top BMW 323Ci CONVERTIBLE 2000 E46 Repair Manual

166n
Fully automatic convertible top
*
Closing manually in the event
of an electrical malfunction
Closing the convertible top manu-
ally is best done from the outside
with the driver's door open and the
driver's seat tilted forward. The rear
seat should not be occupied while this
operation is taking place.c
1 Remove the filler piece from between
the rear seats. Remove the trim from
the guide rod and tilt it forward. Press
forcefully on the emergency lock op-
eration (arrow). Doing this will unlock
the mechanisms for the convertible
top compartment lid after a short
delay
46cde071
2 With the luggage compartment lid
closed, open the convertible top
compartment lid all the way
3 Take hold of the convertible top by its
lateral guide section and its front
convertible top frame and lift it out
(arrow). Position the rear convertible
top bar vertically and close the con-
vertible top compartment lid. Flip the
rear convertible top bar downward46cde075
4 Using a screwdriver, lift out the cover
panel in the center of the front con-
vertible top frame
5 Put the dual-end Allen wrench
(stored next to the emergency lock,
see left column) into the hex slot
(arrow)
6 Pull the front convertible top frame
downward as far as possible. Con-
tinue the closing process by turning
the Allen wrench to the left; keep on
turning until the front convertible top
frame is locked onto the windshield
frame. The rear convertible top frame
will be automatically pressed onto
the convertible top compartment lid,
and because of the pressure, will be
sealed off when closed.46cde069

167n
IndexDataTechnologyRepairsCar careControlsOverview
Fully automatic convertible top
*
Please refer to your BMW center
to have the defect corrected.c
In the event of an electrical defect,
never open the convertible top by
hand. The convertible top compartment
lid cannot be locked and would open
while driving.c

169n
IndexDataTechnologyRepairsCar careControlsOverview
Towing the vehicleTow fittingThe screw-in tow fitting is stored in the
onboard tool kit; be sure that it remains
in the vehicle at all times. This fitting
is designed for installation in the tow
sockets located at the front and rear of
the vehicle. It is intended for towing on
paved road surfaces only. This fitting
should not be used to pull a vehicle out
of deep snow, mud, sand, etc.
Always comply with all applicable
towing laws and regulations.Access to tow socketsFront:
Using a screwdriver, press out the cover
panel on the top part of the recess.462de254
Rear:
Using a screwdriver, press out the cover
panel on the top part of the recess.
Screw the tow fittings in com-
pletely and tightly. If you do not,
the threads could be damaged.
Do not tow the vehicle by any compo-
nents of the running gear, or lash them
down in any way. If you do, the compo-
nents could be damaged, leading to
possible accidents.<462de255
Towing with a commercial tow
truck>Do not tow with sling-type equipment
>Use wheel lift or flat bed equipment
>Please comply with applicable state
towing laws.
Never allow passengers to ride in
a towed vehicle for any reason.
Never attach tie-down hooks, chains,
straps, or tow hooks to the tie rods,
control arms, or any other part of the
vehicle suspension. If you do so, severe
damage will occur to these compon-
ents.c46cus031

174n
Radio reception Safety belt tensionerThe AM frequency bands (medium-
wave, long-wave and short-wave)
make it possible to receive stations
from a great distance, because the
broadcast signals travel not only along
the ground as surface waves, but also
as atmospheric waves that are re-
flected from the ionosphere.
Frequency-modulation (FM) provides
substantially better sound quality than
the other frequencies. However,
because FM transmissions rely on line-
of-sight broadcast waves, their effec-
tive reception range is limited. 360de084
The limitations inherent to radio recep-
tion in a moving vehicle have been min-
imized by a number of innovative sys-
tem designs:
The "Radio Data System" (RDS) makes
sure that, for stations broadcasting on
several frequencies, the radio automati-
cally tunes to the frequency with the
best reception quality.
With the Diversity Antenna system, sev-
eral FM antennas are integrated within
the convertible top compartment lid to
provide three separate sources for re-
ceiving broadcast waves. An integral
processor automatically selects the an-
tenna with the best FM reception qual-
ity at any given time. The selection of
the antenna takes place within millisec-
onds, and is therefore not noticed by
the radio listener.The safety belt tensioners respond to
severe head-on collisions by tightening
the belts to ensure that occupants
remain firmly positioned in their seats.
A gas-pressure system retracts the
buckle assembly to tension the shoul-
der and lap belts within fractions of a
second. This reduces the tendency to
slide under the lap belt.
390de330

178n
Self-diagnostics All of the important electrical and elec-
tronic systems in the vehicle are tested
regularly and automatically; the driver
does not have to perform any extra
operations or adjustments.
The indicator lamps come on briefly
when the ignition is switched on.
While you are driving, the functional
status of the actuator motors (for the
windshield wipers, power windows,
seats, etc.) is constantly analyzed by
current measurements in their relays. 46cde052
In the same manner, the electrical re-
sistance of the airbag ignition genera-
tors and all of the remaining airbag
components is measured at all times.
Any fault in this system would be de-
tected immediately by a current fluctua-
tion that would necessarily accompany
it. The fault would be indicated immedi-
ately by the airbag warning lamp.
Even after you shut off the engine, the
overall functional status of your vehicle
is being monitored. For example, all of
the flaps for the heating and ventilation
system travel to the nearest limit posi-
tion. This action ensures that in any
case, the defrosting function will remain
intact, even if a malfunction in the auto-
matic climate control should occur dur-
ing the night while the vehicle is parked.
A calibration cycle runs every tenth time
the engine is shut off. During this cycle,
the actuator motors of all the heating
and ventilation flaps travel to their limit
stops in both directions. The limit posi-
tions and the return travel paths are
checked in this manner in order to en-
sure that appropriate adjustments for
the operating elements can be made at
any time.The sounds the automatic climate con-
trol makes as it carries out its self-diag-
nostics are noticeable because of the
noise that the ventilation flaps make af-
ter the ignition has been switched off.
All of the other self-diagnostics func-
tions operate silently in the back-
ground.
Any possible defects detected during
these self-diagnostics can be read out
by your BMW center and quickly cor-
rected during the vehicle's next regu-
larly scheduled maintenance.

184n
Weights
BMW 323Ci
Curb weight (with one person, ready for operation, full tank of fuel, options not included)
with manual transmission
with automatic transmission
*
lbs. (kg)
lbs. (kg)3,560 (1,615)
3,627 (1,645)
Approved gross vehicle weight
with manual transmission
with automatic transmission
*
lbs. (kg)
lbs. (kg)4,442 (2,015)
4,508 (2,045)
Approved front axle weight lbs. (kg) 2,094 (950)
Approved rear axle weight lbs. (kg) 2,469 (1,120)
Permissible roof load for the hardtop
*
lbs. (kg) 165 (75)
Luggage compartment capacity
with raised convertible top compartmentcu ft (l)
cu ft (l)9.2 (260)
10.6 (300)
Permitted axle loads and permitted total vehicle weight may not be exceeded.

Everything from A to ZAABS (Antilock Brake
System)22, 114
Accessories6
Activated charcoal filter98
Adaptive Transmission
Control (ATC)74, 172
Adding engine oil133
Adding washer
fluid132, 185
Adjust seats53
Adjust the temperature96
Adjusting the steering
wheel58
Air distribution96
Air outlets94
Air pressure123
Air supply97
Airbags21, 63, 146, 173
sitting properly with64
Alarm system42
Antenna120
Antenna, Diversity174
Antifreeze135
Antifreeze, radiator118
Antilock Brake System
(ABS)22, 114
Anti-theft alarm system42
Aquaplaning113, 123
Armrest102
Ashtray
front103
rear104Assisted rear entry56
ATC (Adaptive Transmission
Control)74, 172
Attaching vehicle vacuum
cleaner104
AUC (Automatic recirculated
air control)97
Automatic car washes139
Automatic climate
control94
remove window
condensation97
Automatic cruise control80
Automatic dimming, interior
rearview mirror59
Automatic recirculated air
control (AUC)97
Automatic transmission with
Steptronic22, 74
Automatic windshield
washer78
Average consumption86
Average speed86
Avoiding unwanted
alarm43
Axle loads184
BBackrest
release56
Backup lamps73
bulb replacement155Battery162, 186
capacity186
charge164
charge current20
drained168
removal and
installation164
Belts61
Blower97
BMW High Performance
Synthetic Oils134
BMW Sports Seat55
BMW Universal
Transmitter100
Bore182
Brake fluid136
Brake hydraulic system20
Brake lamps
bulb replacement155
Brake pads22
Brakes116
malfunctions117
Break-in procedure112
Breaking in the vehicle112
Bulb replacement152
CCapacities185
Car Memory60
Car radio120
refer also to the separate
Owner's ManualCar radio
reception120, 174
Car wash139
Care
convertible top144
exterior140
interior141
Care of upholstery142
Cargo loading106
Caring for the vehicle
finish140
Caring for wool velour142
Cassette operation, refer to
the Radio Owner's Manual
Catalytic converter113
CBC (Cornering Brake
Control)21, 115
CD operation, refer to the
Radio Owner's Manual
Cellular phone103, 120
refer also to the separate
Owner's Manual
Center armrest102
Center brake lamp157
Central locking system34
key38
Changing tires159
Check Control84
Child restraint
systems61, 66, 67
installation67
Child's seat61, 66
Everything from A to Z

Everything from A to Z
191n
IndexDataTechnologyRepairsCar careControlsOverview
Cigarette lighter104
Clock84
Cockpit16
Code, refer to the Radio
Owner's Manual
Coin box, cup holder103
Combination switch77
Compression182
Computer85
Configure settings60
Consumption86
Consumption display83
Convertible top
care144
electrical defect166
Convertible top
compartment panel41
Convertible top operation,
fully automatic convertible
top49
Coolant118, 135, 185
antifreeze118
Coolant temperature
gauge83
Cooling system185
Cornering Brake Control
(CBC)21, 115
Cruise control80
Cruising range86
Curb weight184
Current check indicator20
DDash lighting91
Dashboard16
Data
dimensions183
engine182
technical182
weights184
Daytime-driving lamp
switch91
Defrost setting97
Defrosting the
windows97, 98
Digital clock84
Dimensions183
Dipstick, engine oil133
Disc brakes116
Displacement182
Display lighting91
Displays18
Distance warning87
Diversity Antenna174
Door key32
Door locks, care118
Doors
emergency actuation34
remote control35
unlocking and locking34
Drive belts186
Driving hints113
Driving in winter118Driving lamps91
DSC (Dynamic Stability
Control)22, 88, 173
EElectric power windows44
Electrical accessories,
failure165
Electrical system186
Electronic vehicle
immobilizer33
Elements of operation16
Emergency actuation
doors34
fuel filler door165
fully automatic convertible
top166
Emergency closure166
Energy Control82
Engine compartment130
Engine coolant135, 185
Engine data182
Engine oil
capacity185
consumption133
pressure20
quality134
specifications134
viscosity134
Engine oil level21
check133Engine speed182
Engine, starting70
Entry to the rear56
Exterior mirrors58
Eyes169
FFailure messages84
Fault displays84
Fault, ABS115
Filler cap cover26
Filling capacities185
Filling the washer
reservoir185
First-aid kit25
Flashlight99
Flat tire123, 159
Fog lamps92
bulb replacement155
"Follow-Me-Home"
lamps91
Footbrake116
Footwell lamps92
bulb replacement158
Front seat adjustment53
Frost protection,
radiator135
Fuel27
gauge83
preparation182
quality27
Fuel consumption86

Everything from A to ZFuel consumption
display83
Fuel reserve indicator
lamp83
Fuel tank capacity185
Fuel tank gauge83
Fully automatic convertible
top
actuation49
emergency closure166
one-touch operation34
Functional status178
Fuses165GGarage-door opener100
Gasoline27
Gasoline gauge83
Glove compartment99
Glove compartment lamp
bulb replacement158
Grills94
Gross vehicle weight184HHandbrake72
Hands-free system103
Hanging the luggage
compartment floor up by
the hook40
Hardtop121
Hazard warning flashers25Hazard warning triangle25
Head restraints54
Headlamp covers,
care139, 153
Headlamp flasher92
Headlamp washer
system79, 132, 185
Heated seats99
Heater and ventilation94
Heavy loads106
Height183
High beams23, 77, 92
bulb replacement153
Hood release129
Horn17
Hub cap160
IIce warning85
Identification, tires126
Ignition key32
Ignition lock70
Increasing the space in the
luggage compartment41
Indicator lamps20
Inflated pressure27, 123
Inflation pressure
monitoring89, 177
INSPECTION83
Instrument cluster18
Instrument lighting91Interaxle tire rotation125
Interface socket for On-
Board Diagnostics149
Interference
cellular phones120
Interior lamps37, 92
bulb replacement157
remote control37
Interior rearview mirror,
automatic dimming
feature59, 175
Interlock70
Intermittent wipe77
ISOFIX Attachment of the
child seat62
JJack159
Jets94
Jump starting168KKey32
Key Memory60
Key with remote control32L"Lamps on" warning91
Lashing eyes107
Leather care143
Length183License plate lamp
bulb replacement157
Light switch91
Light-alloy wheels128
Lighter104
Load-securing devices107
Low beams91
bulb replacement153
Lug bolts160
Luggage compartment39
capacity184
emergency release39
floor panel41
remote control37
Luggage compartment
lamps
bulb replacement158
Luggage compartment
lid39
emergency release39
Luggage compartment
lighting39
Luggage rack108
Lumbar support56
MM+S tires127
Maintenance83, 138
Malfunction displays84
Manual convertible top
operation in the event of an
electrical malfunction166

Everything from A to Z
193n
IndexDataTechnologyRepairsCar careControlsOverview
Manual transmission73
Manually controlled
recirculated-air97
Memory57
MFL (Multifunction steering
wheel)24
Mirror memory57
Mirrors58
Mobile phones120
Modifications,
technical6, 148
Multifunction steering wheel
(MFL)24NNavigation system, refer to
the Radio Owner's ManualOOBD interface socket149
Odometer82
Oil
additives133
capacity185
consumption133
dipstick133
quality134
specifications134
viscosity134
Oil change intervals, see the
Service and Warranty
Information BookletOil filter change185
Oil level
check133
Indicator lamp20
Oil pressure, indicator
lamp20
OILSERVICE83
Onboard computer85
also refer to separate
Owner's Manual
Onboard tool kit152
Opening and closing
from inside38
from outside34
Operating the convertible
top
manual convertible top45
Outlets, ventilation94
Outside temperature
display85
PPaint blemishes140
Paint, care140
Paintwork, minor
repairs141
Paintwork, waxing141
Park Distance Control
(PDC)87
Parking brake72
Parking help87
Parking lamps92Parking, winter119
PDC (Park Distance
Control)87
Performance182
Pocket lamp99
Pollen98
Power seats53
Power steering120
Power windows44
Pressure monitoring,
tires89, 177
Pressure, tires27, 123
RRadiator185
Radio Data System
(RDS)174
Radio reception120, 174
Radio, refer to the separate
Owner's Manual
Rain sensor78, 176
RDC (Tire Pressure
Control)89, 177
RDS (Radio Data
System)174
Reading lamps93
Rear lamp155
Rear window
defroster79, 98
Rearview mirror58, 59
Reclining seat53
Refueling26Remote control35
Remote control key32
Remove condensation,
windows97
Replacement key32
Reporting safety defects7
Restraint system61, 66
Reverse17, 73
Rollover protection
system68, 179
lowering68
Roof load capacity184
Roof luggage rack108
Roof-carrier assembly121
Rubber parts118
SSafety belt tensioners174
Safety belts61
Safety buttons38
Seat heating99
Seat memory57
Seat-integrated safety belt
system56
Seats
sitting properly53, 64
Securing cargo107
Securing loads107
Selector lever, automatic
transmission74
Self-defrosting mirrors59
Self-diagnostics178