light CHEVROLET TRACKER 2004 2.G Manual PDF

Engine Compartment Fuse Block
The engine compartment fuse block is located in the
engine compartment on the passenger's side of
the vehicle and protects all electrical loads. See
Engine
Compartment Overview on page 5-12for more
information on location.For access to the main fuses, pull off the cover.
Fuses/Relays Usage
1 Accessory Power Outlet
2 Electronic Fuel Injection System
3 Right Headlamp
4 Left Headlamp, High-Beam Indicator
5 Heater
6Hazard Lamps, Rear Combination
Lamps, Dome Light, Horn
7Cigar Lighter, Radio, I.G., Meter,
Wiper, Washer, Rear Defroster,
Turn Signals, Back-Up Lamps
5-96

At Least Twice a Year
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages
are working properly. Look for any other loose or
damaged safety belt system parts. If you see anything
that might keep a safety belt system from doing its
job, have it repaired. Have any torn or frayed safety belts
replaced.
Also look for any opened or broken air bag coverings,
and have them repaired or replaced. (The air bag
system does not need regular maintenance.)
Wiper Blade Check
Inspect wiper blades for wear or cracking. Replace
blade inserts that appear worn or damaged or that
streak or miss areas of the windshield. Also see
Cleaning the Outside of Your Vehicle on page 5-89.
Weatherstrip Lubrication
Silicone grease on weatherstrips will make them last
longer, seal better, and not stick or squeak. Apply
silicone grease with a clean cloth. During very cold,
damp weather more frequent application may be
required. See
Part D: Recommended Fluids and
Lubricants on page 6-30.
Fluid Level Check
Check the transfer case, axle differential(s) and
automatic or manual transmission ¯uid levels and add
as needed. See
Rear Axle on page 5-48,Four-Wheel
Drive on page 5-49, andAutomatic Transmission
Fluid on page 5-20orManual Transmission Fluid on
page 5-23. Check for leaks. A ¯uid loss in these systems
could indicate a problem. Have the system inspected
and repaired at once.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
speci®ed in Part D.
Body Lubrication Service
Lubricate all body door hinges. Also lubricate all hinges
and latches, including those for the hood, rear
compartment, glove box door, console door and folding
seat hardware. Part D tells you what to use. More
frequent lubrication may be required when exposed to a
corrosive environment.
6-25

A
About Driving Your Vehicle................................. 0-2
Accessory Power Outlets.................................3-18
Adding Washer Fluid.......................................5-38
Additional Program Information........................... 7-8
Additives, Fuel................................................. 5-6
Add-On Electrical Equipment............................5-93
Adjusting the Speakers (Balance/Fade)..............3-42
After Off-Road Driving.....................................4-30
Air Bag
Readiness Light..........................................3-29
Air Bag System, Supplemental Restraint
System (SRS).............................................1-52
Air Cleaner/Filter, Engine.................................5-18
Airbag Sensing and Diagnostic Module (SDM)...... 7-9
AM ...............................................................3-45
Antenna, Fixed Mast.......................................3-45
Anti-lock Brake System (ABS)............................ 4-8
Anti-Lock Brake System Warning Light...............3-31
Appearance Care............................................5-85
Care of Safety Belts....................................5-88
Chemical Paint Spotting...............................5-91
Cleaning the Inside of Your Vehicle................5-86
Cleaning the Outside of Your Vehicle..............5-89
Finish Damage............................................5-91
Sheet Metal Damage...................................5-91Appearance Care (cont.)
Underbody Maintenance...............................5-91
Vehicle Care/Appearance Materials................5-92
Weatherstrips..............................................5-88
Approaching a Hill..........................................4-20
Ashtrays........................................................3-19
Audio System(s).............................................3-39
Care of Your CD Player...............................3-45
Care of Your CDs........................................3-45
Fixed Mast Antenna.....................................3-45
Radio with CD............................................3-40
Setting the Time..........................................3-39
Understanding Radio Reception.....................3-45
Automatic Headlamp System............................3-15
Automatic Transmission...................................2-14
Fluid..........................................................5-20
Operation...................................................2-16
Automatic Transmission Shift Lock Control
System Check.............................................6-26
B
Backing Up....................................................4-61
Battery..........................................................5-42
Battery Replacement......................................... 2-5
Before Leaving on a Long Trip.........................4-36
Before You Go Off-Roading..............................4-16
Body Lubrication Service..................................6-25
1

Brake
Parking......................................................2-24
System Inspection.......................................6-29
System Warning Light..................................3-30
Brake Adjustment............................................5-41
Brake Fluid....................................................5-39
Brake Pedal Travel.........................................5-41
Brake Wear...................................................5-41
Brakes..........................................................5-39
Braking........................................................... 4-7
Braking in Emergencies...................................4-10
Break-In, New Vehicle.....................................2-12
Bulb Replacement...........................................5-51
Front Turn Signal and Parking Lamps.............5-53
Halogen Bulbs............................................5-51
Headlamps.................................................5-51
Rear Combination Lamps.............................5-54
Replacement Bulbs......................................5-55
Sidemarker Lamps.......................................5-53
Buying New Tires...........................................5-67
C
California Fuel.................................................. 5-5
Canada ± Customer Assistance.......................... 7-4
Canadian Owners................................................ ii
Canadian Roadside Assistance........................... 7-6
Canceling a Rear Door Security Lock.................. 2-9
Capacities and Speci®cations............................5-98Carbon Monoxide.....................4-40, 4-57, 2-9, 2-29
Care of
Safety Belts................................................5-88
Your CD Player...........................................3-45
Your CDs ...................................................3-45
Cargo Cover..................................................2-36
Cargo Lamp...................................................3-17
CD Messages................................................3-44
Center Passenger Position, Safety Belts.............1-24
Chains, Tires..................................................5-71
Charging System Light....................................3-30
Check
Engine Light...............................................3-33
Checking Brake Fluid......................................5-40
Checking Coolant............................................5-26
Checking Engine Oil........................................5-14
Checking Things Under the Hood......................5-10
Checking Your Restraint Systems......................1-59
Chemical Paint Spotting...................................5-91
Child Restraints
Child Restraint Systems...............................1-35
Infants and Young Children...........................1-31
Lower Anchorages and Top Tethers for
Children (LATCH System)..........................1-42
Older Children.............................................1-29
Securing a Child Restraint Designed for the
LATCH System........................................1-44
Securing a Child Restraint in a Center Rear
Seat Position...........................................1-47
2

Child Restraints (cont.)
Securing a Child Restraint in a Rear Outside
Seat Position...........................................1-44
Securing a Child Restraint in the Right Front
Seat Position...........................................1-49
Top Strap...................................................1-39
Top Strap Anchor Location............................1-41
Where to Put the Restraint...........................1-38
Cigarette Lighter.............................................3-19
Cleaning
Inside of Your Vehicle..................................5-86
Outside of Your Vehicle................................5-89
Underbody Maintenance...............................5-91
Weatherstrips..............................................5-88
Cleaning Aluminum Wheels..............................5-90
Cleaning Exterior Lamps/Lenses.......................5-89
Cleaning Fabric/Carpet....................................5-86
Cleaning Glass Surfaces..................................5-88
Cleaning Interior Plastic Components.................5-88
Cleaning Leather............................................5-87
Cleaning the Top of the Instrument Panel...........5-88
Cleaning the Windshield, Backglass and
Wiper Blades..............................................5-90
Cleaning Tires................................................5-91
Cleaning Vinyl................................................5-87
Climate Control System...................................3-19
Air Filter, Passenger Compartment.................3-23
Outlet Adjustment........................................3-22Clutch, Hydraulic.............................................5-24
Coinholder(s)..................................................2-33
Control of a Vehicle.......................................... 4-7
Convenience Net............................................2-36
Coolant
Engine Temperature Gage............................3-32
Heater, Engine............................................2-15
Cooling System..............................................5-31
Cruise Control.................................................. 3-9
Cupholder(s)..................................................2-33
Current and Past Model Order Forms................7-12
Customer Assistance Information
Courtesy Transportation.................................. 7-7
Customer Assistance for Text
Telephone (TTY) Users............................... 7-4
Customer Assistance Offices........................... 7-4
Customer Satisfaction Procedure..................... 7-2
GM Mobility Program for Persons with
Disabilities................................................ 7-5
Reporting Safety Defects to General Motors....7-10
Reporting Safety Defects to the Canadian
Government............................................7-10
Reporting Safety Defects to the United States
Government............................................7-10
Roadside Assistance Program......................... 7-5
Service Publications Ordering Information........7-11
3

D
Daytime Running Lamps..................................3-14
Defensive Driving............................................. 4-3
Defogging and Defrosting.................................3-21
Dinghy Towing................................................4-48
Doing Your Own Service Work........................... 5-3
Dolly Towing..................................................4-50
Dome Lamp...................................................3-16
Door
Locks.......................................................... 2-6
Power Door Locks......................................... 2-7
Rear Door Security Locks............................... 2-8
Driver
Position, Safety Belt.....................................1-15
Driver Behavior................................................ 4-2
Driving
At Night.....................................................4-30
City...........................................................4-34
Defensive..................................................... 4-3
Drunken....................................................... 4-4
Environment................................................. 4-2
Freeway.....................................................4-35
Hill and Mountain Roads..............................4-38
In Rain and on Wet Roads...........................4-32
Winter........................................................4-40
Driving Across an Incline..................................4-26
Driving Downhill..............................................4-24
Driving in Mud, Sand, Snow or Ice....................4-28
Driving in Water..............................................4-29Driving On Grades..........................................4-62
Driving on Off-Road Hills.................................4-20
Driving On Snow or Ice...................................4-41
Driving Through Deep Standing Water...............4-33
Driving Through Flowing Water.........................4-34
Driving Uphill..................................................4-21
Driving with a Trailer.......................................4-61
E
Electrical System
Add-On Equipment......................................5-93
Fuses and Circuit Breakers...........................5-94
Emissions Inspection and Maintenance
Programs...................................................3-35
Engine
Air Cleaner/Filter.........................................5-18
Battery.......................................................5-42
Check and Service Engine Soon Light............3-33
Coolant......................................................5-25
Coolant Heater............................................2-15
Coolant Temperature Gage...........................3-32
Cooling System Inspection............................6-28
Drive Belt Routing......................................5-101
Engine Compartment Overview......................5-12
Exhaust.....................................................2-29
Oil .............................................................5-13
Overheating................................................5-28
Starting......................................................2-14
4

Engine Compartment Fuse Block......................5-96
Engine Coolant Level Check.............................6-24
Engine Oil Additives........................................5-16
Engine Oil Level Check...................................6-24
Entry Lighting.................................................3-17
Environmental Concerns..................................4-17
Event Data Records (EDR)................................ 7-9
Express-Down Window....................................2-11
Extender, Safety Belt.......................................1-28
Exterior Lamps...............................................3-13
F
Filter
Engine Air Cleaner......................................5-18
Finding a Station............................................3-40
Finish Care....................................................5-89
Finish Damage...............................................5-91
Five-Speed....................................................2-20
Fixed Mast Antenna........................................3-45
Flash to Pass.................................................. 3-7
Flat Tire........................................................5-72
Flat Tire, Changing.........................................5-72
Fluid
Automatic Transmission................................5-20
Manual Transmission....................................5-23
Power Steering...........................................5-37
Windshield Washer......................................5-37
Fluid Level Check...........................................6-25FM ...............................................................3-45
Folding the Seatback........................................ 1-6
Following Distance..........................................4-61
Footnotes................................................6-7, 6-17
Four-Door Models...................................1-24, 1-47
Four-Wheel Drive....................................2-22, 5-49
Four-Wheel-Drive Light....................................3-37
Front Axle......................................................5-50
Fuel............................................................... 5-4
Additives...................................................... 5-6
California Fuel.............................................. 5-5
Filling a Portable Fuel Container..................... 5-9
Filling Your Tank........................................... 5-7
Fuels in Foreign Countries.............................. 5-6
Gage.........................................................3-38
Gasoline Octane........................................... 5-4
Gasoline Speci®cations.................................. 5-4
System Inspection.......................................6-28
Fuses
Fuses and Circuit Breakers...........................5-94
G
Gage
Engine Coolant Temperature.........................3-32
Fuel..........................................................3-38
Speedometer..............................................3-28
Tachometer.................................................3-28
5

Gasoline
Octane........................................................ 5-4
Speci®cations............................................... 5-4
Getting Familiar with Off-Road Driving................4-18
Glove Box.....................................................2-33
GM Mobility Program for Persons with
Disabilities.................................................... 7-5
H
Hazard Warning Flashers................................... 3-4
Head Restraints............................................... 1-5
Headlamp High/Low-Beam Changer.................... 3-7
Headlamps....................................................5-51
Bulb Replacement.......................................5-51
Front Turn Signal and Parking Lamps.............5-53
Halogen Bulbs............................................5-51
Sidemarker Lamps.......................................5-53
Headlamps On Reminder.................................3-15
Highway Hypnosis...........................................4-37
Hill and Mountain Roads..................................4-38
Hitches..........................................................4-60
Hood
Checking Things Under................................5-10
Release.....................................................5-10
Hood Latch Operation Check............................6-24
Horn............................................................... 3-5How to Add Coolant to the Coolant
Recovery Tank............................................5-33
How to Add Coolant to the Radiator..................5-35
How to Add Fluid....................................5-22, 5-24
How to Check................................5-20, 5-23, 5-64
How to Check and Add Fluid............................5-25
How to Check Lubricant...................................5-48
How to Check Power Steering Fluid..................5-37
How to Inspect the Engine Air Cleaner/Filter.......5-18
How to Use This Manual...................................... ii
How to Wear Safety Belts Properly...................1-14
Hydraulic Clutch.............................................5-24
Hydroplaning..................................................4-33
I
If No Steam Is Coming From Your Engine..........5-30
If Steam Is Coming From Your Engine...............5-29
If the Light Is Flashing.....................................3-34
If the Light Is On Steady.................................3-34
If You Are Caught in a Blizzard.........................4-42
If You Are Stuck in Sand, Mud, Ice or Snow.......4-44
If You Do Decide To Pull A Trailer.....................4-58
Ignition Positions.............................................2-12
Ignition Transmission Lock Check......................6-27
Infants and Young Children, Restraints...............1-31
In¯ation - Tire Pressure...................................5-63
6

Inspection
Brake System.............................................6-29
Engine Cooling System................................6-28
Exhaust System..........................................6-28
Fuel System...............................................6-28
Part C - Periodic Maintenance.......................6-28
Steering, Suspension and Front Drive Axle
Boot and Seal.........................................6-28
Throttle System...........................................6-29
Instrument Panel
Cluster.......................................................3-27
Overview..................................................... 3-2
Instrument Panel Brightness.............................3-16
Instrument Panel Fuse Block............................5-94
Interior Lamps................................................3-16
J
Jump Starting.................................................5-43
K
Key Lock Cylinders Service..............................6-25
Keyless Entry System....................................... 2-3
Keys............................................................... 2-2
L
Lamps
Exterior......................................................3-13
Interior.......................................................3-16
Lap Belt........................................................1-25
Lap-Shoulder Belt...................................1-15, 1-26
LATCH System
Child Restraints...........................................1-42
Securing a Child Restraint Designed for the
LATCH System........................................1-44
Leaving Your Vehicle......................................... 2-9
Leaving Your Vehicle With the Engine
Running.....................................................2-26
Light
Air Bag Readiness.......................................3-29
Anti-Lock Brake System Warning...................3-31
Brake System Warning.................................3-30
Charging System.........................................3-30
Four-Wheel-Drive.........................................3-37
Malfunction Indicator....................................3-33
Oil Pressure...............................................3-36
Overdrive Off..............................................3-37
Power Indicator...........................................3-37
Safety Belt Reminder...................................3-28
Loading Your Vehicle.......................................4-51
Loading Your Vehicle for Off-Road Driving..........4-16
7

Locks
Door........................................................... 2-6
Leaving Your Vehicle..................................... 2-9
Power Door.................................................. 2-7
Rear Door Security Locks............................... 2-8
Long Trip/Highway De®nition.............................. 6-6
Long Trip/Highway Intervals............................... 6-6
Long Trip/Highway Scheduled Maintenance........6-17
Loss of Control...............................................4-15
Luggage Carrier..............................................2-34
Lumbar
Manual Controls............................................ 1-3
M
Maintenance, Normal Replacement Parts..........5-100
Maintenance Schedule
At Each Fuel Fill.........................................6-24
At Least Once a Month................................6-24
At Least Once a Year..................................6-25
At Least Twice a Year..................................6-25
Brake System Inspection..............................6-29
Engine Cooling System Inspection.................6-28
Exhaust System Inspection...........................6-28
Fuel System Inspection................................6-28
How This Section is Organized....................... 6-3
Introduction.................................................. 6-2
Long Trip/Highway Scheduled Maintenance.....6-17
Maintenance Requirements............................. 6-2Maintenance Schedule (cont.)
Part A - Scheduled Maintenance Services......... 6-4
Part B - Owner Checks and Services.............6-24
Part C - Periodic Maintenance Inspections......6-28
Part D - Recommended Fluids and
Lubricants...............................................6-30
Part E - Maintenance Record........................6-32
Rear Axle and Front Axle (Four-Wheel-Drive)
Service...................................................6-29
Selecting the Right Schedule.......................... 6-4
Short Trip/City Scheduled Maintenance............. 6-7
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection..........................6-28
Throttle System Inspection............................6-29
Using Your................................................... 6-4
Your Vehicle and the Environment................... 6-2
Maintenance When Trailer Towing.....................4-64
Making Turns.................................................4-62
Malfunction Indicator Light................................3-33
Manual Lumbar Controls.................................... 1-3
Manual Seats................................................... 1-2
Manual Transmission.......................................2-14
Fluid..........................................................5-23
Operation...................................................2-20
Manual Windows............................................2-11
Matching Transmitter(s) to Your Vehicle............... 2-5
Mexico, Central America and Caribbean Islands/
Countries (Except Puerto Rico and U.S. Virgin
Islands) ± Customer Assistance....................... 7-4
8