ECU AUDI Q5 2015 Workshop Manual

M N
co ~ co
rl I.O
"' N
"' rl
-When conne cting jump er cabl es, make sur e
that they cannot get caught in any moving
parts in the engine compartment.
- Do not bend over the batteries -danger of
chemical burns!
- The battery cell locking screws must be
tightened securely .
- Before you check anything in the engine
compa rtment, always read and heed all
WARNINGS
¢ page 221.
(D Note
Improper hook-up of jumper cables can ruin
the generator.
- Always connect POSITIVE(+) to POSITIVE
(+), and NEGATIVE(-) to NEGATIVE(-)
ground post of the battery manager control
unit.
- Check that all screw plugs on the battery
cells are screwed in firmly . If not, tighten
plugs prior to connecting clamp on negative
battery terminal.
- Please note that the procedure for connect­
ing a jumper cable as described above ap­
plies specifically to the case of your vehicle
being jump started . When you are giving a
jump start to another vehicle, do
not con­
nect the negative(-) cable to the negative
(-) terminal on the discharged battery@
¢
fig. 228. Instead, securely connect the
negative (-) cable to either a solid metal
component that is firmly bolted to the en­
gine block or to the engine block itself. If
the battery that is being charged does not
vent to the outside, escaping battery gas
could ignite and explode !
Towing with a tow truck
General hints
Your Audi requires special handling for towing .
The following information is to be used by com ­
mercial tow truck operators who know how to op­
e rate their equipment safely .
-Never tow your Audi, towing will cause dam­
age to the engine and transmission.
Emergency situations
- Never wrap the safety chains or winch cables
around the brake lines.
- To prevent unnecessary damage, your Audi
must be transported with a flat bed truck.
- To load the vehicle on to the flat bed, use the
towing loop found in the vehicle tools and at­
tach to the front or rear anchorage
¢ pag e 273 and ¢ pag e 274.
A WARNING
--
A vehicle being towed is not safe for passen­
gers. Never allow anyone to ride in a vehicle
being towed, for any reason .
Front towing loop
Do not install the front towing loop unt il it is
needed.

Fig. 229 Fro nt bump er: r em oving th e cover ca p

.·~G
' -
Fig. 230 Fro nt bumper: s crewing in th e tow in g l oo p
The towing loop fits into the threaded hole locat­
ed on the right side of the front bumper and
cov­
ered by a cover when not in use.
.,. Remove the towing loop from the vehicle tool­
kit ¢
page 255.
"' Carefully remove the cover ¢ fig. 229 .
.,. Screw the towing loop tightly into the threaded
hole as far as it will go¢
fig. 230. IJi,,
273

M N
co ~ co
rl I.O
"' N
"' rl
Loading the vehicle onto a flat bed truck
Fig. 233 Veh icle on flat bed truck
Front hook up
• Align the vehicle with the centerline of the car
carrier ramp.
• Attach the winch hook to the front towline eye
previously installed .
Rear hook up
• Align the vehicle with the centerline of the car
carrier ramp.
• Attach the winch hook to the rear towline eye
previously installed.
@ Tips
Check carefully to make sure the hook-up is
secure before moving the car up the flatbed
truck ramp .
Raising the vehicle
Lifting with workshop hoist and with floor
jack
The vehicle may only be lifted at the lifting
points illustrated .
Fig. 234 Front lift ing point
Emergency situations
Fig. 23S Rear lifting point
• Read and heed WARNING ~ .&, .
• Locate lifting points ¢ fig. 234 and ~ fig. 235 .
• Adjust l ifting arms of wo rkshop hoist or floor
jack to match vehicle lifting points.
• Insert a rubber pad between the floor jack/
workshop hoist and the lifting points.
If you must lift your vehicle with a floor jack to
work underneath, be sure the vehicle is safely
supported on stands intended for this purpose.
Front lifting point
The lifting point is located on the floo r pan rein­
forcement about at the same level as the jack
mounting point¢
fig. 234. Do not lift the vehi·
cleat the vertical sill reinforcement.
Rear lifting point
The lifting point is located on the vert ica l rein­
forcement of the lower sill for the on board jack*
¢fig. 235.
Lifting with vehicle jack*
Refer to ¢ page 262 .
A WARNING
-To reduce the risk of ser ious injury and vehi­
cle damage.
- Always lift the vehicle only at the special
workshop hoist and floor jack lift points il­
lustrated
q fig. 234 and ¢ fig. 235.
-Failure to lift the vehicle at these points
could cause the vehicle to tilt or fall from
a lift if there is a change in vehicle weight
distribution and balance . This might hap-
pen, for example, when heavy components
Ill>
275

Consumer information
today's automobiles, have steadily reduced the
scope of maintenance and repairs which can be
carried out by vehicle owners.
Also, safety and
environmental
concerns place very strict limits
on the nature of repairs and adjustments to en­
gine and transmission parts which an owner can perform .
Maintenance, adjustments and repairs usually re­
quire special tools , testing devices and other
equipment available to specially trained work ­
shop personnel in order to assure proper per­
formance, reliability and safety of the vehicle and its many systems.
Improper maintenance, adjustments and repairs
can impair the operation and reliability of your
vehicle and even
void your vehicle warranty .
Therefore, proof of servicing in accordance with
the maintenance schedule may be a condition for
upholding a possible warranty claim made within
the warranty period .
Above all, operational safety can be adversely af­
fected, creating unnecessary risks for you and
your passengers.
If in doubt about any servicing, have it done by
your authorized Audi dealer or any other properly equipped and qualified workshop. We strongly
urge you to give your authorized Audi dealer the
opportunity to perform all scheduled mainte­ nance and necessary repairs. Your dealer has the
facilities, original parts and trained specialists to keep your vehicle running properly.
Performing limited maintenance yourself
The following pages describe a limited number of
procedures which can be performed on your vehi­
cle with ordinary tools, should the need arise and
trained personnel be unavailable. Before per­
forming any of these procedures, always thor­
oughly read all of the applicable text and careful­ly follow the instructions given . Always rigorously
observe the
WARNINGS provided.
Before you check anything in the engine com­
partment, always read and heed all WARNINGS
c::> & and c::> & in Working in the engine compart­
ment on page 221 .
282
A WARNING
-
-Serious personal injury may occur as a result
of improperly performed maintenance, ad ­
justments or repairs.
- Always be extremely careful when working
on the vehicle . Always follow commonly ac­
cepted safety pract ices and general com­
mon sense. Never risk personal injury.
- Do not attempt any of the maintenance,
checks or repairs described on the following
pages if you are not fully familiar with these
or other procedures with respect to the vehi­
cle, or are uncertain how to proceed.
- Do not do any work without the proper tools
and equipment. Have the necessary work
done by your authorized Audi dealer or an­
other properly equipped and qualified work­
shop.
- The engine compartment of any motor vehi­ cle is a potentially hazardous area. Never
reach into the area around or touch the radi­
ator fan. It is temperature controlled and
can switch on suddenly - even when the en­
gine is off and the ignition key has been re ­
moved. The radiator fan switches on auto­
mat ically when the coolant reaches a certain
temperature and will continue to run until
the coolant temperature drops.
- Always remove the ignition key before any­
one gets under the vehicle.
-Always support your vehicle with safety
stands if it is necessary to work underneath
the vehicle. The jack* supplied with the vehi­
cle is not adequate for this purpose and
could collapse causing serious personal in­
jury.
- If you must work underneath the vehicle
with the wheels on the ground, always make
sure the vehicle is on level ground, that the
wheels are always securely blocked and that
the engine cannot be started.
- Always make sure the transmission selector
lever (automatic transmission) is in P (Park
position) and the park brake is applied.

Child restraints Dang er of using child rest raints in th e front
seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
153
System anchors . . . . . . . . . . . . . . . . . . . . . 184
Where can I get additional information
about child restraints and their use? . . . .
189
Child saf ety . . . . . . . . . . . . . . . . . . . . . . . . . . 172
Important safety instructions for using child
safety seats . . . . . . . . . . . . . . . . . . . . . . . .
17 5
Inst alling a child restraint using the LATCH
system
186
Mounting and releasing the anchorage
hook . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
186
Tether anchors . . . . . . . . . . . . . . . . . . . . . . 187
Tether straps . . . . . . . . . . . . . . . . . . . . . . . 187
Child safety locks
Rear doors . . . . . . . . . . . . . . . . . . . . . . . . . . 45
Child saf ety seats
Booster seats . . . . . . . . . . . . . . . . . . . . . . .
180
Convertible child seats . . . . . . . . . . . . . . . 178
Danger of using child restraints in the front
seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
153
H ow do I properly install a child safety seat
. h' l 7 1nm yve1ce ...... .... ... .... .. .. .. . 175
Infant seats . . . . . . . . . . . . . . . . . . . . . . . . 177
LA TCH system . . . . . . . . . . . . . . . . . . . . . . . 186
Lower anchorages . . . . . . . . . . . . . . . . . . . 185
Safety instructions . . . . . . . . . . . . . . . . . . . 17 5
Unused safety belts on the rear s eat . . . .
177
Ch ild seats .. .. ............. .. .. .. .. . 177
Secur ing . . . . . . . . . . . . . . . . . . . . . . . . . . . 181
Cigarette lighter . . . . . . . . . . . . . . . . . . . . . . . 76
C leaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . 208
Cleaning/remov ing ice from windows . . . . . 2 10
Cleaning Alcantar a ......... .... .. .. .. . 211
C leaning artific ial leather. . . . . . . . . . . . . . . 211
Cleaning carbon parts .. .. .. .. .. .. . 210 ,211
C leaning controls .......... .... .. .. .. . 210
C lean ing decorative parts and trim .. .. .. . 210
Cleaning displays . . . . . . . . . . . . . . . . . . . . . 210
C leaning exhaust tail pip es . . . . . . . . . . . . . 209
Clean ing plast ic parts ....... .. .. .. .. .. . 210
Cleaning rims . . . . . . . . . . . . . . . . . . . . . . . . 209
;::J C leaning textiles .............. ... .. .. . 211
co
~ Climate control
~ Air vents . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82 1.1'1 A t t· . l . ~ u oma 1c rec1rcu at1on . . . . . . . . . . . . . . . . 82 ,....,
Index
Operation . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82
Supplementary . . . . . . . . . . . . . . . . . . . . . . 83
Synchroni zing . . . . . . . . . . . . . . . . . . . . . . . . 82
Climate control system . . . . . . . . . . . . . . . . . 80
Climatized cupholder . . . . . . . . . . . . . . . . . . . 75
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Closing
Panoramic slid ing sunroof . . . . . . . . . . . . . .
47
Coat hooks . . . . . . . . . . . . . . . . . . . . . . . . . . . 79
Compass mirror . . . . . . . . . . . . . . . . . . . . . . . 61
Compliance . . . . . . . . . . . . . . . . . . . . . . . . . . 284
Consumer information . . . . . . . . . . . . . . . . . 281
Consumer Information . . . . . . . . . . . . . . . . . 142
Contacting NHTSA . . . . . . . . . . . . . . . . . . . . 142
Convenience
Closing . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
47
Opening . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
Convenience key . . . . . . . . . . . . . . . . . . . . . . . 40
Indicator lights . . . . . . . . . . . . . . . . . . . . . . 88
Locking and unlocking vehicle . . . . . . . . . . . 40
Starting engine (START ENGINE STOP but-
ton) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
87
Stopping the engine (S TAR T E NGINE STOP
button) . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
88
Switching on ignition . . . . . . . . . . . . . . . . . . 87
Convertib le child s afety seats . . . . . . . . . . . 178
Convertible locking retractor
Activating . . . . . . . . . . . . . . . . . . . . . . . . . .
183
Deactivating . . . . . . . . . . . . . . . . . . . . . . . . 184
Using to secure a child safety seat . . . . . . 183
Coolant system . . . . . . . . . . . . . . . . . . . . . . . 227
Cooled cupholder . . . . . . . . . . . . . . . . . . . . . . 75
Cooling box in glove compartment . . . . . . . . 78
Cooling mode (climate control) . . . . . . . . . . . 81
Cooling System
Expansion t ank . . . . . . . . . . . . . . . . . . . . . .
227
Cornering light . . . . . . . . . . . . . . . . . . . . . . . . 54
Cruise control Changing speed . . . . . . . . . . . . . . . . . . . . . . 96
Preselect speed . . . . . . . . . . . . . . . . . . . . . . 96
Switching off . . . . . . . . . . . . . . . . . . . . . . . . 96
Switching on . . . . . . . . . . . . . . . . . . . . . . . . . 95
Warning/ indicator lights . . . . . . . . . . . . . . .
17
Cruising range . . . . . . . . . . . . . . . . . . . . . . . . . 22
287

Index
Remote control key
Unlocking and locking . . . . . . . . . . . . . . . . . 40
Remote rear lid release . . . . . . . . . . . . . . . . . 43
Repair manuals . . . . . . . . . . . . . . . . . . . . . . . 281
Repairs Airbag system 165
Replacing Light bulbs . . . . . . . . . . . . . . . . . . . . . . . . . 269
Replacing wiper blades . . . . . . . . . . . . . . . . . 58
Reporting Safety Defects . . . . . . . . . . . 142, 143
Reset button . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Retracto r . . . . . . . . . . . . . . . . . . . . . . . . . . . . 147
Right hand d rive . . . . . . . . . . . . . . . . . . . . . . . 54
Rims ...... ... .. ................ ... . 249
Roof rack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
Attachment points . . . . . . . . . . . . . . . . . . . . 72
Insta lling the attachments . . . . . . . . . . . . . 73
Installing the roof rack . . . . . . . . . . . . . . . . 73
Roof load . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
Rule of behavior offroad . . . . . . . . . . . . . . . . 202
s
Safe dr iving habits
Safety 135
Airbag system . . . . . . . . . . . . . . . . . . . . . . 152
Belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 144
Ca rgo . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
Cor rect sea ting posit ion . . . . . . . . . . . . . . 136
P eda l area . . . . . . . . . . . . . . . . . . . . . . . . . . 139
Safety belt position . . . . . . . . . . . . . . . . . . . 148
Safety belt he ight ad justment . . . . . . . . . 149
Safety belts worn by p regna nt women . . . 1 49
Safety belt pretens ioner
Service and disposal . . . . . . . . . . . . . . . . . 151
Safety belts . . . . . . . . . . . . . . . . . . . . . . 144, 147
Cleaning . .. .. .. ............. .. .. .. . 210
Danger to passengers who do not wear a
sa fety belt . . . . . . . . . . . . . . . . . . . . . . . . . 145
Fastening . . . . . . . . . . . . . . . . . . . . . . . . . . 147
H eight adjustment . . . . . . . . . . . . . . . . . . . 149
I mp rope rly wor n . . . . . . . . . . . . . . . . . . . . 150
Not wo rn . . . . . . . . . . . . . . . . . . . . . . . . . . 145
Safety belt posi tion . . . . . . . . . . . . . . . . . . 148
Safety ins tructions . . . . . . . . . . . . . . . . . . . 1 46
Securing chi ld safety seats . . . . . . . . . . . . 18 1
294
Special considerations for pregnant wom-
en . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 149
U nfastening . . . . . . . . . . . . . . . . . . . . . . . . 149
Warning/indicator light . . . . . . . . . . . . 17, 144
Worn properly . . . . . . . . . . . . . . . . . . . . . . 146
Safety compliance stic ker . . . . . . . . . . . . . . 277
Safety equ ipment . . . . . . . . . . . . . . . . . . . . . 135
Safety features fo r occ upant restraint and
protection . . . . . . . . . . . . . . . . . . . . . . . . . . . 135
Safety gu idelines
Seat adjustment . . . . . . . . . . . . . . . . . . . . . . 63
Safety instr uctions
E ngine compartment ............. .. .. 2 21
for s ide cu rtain airbags . . . . . . . . . . . . . . . 171
for using child safety sea ts . . . . . . . . . . . . 175
for using sa fety be lts . . . . . . . . . . . . . . . . . 146
Monito ring the Advanced Airbag System . 164
Safety sys tems
Warning/indic ator lights . . . . . . . . . . . . . . . 16
Seat Heating ......... ... ............. .... 82
Number of seats . . . . . . . . . . . . . . . . . . . . 144
Ventilation . . . . . . . . . . . . . . . . . . . . . . . . . . 82
Seat adjustment . . . . . . . . . . . . . . . . . . . . . . . 64
Driver's seat . . . . . . . . . . . . . . . . . . . . . . . . . 63
Front passenger's seat . . . . . . . . . . . . . . . . . 63
Head restra ints . . . . . . . . . . . . . . . . . . . . . 138
Safety gu idelines . . . . . . . . . . . . . . . . . . . . . 63
Seat belts
refer to Safety belts . . . . . . . . . . . . . . . . . . 144
Seating capac ity
Seating position 144
D rive r . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 136
Fron t passenger . . . . . . . . . . . . . . . . . . . . . 13 7
How to ad just the front seats . . . . . . . . . . 137
Incorrect seat position . . . . . . . . . . . . . . . . 139
Occupants . . . . . . . . . . . . . . . . . . . . . . . . . . 136
Rear passengers . . . . . . . . . . . . . . . . . . . . . 138
Sea transpor t
Seats 106
Cleaning ...... .. .................. . 211
Correct seating position . . . . . . . . . . . . . . 136
Se lective cata lytic reduct ion
refer to Ad Blue. .. .. .. ........... .. .. 218
Se lective unlock feature . . . . . . . . . . . . . . . . . 39
Selective wheel torque control (all-wheel
drive) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 191