belt DODGE DAKOTA 2009 3.G Service Manual

include cleaning of the condenser fins and a performance
test. Drive belt tension should also be checked at this
time.
WARNING!
²Use only refrigerants and compressor lubricants
approved by the manufacturer for your air condi-
tioning system. Some unapproved refrigerants are
flammable and can explode, injuring you. Other
unapproved refrigerants or lubricants can cause
the system to fail, requiring costly repairs. Refer to
Section 3 of the Warranty Information book for
further warranty information.
²The air conditioning system contains refrigerant
under high pressure. To avoid risk of personal
injury or damage to the system, adding refrigerant
or any repair requiring lines to be disconnected,
should be done by an experienced repairman.NOTE:Use only manufacturer approved A/C System
Sealers, Stop Leak Products, Seal Conditioners, Compres-
sor Oils and Refrigerants.
Refrigerant Recovery and Recycling
R-134a air conditioning refrigerant is a hydrofluoro-
carbon (HFC) that is endorsed by the Environmental
Protection Agency (EPA), and is an ozone-saving prod-
uct. However, the manufacturer recommends that air
conditioning service be performed by authorized dealers
or other service facilities using recovery and recycling
equipment.
Drive Shaft Constant Velocity Joints
All 4-wheel drive models are equipped with four con-
stant velocity joints. Periodic lubrication of these joints is
not required. However, the joint boot should be inspected
for external leakage or damage periodically. If external
leakage or damage is evident, the joint boot and grease
should be replaced immediately. Continued operation
MAINTAINING YOUR VEHICLE 361
7

Seat Belt Maintenance
Do not bleach, dye or clean the belts with chemical
solvents or abrasive cleaners. This will weaken the fabric.
Sun damage will also weaken the fabric.
If the belts need cleaning, use a mild soap solution or
lukewarm water. Do not remove the belts from the car to
wash them.
Replace the belts if they appear frayed or worn, or if the
buckles do not work properly.
FUSES
CAUTION!
When replacing a blown fuse, it is important to use
only a fuse having the correct amperage rating. The
use of a fuse with a rating other than indicated may
result in a dangerous electrical system overload. If a
properly rated fuse continues to blow, it suggests a
problem in the circuit that must be corrected.
Underhood Fuses (Power Distribution Center)
Your vehicle is equipped with an electrical power distri-
bution center located on the left side of the engine
compartment.
MAINTAINING YOUR VEHICLE 381
7

120,000 Miles (200,000 km) or 120 Months Maintenance Service Schedule
oChange the engine oil and engine oil filter.
oRotate tires.
oReplace the engine air cleaner filter.
oReplace the ignition cables (3.7L engine).
oReplace the spark plugs (3.7L engines).
oReplace the top row of spark plugs (4.7L engines). **
oInspect the brake linings, replace if necessary.
oInspect the CV joints.
oInspect the exhaust system.
oInspect the front suspension, tie rod ends and boot seals, replace if necessary.
oChange the manual transmission fluid if using your vehicle for any of the following: trailer towing, snow plowing, heavy loading, taxi, police,
delivery service (commercial service), off-road, desert operation or more than 50% of your driving is at sustained high speeds during hot
weather, above 90ÉF (32ÉC).
oChange the automatic transmission fluid & filter.
oChange the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, off-road, or frequent trailer towing.
oReplace the accessory drive belt(s).
Odometer Reading Date
Repair Order # Dealer Code
Signature Authorized Chrysler Dealer
MAINTENANCE SCHEDULES 413
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Battery............................... 359
Charging............................ 343
Emergency Starting..................... 343
Gas Caution.......................... 343
Keyless Transmitter Replacement (RKE)....... 26
Saving Feature (Protection)............... 124
Belts, Seat.............................. 37
Body Mechanism Lubrication............... 362
Box, Sound............................ 220
B-Pillar Location........................ 276
Brake Fluid............................ 398
Brake System........................269,371
Anti-Lock (ABS)....................269,270
Fluid Check.......................... 371
Master Cylinder....................... 371
Parking............................. 267
Warning Light.....................170,174
Brake/Transmission Interlock............... 246
Break-In Recommendations, New Vehicle........ 70Bulb Replacement....................... 387
Bulbs, Light............................ 387
Calibration, Compass..................... 140
Camper............................... 157
Capacities, Fluid........................ 396
Caps, Filler
Oil (Engine).......................... 357
Power Steering........................ 266
Radiator (Coolant Pressure)............... 368
Car Washes............................ 377
Carbon Monoxide Warning..............158,302
Cargo Light............................ 126
Cargo (Vehicle Loading)................... 308
Cellular Phone........................82,228
Center High Mounted Stop Light............ 391
Certification Label....................... 308
Changing A Flat Tire..................... 332
Charging.............................. 343
INDEX 429
10

Exhaust Gas Caution..................71,302
Flooded, Starting...................... 240
Fuel Requirements..................... 396
Jump Starting......................... 343
Oil ...........................356,396,397
Oil Filler Cap......................... 357
Oil Selection.......................... 396
Oil Synthetic......................... 358
Starting............................. 239
Temperature Gauge..................... 168
Entry System, Illuminated.................. 20
Event Data Recorder...................... 56
Exhaust Gas Caution................71,302,364
Exhaust System.......................71,363
Extender, Seat Belt........................ 45
Exterior Lighting........................ 125
Fabric Care............................ 379Filters
Air Cleaner.......................... 359
Engine Oil........................358,397
Engine Oil Disposal.................... 358
Flashers
Hazard Warning....................... 332
Turn Signal.....................127,168,389
Flat Tire Stowage........................ 343
Flexible Fuel Vehicles
Cruising Range........................ 305
Engine Oil........................... 305
Fuel Requirements..................302,304
Replacement Parts..................... 305
Starting............................. 305
Flooded Engine Starting................... 240
Floor Console.......................... 154
Fluid, Brake........................... 398
Fluid Capacities......................... 396
432 INDEX

Intermittent Wipers (Delay Wipers)........... 130
Introduction............................. 4
Jack Operation.......................332,337
Jacking Instructions...................... 338
Key, Programming........................ 17
Key, Replacement........................ 17
Key, Sentry (Immobilizer)................... 16
Keyless Entry System...................... 21
Keys................................. 12
Knee Bolster............................ 46
Lane Change and Turn Signals.........127,168,389
Lap/Shoulder Belts....................... 37
LATCH (Lower Anchors and Tether for
CHildren).............................. 61
Life of Tires............................ 286
Lights..............................73,123Airbag............................55,178
Anti-Lock Warning..................... 170
Back-Up............................. 389
Brake Warning........................ 174
Bulb Replacement...................... 387
Cargo .............................. 126
Center Mounted Stop................... 391
Courtesy/Reading..................... 136
Cruise.............................. 178
Daytime Running...................... 126
Fog ..........................126,173,395
Hazard Warning Flasher................. 332
Headlights........................... 125
High Beam........................... 128
High Beam/Low Beam Select............. 128
Instrument Cluster..................... 168
Intensity Control....................... 123
Interior..........................123,136
License............................. 394
INDEX 435
10

Lights On Reminder.................... 126
Low Fuel............................ 168
Malfunction Indicator (Check Engine)........ 175
Passing............................. 128
Seat Belt Reminder..................... 169
Service.............................. 387
Tire Pressure Monitoring (TPMS)........... 176
Turn Signal.....................127,387,389
Voltage............................. 170
Warning (Instrument Cluster Description)..... 168
Limited-Slip Differential................... 262
Loading Vehicle......................... 308
Tires ............................... 276
Locks................................. 29
Auto Unlock.......................... 31
Automatic Door........................ 30
Child Protection........................ 32
Door................................ 29
Keys................................ 12Power Door........................... 29
Steering Wheel......................... 15
Lower Anchors and Tether for CHildren
(LATCH).............................. 61
Lubrication, Body....................... 362
Lug Nuts............................. 341
Lumbar Support........................ 117
Maintenance Free Battery.................. 359
Maintenance Procedures................... 356
Maintenance Schedule.................... 400
Malfunction Indicator Light (Check Engine) . . 175,354
Manual, Service......................... 421
Manual Transmission...............239,242,372
Fluid Level Check...................... 372
Lubricant Selection..................372,398
Shift Speeds.......................... 243
Map/Reading Lights..................... 136
Mirrors................................ 80
436 INDEX

Parking Brake.......................... 267
Parking On Hill......................... 267
Passing Light........................... 128
Pets.................................. 70
Pets, Transporting........................ 70
Phone, Cellular.......................... 82
Phone, Hands-Free (UConnectt) .............. 82
Pickup Box............................ 159
Placard, Tire and Loading Information......... 276
Power
Distribution Center (Fuses)............... 381
Door Locks.........................20,29
Mirrors.............................. 81
Outlet (Auxiliary Electrical Outlet).......... 149
Steering............................. 266
Windows............................. 34
Power Steering Fluid..................... 398
Pregnant Women and Seat Belts.............. 45
Preparation for Jacking.................... 337Pretensioners
Seat Belts............................. 44
Programming Transmitters (Remote Keyless
Entry)................................. 25
Quad Cab............................. 120
Radial Ply Tires......................... 283
Radiator Cap (Coolant Pressure Cap).......366,368
Radio Operation........................ 228
Radio, Satellite.......................... 221
Rear Axle (Differential).................... 376
Rear Cargo Area Utility Rails............... 155
Rear Convenience Storage Crates............. 151
Rear Window.......................... 157
Rear Window Defroster................... 156
Rear Window Features.................... 156
Rearview Mirrors........................ 80
Reclining Front Seats..................... 116
438 INDEX

Recorder, Event Data...................... 56
Recreational Towing...................... 324
Shifting into Transfer Case Neutral (N)....... 325
Shifting out of Transfer Case Neutral (N)..... 327
Reformulated Gasoline.................... 298
Refrigerant............................ 361
Release, Hood.......................... 121
Reminder, Seat Belt....................... 44
Remote Keyless Entry (RKE)................. 21
Remote Sound System (Radio) Controls........ 226
Remote Starting System.................... 27
Replacement Keys........................ 17
Replacement Parts....................... 355
Replacement Tires....................... 287
Reporting Safety Defects................... 420
Resetting Oil Change Indicator.............. 172
Restraints, Child.......................58,63
Restraints, Occupant...................... 36
Rocking Vehicle When Stuck................ 346Rotation, Tires.......................... 291
Safety Checks Inside Vehicle................. 72
Safety Checks Outside Vehicle............... 73
Safety Defects, Reporting.................. 420
Safety Information, Tire................... 272
Safety Tips............................. 71
Satellite Radio.......................... 221
Satellite Radio Antenna................... 222
Schedule, Maintenance.................... 400
Seat Belt Maintenance.................... 381
Seat Belt Reminder....................... 44
Seat Belts..........................36,37,72
And Pregnant Women................... 45
Child Restraint.......................58,59
Extender............................. 45
Front Seat............................ 37
Pretensioners.......................... 44
Reminder............................ 169
INDEX 439
10

Seats................................. 115
Adjustment.......................... 115
Cleaning............................ 379
Heated............................. 120
Lumbar Support....................... 117
Reclining............................ 116
Security Alarm (Theft Alarm).............19,170
Selection of Coolant (Antifreeze)..........367,397
Selection of Oil......................... 357
Sentry Key (Immobilizer)................... 16
Sentry Key Programming................... 17
Sentry Key Replacement................... 17
Service and Maintenance.................. 356
Service Assistance....................419,423
Service Contract......................... 425
Service Manuals........................ 421
Setting the Clock.............179,182,196,199,209
Shift Speeds........................... 243Shifting
Automatic Transmission................. 246
Manual Transmission................... 242
Transfer Case......................... 251
Transfer Case, Shifting into Transfer Case
Neutral (N).......................... 325
Transfer Case, Shifting out of Transfer Case
Neutral (N).......................... 327
Shoulder Belt Upper Anchorage.............. 42
Shoulder Belts........................... 37
Signals, Turn.....................127,168,389
Snow Chains (Tire Chains)................. 289
Snow Plow............................ 323
Snow Tires............................ 291
Sound Box............................ 220
Spare Tire..........................284,334
Speed Control (Cruise Control).............. 132
Speedometer........................... 170
Starting............................... 239
440 INDEX