Ant CADILLAC DEVILLE 1994 7.G Owners Manual

Downloaded from www.Manualslib.com manuals search engine VEHICLE IDENTIFICATION NUMBER
(VI.)
El - lG6KD52BXRU200001 IG"I
1 G6 KD 5 2 BX R U200001
1 = USA
MANUFACTURER
G = GENERAL
MOTORS
MAKE
6 = CADILIAC
CARLINE/SERIES -I
KD I= SEDAN DEVILLE
VIN BODY CODE = BODY TYPE
5 = 69SEDAN4DOOR
.-
-I PRODUCTION
SEQUENCE NUMBER
- ASSEMBLY PLANT
U = HAMTRAMCK, MICH.
- MODEL YEAR
R = 1994
- CHECK DIGIT
- ENGINE CODE
B = 4.9 LITER (200 HP)
- RESTRAINT SYSTEM:
2 - ACTIVE (MANUAL) BELTS WITH DRIVER AND
PASSENGERS INFLATABLE RESTRAINT SYSTEM

Downloaded from www.Manualslib.com manuals search engine ADD-ON ELECTRICAL EQUIPMENT
NOTICE:
Don’t add anything electrical to your Cadillac unless you check
with your dealer first. Some electrical equipment can damage
your vehicle and the damage wouldn’t be covered by your
warranty. Some add-on electrical equipment can keep other
components from working
as they should.
Your vehicle has an air bag system. Before attempting to add anything
electrical to your Cadillac,
see “Servicing Your Air Bag-Equipped
Cadillac”
in the Index.
Retained Accessory Power
When you stop your Cadillac and turn the key to Off, you can use these
accessories for
10 more minutes:
Radio
Power Windows
Astroroof
Windshield Wipers
If you open a door, everything will
go off. And, after 10 minutes
everything will go off, also.
If you want power for another 10 minutes, just turn the key to Run and
then back to Off.
313

Downloaded from www.Manualslib.com manuals search engine r I
r i
r‘ I
!- I
r
? ! i
!- i
I
r‘ L
DlSTR SIR PCM (IGN) INJ INJ IGN 1
]mmmmmmri
~mnmmmml
PCM (BAT) RTD BATT A/C COMP HDLPS STOP LP TURN/HAZ
DRL
L HDLP LO
R HDLP LO L HDLP HI R HDLP HI IGN 3 COOL FAN TRANS
I FUSE CENTER IDENTIFICATION
ENGINE COMPARTMENT FUSE BLOCK
DISTR 20A TURN/HAZ 20A
SIR 20A - IGNITION CONTROL MODULE - HAZARD FLASHER
- DIAGNOSTIC/ENERGY RESERVE
- DUAL POLE ARMING SENSOR - DAYTIME RUNNING LIGHTS (CANADA)
- TURN FLASHER RELAY - TURN FLASHER MODULE
MODULE (DERM) DRL 10A (CANADA)
PCM IGN) 10A DRL 10A (CANADA)
- PASS-Key@ DECODER MODULE HTD W/S 1OA
INJ 1OA - HEATED WINDSHIELD CONTROL MODULE
INJ 1OA - LEFT REAR STRUT
IGN 1 10A
- P6WERTRAIN CONTROL MODULE (PCM) - LEFT AND RIGHT LO BEAM HEADLAMP
- 1,4,6, AND 7 FUEL INJECTORS LR STRUT 1OA
- 2,3,5, AND 8 FUEL INJECTORS RR STRUT 10A
- A/C REFRIGERANT PRESSURE SWITCH - TRANSAXLE RANGE SWITCH - STOP/BTSI/CRUISE BRAKE SWITCH - INSTRUMENT PANEL CLUSTER - KEYLESS ENTRY MODULE - DIAGNOSTIC/ENERGY RESERVE MODULE
- RIGHT REAR STRUT LF STRUT 1OA
RF STRUT 1OA
L HDLP LO 1OA
R HDLP LO 10A
L HDLP HI 1OA
R HDLP HI 1OA
IGN 3 10A
- LEFT FRONT STRUT
- RIGHT FRONT STRUT
- LEFT LO BEAM HEADLAMP
- RIGHT LO BEAM HEADLAMP
- LEFT HI BEAM HEADLAMP
- RIGHT HI BEAM HEADLAMP
- REAR DEFOGGER RELAY - ELECTRONIC LEVEL CONTROL (ELC) - HEATED WINDSHIELD - HEATER AND A/C PROGRAMMER - CRUISE CONTROL
LFR2RING
LIGHTS
-
- TURN/HAZARD SWITCH ASSY - CHIME MODULE - HEADLIGHT SWITCH - TWILIGHT SENTINEUDRL MODULE
- FUELPUMP - OIL PRESSURE SWITCH - POWERTRAIN CONTROL MODULE (PCM)
FUEL PUMP 20A
PCM BAT) 10A
RTD (BAT) 20A
A/C COMP 1OA
- POWERTRAIN CONTROL MODULE (PCM)
HDLPS 30A
- P6WERTRAIN CONTROL MODULE pCM) COOLING FAN 1OA - ROAD SENSING SUSPENSION (RSS) MODULE - EXTENDED TRAVEL BRAKE SWITCH
- A/C COMPRESSOR CLUTCH - COOLING FAN RELAYS 1,2, AND 3.
- HEADLIGHT DIMMER SWITCH - HEADLIGHT RELAY “D” (ENGINE COMP MICRO - OVERSPEED ALERT MODULE (EXPORT)
- DRL HEADLIGHT RELAY “E (WITH DAYTIME - POWER STEERING PRESSURE SWITCH - EXHAUST GAS RECIRCULATION (EGR) VALVE
- POWERS C13 - TRANSAXLE SHIFT SOLENOIDS A & B - EVAPORATIVE EMISSION CONTROL SOLENOID
- STOP/BTSI/CRUISE SWITCH - POWERTRAIN CONTROL MODULE (PCM)
- STOPLIGHT SWITCH CAPACITOR - TORQUE CONVERTER CLUTCH SOLENOID - TCC BRAKE SWITCH
- FRONT AND REAR HEATED OXYGEN SENSOR TRANS/ECS 1 OA
RELAY CENTER)
RUNNING LIGHTS)
STOP LP 20A
315

Downloaded from www.Manualslib.com manuals search engine I 60A I
I I 30A
E "
I 60A I
60A
LH MAXI8 FUSE BLOCK
FUSE 1 (50 AMP) (STRG 1-2)
- RETAINED ACCESSORY POWER (RADIO/WIPERS)
- STARTER
- TRUNK COMF FUSES B11 AND 813
FUSE 2 (60 AMP) (BODY)
- ENGINE COMF! B11
- ROAD SENSING SUSPENSION
- FOG LIGHTS
- TRUNK COMF! FUSE C1, C3, C5, C7, C9, AND
c11
- TRUNK COMI? FUSE C13 (EXPORT)
- REAR FOG LIGHT (EXPORT)
CIRCUIT BREAKER 3 (30 AMP) (SEAT)
- LEFT AND RIGHT POWER SEAT SWITCHES
- LEFT AND RIGHT LUMBAR RELAYS
- POWER DOOR LOCKS
- KEYLESS ENTRY MODULE
- HORNS
- FUEL DOOR RELEASE SWITCH
- TRUNK RELEASE SWITCH
FUSE 4 (30 AMP) (IPC)
- POWERTRAIN CONTROL MODULE (PCM)
- ELECTRONIC CLIMATE CONTROL
'- RAPALLUMINATED ENTRY MODULE
- INSTRUMENT PANEL CLUSTER
- PASS-Key@ DECODER MODULE - THEFT DETERRENT
FUSE 5 (SO AMP) (HVAC) - LEFT AND RIGHT HEATED SEATS
- ELECTRONIC LEVEL CONTROL (ELC)
- TRUNK LID PULL DOWN
- POWER ANTENNA
- REAR DEFOGGER - LEFT AND RIGHT MIRROR DEFOGGERS
FUSE 6 (60 AMP) (STRG 3)
- RETAINED ACCESSORY POWER
(SUNROOF/POWER WINDOWS)
- ENGINE COMF! FUSES Dl, D3, D5
- TRUNK COMI? FUSES A1 , A3, A5, A7, A9
RH MAXI8 FUSE BLOCK
CIRCUIT BREAKER 1 (30 AMP) (DAB)
- RETAINED ACCESSORY POWER (RAP)
(SUNROOF/POWER WINDOWS)
FUSE 2 (30 AMP) (RADIO)
- DELCO-BOSEB SPEAKERS
- RADIO CONTROL HEAD
- REMOTE RADIO RECEIVER
FUSE 3 (50 AMP) (COOL)
FUSE
4 (40 AMP) HVAC BLOWER (BLOWER)
- COOLING FANS
- HVAC POWER MOTOR
- A/C COMPRESSOR
FUSE 5 (50 AMP) ABS (BRAKES)
FUSE
6 (50 AMP) (LAMPS)
- BRAKE PRESSURE MODULATOR VALVE
- TURN FLASHER MODULE
- HAZARD FLASHER
- STOP/BTSI/CRUISE BRAKE SWITCH
- PARKING LIGHTS
- DAY TIME RUNNING LIGHTS (CANADA)
- ENGINE COME FUSES 61, B3 AND B5
- TRUNK COMF! FUSES Dl 1, Dl3
316

Downloaded from www.Manualslib.com manuals search engine IGN 1 HDLP WASH IPC (IGN) RTD
~~l~~~mm
WIPER RAD (IGN) R DEFOG HTD MlRR IPC (BATT) THEFT HVAC/DABIE
CIGAR BODY
2 BODY 1 READ LP
L PRK LP
R PRK LP RAD (BAT) TRUNK PLD R HTD SEAT L HTD SEAT
DEVILLE TRUNK COMPARTMENT FUSE BLOCK
CRANK (10 AMP)
- DlAGNOSTlClENERGY RESERVE
- TRANSAXLE RANGE SWITCH (NSSS)
- RAP/ILLUMINATED ENTRY MODULE
MODULE (DERM)
ION 1 (10 AMP) - TRUNWFUEL DOOR RELEASE INHIBIT RELAY "E" - FUEL LEVER SENSOR - ELECTROCHROMIC MIRROR - RAP/ILLUMINATED ENTRY MODULE - THEFT DETERRENT MODULE - KEYLESS ENTRY MODULE - TURN FLASHER RELAY "F TRUNK COMP.
HDLP WASH (30 AMP) EXPORT ONLY
IPC
(ION) (10 AMP) - INSTRUMENT PANEL CLUSTER RTD SUSP (10 AMP)
- ENGINE COMP MICRO REL4Y CENTER
ABS (IO AMP) - ELECTRONIC BRAKE AND TRACTION CONTROL MODULE
(EBTCM)
WIPER (30 AMP) - WIPERMASHER SWITCH RAD (IGN) (10 AMP)
R DEFOG (30 AMP) - REAR DEFOGGER HTD MlRR (10 AMP) - LTAND RT OUTSIDE MIRROR DEFOGGERS IPC (BATr) (10 AMP)
THEFT
(10 AMP) - PASS-Key@ DECODER MODULE - THEFT DETERRENT RELAY "D" (TRUNK COMP.
- THEFT DETERRENT MODULE HVAC/DABIE (10 AMP) - HEATER AND A/C PROGRAMMER
RADIO (30 AMP) - ACTIVE AUDIO AMPLIFIER TRAILER (20 AMP)
ANT
I10 AMP)
MICRO RELAY CENTER
- NOT EQUIPPED
- SPEED SENSITIVE SUSPENSION
RSS DAMPER RELAY "F"
- REMOTE RADIO RECEIVER
- INSTRUMENT PANEL CLUSTER
RELAY CENTER)
- RAP/ILLUMINATED ENTRY MODULE
- NOT EQUIPPED
CIGAR (20 AMP) - LT AND RT REAR CIGARETTE LIGHTERS - FRONT CIGARETTE LIGHTER - CHIME MODULE BODY 2 (10 AMP) - POWER MIRROR SWITCH - RAPRELAY - LOCK-OUT INHIBIT RELAY "A" (TRUNK COMP 1 MICRO
- COURTESY LIGHTS RELAY "C" (TRUNK COME 2 MICRO
RELAY CENTER)
RELAY CENTER)
- RAP RELAY "E (TRUNK COMP. 2 MICRO
RELAY CENTER) - KEYLESS ENTRY MODULE - TRUNKLAMP
- FRONT DOOR LOCK SWITCHES BODY 1 (10 AMP)
- FRONT DOOR COURTESY LAMP - GLOVE BOX LAMP - HEADLIGHT SWITCH READ LP (10 AMP) - LTAND AT FRONT HEADER LAMP - GARAGE DOOR OPENER - LT AND RT REAR HEADER LAMPS L PRK LP (10 AMP) - LT REAR TAlUSTOPrURN LAMPS
- FRONT AND REAR LEFT SIDE MARKER LAMPS - RT REAR MARKER LAMP - HEADLIGHT SWITCH - INSTRUMENT PANEL CLUSTER R PRK LP (10 AMP) - RADIO CONTROL HEAD - RT TAIUSTOP TURN LAMPS - RT FRONT AND REAR SIDE MARKER LAMPS - RT FRONT PARK AND TURN LAMPS - ENGINE COME LAMP - LICENSE PLATE LAMPS RAD (BAT) (10 AMP) - RADIO TRUNK PLD (20 AMP) - TRUNK LID PULL DOWN MOTOR ELC (30 AMP) - ELECTRONIC LEVEL CONTROL (ELC) R HTD SEAT (10 AMP) - PASSENGERS HEATED SEAT
- LT FRONT PARWURN LAMPS
L HTD SEAT (10 AMP) - ANTENNA MOTOR - DRIVER'S HEATED SEAT
318
,

Downloaded from www.Manualslib.com manuals search engine EXhlAUST SYSTEM
Type ............................... Single with Crossover Pipe
Muffler
.................................. One-Reverse Flow
Resonator
............................................ None
Exhaust Pipe
.................................. .Stainless Steel
Intermediate Pipe
............................. ,- Stainless Steel
Tail Pipe
..................................... Stainless Steel
ELECTHCA SYSTEM
Voltage ................................................ 12
Generator ......................................... 140Amp
Ground
........................................... Negative
AIR CONRITIONING SYSTEM
Refrigerant-R134a ............................ .2.0 lbs. (.91 kg)
Not all air conditioning refrigerants are the same.
If the air conditioning
system in your vehicle needs refrigerant, be sure the proper refrigerant is
used. If you’re not sure, ask your Cadillac dealership.
FLUID CAPACITIES
Transaxle (4T60E) .............................. 20 pts. (9.5 L)
Engine Oil ................................... 5.0 qts. (4.7 L)
With Filter Change ............................ 5.5 qts. (5.2 L)
Engine Cooling System ......................... 11 qts. (10.5 L)
Fuel Tank .................................. 20 gallons (76 L)
Power Steering .............................. 1.3 quarts (1.2 L)
Windshield Washer Reservoir .................. 4.2 quarts (4.1 L)
TIGHTEN TORQUE
Spark Plugs ............................... .20 Nm (15 lbs. ft.)
Oil Pan Drain Plug. ......................... 30N.m (22 lbs. ft.)
328
tl
r_
.c-
FC

Downloaded from www.Manualslib.com manuals search engine - Cadillac Owner Privileges sm -
Roadside Service provides several Cadillac Owner Privilegessm at \
"no
charge", throughout your 1994 Cadillac Warranty Period - 48 Months
or 50,000 Miles/80,000 Kilometers.
0 EMERGENCY ROAD SERVICE - is performed on site for the
following situations:
TOWING SERWCE BA'ITF,RY JUMP
START
LOCK OUT ASSISTANCE
FUEL DELIVERY
FLAT TIRE CHANGE (* Covers change only)
* Tire replacement/warranty coverage must be
determined by a Caddac dealer or appropriate
tire manufacturer.
L
f I
.'
I
b -*
2

Downloaded from www.Manualslib.com manuals search engine r
0
r:
i
i
0
- Cadillac Owner Privileges sm -
TRIP INTERRUPTION - If your trip is interrupted due to a
warranty failure, incidental expenses may be reimbursed during
the
48 months or 50,000 miles/80,000 kilometers warranty
period. Items covered are hotel, meals and rental
car.
TRIP ROUTING - Free trip routing assistance is available
during the
48 months or 50,000 miles/80,000 kilometers
warranty period.
Within a week of contacting Roadside Service
with your travel plans, Cadillac
will provide a detailed trip
routing.
Along with your first trip routing, you will receive a
Rand McNdy North American Road Atlas.
3

Downloaded from www.Manualslib.com manuals search engine mat Will Roadside Service Cost You ? ? ?
There is no cost to call the toll-free Roadside Service number. Many
times Roadside Advisors
can assist you over the phone.
There
is no cost for Roadside Service if the repair is under warranty or
the provided service is one of the covered Emergency Road Services.
If a dealership Service Technician travels to your location, and t\
he
$emir
is not covered under warranty, there is a nominal service fee to
cover
the technician's travel to and from your location. Labor is
charged at one and
half times the Cadillac dealership retail labor rate,
with a
30 minute minimum. There is also a charge for any parts used
and a mileage fee if the technician travels beyond 30 miles.
How Do You Pay For Roadside Service ? ? ?
Payment is due at the time services are performed if it is determined
they are non-warranty related. Payment may be made by cash, personal
check or
any major credit card honored by the participating Cadillac
dealership, tow service or locksmith.
In some instances where warranty determination cannot be made, the
charges
must still be paid. Retain the bill and submit it to an authorized
Cadillac dealership Service Department for review. If the repair\

is
determined to be covered by warranty the dealer will expedite
reimbursement directly to you.
II
4

Downloaded from www.Manualslib.com manuals search engine Who Will Repair Your Cadillac At Roadside ? ? ?
In many cases, the advisor at the Roadside Service Center can provide
instructions to get you back on the road.
To resolve more complex problems, the advisor
will page an
experienced Cadillac dealership Service Technician. The technician\

will
call you and evaluate the possible cause. If a roadside repair is possible,
the technician will come to your location and provide a permanent or
temporary repair.
What I Your Cadillac Is In An Unsafe Location Or
On A t irnited Access Highway ? ? ?
If your car is located in an area that is determined to be unsafe (by you,
the advisor or the technician) or if the vehicle is on a limited access
freeway or regulated highway, the advisor
will arrange to tow your
Cadillac to a safe location, where service can be performed. Additional
assistance
will be provided if necessary.
WItat If Your Cadillac Cannot Be Repaired
At Roadside ? ? ?
If your car cannot be repaired at roadside within a reasonable period of
time (approximately
45 minutes) or requires the resources of a Cadillac
dealership service facility,
the advisor will arrange a tow service for you.
Towing may also be necessary after the technician has attempted a
repair, but determines that your car cannot be repaired at roadside.
Tow services are provided by independent companies,
so therefore,
Cadillac
is not responsible for the tow company. During the 48 months
or
50,000 miles/8O,OOO kilometers warranty period, towing services are
covered for
any disablement.
6