser x Discharge tube5.45548 in.´lbf
Condenser x Liquid tube101007
Compressor x Discharge hose101007
Compressor x Suction hose101007
Expansion valve x Evaporator3.43530
Liquid line (Block joint)101007
Liquid line (Piping line)1414010
Discharge line (Piping joint)2222516
Suction line (Block joint)101007
Suction line (Piping joint)5/8º3233024Suction line (Pi ing joint) 5/8
3/4º4242531
Compressor x Cylinder block4950036

SS0OO-02
- SERVICE SPECIFICATIONSAUTOMATIC TRANSMISSION
SS-23
163 Author
: Date
:
2004 LAND CRUISER (RM1071U)
AUTOMATIC TRANSMISSION
SERVICE DATA
A750F
Line pressure (Wheel locked)
Engine idling
D position
R position
AT stall (Throttle valve fully opened)
D position
R position
362 - 420 kPa (3.7 - 4.3 kgfVcm2, 53 - 61 psi)
500 - 580 kPa (5.1 - 5.9 kgfVcm2, 73 - 84 psi)
1,360 - 1,460kPa (13.9 - 14.9 kgfVcm
2, 197 - 212 psi)
1,295 - 1,415 kPa (13.2 - 14.4 kgfVcm2, 188 - 205 psi)
Engine stall revolution D and R positions2,150
150 rpm
Time lag N " D position
N " R positionLess than 1.2 seconds
Less than 1.5 seconds
Engine idle speed
(A/C OFF) N position
700
50 rpm
Drive plate runoutMax.
Torque converter runout Max.
Torque converter clutch installation distance0.20 mm (0.0079 in.)
0.30 mm (0.0118 in.)
More than 17.1 mm (0.673 in.)
Shift schedule
D position
(Throttle valve fully opened) 1 " 2
2 " 3
3 " 4
4 " 5
5 " 4
4 " 3
3 " 2
2 " 1
(Throttle valve fully closed) 4 " 5
5 " 4
3 position
(Throttle valve fully opened) 1 " 2
2 " 3
4 " 3
3 " 2
2 " 1
2 position
(Throttle valve fully opened) 1 " 2
3 " 2
2 " 1
L position
(Throttle valve fully opened) 2 " 1
45 - 57 km/h (28 - 35 mph)
79 - 90 km/h (49 - 56 mph)
113 - 128 km/h (70 - 80 mph)
165 - 180 km/h (103 - 112 mph)
158 - 173 km/h (98 - 108 mph)
105 - 117 km/h (65 - 73 mph)
70 - 78 km/h (43 - 48 mph)
35 - 41 km/h (22 - 25 mph)
32 - 38 km/h (20 - 24 mph)
24 - 29 km/h (15 - 18 mph)
45 - 57 km/h (28 - 35 mph)
79 - 90 km/h (49 - 56 mph)
119 - 132 km/h (74 - 82 mph)
70 - 78 km/h (43 - 48 mph)
35 - 41 km/h (22 - 25 mph)
45 - 57 km/h (28 - 35 mph)
80 - 88 km/h (50 - 55 mph)
35 - 41 km/h (22 - 25 mph)
41 - 47 km/h (25 - 29 mph)
Lock-up pointThrottle valve opening 5 %
D position
5th gearLock-up ON
Lock-up OFF
4 position
4th gearLock-up ON
Lock-up OFF
67 - 74 km/h (42 - 46 mph)
60 - 67 km/h (37 - 42 mph)
61 - 68 km/h (38 - 42 mph)
54 - 61 km/h (34 - 38 mph)

SS0OP-02
SS-24
- SERVICE SPECIFICATIONSAUTOMATIC TRANSMISSION
164 Author
: Date
:
2004 LAND CRUISER (RM1071U)
TORQUE SPECIFICATION
Part tightenedN´mkgf´cmft´lbf
No.1 vehicle speed sensor x Transfer case1616012
No.2 vehicle speed sensor x Transmission case NT
SP25.4
5.455
5548 in.´lbf
48 in.´lbf
ATF temperature sensor (for linear control ) x Valve body1111 28
ATF temperature sensor (for oil temp warning lamp ) x Valve body101007
ATF temperature sensor x Transmission case5.45548 in.´lbf
Park/neutral position switch Bolt
Nut13
3.9130
409
35 in.´lbf
Transmission control shaft lever x Transmission control rod131309
Shift solenoid lock plate x Valve body6.46557 in.´lbf
Shift solenoid S1 S2 x Valve body101027
Shift solenoid SR x Valve body6.46557 in.´lbf
Valve body x Transmission case1111 08
Oil stainer x Valve body101007
Oil pan x Transmission case4.45539 in.´lbf
Drain plug x Oil pan2020515
Parking lock pawl bracket x Transmission case7.47565 in.´lbf
Shift lever assembly x Body8.38573 in.´lbf
Control lever x Shift lever plate131309
Transmission control rod x Shift lever assembly131309
Shift lever guide housing x Shift lever plate4.95043 in.´lbf
Power steering oil cooler sub-assy x Body7.57666 in.´lbf
Oil cooler bracket x Body1211 78
Oil cooler bracket x Oil cooler4.95043 in.´lbf
Oil cooler pipe x Body4.95043 in.´lbf
Oil filler pipe121229
Transfer shift lever x Transfer shift lever rod assembly121229
Transfer shift lever boot x Body5.45548 in.´lbf
Hole plug x Transmission housing1818513
Drive plate x Torque converter clutch4849035
Oil cooler pipe union nut3434725
Crossmember Bolt
Nut50
74510
75037
54
Engine mounting insulator rear x Transmission case5960043
Transmission housing x Engine Bolt A
Bolt B71
37724
37752
27
Drive plate x Crankshaft 1st
2nd49
Turn 90°500
Turn 90°36
Turn 90°

SS0CN-30
SS-46
- SERVICE SPECIFICATIONSBODY ELECTRICAL
186 Author
: Date
:
2004 LAND CRUISER (RM1071U)
BODY ELECTRICAL
SERVICE DATA
AUTOMATIC LIGHT CONTROL SENSOR
(Connector disconnected)
3 - Ground (Ignition switch ON)5.2 - 9.0V
TURN SIGNAL FLASHER
1 - Ground (Ignition switch LOCK or ACC)No voltage
1 - Ground (Ignition switch ON)Battery positive voltage
4 - Ground (Constant)Battery positive voltage
SPEEDOMETER (ON-VEHICLE)
USA:
Standard indication (mph)Allowable range (mph)
2018 - 24
4038 - 44
6056 - 66
8078 - 88
10098 - 110
120118 - 132
CANADA:
Standard indication (km/h)Allowable range (km/h)
2017 - 24
4038 - 46
6057.5 - 67
8077 - 88
10096 - 109
120115 - 130
140134 - 151.5
160153 - 173
TACHOMETER (ON-VEHICLE)/ DC 13.5 V 25 °C at (77 °F)
Standard indicationAllowable range
700630 - 770
1,000900 - 1,100
2,0001,850 - 2,150
3,0002,800 - 3,200
4,0003,800 - 4,200
5,0004,800 - 5,200
6,0005,750 - 6,250
7,0006,700 - 7,300
FUEL SENDER GAUGE
Float position mm (in.)Voltage (V)
F: Approx. 85.3 (3.36)Approx. 0.30 ± 0.1
1/2: Approx. 1.7 (0.76)Approx. 2.45 ± 0.1
E: Approx. 9.19 (3.62)Approx. 4.60 ± 0.1
DEFOGGER SWITCH (w/ Navigation)
B22 - Ground (Ignition switch LOCK or ACC)No voltage

- SERVICE SPECIFICATIONSBODY ELECTRICAL
SS-47
187 Author
: Date
:
2004 LAND CRUISER (RM1071U) B22 - Ground (Ignition switch ON)
Battery positive voltage
A10 - Ground (Constant)Battery positive voltage
DEFOGGER SWITCH (w/o Navigation)
8 - Ground (Ignition switch LOCK or ACC)No voltage
8 - Ground (Ignition switch ON)Battery positive voltage
2 - Ground (Constant)Battery positive voltage
SLIDING ROOF CONTROL ASSEMBLY
5 - Ground (Constant)Battery positive voltage
8 - Ground (Ignition switch LOCK or ACC)No voltage
8 - Ground (Ignition switch ON)Battery positive voltage
POWER MIRROR SWITCH
4 - Ground (Ignition switch LOCK)No voltage
4 - Ground (Ignition switch ACC or ON)Battery positive voltage
POWER SEAT SWITCH (Driver's Seat)
11 - Ground (Constant)Battery positive voltage
POWER SEAT SWITCH (Passenger's Seat)
11 - Ground (Constant)Battery positive voltage
LUMBAR SUPPORT SWITCH (Driver's Seat)
POWER MIRROR SWITCH (Wire harness side)
4 - Ground (Ignition switch is LOCK)No voltage
4 - Ground (Ignition switch is ACC or ON)Battery positive voltage
POWER AMPLIFIER
7 - Ground (Constant)Battery positive voltage
16 - Ground (Constant)Battery positive voltage
REAR SEAT AUDIO
24 - Ground (Ignition switch LOCK)No voltage
24 - Ground (Ignition switch ACC or ON)Battery positive voltage
12 - Ground (Constant)Battery positive voltage
DVD CHANGER
1 - Ground (Ignition switch LOCK)No voltage
1 - Ground (Ignition switch ACC or ON)Battery positive voltage
10 - Ground (Constant)Battery positive voltage
RADIO RECEIVER
A1 - Ground (Ignition switch LOCK)No voltage
A11 - Ground (Ignition switch ACC or ON)Battery positive voltage
A11 - Ground (Constant)Battery positive voltage
ANTENNA MOTOR CONTROL RELAY
4 - Ground (Constant)Battery positive voltage
7 - Ground (Ignition switch ACC or LOCK)No voltage
7 - Ground (Ignition switch ON)Battery positive voltage
17 - Ground (Ignition switch LOCK)No voltage
17 - Ground (Ignition switch ACC or ON)Battery positive voltage
OVERHEAD J/B
8 - Ground (Constant)Battery positive voltage

SS-48
- SERVICE SPECIFICATIONSBODY ELECTRICAL
188 Author
: Date
:
2004 LAND CRUISER (RM1071U) 11 - Ground (Ignition switch OFF or ACC)
No voltage
11 - Ground (Ignition switch ON)Battery positive voltage

SS0OL-1 1
- SERVICE SPECIFICATIONSBODY
SS-49
189 Author
: Date
:
2004 LAND CRUISER (RM1071U)
BODY
TORQUE SPECIFICATION
Part tightenedN´mkgf´cmft´lbf
FRONT BUMPER---
Front bumper cover x Body Bolt:8.58776 in.´lbf
Front bumper cover x Body Screw:3.03127 in.´lbf
Fog light x Front bumper cover4.95043 in.´lbf
Front bumper reinforcement x Body5859043
REAR BUMPER---
Rear bumper cover x Body2020415
Reflex reflector x Rear bumper cover4.95043 in.´lbf
Rear bumper step reinforcement x Extension mounting bracket12.512711
Extension mounting bracket x Body1919514
Rear bumper reinforcement x Body2020415
HOOD---
Hood x Hood side hinge1818513
FRONT DOOR---
Door glass x Window regulator8.08271 in.´lbf
Window regulator x Door panel8.08271 in.´lbf
Door lock x Door panel5.05144 in.´lbf
Outside handle x Door panel5.05144 in.´lbf
Door lock cylinder x Outside handle5.05144 in.´lbf
Door hinge x Body2323517
Door hinge x Door panel2626519
Door check x Door panel5.05144 in.´lbf
Door check x Body2727520
Door lock striker x Body1111 58
REAR DOOR---
Door glass x Window regulator8.08271 in.´lbf
Window regulator x Door panel8.08271 in.´lbf
Door lock x Door panel5.05144 in.´lbf
Outside handle x Door panel5.05144 in.´lbf
Door hinge x Body2323517
Door hinge x Door panel2626519
Door check x Door panel5.05144 in.´lbf
Door check x Body2727520
Door lock striker x Body1111 58
UPPER BACK DOOR---
Back door hinge x Body2828621
Back door hinge x Door panel3131623
Door lock striker x Door panel11.511 78
Back door control x Door panel5.05144 in.´lbf
Back door lock x Door panel7.07162 in.´lbf
LOWER BACK DOOR---
Back door lock x Door panel5.05144 in.´lbf