Engine start TOYOTA RAIZE 2023 Service Manual

3757-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
When trouble arises
7
Emergency towing procedure
To have your vehicle towed by another vehicle, the towing eyelet must be
installed to your vehicle. Install the towing eyelet using the following procedure.
aTake out the wheel nut wrench and towing eyelet (➞ P. 397)
b Remove the eyelet cover using a
flathead screwdriver.
To protect the bodywork, place a rag
between the screwdriver and the vehi-
cle body as shown in the illustration.
cInsert the towing eyelet into the
hole and tighten partially by
hand.
d Tighten down the towing eyelet
securely using a wheel nut
wrench or hard metal bar.
e Securely attach cables or ch ains to the towing eyelet.
Take care not to damage the vehicle body.
fEnter the vehicle being towed and start the engine.
If the engine does not start, turn the engine switch to “ON”.
gShift the shift lever to N and release the parking brake.
When the shift lever cannot be shif ted (continuously variable transmis-
sion): ➞P. 191
KBRO720106E
KBRO720108TN
KBRO720109TN
RAIZE_OM_General_BZ358E.book 375 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3767-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
⬛While towing
If the engine is not running, the power assist for the brakes and steering will
not function, making steering and braking more difficult.
⬛Wheel nut wrench
The wheel nut wrench is stored at the bottom of the front left seat. ( ➞P. 397)
⬛After towing
Remove the towing eyelet and secu rely attach the cover in place.
WARNING
Observe the following precautions. Failure to do so may result in death or seri-
ous injury.
⬛While towing
⚫When towing using cables or chains, avoid sudden starts, etc. which place
excessive stress on the towing eyelets, cables or chains. The towing eyelets,
cables or chains may become damaged, broken debris may hit people, and
cause serious damage.
⚫Do not turn the engine switch “OFF”.
There is a possibility that the steerin g wheel is locked and cannot be oper-
ated.
⬛Installing towing eyelets to the vehicle
Make sure that towing eyelets are instal led securely. If not securely installed,
towing eyelets may come loose during towing.
NOTICE
⬛To prevent damage to the vehicle during emergency towing
Do not secure cables or chains to the suspension components.
⬛When the engine switch malfunctions (vehicles with key-free system)
Since the steering wheel cannot be unloc ked, towing by rope is not possible.
RAIZE_OM_General_BZ358E.book 376 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3787-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
Fuel pump shut off system
If the engine stalls due to a strong external impact, the fuel pump
shut off system may be operating. The fuel pump shut off system is a
device that prevents secondary disasters such as fires by stopping
the supply of fuel to the engine.
Follow the procedure below to restart the engine after the system is
activated
a Turn the engine switch to “ACC” or “OFF”
b Restart the engine
WARNING
⬛Before starting the engine
Inspect the ground under the vehicle.
If you find that fuel has leaked onto th e ground, the fuel system has been dam-
aged and is in need of repair. Do not restart the engine.
RAIZE_OM_General_BZ358E.book 378 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3837-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
When trouble arises
7
*5Driver’s/front passenger’s seat belt reminder warning buzzer:
If the vehicle speed becomes approx. 20 km/h (12 mph) or faster when the
driver’s/front passenger’s seat belt is unfastened, the warning buzzer will
sound intermittently for 30 seconds. Th en, if the driver’s/front passenger’s
seat belt is still unfastened, the buzzer w ill sound in a different tone for 90 sec-
onds.
*6Passenger detection sensor for front pa ssenger’s seat belt reminder warning
light:
If luggage is placed on the front passenger’s seat, the front passenger detec-
tion sensor may cause the warning light to flash even if a passenger is not sit-
ting in the seat.
If a cushion is placed on the seat, the sensor may not detect a passenger, and
the warning light may not operate properly.
*7A warning is displayed to the upper pa rt of the inside rear view mirror.
*8Rear seat belt reminder warning light:
The rear seat belt reminder light come s on when the engine switch is turned
“ON” with the rear seat belt not fastened, or when the rear seat belt is unfas-
tened.
The light turns off when the rear seat belt is fastened or approx. 60 seconds
(approx. 30 seconds if the warning buzz er is sounding) after the vehicle is
driven at the vehicle speed of appr ox. 20 km/h (12 mph) or faster.
The light also turns on when a rear do or is opened and closed while the rear
seat belt is unfastened at approx. 5 km/h (3 mph) or slower.
*9Rear seat belt reminder warning buzzer:
When any of the rear seat passengers un fasten their seat belt when the vehi-
cle speed is approx. 20 km/h (12 mph) or faster, the buzzer will continue to
sound for approx. 30 seconds. Once the warning buzzer starts sounding, it
will continue to sound for approx. 30 seconds even the vehicle is traveling at
approx. 20 km/h (12 mph) or slower.
The buzzer will stop when the rear seat belt is fastened or a rear door is
opened and closed while the vehicle is traveling at approx. 5 km/h (3 mph) or
slower.
*10Parking brake non-release warning buzzer:
The warning buzzer sounds when the vehicle speed reaches approx. 5 km/h
(3 mph) or faster with the parking brake being applied.
RAIZE_OM_General_BZ358E.book 383 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3887-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E ✽
: If equipped
“Engine Control Sys-
tem Malfunction Visit
Your Dealer”
Malfunction in the electronic engine control
system
Electronic control throttle error
➞ Have the vehicle inspected at your Toy-
ota dealer immediately.
“Transmission System
Malfunction Visit Your
Dealer”Malfunction in the e lectronic automatic
transmission control system
✽
➞ Have the vehicle inspected at your Toy-
ota dealer immediately.
“SRS Airbag Malfunc-
tion Visit Your Dealer”
Malfunction in the SRS airbag system
Malfunction in the seat belt pretensioner &
force limiter system
➞ Have the vehicle inspected at your Toy-
ota dealer immediately.
“ABS System Malfunc-
tion Visit Your Dealer”Malfunction in the ABS system
➞Have the vehicle inspected at your Toy-
ota dealer immediately.
“Power Steering Mal-
function Visit Your
Dealer”
(Red)
Malfunction in EPS (Electric Power Steering)
system
The warning buzzer will sound.
➞ Have the vehicle inspected at your Toy-
ota dealer immediately.
“Steering Performance
Is Reduced Steering
Power Low”
(Yellow)
Low battery voltage/Electric power steering
overheating
The warning buzzer will sound.
➞ Steering wheel operation becomes
heavy. Restrain from operating the
steering wheel for a short while. When
about 10 minutes has passed, it will
return to its usual weight.
“Smart Entry & Start
System Malfunction
Visit Your Dealer”Malfunction in th e key-free system
➞ Have the vehicle inspected at your Toy-
ota dealer immediately.
Warning messages
Indicators/
Warning lights
Warning content/Action to take
RAIZE_OM_General_BZ358E.book 388 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3937-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
When trouble arises
7
Situations requiring immediate action
Take action according to each troubleshooting method and check to see if
the key-free system’s wa rning message turns off.
Internal
warning buzzerExternal
warning buzzer
Warning messagesWarning content/Action to take
――“Key NOT Detected”
You tried to start the engine with-
out the electronic key on hand
➞ Keep the electronic key with
you*
1
5
times3
times“Key NOT Detected”
When the engine switch was “ACC”
or “ON”, any of the doors were
opened, and the electronic key was
taken outside the vehicle, and then
the door was closed
⦁The warning buzz er will sound.
➞ Keep the electronic key with you
and get in the vehicle
―1 time“Key Detected in Vehicle”
With the electronic key left inside
the vehicle, someone tried to lock
the doors using the lock/unlock
switch on the front door or back
door
➞ Take the electronic key from the
vehicle and lock it again
―1 time“Key Detected in Vehicle”
When the engine switch was “OFF”
and the electronic key was left
inside the vehicle, the door was
opened and closed while all the
doors were locked and any of the
inside lock buttons except the
driver’s door were set to the
unlocked side
➞ Keep the electronic key with you
and lock the doors
RAIZE_OM_General_BZ358E.book 393 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3947-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E ✽
: If equipped
―1 time“Key Detected in Vehicle”
When the engine switch was “OFF”
and the electronic key was left
inside the vehicle, you opened the
driver’s door and then tried to close
and lock the door with the door
handle pulled while the inside lock
button was set to the locked side
➞ Take the electronic key from the
vehicle and lock it again
――
“Press Brake Pedal and
Touch Engine Switch with
Key”You tried to start the engine 2 times
without the electronic key on hand
➞ Keep the electronic key with
you*
1
――“Auto Power OFF to Con-
serve Battery”
The engine switch turned “OFF”
automatically
⦁It will be displayed after 1 hour or
more when the engine switch is
“ACC”. When it is “ON”, it will be
displayed after 20 minutes or
more.
➞ Set the engine speed to a slightly
higher level when you start the
engine next time, and keep the
same speed for approx. 5 min-
utes and charge the battery
3
times―“Key Battery Low Replace
Key Battery”
The engine switch was turned “OFF”
when the electronic key battery was
close to its end of life*
2
⦁The warning buzz er will sound.
➞ Replace it with a new battery
(➞ P. 344)
Internal
warning buzzerExternal
warning buzzer
Warning messagesWarning content/Action to take
RAIZE_OM_General_BZ358E.book 394 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3957-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
When trouble arises
7
*1If the engine does not start even when the electronic key is placed inside the
vehicle, it is possible that the key is running out of battery. ( ➞P. 344)
*2If the low battery state continues, the message also appears even when the
engine switch is turned to “ACC” or “ON”.
⬛Warning messages
➞ P. 3 9 2
⬛Warning message display
➞P. 3 9 2
⬛Warning buzzers
Depending on the situation, you ma y have difficulty hearing the buzzer
because of the noise outside or audio sound.
――
“Press Engine SW While
Turning Steering Right
and Left”
Unable to unlock the steering
wheel by pressing the engine
switch
➞ Step on the brake pedal and
press the engine switch while
turning the steering wheel right
and left
――“Shift to P and Turn Power
OFF”
You tried to turn “OFF” the engine
switch while the shift lever is placed
in a position other than P
✽
➞Set the shift lever to P
―1 time“Turn Power OFF”
When the engine switch was “ACC”
or “ON”, someone tried to lock the
doors using the lock/unlock switch
on the front or back door
➞ Turn the engine switch to “OFF”
and lock the doors
Internal
warning buzzerExternal
warning buzzer
Warning messagesWarning content/Action to take
RAIZE_OM_General_BZ358E.book 395 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3987-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
WARNING
⚫Do not start the engine or drive the ve hicle while the vehicle is supported by
the jack
⚫Do not raise the vehicle while someone is inside
⚫When raising the vehicle, do not put an object on or under the jack
⚫Do not raise the vehicle to a height greater than that required to replace the
tire
⚫Use a jack stand if it is necessary to get under the vehicle
⚫When lowering the vehicle, make sure that there is no-one near the vehicle.
If there are people nearby, warn them vocally before lowering
Procedure to take out jacks and tools
aSlide the front left seat all the way
forward and partly remove its
cover
b Loosen and remove the jack
aTighten
b Loosen
c Take out the tool bag
KBRO620602E
1
2
KBRO620603N
RAIZE_OM_General_BZ358E.book 398 ページ ２０２２年５月１７日　火曜日　午後１時５９分

4057-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
When trouble arises
7
If the engine does not start
If the engine does not start even though correct starting procedures
are being followed ( ➞P. 184), consider each of the following points:
The engine does not start even though the starter motor operates
normally
One of the following may be the cause of the problem:
⚫There may not be sufficient fuel in the vehicle’s tank.
Refuel the vehicle.
⚫The engine may be flooded.
Try to restart the engine again fo llowing correct starting procedures
( ➞ P. 1 8 4 ) .
⚫There may be a malfunction in th e engine immobilizer system. (➞P. 72)
The starter motor runs slowly, the interior light and headlights are
dim, or the horn does not so und or sounds at a low volume
One of the following may be the cause of the problem:
⚫The battery may be discharged. ( ➞P. 408)
⚫The battery terminal connections may be loose.
If the starter does not operat e (vehicles with key-free system)
⚫There may be an issue in the electrical system, such as a disconnected
electrical component or blown fuse. Depending on the cause, you may
be able to start the engine using temporary measures. ( ➞P. 406)
⚫There may be a malfunction in the steering wheel lock system.
The starter motor does not run, the interior light and headlights do
not turn on, or the horn does not sound
One of the following may be the cause of the problem:
⚫There may be a disconnected battery terminal.
⚫The battery may be discharged. ( ➞P. 408)
Contact your Toyota dealer if the procedures are not clear, or if the engine does not
start even after the measures have been taken.
RAIZE_OM_General_BZ358E.book 405 ページ ２０２２年５月１７日　火曜日　午後１時５９分