belt CHRYSLER VOYAGER 1996 Workshop Manual

WARNING: BE SURE THAT THE IGNITION SWITCH
ALWAYS IS IN THE OFF POSITION, UNLESS THE
PROCEDURE REQUIRES IT TO BE ON.
WARNING: SET THE PARKING BRAKE WHEN
WORKING ON ANY VEHICLE. AN AUTOMATIC
TRANSMISSION SHOULD BE IN PARK. A MANUAL
TRANSMISSION SHOULD BE IN NEUTRAL.
WARNING: OPERATE THE ENGINE ONLY IN A
WELL-VENTILATED AREA.
WARNING: KEEP AWAY FROM MOVING PARTS
WHEN THE ENGINE IS RUNNING, ESPECIALLY THE
FAN AND BELTS.
WARNING: TO PREVENT SERIOUS BURNS, AVOID
CONTACT WITH HOT PARTS SUCH AS THE RADIA-
TOR, EXHAUST MANIFOLD(S), TAIL PIPE, CATA-
LYTIC CONVERTER, AND MUFFLER.
WARNING: DO NOT ALLOW FLAME OR SPARKS
NEAR THE BATTERY. GASES ARE ALWAYS
PRESENT IN AND AROUND THE BATTERY.
WARNING: ALWAYS REMOVE RINGS, WATCHES,
LOOSE HANGING JEWELRY, AND LOOSE CLOTH-
ING.
TAKE OUTS
The abbreviation T/O is used in the component
location section to indicate a point in which the wir-
ing harness branches out to a component.
ELECTROSTATIC DISCHARGE (ESD) SENSITIVE
DEVICES
All ESD sensitive components are solid state and a
symbol (Fig. 4) is used to indicate this. When han-
dling any component with this symbol comply with
the following procedures to reduce the possibility of
electrostatic charge build up on the body and inad-
vertent discharge into the component. If it is not
known whether the part is ESD sensitive, assume
that it is.
(1) Always touch a known good ground before han-
dling the part. This should be repeated while han-
dling the part and more frequently after sliding
across a seat, sitting down from a standing position,
or walking a distance.
(2) Avoid touching electrical terminals of the part,
unless instructed to do so by a written procedure.(3) When using a voltmeter, be sure to connect the
ground lead first.
(4) Do not remove the part from its protective
packing until it is time to install the part.
(5) Before removing the part from its package,
ground the package to a known good ground on the
vehicle.
POSITIVE TEMPERATURE COEFFICIENT
Positive Temperature Coefficient (PTC) devices are
being used for circuit protection. These PTC's act like
a solid state fuse. They are located in the junction
block, and are used to protect such items as: power
door lock motors, power windows, and various engine
solenoids.
A special symbol is used to identify these in the
wiring diagrams (Fig. 5).
DIAGNOSIS AND TESTING
TROUBLESHOOTING TOOLS
When diagnosing a problem in an electrical circuit
there are several common tools necessary. These tools
are listed and explained below.
²Jumper Wire - This is a test wire used to con-
nect two points of a circuit. It can be used to bypass
an open in a circuit.
WARNING: NEVER USE A JUMPER WIRE ACROSS
A LOAD, SUCH AS A MOTOR, CONNECTED
BETWEEN A BATTERY FEED AND GROUND.
Fig. 4 Electrostatic Discharge Symbol
Fig. 5 Positive Temperature Coefficient Symbol
8W - 01 - 8 8W-01 GENERAL INFORMATIONNS/GS
DESCRIPTION AND OPERATION (Continued)

Component Page
Seat Belt Indicator Lamp.................8W-40
Seat Belt Switch........................8W-40
Sentry Key Immobilizer Module............8W-39
Service Engine Soon Lamp.............8W-30, 46
Sliding Door Contacts....................8W-61
Sliding Door Lock Motors.................8W-61
Speed Control Switches...............8W-30, 33
Speedometer...........................8W-40
Stop Lamp Switch...................8W-33, 51
Stop/Turn Signal Relays..................8W-54
Tachometer............................8W-40
Tail/Stop Lamp.........................8W-51
Tail/Turn Signal Lamp................8W-51, 52
Throttle Position Sensor..................8W-30
Traction Control Switch..................8W-35
Trailer Tow Connector...................8W-54
Transmission Control Module..............8W-31
Transmission Control Relay............8W-10, 31
Transmission Control Solenoids............8W-31
Transmission Range Sensor...............8W-31
Trip Odometer.........................8W-40Component Page
Turbine Speed Sensor....................8W-31
Turbo Boost Pressure Sensor..............8W-30
Turn Indicators......................8W-46, 52
Turn Signal/Hazard Switch............8W-46, 52
Underdrive Solenoid.....................8W-31
Universal Garage Door Opener............8W-49
Vacuum Solenoid.......................8W-33
Vehicle Speed Control Servo...............8W-33
Vehicle Speed Sensor....................8W-30
Vent Motors...........................8W-60
Vent Solenoids.........................8W-33
Visor/Vanity Mirror Lamps................8W-44
Voltage Regulator.......................8W-20
Volts Indicator Lamp....................8W-40
VTSS Lamp........................8W-39, 46
Washer Module.........................8W-53
Wheel Speed Sensors....................8W-35
Wiper High/Low Relay...................8W-53
Wiper Module..........................8W-53
Wiper On Relay........................8W-53
NS/GS8W - 02 COMPONENT INDEX 8W - 02 - 3

8W-15 GROUND DISTRIBUTION
Component PageA/C Compressor Clutch....................8W-15-2, 3
A/C Heater Control........................8W-15-4
Airbag Control Module......................8W-15-4
All Wheel Drive Solenoid....................8W-15-13
Ash Receiver Lamp........................8W-15-6
Automatic Day/Night Mirror...................8W-15-5
AW4B13..............................8W-15-13
AWS1................................8W-15-13
Battery..............................8W-15-2, 3
Body Control Module.......................8W-15-6
Brake Pressure Switch......................8W-15-8
BS08.................................8W-15-5
BS31.................................8W-15-3
BS40.................................8W-15-3
BS41.................................8W-15-3
Center High Mounted Stop Lamp...............8W-15-14
Cigar/Accessory Relay.......................8W-15-7
Clockspring.............................8W-15-4
Clutch Switch............................8W-15-8
Combination Flasher/DRL Module...............8W-15-6
Controller Anti-Lock Brake....................8W-15-4
Crank Case Heater........................8W-15-3
CS06..............................8W-15-11, 12
Data Link Connector....................8W-15-2, 4, 12
Door Lock Relay..........................8W-15-6
Door Unlock Relay.........................8W-15-6
Downstream Heated Oxygen Sensor..............8W-15-5
Driver Door Arm/Disarm Switch.............8W-15-11, 12
Driver Door Courtesy Lamp...................8W-15-7
Driver Door Lock Switch..................8W-15-11, 12
Driver Door Unlock Relay....................8W-15-6
Driver Heated Seat Back.....................8W-15-9
Driver Heated Seat Cushion...................8W-15-9
Driver Heated Seat Module...................8W-15-9
Driver Heated Seat Switch....................8W-15-9
Driver Power Mirror........................8W-15-4
Driver Power Seat Switch....................8W-15-5
Driver Power Window Switch..................8W-15-7
DS01.................................8W-15-7
EC1C19...............................8W-15-5
Engine Speed Sensor.......................8W-15-3
ES01.................................8W-15-3
ES02.................................8W-15-3
ES11 .................................8W-15-2
ES12.................................8W-15-3
ES18.................................8W-15-2
ES23.................................8W-15-2
ES30.................................8W-15-3
ES31.................................8W-15-3
Front Blower Motor Relay....................8W-15-7
Front Cigar Lighter/Power Outlet...............8W-15-4
Fuel Heater.............................8W-15-3
Fuel Heater Relay.........................8W-15-3
Fuel Tank Module........................8W-15-13
G100................................8W-15-2, 3
G101.................................8W-15-2
G102................................8W-15-2, 3
G103................................8W-15-2, 3
G104.................................8W-15-4
G200.................................8W-15-4
G201.................................8W-15-4
G202.................................8W-15-5
G204.................................8W-15-4
G300...........................8W-15-5, 6, 7, 8, 9
G301............................8W-15-10, 11, 12
G302.................................8W-15-13
G400.................................8W-15-14
Headlamp Dimmer Switch....................8W-15-4
Headlamp Switch........................8W-15-4, 6
Headlamp Washer........................8W-15-10
High Note Horn.......................8W-15-11, 12
Hood Ajar Switch.........................8W-15-10
HS1..................................8W-15-9
HS3..................................8W-15-9
HS5D B09..............................8W-15-9
HS5P B56..............................8W-15-9
Ignition Switch.........................8W-15-4, 6
Instrument Cluster.......................8W-15-4, 6
Junction Block...........................8W-15-6
Key-In Halo Lamp.........................8W-15-6
Left Combination Relay.....................8W-15-13Component PageLeft Door Speaker.........................8W-15-5
Left Front Park/Turn Signal Lamp...............8W-15-7
Left Headlamp...........................8W-15-8
Left Headlamp Leveling Motor.................8W-15-8
Left High Headlamp........................8W-15-8
Left Liftgate Flood Lamp....................8W-15-14
Left Low Headlamp........................8W-15-8
Left Rear Door Ajar Switch...................8W-15-13
Left Rear Lamp Assembly....................8W-15-13
Left Rear Speaker.........................8W-15-5
Left Repeater Lamp........................8W-15-5
Left Speed Control Switch....................8W-15-4
Left Stop/Turn Signal Relay..................8W-15-13
License Lamp...........................8W-15-14
Liftgate Ajar Switch.......................8W-15-14
Liftgate Arm/Disarm Switch..................8W-15-14
Low Coolant Level Switch....................8W-15-3
Low Note Horn..........................8W-15-10
Low Washer Fluid Switch.................8W-15-11, 12
Memory Power Seat Switch..................8W-15-5, 9
Memory Seat/Mirror Module.................8W-15-5, 9
Memory Set Switch........................8W-15-7
Message Center...........................8W-15-6
Name Brand Speaker Relay...................8W-15-6
Needle Movement Sensor.....................8W-15-3
Overhead Console......................8W-15-11, 12
Passenger Door Arm/Disarm Switch.............8W-15-10
Passenger Door Courtesy Lamp.................8W-15-7
Passenger Door Lock Switch..................8W-15-10
Passenger Heated Seat Back...................8W-15-9
Passenger Heated Seat Cushion.................8W-15-9
Passenger Heated Seat Module.................8W-15-9
Passenger Heated Seat Switch.................8W-15-9
Passenger Power Mirror.....................8W-15-4
Passenger Power Seat Switch................8W-15-5, 12
Passenger Power Window Switch................8W-15-7
Power Distribution Center.................8W-15-2, 3, 7
Power Folding Mirror Switch..................8W-15-6
Power Mirror Switch.......................8W-15-6
Powertrain Control Module..................8W-15-2, 3
Radiator Fan Disconnect.....................8W-15-3
Radiator Fan No. 1........................8W-15-2
Radiator Fan No. 2........................8W-15-2
Radiator Fan Relay........................8W-15-2
Radiator Fan Relay No. 1.....................8W-15-3
Radio.................................8W-15-5
Rear Blower Front Control Switch...............8W-15-4
Rear Blower Rear Control Switch...............8W-15-13
Rear Cigar Lighter/Power Outlet...............8W-15-13
Rear Window Defogger.....................8W-15-14
Rear Wiper Motor.........................8W-15-14
Remote Keyless Entry Module..................8W-15-4
RF3E40...............................8W-15-2
RFS2.................................8W-15-2
Right Combination Relay....................8W-15-13
Right Door Speaker........................8W-15-5
Right Front Park/Turn Signal Lamp.............8W-15-10
Right Headlamp..........................8W-15-10
Right Headlamp Leveling Motor................8W-15-10
Right High Headlamp......................8W-15-10
Right Liftgate Flood Lamp...................8W-15-14
Right Low Headlamp......................8W-15-10
Right Rear Door Ajar Switch..................8W-15-13
Right Rear Lamp Assembly...................8W-15-13
Right Rear Speaker........................8W-15-5
Right Repeater Lamp......................8W-15-10
Right Speed Control Switch...................8W-15-4
Right Stop/Turn Signal Relay.................8W-15-13
Seat Belt Switch..........................8W-15-8
Sentry Key Immobilizer Module.................8W-15-4
Stop Lamp Switch.......................8W-15-6, 7
Traction Control Switch......................8W-15-6
Trailer Tow Connector......................8W-15-13
Transmission Control Module..................8W-15-2
Transmission Control Relay...................8W-15-2
Universal Garage Door Opener..............8W-15-11, 12
Upstream Heated Oxygen Sensor................8W-15-2
Vehicle Speed Control Servo...................8W-15-2
Wiper Module............................8W-15-5
Wiper On Relay...........................8W-15-7
NS/GS8W - 15 GROUND DISTRIBUTION 8W - 15 - 1

G300
1
BUILT-UP-EXPORT EXCEPT BUILT-
UP-EXPORT B
(CHRYSLER) HEADLAMP
HIGH
LEFT
2
SEAT
BELT
SWITCHSWITCH
CLUTCH
2
LEFT
HEADLAMP
LEVELING
MOTOR
1
Z1
20
BK
Z1
20
BK
Z1
20
BK
Z1
20
BK
UP-EXPORT EXCEPT BUILT-BUILT-UP
-EXPORT
9B
BRAKE
PRESSURE
SWITCH
Z1
20
BK
Z1
20
BK
Z1
20
BKZ1
20
BK
3
LEFT
HEADLAMPOTHER CHRYSLER B
LEFT
LOW
HEADLAMPHEADLAMP LEFT2
Z1
20
BK
Z1
20
BK
(DIESEL)
(8W-50-5)
(8W-40-4) (8W-30-39)(8W-50-8)
(8W-46-3)(8W-50-6) (8W-50-5)(8W-50-6)
8W - 15 - 8 8W-15 GROUND DISTRIBUTIONNS/GS
J988W-3GS001508

8W-40 INSTRUMENT CLUSTER
Component Page
A/C Heater Control....................8W-40-4
AW4B13............................8W-40-2
Body Control
Module........8W-40-2, 3, 4, 5, 6, 7, 8, 9, 10, 11
BS05........................8W-40-5, 6, 8, 10
BS06........................8W-40-5, 6, 8, 10
BS30...............................8W-40-7
BS40...............................8W-40-7
Clockspring......................8W-40-10, 11
Cluster Illumination Lamps.............8W-40-4
Cruise Indicator Lamp..............8W-40-10, 11
Data Link Connector...................8W-40-9
Door Ajar Indicator Lamp...............8W-40-3
Driver Door Ajar Switch................8W-40-3
Electronic PRNDL Indicator.............8W-40-5
Engine Coolant Temperature Gauge.....8W-40-8, 9
Engine Coolant Temperature Sensor.....8W-40-8, 9
Engine Speed Sensor...................8W-40-7
ES13........................8W-40-5, 6, 8, 10
ES14........................8W-40-5, 6, 8, 10
ES30...............................8W-40-7
Fuel Gauge..........................8W-40-2
Fuel Tank Module.....................8W-40-2
Fuse 2 (JB)..............8W-40-2, 3, 4, 5, 6, 8, 10
Fuse 28 (PDC)........................8W-40-2
G200...............................8W-40-2
G300...............................8W-40-4
G301...............................8W-40-7
G302...............................8W-40-3
G400...............................8W-40-3Component Page
Ignition Switch.....................8W-40-2, 4
Instrument Cluster............8W-40-2, 3, 4, 5, 6,
7, 8, 9, 10, 11
Junction Block...........8W-40-2, 3, 4, 5, 6, 8, 10
Left Rear Door Ajar Switch..............8W-40-3
Left Speed Control Switch...........8W-40-10, 11
Liftgate Ajar Indicator Lamp.............8W-40-3
Liftgate Ajar Switch...................8W-40-3
Low Fuel Warning Indicator Lamp........8W-40-2
Low Washer Fluid Level
Indicator Lamp.................8W-40-10, 11
Low Washer Fluid Switch...........8W-40-10, 11
Memory Seat/Mirror Module.............8W-40-2
Odometer............................8W-40-5
Passenger Door Ajar Switch.............8W-40-3
Power Distribution Center..............8W-40-2
Powertrain Control
Module..............8W-40-5, 6, 7, 8, 9, 10, 11
PS01............8W-40-2, 3, 4, 5, 6, 7, 8, 9, 10, 11
PS02............8W-40-2, 3, 4, 5, 6, 7, 8, 9, 10, 11
Right Rear Door Ajar Switch.............8W-40-3
Right Speed Control Switch..........8W-40-10, 11
Seat Belt Indicator Lamp...............8W-40-4
Seat Belt Switch......................8W-40-4
Speedometer.......................8W-40-6, 7
Tachometer........................8W-40-6, 7
Transmission Control Module..........8W-40-5, 6
Trip Odometer........................8W-40-5
Vehicle Speed Sensor.................8W-40-6, 7
Voltage Indicator Lamp...............8W-40-8, 9
NS/GS8W - 40 INSTRUMENT CLUSTER 8W - 40 - 1

1
LG/RD18 G10
C178
SENSE SWITCHBELT SEAT
SWITCH
BELT
SEAT
1
VT/BR20 D1WT/BK20 D2
BK20Z1
IGNITION
SWITCH
2
BK20Z1
BK14Z1
8
G300
C22
LAMPS ILLUMINATIONCLUSTER
C428
13
2BLOCK
JUNCTION
OR20 E2
6
LAMPSPANEL
8C4
DRIVER
WT/BK20 D2
(-)
C234
CCD
BUS
PS02
D1
20
VT/BR
(+)
C23
CCD
BUS
PS01JUNCTION
BLOCK ST-RUN-OFF A81
10A
FUSE
2
CLUSTER INSTRUMENT
10C4
11
(ST-RUN-OFF)IGNITIONFUSEDF11
20
RD/WT
910
CCD
BUS
(+) (-)BUS CCD
LAMP LAMP
CONTROL INDICATORBELT
BELT
INDICATOR
BODY
CONTROL
MODULEGROUND
2
Z1
20
BK
FROM
CONTROLA/C
E2
20
OR
C2
SEAT
SEAT
HEATER
PAIR TWISTED
D1
(8W-10-14)
(8W-15-6)
(8W-15-8)(8W-12-2) (8W-30-4)
(8W-30-31) (8W-30-4)
(8W-30-31)(8W-12-2) (8W-10-16)
(8W-12-9)
(8W-45-3)
(8W-45-5)
(8W-45-7) (8W-42-3)
(8W-12-19) (8W-12-23)
8W - 40 - 4 8W-40 INSTRUMENT CLUSTERNS/GS
J988W-3GS004004

8W-45 BODY CONTROL MODULE
Component Page
A/C Heater Control..................8W-45-5, 6
Ash Receiver Lamp....................8W-45-5
Automatic Day/Night Mirror.............8W-45-8
Back-Up Switch.......................8W-45-9
Battery.............................8W-45-9
Body Control Module . .8W-45-2, 3, 4, 5, 6, 7, 8, 9, 10
BS02...............................8W-45-9
BS10...............................8W-45-8
BS30...............................8W-45-9
Clockspring..........................8W-45-3
Combination Flasher/DRL Module........8W-45-5
Controller Anti-Lock Brake..............8W-45-6
CS03...............................8W-45-8
Data Link Connector...................8W-45-3
Door Lock Relay......................8W-45-7
Door Unlock Relay....................8W-45-7
Driver Door Ajar Switch................8W-45-7
Driver Door Arm/Disarm Switch..........8W-45-8
Driver Door Lock Switch..............8W-45-6, 8
Driver Door Unlock Relay...............8W-45-7
Driver Power Mirror..................8W-45-10
Driver Power Window Switch............8W-45-6
Engine Coolant Temperature Sensor.......8W-45-9
Engine Oil Pressure Switch..............8W-45-7
ES01...............................8W-45-9
ES02...............................8W-45-9
Front Cigar Lighter/Power Outlet.........8W-45-5
Front Reading Lamps/Switch............8W-45-8
Front Wiper Switch....................8W-45-4
Fuel Tank Module...................8W-45-7, 9
Fuse 1 (JB)..........................8W-45-3
Fuse 2 (JB)..........................8W-45-2
Fuse 3 (JB)..........................8W-45-3
Fuse 6 (JB)..........................8W-45-2
Fuse 19 (PDC)........................8W-45-4
Fuse 22 (PDC)........................8W-45-3
Fuse 28 (PDC)........................8W-45-2
G100...............................8W-45-9
G103...............................8W-45-9
G300............................8W-45-2, 10
G302...............................8W-45-9
Glove Box Lamp......................8W-45-8
Headlamp Dimmer Switch..............8W-45-5
Headlamp Switch...............8W-45-2, 3, 4, 5
Hood Ajar Switch.....................8W-45-7
Horn Relay..........................8W-45-3
HVAC Control........................8W-45-6
Ignition Switch.....................8W-45-2, 5
Instrument Cluster....................8W-45-5
Junction Block...........8W-45-2, 3, 4, 5, 6, 7, 10
Key-In Halo Lamp....................8W-45-10Component Page
Left Mid Reading Lamp................8W-45-8
Left Rear Door Ajar Switch..............8W-45-8
Left Rear Reading Lamp................8W-45-8
Left Visor/Vanity Mirror Lamps..........8W-45-8
Liftgate Ajar Switch...................8W-45-7
Liftgate Arm/Disarm Switch.............8W-45-6
LJ01 B17..........................8W-45-4, 6
Low Beam Relay......................8W-45-5
Low Coolant Level Switch...............8W-45-9
Low Washer Fluid Switch...............8W-45-3
Memory Seat/Mirror Module...........8W-45-2, 6
Message Center.....................8W-45-5, 6
Park Lamp Relay.....................8W-45-3
Passenger Door Ajar Switch.............8W-45-7
Passenger Door Arm/Disarm Switch.......8W-45-8
Passenger Door Lock Switch...........8W-45-6, 8
Passenger Power Mirror...............8W-45-10
Passenger Power Window Switch.........8W-45-6
Power Distribution Center...........8W-45-2, 3, 4
Power Folding Mirror Switch...........8W-45-10
Power Mirror Fold Relay...............8W-45-10
Power Mirror Switch...................8W-45-5
Power Mirror Unfold Relay.............8W-45-10
Powertrain Control Module..............8W-45-9
PS01...............................8W-45-3
PS02...............................8W-45-3
PTC 3 (JB)..........................8W-45-7
Radio.............................8W-45-4, 5
Rear Blower Front Control Switch........8W-45-5
Rear Blower Rear Control Switch.........8W-45-6
Rear Washer Motor....................8W-45-4
Rear Wiper Motor.....................8W-45-4
Remote Keyless Entry Module...........8W-45-6
Right Mid Reading Lamp...............8W-45-8
Right Rear Door Ajar Switch.............8W-45-8
Right Rear Reading Lamp...............8W-45-8
Right Visor/Vanity Mirror Lamps.........8W-45-8
Seat Belt Switch......................8W-45-7
Traction Control Switch.................8W-45-5
Universal Garage Door Opener...........8W-45-6
Wiper Module........................8W-45-3
Wiper On Relay.......................8W-45-4
NS/GS8W - 45 BODY CONTROL MODULE 8W - 45 - 1

SIGNAL SENSORLEVELFUEL
46
C1
FUEL
TANK
MODULE
DB18 G4
3
BODY
CONTROL
MODULE
BLOCK JUNCTION
52
1
8
G6
20
GY
C1 C1
SWITCH BELT
SEAT
LG/RD18 G10
1
78 OIL
PRESSURE
SWITCH
SENSE SENSESWITCHBELT
9
B33
E36
GY16 G6
SWITCH PRESSURE
OIL
ENGINE
79
G75
18
TN
C1
SWITCH AJAR
DOOR DRIVER
DRIVER
DOOR
AJAR
SWITCH
SENSE SENSESWITCHAJAR DOOR PASSENGER
C1
TN/RD18 G74
48
PASSENGER
DOOR
AJAR
SWITCH
LJ01 B174 SENSE SWITCHAJAR LIFTGATE
C1
TN/BK18 G78
3
59
G78
18
TN/BK
4
J03A
L16
TN/BK18 G78
LIFTGATE
AJAR
SWITCH
1
43
G70
18
BR/TN
C1
HOOD
AJAR
SWITCH
SENSE
HOOD
AJAR
SWITCH
86
85
DOOR
LOCK
RELAY RELAYUNLOCK
DOOR
85
86
6
85
86
5
RELAY UNLOCK
DOOR DRIVER
CONTROLRELAY DOOR LOCK DOOR UNLOCK
RELAY
CONTROL
CONTROLRELAY UNLOCKDRIVER
BATT A2
SEAT
3PTC
9A
(GAS)
ENGINE
ENGINE
OIL
PRESSURE
SWITCH
SENSESEAT
BELT
SWITCH
SENSEFUEL
LEVEL
SENSOR
SIGNAL
LIFTGATE
AJAR
SWITCH
SENSEHOOD
AJAR
SWITCH
SENSE
3B13
AW4
(8W-30-6)
(8W-30-20)(8W-12-2)
(8W-40-4)
(8W-46-2)(8W-44-5)(8W-44-5) (8W-61-3)
(8W-61-4)
(8W-61-7)
(8W-61-8)(8W-61-3)
(8W-61-4)
(8W-61-7)
(8W-61-8)(8W-61-7)
(8W-61-8) (8W-10-13)
(8W-12-14)
(8W-12-15)
NS/GS8W-45 BODY CONTROL MODULE 8W - 45 - 7
GS004507J988W-3

Component Page
Seat Belt Switch.....................8W-80-83
Sentry Key Immobilizer Module.........8W-80-83
Speed Control Dimming Module.........8W-80-83
Stop Lamp Switch....................8W-80-83
Throttle Position Sensor (2.0L)..........8W-80-84
Throttle Position Sensor (Except 2.0L). . . .8W-80-84
Traction Control Switch................8W-80-84
Trailer Tow Connector.................8W-80-84
Transmission Control Module...........8W-80-85Component Page
Transmission Control Solenoids..........8W-80-86
Transmission Range Sensor.............8W-80-86
Turbine Speed Sensor.................8W-80-87
Turbo Boost Pressure Sensor............8W-80-87
Upstream Heated Oxygen Sensor........8W-80-87
Vehicle Speed Control Servo............8W-80-87
Vehicle Speed Sensor..................8W-80-88
Wiper Module (Built-Up-Export).........8W-80-88
Wiper Module (Except Built-Up-Export) . . .8W-80-88
8W - 80 - 4 8W - 80 CONNECTOR PIN-OUTSNS/GS

M20 20BR G75 18TN G10 18LG/RD
G76 18TN/YL V14 18RD/VT G78 18TN/BK G29 20BK/TN P96 20WT/LG G6 20GY V20 20BK/WT V13 18BR/LG G74 18TN/RD G77 18TN/OR
G4 18DB
P97 20WT/DG
P98 20WT/RD
G70 18BR/TN V7 20DG/WT
80 79 78
77
76 75 74 73 72 71
70
69 68 67
66
65
64
63 62 61 60 59 58 57 56 55 54 53
52 51 50 49 48 47
46
45
44
43
42 41 CAV COURTESY LAMP GROUND DRIVER DOOR AJAR SWITCH SENSE SEAT BELT SWITCH SENSE
RIGHT REAR DOOR AJAR SWITCH SENSE WIPER ON/OFF RELAY CONTROL LIFTGATE AJAR SWITCH SENSE WASHER FLUID SWITCH SENSE PASSENGER DOOR SWITCH MUX ENGINE OIL PRESSURE SWITCH SENSE REAR WASHER MOTOR CONTROL REAR WIPER MOTOR CONTROL PASSENGER DOOR AJAR SWITCH SENSE LEFT REAR DOOR AJAR SWITCH SENSE
FUEL LEVEL SENSOR SIGNAL
DRIVER DOOR SWITCH MUX
LIFTGATE LOCK/UNLOCK MUX
HOOD AJAR SWITCH SENSE WIPER PARK SWITCH SENSE
- -
-
-
-
- - -
-
- - - CIRCUIT
- -
-
-
-
- - -
-
- - - FUNCTION
G7 18WT/OR*
V38 20LB/RD*
G18 20PK/BK*
G58 20BK/YL* ENGINE COOLANT TEMPERATURE SENSOR SIGNAL
G55 20OR/BK* ENGINE DISABLE SIGNALPOWER MIRROR FOLD RELAY P171 20VT/WT
P174 20YL/RD POWER MIRROR UNFOLD RELAY
ENGINE SPEED SENSOR SIGNAL K159 20VT/RD*
BODY
CONTROL
MODULE - C1
NATURAL
80 70 60 50
71 61 51 41 L24 20WT/LG**
L193 20OR/WT**
* DIESEL
** GAS
BUILT-UP-EXPORT
VEHICLE SPEED SENSOR SIGNAL
AUTOMATIC HEADLAMP SIGNAL
SPEED CONTROL LAMP DRIVER
COOLANT LEVEL SWITCH SENSE
LOW BEAM RELAY CONTROL
NS/GS8W-80 CONNECTOR PIN-OUTS 8W - 80 - 15
NSGS8015J988W-3