fuel CHEVROLET TRACKER 1993 Owner's Guide

ITEM
NO. SERVICE
11 Fuel Tank, Cap and Lines Inspection** -
Inspect fuel tank, cap, lines and hoses for damage or
leaks. Inspect fuel cap gasket for an even filler neck
imprint or any damage at
30,000 miles (50 OOO km).
Replace parts as needed. Replace the cap and gasket
at
60,OOO mile (100 OOO km) intervals.
12 Oxygen Sensor Replacement* - Replace at 80,000
miles (133 OOO km).
ITEM
NO. SERVICE
13 Charcoal Canister Replacement* - Replace at
100,OOO mile
(166 OOO km) intervals.
14 Engine Control Module (ECM) and Associated
Sensors Inspection*
- Inspect at 100,OOO mile
(166 OOO km) intervals.
15 Fuel Injector Inspection* - Inspect at 100,OOO
mile (166 OOO km) intervals.
*An Emission Control Service.
*The
U. S. Environmental Protection Agency has determined that the failure to pe~orm this maintenance item will not nullify the emission
warranty or limit recall liability prior to the completion
of vehicle useful life. General Motors, however, urges that all recommended
maintenance services be pe~ormed at the indicated intervals and the maintenance be recorded in “Section
E: Maintenance Record. ”
ProCarManuals.com

Other Emission Related Mainfenance Setvice
ITEM
NO. SERVICE
1 Valve Clearance Adjustment* - Inspect the valve
lash every
15,000 miles (25 000 km) and adjust if
necessary.
2 Camshaft Timing Belt Adjustment* - Inspect and
adjust if necessary at
60,000 miles (100 OOO km), and
every 30,000 miles (50 OOO km) thereafter.
3 Fan (Water Pump) Drive Belt Service* - Inspect
and adjust if necessary at
30,000 miles (50 000 km), or
30 month intervals. Replace the belt at 60,000 miles
(100
OOO km) and 120,000 miles (200 OOO km).
*An Emission Control Service.
ITEM
NO. SERVICE
4 Wiring Harness and Connectors Inspection* - At
60,000 miles (100 OOO km), or 60 month intervals,
inspect
the underhood wiring harness for loose
connections, chafed wires and damage, especially if
used extensively for off-road driving.
underhood label specifications,
if necessary, at
60,000 mile (100 000 km) intervals.
6 Fuel Filter* - Replace the fuel filter every 30,000
miles (50 OOO km), or sooner if clogged.
5 Engine Timing Check* - Adjust the timing to
295 9
ProCarManuals.com

Maintenance Schedule
Section B: Owner Checks and Services
Listed below are owner checks and services which should be
performed at the intervals specified to help ensure the
safety, dependability and emission control performance of
your vehicle. Be
sure any necessary repairs are completed at once.
Whenever any fluids or lubricants are added to your vehicle,
make sure they are the proper ones, as shown
in Section D.
Af Each Fuel fj// (It is important for you or a service station attendant to perform these underhood checks at \
each fuel fill.)
1
CHECK
1 OR SERVICE I WHAT TO DO
I Engine Oil Level Check the engine oil level and add the proper oil if necessary. See “Engine Oil” in the Index for
further details.
I
I Engine Coolant Level Check the engine coolant level in the coolant recovery tank and add the proper coolant mix if
1 necessary. See “Coolant” in the Index for further details.
Windshield Washer
Fluid Level
Hood Latch
Operation Check
the windshield washer fluid level in the windshield washer tank and add the proper fluid if
necessary. See “Windshield Washer Fluid” in the Index for further details.
Pull the primary hood latch release handle inside the vehicle. The secondary latch should keep
hood from opening all the way when the primary latch is released. Make sure the hood closes
firmly. See
“Hood Release” in the Index for further details.
... 298
ProCarManuals.com

USAGE
Transfer Case (Four-wheel Drive)
Hood Latch Assembly
a. Pivots and Spring
b. Release Pawl
Anchor
Hood, Door,
and
Liftgate Hinges, Rear Folding Seat,
Fuel Door
Hinge, Rear Compart-
ment Lid Hinges
Weatherstrips Constant Velocity
Universal Joint
FLUID/LUBRICANT
SAE 75W-90, GL-4 gear lubricant (GM Part No. 12345871).
a. Engine oil.
b. Chassis lubricant meeting requirements
of NLGI Grade 2, Category LB or GC-LB
(GM Part No.
1052497 or equivalent).
Engine oil.
Dielectric Silicone Grease (GM Part
No. 12345579) or equivalent.
Chassis lubricant meeting requirements
of NLGI Grade 2, Category LB or GC-LB (GM Part No.
1052497 or equivalent).
See “Replacement Parts” in the Index for recommended replacement filters, valves and spark plugs.
307
ProCarManuals.com

In Mud. Sand. Snow. or Ice ...... 155
In the Rain
.................... 160
In Water ...................... 156
Long Distance
................. 167
On Curves
.................... 132
On Grades (With a Trailer)
....... 184
On Off-Road Hills.
............. 145
On Snow or Ice
................ 174
On the Freeway
................ 165
Suggestions.
A Few More Night . . 159
Uphill
........................ 147
Winter
....................... 173
With a Trailer
................. 182
Drunken Driving
................ 123
Easy Entry Seats
................. 14
Electrical Equipment. Add-on
...... 272
Emergencies. Braking
in .......... 132
Emergencies. Steering
in ......... -134
Engine
Coolant
...................... 240
Coolant Temperature Gage
........ 85
Exhaust
....................... 64
Identification
.................. 272
Oil
.......................... 229
Oil Pressure Light
............... 86
Overheating
................... 200
Specifications
................. 277
Starting Your
................... 49
Through
Deep Standing Water
..... 50 Environment.
Your Vehicle and the
. 282
Exhaust. Engine
.................. 64
Extender. Safety Belt
.............. 39
Fabric Protection
.................... 264
Using Solvent-Type Cleaner on
... 263
Features and Controls
.............. 43
Filling Your Tank (Fuel)
.......... 226
Filter Replacement. Air
........... 234
Flashers. Hazard Warning
......... 190
Flat Tire. Changing a
............. 208
Flat. If a Tire Goes
............... 208
Fluid Using Foam-Type
Cleaner on
..... 263
Five-Speed Manual Transmission
.... 54
Flow-Through Ventilation System
... 106
Automatic Transmission
......... 234
Manual Transmission
........... 237
Recommended
............ 27 1. 305
Windshield Washer
............. 244
Fog. Tips
on Driving in ........... 163
Folding Rear Seats
................ 15
Following Distance (With
a Trailer)
..................... 183
Foreign Countries. Fuels
in ........ 225
Four-wheel Drive
........... .57. 239
Power
Steering
................ 243
Fog. Mist and Haze. Driving
in ..... 162
Foreign Material Paint Damage
..... 269 Four-Wheel-Drive
Vehicle.
Freeway Off-Road
Driving with Your Geo
. . 140
Driving
...................... 165
Driving on the
................. 165
Entering the
................... 165
Leaving the
................... 165
Free-Wheeling Hubs
.............. 58
Automatic
..................... 59
Manual
........................ 59
Fuel
........................... 223
FuelGage
....................... 83
Fuel Tank Filling
................ 226
Fuels
in Foreign Countries ......... 225
Fuse Block. Instrument Panel
...... 275
Fuse Block. Main
................ 274
Fuses and Circuit Breakers
......... 273
Gage. Engine Coolant Temperature
. . 85
Gage. Fuel
...................... 83
Gages and Indicators. Warning
Lights
......................... 82
Gasolines for Cleaner Air
.......... 224
Glass Cleaning
.................. 266
GloveBox
....................... 75
GM Participation
in Better
Business Bureau Mediation/
Arbitration Program
............ 315
Grips. Passenger Assist
............ 76
Guidelines. Utility Vehicle Driving
. . 140
327 9
ProCarManuals.com

Index
Stains .......................... 264
Stalling on an Incline ............. 154
Starting Your Engine .............. 49
Starting. Jump ................... 191
Steam (Engine Overheating) ...... -200
Steering ........................ 132
Fluid, Power .................. 243
In Emergencies ................ 134
Power ....................... 132
Storage and Compartments ......... 75
Storage. Vehicle ................. 247
Stuck: In Sand. Mud. Ice or
Snow, If You’re
............... 2 17
Sun Visors ....................... 76
Sunroof. Opening and
Closing Your
................... 89
Switch, Ignition .................. 48
Symbols. Safety Warnings and ....... 6
Symbols. Vehicle ................. 18
Tachometer ..................... 82
Tailgate (Door Locks) ............. 46
Tank, Filling Your (Fuel) .......... 223
Temperature Gage, Engine
Coolant
....................... 85
Terrain. Scanning the ............. 144
Theft ........................... 47
Tips ......................... 132
Stuck in Deep Snow, If You’re ..... 177
Symbols on Road Signs ........... 120
Theft Deterrent Feature
(AM/FM Stereo with Cassette
Tape Player)
................ 1 13
Thermostat ..................... 243
Tilt Wheel ...................... -67
Tires .......................... 253
Balance ...................... 259
Chains ....................... 26 1
Changing a Flat
................ 208
Cleaning White Sidewall ........ 269
Inflation Pressure .............. 254
Inspection .................... 255
Loading Information Label ....... 252
New ......................... 256
Rotation ...................... 255
Temperature Grades ............ 258
Total Weight on Your Vehicle’s. .. 180
Traction Grades ................ 258
Treadwear .................... 258
Uniform Quality Grading ........ 257
AM/FM Stereo ................ 109
AM/FM Stereo with
Cassette Tape Player
.......... 1 1 1
Tone, Setting the
Top Strap (Child Restraint)
......... 33
Top, Convertible ................. 87
Storage ........................ 96
Top, Preparing Your Canvas for
Top, Removing and Installing
Your Canvas
................... 91
Torque Lock .................... 173
Towing a Trailer ................. 177
Towing Hook.Ups. Front ......... -198
Towing Hook.Ups. Rear .......... 199
Towing Your Vehicle ............. 196
Towing. Recreational ............. 186
From the Front ................ 187
From the Rear ................. 186
Traffic Lights ................... 120
Traffic Officer .................. 122
Trailer
Backing Up with a
.............. 183
Brakes
....................... 181
Driving on Grades .............. 184
Driving with a ................. 182
Following Distance with a ....... 183
Hitches ....................... 180
If You Do Decide to Pull a ....... 178
Making Turns with a ............ 183
Parking on Hills with a .......... 184
Passing with a ................. 183
Safety Chains ................. 181
Tongue, Weight of the .......... 180
Towing a ..................... 177
Towing. Maintenance When ..... 185
Turn Signals When Towing a ..... 183
Weight of the .................. 179
When You Are Ready to Leave
after Parking on a Hill
......... 185
ProCarManuals.com