DODGE NEON 1997 1.G Wiring Diagrams Workshop Manual

Downloaded from www.Manualslib.com manuals search engine There are two switches used in this system and
they are wired in parallel form. A parking brake
switch located on the parking brake mechanism will
illuminate the lamp if the normally OPEN switch is
CLOSED. This switch is case grounded.
The other switch used is the brake warning lamp
switch. This switch is normally OPEN. When the
brake system pressure is below a predetermined level
the switch CLOSES and completes a path to ground
from the G9 circuit at the cluster, through the
switch, to the left headlamp ground.
ANTI-LOCK WARNING LAMP
The Anti-Lock warning lamp is used to alert the
driver of a problem in the ABS system. When the
ABS controller determines a problem in the system it
grounds the G19 circuit and illuminates the lamp.
HELPFUL INFORMATION
²Check the 5 amp fuse in cavity 11 of the fuse
block.
²Check the 4 amp fuse in cavity 12 of the fuse
block.
²Check the Ignition-Off Draw fuse in the PDC.
²Check for a good ground at the instrument panel
left center support.
²For additional diagnostic tests refer to the
appropriate section of the Service Manual.
PL8W - 40 INSTRUMENT CLUSTER 8W - 40 - 9
DESCRIPTION AND OPERATION (Continued)

Downloaded from www.Manualslib.com manuals search engine

Downloaded from www.Manualslib.com manuals search engine 8W-41 HORNS/CIGAR LIGHTER
INDEX
page
SCHEMATICS AND DIAGRAMS........................................................... 1
DESCRIPTION AND OPERATION.......................................................... 4
Component Page
Cigar Lighter Relay..................8W-41-3
Cigar Lighter/Power Outlet.............8W-41-3
Clockspring.........................8W-41-2
Fuse 1 (FB).........................8W-41-3
Fuse 3 (PDC)........................8W-41-3
Fuse 15 (FB)........................8W-41-3
Fuse 23 (PDC).......................8W-41-2
Fuse Block.........................8W-41-3
G101..............................8W-41-2
G103..............................8W-41-2
G204..............................8W-41-3
Horn No. 1.........................8W-41-2Component Page
Horn No. 2.........................8W-41-2
Horn Relay.........................8W-41-2
Left Horn Switch.....................8W-41-2
Power Distribution Center...........8W-41-2, 3
Right Horn Switch...................8W-41-2
S108..............................8W-41-2
S111 ..............................8W-41-2
S117 ..............................8W-41-2
S131..............................8W-41-2
S202..............................8W-41-3
S206..............................8W-41-3
S213..............................8W-41-3
8W - 41 - 2 8W - 41 HORNS/CIGAR LIGHTERPL

Downloaded from www.Manualslib.com manuals search engine BATT A0
23FUSE10A
POWER
DISTRIBUTION
CENTER
RELAY HORN
6266
6365
CLOCKSPRING
1
SWITCH
HORN
LEFT
SWITCH HORN
RIGHT
5C101
X3
20
BK/RD
B A
BK14Z1
G101 S108
BK14Z1
S111
Z1
20
BK
X2
18
DG/RD
23
23
X3
18
BK/RD
DG/RD18 X2
BK20Z1
S117
Z1
14
BK
G103
A
B
S131
X2
18
DG/RD
HORN
NO. 1 NO. 2HORN
(8W-10-9)(8W-10-4)
(8W-10-4)
(8W-15-2) (8W-15-2) (8W-15-2)
(8W-15-4)
(8W-15-2)
8W - 41 - 2 8W-41 HORN/CIGAR LIGHTER/POWER OUTLETPL-RHD
978W-1PLR04101

Downloaded from www.Manualslib.com manuals search engine 40A
FUSE
3
BATT A0
POWER
DISTRIBUTION
CENTER
A3
12
RD/WT
3C102
A3
12
RD/WT
S213
A3
12
RD/WT
1FUSE15A
BLOCK
FUSE
F38
16
RD
BK20Z1
G204
CIGAR
LIGHTER/
POWER
OUTLET
S202
Z1
20
BK
1
3 73
21
B1
B2
B5B3
F38
18
RD
CIGAR
LIGHTER
RELAY
5
35
RUN A22
15FUSE20A
FUSE
BLOCK
F13
18
DB
F13
18
DB
S206
Z1
20
BK
NOT USEDF38
18
RD
(8W-10-4)
(8W-10-6)(8W-10-4)
(8W-10-6)
(8W-11-4)(8W-11-2)
(8W-15-7) (8W-15-7) (8W-11-12)(8W-10-6)
(8W-11-2)
(8W-11-12)
PL-RHD8W-41 HORN/CIGAR LIGHTER/POWER OUTLET 8W - 41 - 3
PLR04102978W-1

Downloaded from www.Manualslib.com manuals search engine 8W-41 HORNS/CIGAR LIGHTER
DESCRIPTION AND OPERATION
HORNS
The horn system is powered by a 15 amp fuse
located in the Power Distribution Center (PDC)
which is HOT at all times on circuit F31. This circuit
supplies voltage to the coil and contact side of the
horn relay.
When the operator presses the horn switch, a
ground path is completed on the coil side of the horn
relay through the switch. The horn relay, located in
the PDC, then CLOSES the relay contacts. Voltage is
passed through the CLOSED relay contacts on circuit
X2 to the horn. Grounding for the horn is on the Z1
circuit to the left headlamp ground which is located
on the left side of the radiator closure panel.
HELPFUL INFORMATION
²Check the 15 amp fuse in the PDC.²Press the horn switch and listen for the horn
relay to click. A clicking relay indicates voltage is
present up to the switch.
²Check for a good ground at the left headlamp
ground.
CIGAR LIGHTER
The cigar lighter in this vehicle uses a cigar lighter
relay and a cigar lighter element. Power for the cigar
lighter relay is supplied by two sources.
Power for the coil side of the relay is supplied by
circuit F13. This circuit is protected by a 20 amp fuse
located in the fuse block. Power for the contact side
of the relay is supplied on circuit F38. The F38 cir-
cuit is protected by a 15 amp fuse.
Ground for the cigar lighter element and relay is
supplied on circuit Z1.
8W - 41 - 4 8W - 41 HORNS/CIGAR LIGHTERPL

Downloaded from www.Manualslib.com manuals search engine 8W-42 AIR CONDITIONING-HEATER
INDEX
page
SCHEMATICS AND DIAGRAMS........................................................... 1
DESCRIPTION AND OPERATION.......................................................... 6
Component Page
A/C Compressor Clutch................8W-42-2
A/C Compressor Clutch Relay...........8W-42-2
A/C Cycling Switch...............8W-42-3, 4, 5
A/C Heater Blower Motor..............8W-42-3
A/C Heater Control Switch...........8W-42-3, 3
A/C High Pressure Switch..............8W-42-5
A/C Low Pressure Switch............8W-42-4, 5
Blower Motor Resistor Block............8W-42-3
Diode..............................8W-42-2
Fuse 5 (FB).........................8W-42-4
Fuse 5 (PDC)........................8W-42-5
Fuse 7 (FB).........................8W-42-3
Fuse 9 (FB).........................8W-42-3
Fuse 10 (FB)........................8W-42-2
Fuse 18 (PDC).......................8W-42-2
Fuse Block......................8W-42-2, 3, 4Component Page
G101..............................8W-42-5
G103..............................8W-42-2
G203..............................8W-42-3
Headlamp Switch....................8W-42-3
Power Distribution Center...........8W-42-2, 5
Powertrain Control Module...........8W-42-2, 5
Radiator Fan Motor..................8W-42-5
Rear Fog Lamp Switch................8W-42-3
S108..............................8W-42-5
S109..............................8W-42-2
S111 ..............................8W-42-5
S204..............................8W-42-3
S210..............................8W-42-3
S211 ..............................8W-42-4
S314..............................8W-42-3
Solid State Fan Relay.................8W-42-5
8W - 42 - 2 8W - 42 AIR CONDITIONING-HEATERPL

Downloaded from www.Manualslib.com manuals search engine 18
36
35
3271
POWER
DISTRIBUTION
CENTER
15A
FUSE
10
9
30BLOCK FUSE
F12
20
DG/WT
F12
20
DG/WT
F12
18
DG/WT
6C101
Z1
20
BK
G103CLUTCH COMPRESSOR
A/C
C1
64
POWERTRAIN
CONTROL
MODULE S109
C28
18
DB/OR
A/C
COMPRESSOR
CLUTCH
RELAY
CONTROL
ST-RUN A21
10A
FUSE
18
17
BATT A0
1
2
A/C
COMPRESSOR
CLUTCH
RELAY
DIODE
C3 18DB/BK
20BK Z1
(8W-10-4) (8W-11-9)(8W-11-2)
(8W-15-4) (8W-30-11) (8W-11-9)
(8W-10-9) (8W-10-12)
(8W-10-4)
8W - 42 - 2 8W-42 AIR CONDITIONING-HEATERPL-RHD
978W-1PLR04201

Downloaded from www.Manualslib.com manuals search engine 1
5432
11 A/C ON
67
89
0098 7
6
A/C
SWITCH
ILLUM. BLOWER
SWITCH
ILLUM.
MODE
SWITCH
ILLUM. A/C
HEATER
CONTROL
ILLUM.
BLOWER SWITCHA/C
SWITCH
10 11
A/C
HEATER
CONTROL
0 OFF
1 DEFROST
2 MIX
3 HEAT
4 BI-LEVEL
5 PANEL
6 LOW
7 MED-LOW
8 MED-HIGH
9 HIGH
10 A/C OFF
67
C4
14
TNC5
14
LGC6
14
LBC7
14
BK/TN
C7
14
BK/TN
BLOCK RESISTOR
MOTOR
BLOWER
C2
22
DB/YL
C2
22
DB/YL
1C206
G203
Z8
14
BK/VT
S204
4A
FUSE
9
5
27
29
25A
FUSE
7
9
BLOCK FUSE
2 HEAD
1 PARK
0 OFF
SWITCH
HEADLAMP
1
BATT F33
E2
22
OR
C1
14
DG
C1
14
DG
C7
14
BK/TN
C7
14
BK/TN
4C206
6C206
RUN A22
FUSE
BLOCK
E1
20
TN
1
2
5124
MODE
SWITCH
MODE
SWITCH
OUTPUT
4
3 2
152
1 0
MOTOR BLOWER
HEATER
A/C
A/C
CYCLING
SWITCH
C2256
S314
TOZ8
18
BK/VT
E2
2O
OR
S210
6
SWITCH LAMP
FOG
REAR
E2
22
OR
SWITCH
3
(8W-15-6) (8W-11-11)(8W-11-8)(8W-11-2)
(8W-50-2)
(8W-11-2)(8W-10-6)
(8W-11-4)
(8W-42-4)
(8W-15-6) (8W-11-11) (8W-51-6)M
PL-RHD8W-42 AIR CONDITIONING-HEATER 8W - 42 - 3
PLR04202978W-1

Downloaded from www.Manualslib.com manuals search engine RUN A22
5
25
10A
FUSE
5
FUSED
IGN.
(RUN)
SWITCH CYCLING
A/C
C2
22
DB/YL
C2
22
DB/YL
F20
20
WT
F20
22
WT
2C206
2
MODE
SWITCH
OUTPUTA/C
CYCLING
SWITCH
OUTPUT
C21
22
DB/OR
3C206
13
1C206
S211
2C101
C21
20
DB/OR
BLOCK FUSE
C21
22
DB/OR
F20
22
WT
62
SWITCH PRESSURE
LOW
A/C
SWITCH CONTROL
HEATER
A/C
(8W-11-8)
(8W-11-8)(8W-11-2)
(8W-42-5) (8W-10-6)
(8W-42-3)
8W - 42 - 4 8W-42 AIR CONDITIONING-HEATERPL-RHD
978W-1PLR04203