CHEVROLET CAMARO 1967 1.G Chassis Workshop Manual

SPECIFICATIONS 24

CHEVROLET

Engine and Body Styles

All. Engines, All Styles except

Those Shown Below

427 V-8 Super Sport 2-Door Coupe and

Convertible (Z-24 Option)

All Engines, Station Wagon
Tire

14 Inch

8.25

8.25

8.55
Usage

STANDARD TIRE

15 Inch (With Disc

8.15

G70-15

8.45 (8-Ply Rating,
Brakes)

4-Ply)
OPTIONAL TIRE

14 Inch

8.25 (a-Ply Rating,

4-Ply)

. —. ...

8.55 (8-Ply Rating,4-Ply)

All tires listed are 4-Ply Rating, 2-Ply except where indicated.

Recommended Tire Inflation Pressures—Pounds per Square.Inch (Cool)

' Models

All Models Except Station

Wagons

Station Wagons (Without Disc

Brakes—14" Wheels

Station Wagons (With Disc

Brakes-15" Wheels)
Tire Ply-

4 Ply Rating-2 Ply

8 Ply Rating-4 Ply

4 Ply Raging—2 Ply

8 Ply Rating-4 Ply

8 Ply Rating-4 Ply
Standard Inflation

for All Loads

Including Full Rated

1 to 6 Passengers

+ 200 lbs. luggage

(1100 lbs. load)

Front

24

24
Rear

28

28

1 to 6 passengers (2 Seat)

+ 300 lbs. cargo

or 1 to 8 pass. (3 Seat)

(1200 lbs. load)

Front

22

22
Rear

32

32

1 to 6 passengers (2 Seat)

+ 300 lbs. cargo

or 1 to 8 pass. (3 Seat)

(1200 lbs. load)

Front

22
Rear

34
Optional Inflation

ior

Reduced Loads

1 to 5 passengers

(750 lbs. load)

Front

"24~

24
Rear

24

24

1 to 5 passengers

(750 lbs. load)

Front

22

22
Rear

26

26

1 to 5 passengers

(750 lbs. load)

Front

22
Rear

26

1.
Tire inflation pressures may increase as much as

six (6) pounds per square inch (PSI) when hot

2.
For continuous high speed operation (over 75 MPH)

increase tire inflation pressures four (4) pounds per

square inch .over the recommended pressures up to

a maximum of 32 pounds per square inch cool for

4-ply rating tires or 40 pounds per square inch for

8-ply rating tires. Sustained speeds above 75 MPH

are not recommended when the 4 pounds per square

inch adjustment would require pressures greater

than the maximums stated above.

3.
Cool tire inflation pressure? after vehicle has been

inoperative for three (3) hours or more, or driven

less than one (1) mile.
Hot tire inflation pressure: after vehicle has been

driven ten (10) miles or more at 60-70 MPH.

4.
Station Wagon loads should be distributed as far

forward as possible.

5. Vehicles with luggage racks do not have a load

limit greater than the l,000# loads (l,200# for

Station Wagons) specified in the Tire Inflation

Pressure Table.

6. When towing trailers, the allowable passenger and

cargo load must be reduced by an amount equal to

the trailer tongue load on the trailer hitch.

CHEVROLET CHASSIS SERVICE MANUAL

SPECIFICATIONS 25

BODY AND CHASSIS ELECTRICAL

SECTION
12

LAMP USAGE
CANDLE

POWER
BULB

NUMBER

Headlamp Unit

Chevrolet, Chevelle & Corvette

Outer - High Beam

Outer - Low Beam

Inner -• High Beam only

Chevy H

High Beam . .

Low Beam

Parking Lamp and Directional Signal

All Exc. Camaro

Camaro

Tail, Stop and Directional Signal (Exc. Bel Air)

Backing Lamp ••...,

Instrument Illumination Lamps

Chevrolet & Camaro ,

Chevelle and Chevy n

Corvette

Temperature Indicator

Chevrolet & Camaro

Chevelle and Chevy II .............

Oil Pressure Indicator

Chevrolet & Camaro .............

Chevelle and Chevy II

Generator Indicator

Chevrolet & Camaro .

Chevelle and Chevy n ,

Hi-Beam Indicator

Chevrolet & Camaro <

Chevelle and Chevy II

Corvette , . • . ,

Directional Indicator

Chevrolet & Camaro

Chevelle & Chevy II . .

Corvette . .

Cigarette Lighter Lamp

Corvette .

Ignition Lock Lamp

Chevrolet . . .

Corvette . . .

Heater or A/C Control Panel

Chevrolet, Chevelle, Chevy n & Camaro . . .

Corvette . . .

Glove Box Lamps

Chevrolet, Chevelle, Chevy n & Camaro . . .

Corvette . . . . .

Dome and Courtesy Lamps

Cartridge Type (AU)

Bayonet Type (Exc. Corvette) . . .

Corvette ,

Convertible . .
37 1/2 Watts

55 Watts

37 1/2 Watts

55 Watts

45 Watts

4-32

4-32

4-32

Special Fiber

1

2

3

2

3

12

6

6

6
Optic
4002

4002

4001

6012

1157

1034-A

1157

1156

194

1895
.

1816

194

1895

194

1895

194

1895

194

1895

1445

194

1895

1816

1445

Wiring

1445

1895

1893

1895

1893

211

89,
212

90

631

CHEVROLET CHASSIS SERVICE MANUAL

SPECIFICATIONS 26

LAMP USAGE (Cont'd.)
CANDLE

POWER

1

6

4

2

3

2

2

3

2

3

15

15
BULB

NUMBER

1445

212

67

1893

1816

194

1895

1816

257

1816

1003

93
Seat Separator-Compartment Lamp . . . . .

-Courtesy Lamp •

License Plate Lamp . .

Radio Dial Lamp

Chevrolet, Chevelle, Chevy n & Camaro

Corvette

Brake Alarm Lamp

. Chevrolet & Camaro . . .... . .

Chevelle & Chevy n . . . . .'. ;v . . . .

Corvette . . . . . . . .

Headlamp Mqtor Warning Lamp (Flashing) .

Clock Lamp (Corvette) .''> ....

Luggage Compartment Lamp. . ... . . . •

Underhood

FUSES AND CIRCUIT BREAKER

A circuit breaker in the light control switch protects

the headlamp circuit, thus eliminating one fuse. A

separate circuit breaker protects the power window,

seat and top circuits. On Corvettes the headlamp motor
circuit is also protected by a separate circuit breaker.

Where current load is too heavy, the circuit breaker

rapidly opens and closes, protecting the circuit until

the cause is found and eliminated.

louses located in the Fuse Panel under the instrument panel are:

Wiper (Chevrolet, Chevelle, and "F" Car) 3AF/AGC 20 Amp.

Back-up Lamp and Gauges. . . 3AG/AGC 10 Amp.

Heater - Air Conditioning 3AG/AGC 25 Amp.

Radio 3AG/AGC 10 Amp.

Radio - Wiper (Chevy II and Corvette) 3AG/AGC 20 Amp.

Instrument Lamps 3AG/AGC . 4 Amp.

Stop and Tail Lamps ........ t 3AG/AGC 20 Amp.

Clock, Lighter, Courtesy Lamps, and Hazard Warning 3AG/AGC 20 Amp.

In-Line Fuses:

Air Conditioning High Blower Speed Fuse located in wire running

from horn relay to A/C Relay

Comforton and Four Season SAE 30 Amp.

Universal & All Weather (Chevy H) SAE 20 Amp.

Fusible Links: ,

Pigtail lead at battery positive cable (except Corvette) 14 gage brown wire

Molded splice at Solenoid "Bat" terminal (Corvette only) 14 gage brown wire

Molded Splice Located at the horn relay 16 gage black wire

Molded splice in Voltage Regulator #3 terminal wire 20 gage orange wire

Molded splice in Ammeter circuit (Both sides of meter) 20 gage orange wire

CHEVROLET CHASSIS SERVICE MANUAL

SPECIFICATIONS 27

WINDSHIELD WIPERS

Non-Depressed Park Two
Speed

Operation

Test Voltage 12 V.

Crank Arm Rotation CCW

Current Draw

No Load 3.6 Max.

Dry W/S . . , .4.5 Max.

Stall . 12 Max.

Crank Arm

Speed (RPM's)

Low 34 Min.

Hi 65 Min.
Depressed Park—Chevrolet & Corvette Two Speed

Operating Voltage 12 VDC

Gear Ratio 3.36:1

Crank Arm Rotation (Looking at Crank Arm) Clockwise

Crank Arm Speed (No Load)

Lo.
34 RPH^/min.

Hi .65 RPM/min.

Current Draw (amperes)

No load (low speed) 3.6

Installed in Car (dry windshield) ......... 4.5

Stall . 12

Shunt Field Resistance (OHMS) 24

WASHER PUMP

Number of "squirts" at full pressure 12

Pressure (PSI) . 11-15

Coil Resistance (OHMS) . . 20

CHEVROLET CHASSIS SStVK* MANUAL

SPECIFICATIONS 28

BUMPERS

SECTION 14

TORQUE SPECIFICATIONS

Application

Front Bumper to Bumper

Bracket Nuts

Front Bumper to Bumper

Brace Nuts

Front Bumper to Bumper

Brace Lower Nuts

Front Bumper to Center

Brace Bolts

Front Bumper to Outer

Brace Bolts

Front Bumper to Inner

Brace Bolts

Front Bumper to License

Plate Bracket Nuts

Front Bumper Bracket

to Frame Bolts

Front Bumper Bracket
&

Brace to Frame Nuts

Front Bumper Bracket
&

Brace to Frame Bolts

Front Inner Brace to

Frame Crossmember

Nuts

Front Bumper Bracket

to Frame Nuts

Front Outer Brace &

Center Brace to

Frame Bolts

Gas Tank Filler Door

to Rear Bumper Nuts

Rear Bumper to Frame

Crossmember Nuts

Rear Bumper to Bumper

Bracket Nuts

Rear Bumper to Bumper

Brace Nuts
Chevrolet

30 lb. ft.

30 lb. ft.

—

—

53 lb. ft.

—

53 lb. ft.

43 lb. ft.

ZQ
lb. ft.

30 lb. ft.
Chevelle

24 lb. ft.

24 lb. ft.

39 lb. ft.

_

53 lb. ft.

53 lb. ft.

-

43 lb. ft.

—

30 lb. ft.

(45 lb. ft.

for station

wagon & El

Camino)

30 lb. ft.
Chevy U

30 lb. ft.

30 lb. ft.

—.

—

_

28 lb. ft.

—

—

30 lb. ft.

—
Corvette

—

—.

—

30 lb. ft.

30 lb. ft.

43 lb. ft.

85 lb. ft.

_

30 lb. ft.

30 lb. ft.

_

30 lb. ft.

30 lb. ft.
Camaro

25 lb. ft.

25 lb. ft.

_.

mm

M.

,__

__

50 lb. ft.

50 lb. ft.

—

17 lb. ft.

17 lb. ft.

CHEVROLET CHASSIS SERVICE MANUAL

SPECIFICATIONS 29

TORQUE SPECIFICATIONS (CONT'D)

Application

Rear Center Reinforce-

ment to Frame Nuts

Rear Bumper Bracket to

Frame Nuts

Rear Bumper Braces to

Frame Nuts

Rear Bumper Bracket &

Brace to Frame Nuts

Rear Bumper Bracket &

Brace to Frame Bolts

Rear Bumper Spacer to

Bumper Nuts

Rear License Plate

Bezel to Body Screws
Chevrolet

—

50 lb. ft.

—

25 lb. ft.

-
Chevelle

30 lb. ft.

(45 lb. ft.

for station

wagon & El

Camino)

53 lb. ft.

53 lb. ft. ,

—

-
Chevy H

—

28 lb. ft.

—

28 lb. ft.

—
Corvette

—

—

30 lb. ft.

_

—

—

13 lb. in.
Camaro

—

—

—

—

ACCESSORIES

SECTION 15

CRUISE-MASTER

Solenoid Resistance . . . . • . 5 ohms 1/4 ohm

Solenoid Wire Resistance 40 ohms

Maximum allowable Vacuum Leahage Rate for Servo Unit 5 inches of Vacuum

Operational Test Speed . 50 mph

CHEVROLET CHASSIS SERVICE MANUAL

ft *

HA

#4....

V

VXL.
. ...

14

%2

"AA

"Aa

™AA

3/8

*HA

"A*

7M

2%i.

"AA

Vi
DECIMAL
EQUIVALENTS

.015625

.03125

.046875

.0625

.078125

.09375

:
.....
.109375

.125

.
.140625

.15625

171875

.1875

.203125

.21875

.234375

.25

.265625

.28125

.296875

.3125

.328125

.34375

.359375

.375

.390625

40625

.421875

.
.4375

.453125

.46875

.;
. ..
.484375

.5
33y*4

3&

%

*\u

*U4._

%

%

«!<4

S^4

2%2

SHA

%

»»b

"A*
.515625

53125

.546875

.5625

. ....
.578125

.59375

.
609375

.625

640625

.65625

.671875

.
.6875

703125

.
.71875

.734375

.75

765625

78125

796875

8125

.
...828125

.84375

..
.859375

875

890625

.90625

921875

9375

953125

...
.96875

984375

Letter

Sizes

Z

. Y

X

w

V

u

T

S

R

Q

P

0

N

M

L

K

J

1

H

G

F

E

D

G

B

A
Drill

Diam.

Inches

0.413

0.404

0.397

0.386

0.377

0.368

0.358

0.348

0.339

0.332

0.323

0.316

0.302

0.295

0.290

0.281

0.277

0.272

0.266

0.261

0.257

0.250

0.246

0.242

0.238

0.234
Wire

Gage

Sizes

1

2

3

4

5

6

7

8

9

10

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27
DRILL

Drill

Diam.

Inches

0.2280

0.2210

0.2130

0.2090

0.2055

0.2040

0.2010

0.1990

0.1960

0.1935

0.1910

0.1890

0.1850

0.1820

0.1800

0.1770

0.1730

0.1695

0.1660

0.1610

0.1590

0.1570

0.1540

0.1520

0.1495

0.1470

0.1440
SIZES

Wire

Gage

Sizes

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44

45

46

47

48

49

50

51

52

53

54
Drill

Diam.

Inches

0.1405

0.1360

0.1285

0.1200

0.1160

0.1130

0.1110

0.1100

0.1065

0.1040

0.1015

0.0995

0.0980

0.0960

0.0935

0.0890

0.0860

0.0820

0.0810

0.0785

0.0760

0.0730

0.0700

0.0670

0.0635

0.0595

0.0550
Wire

Gage

Sizes

55

56

57

58

59

60

61

62

63

64

65

66

67

68

69

70

71

72

73

74

75

76

77

78

79

80
Drill

Diam.

Inches

0.0520

0.0465

0.0430

0.0420

0.0410

0.0400

0.0390

0.0380

0.0370

0.0360

0.0350

0.0330

0.0320

0.0310

0.0292

0.0280

0.0260

0.0250

0.0240

0.0225

0.0210

0.0200

0.0180

0.0160

0.0145

0.0135

GAGES

GAGE
NO.

0000000

000000

00000

0000

000

00

0

1

2

3

4

5

6

7

8

9
o

11

12

13

14

15

16

17

18

19

20

21

22

23

24

25

26

27

28

29

30

31

32

33

34

35

36

37

38

39

40

41

42

43

44
U.
S.
STANDARD
GAGE*

Approx.
Thickness—Inches

0.490

j
60

29

.398
*

.368

.337

.306

.2757

.2604

.2451

.2298

.2145

.1991

.1838

.1685

.1532

.1379

.1225

.1072

.0919

.0766

.0689

.0613

.0551

.0490

.0429

.0368

.0337

.0306

.0276

.0245

.0214

.0184

.0169

.0153

.0138

.0123

.0107

.0100

.0092

.0084

.0077

.0069

.0065

.0061

.0057

.0054

.0052

.0050

.0048

.0046
AMERICAN
WIRE
or
B
*
S
GAGE

Thickness—Inches

0.5800

.5165

.4600
.

.4096

.3648

.3248

.2893

.2576

.2294

.2043

.1819

.1620

*
L443

285

144

.1019

.0907

0808

.0720

.064!

.057

.0508

.0453

.0403

.0359

.0320

.0285

.0253

.0226

.0201

.0179

.0159

.0142

.0126

.0113

.0100

.00893

.00795

.00708

.00630

.00561

.00500

.00445

.00397

.00353

.00314