No start DODGE NEON 2000 Service Manual PDF
[x] Cancel search | Manufacturer: DODGE, Model Year: 2000, Model line: NEON, Model: DODGE NEON 2000Pages: 1285, PDF Size: 29.42 MB
Page 408 of 1285

(11) Push the two ends of wire together until the
strands of wire are close to the insulation.
(12) Twist the wires together.
(13) Solder the connection together using rosin
core type solder only.Do not use acid core solder.
(14) Center the heat shrink tubing over the joint
and heat using a heat gun. Heat the joint until the
tubing is tightly sealed and sealant comes out of both
ends of the tubing.
(15) Insert the repaired wire into the connector.
(16) Install the connector locking wedge, if
required, and reconnect the connector to its mating
half/component.
(17) Re-tape the wire harness starting 1-1/2 inches
behind the connector and 2 inches past the repair.
(18) Connect battery, and test all affected systems.
DIODE REPLACEMENT
(1) Disconnect the battery.
(2) Locate the diode in the harness, and remove
the protective covering.
(3) Remove the diode from the harness, pay atten-
tion to the current flow direction (Fig. 22).(4) Remove the insulation from the wires in the
harness. Only remove enough insulation to solder in
the new diode.
(5) Install the new diode in the harness, making
sure current flow is correct. If necessary refer to the
appropriate wiring diagram for current flow.
(6) Solder the connection together using rosin core
type solder only.Do not use acid core solder.
(7) Tape the diode to the harness using electrical
tape making, sure the diode is completely sealed
from the elements.
(8) Re-connect the battery, and test affected sys-
tems.
Fig. 22 Diode Identification
1 ± CURRENT FLOW
2 ± BAND AROUND DIODE INDICATES CURRENT FLOW
3 ± DIODE AS SHOWN IN THE DIAGRAMS
PL8W - 01 GENERAL INFORMATION 8W - 01 - 15
SERVICE PROCEDURES (Continued)
Page 410 of 1285

8W-02 COMPONENT INDEX
Component Page
A/C Compressor Clutch Relay............8W-42
A/C Compressor Clutch.................8W-42
A/C Cycling Switch....................8W-42
A/C Heater Blower Motor...............8W-42
A/C Heater Control....................8W-42
A/C Pressure Switches..................8W-42
Airbag Control Module.................8W-43
Airbags.............................8W-43
Antenna.............................8W-47
Automatic Shut Down Relay.............8W-30
Back-Up Lamp Switch..................8W-51
Back-Up Lamps.......................8W-51
Battery.............................8W-20
Blower Motor Resistor Block.............8W-42
Brake Lamp Switch....................8W-30
Brake Shift Interlock Solenoid...........8W-30
Brake Warning Indicator Switch..........8W-40
Camshaft Position Sensor...............8W-30
Cargo Lamp..........................8W-44
Center High Mounted Stop Lamp.........8W-51
Center Stack Lamp....................8W-44
Cigar Lighter/Power Outlet..............8W-41
Circuit Breakers (FB)..................8W-11
City Lamps..........................8W-50
Clockspring.....................8W-33, 41, 43
Clutch Interlock Switch.................8W-30
Combination Flasher...................8W-52
Controller Anti-Lock Brake..............8W-35
Crankshaft Position Sensor..............8W-30
Data Link Connector...................8W-30
Decklid Release Switch.................8W-44
Decklid Solenoid......................8W-61
Diode No. 1..........................8W-42
Dome Lamp..........................8W-44
Dome Lamp/Intrusion Sensor............8W-44
Door Ajar Switches....................8W-40
Door Lock Motors.....................8W-61
Engine Coolant Temperature Sensor.......8W-30
Engine Oil Pressure Switch..............8W-30
Engine Starter Motor Relay.............8W-21
Engine Starter Motor..................8W-21
Fog Lamps........................8W-50, 51
Front Fog Lamp Switch.................8W-50
Fuel Injectors........................8W-30
Fuel Pump Module....................8W-30
Fuel Pump Relay......................8W-30
Fuel Tank...........................8W-30
Fuses (FB)...........................8W-11
Fuses (PDC).........................8W-10
Fuse Block...........................8W-11
Fusible Link A11...................8W-20, 21
Grounds.............................8W-15Component Page
Generator...........................8W-20
Glove Box Lamp/Switch.................8W-44
Headlamp Beam Select..............8W-40, 50
Headlamp Leveling Motors..............8W-50
Headlamp Leveling Switch Illumination....8W-50
Headlamp Leveling Switch..............8W-50
Headlamp Switch...................8W-50, 51
Headlamps..........................8W-50
Horns..............................8W-41
Horn Relay..........................8W-41
Horn Switch.........................8W-41
Hood Ajar Switch......................8W-39
Idle Air Control Motor..................8W-30
Ignition Coil.........................8W-30
Ignition Switch.......................8W-10
Indicators...........................8W-40
Indicator Drivers......................8W-40
Inlet Air Temperature Sensor............8W-30
Instrument Cluster....................8W-40
Instrument Panel Drivers...............8W-40
Knock Sensor.........................8W-30
Leak Detection Pump..................8W-30
License Lamps........................8W-51
Manifold Absolute Pressure Sensor........8W-30
Map/Reading Lamps...................8W-44
Multi- Function Switch.........8W-40, 50, 51, 52
Noise Suppressor......................8W-30
Oxygen Sensors.......................8W-30
Park Brake Switch....................8W-40
Park/Neutral Position Switch............8W-51
Park/Turn Signal Lamps................8W-52
Power Distribution Center...............8W-10
Power Mirror Switch...................8W-62
Power Steering Pressure Switch..........8W-30
Powertrain Control Module..............8W-30
PRNDL Lamp........................8W-44
Proportional Evap/Purge Solenoid.........8W-30
Radiator Fan Motor....................8W-42
Radiator Fan Relay....................8W-42
Radio...............................8W-47
Rear Window Defogger Switch...........8W-48
Rear Window Defogger.................8W-48
Remote Keyless Entry Module............8W-39
Repeater Lamps......................8W-52
Seat Belt Switch......................8W-40
Sentry Key Immobilizer Module..........8W-39
Side Marker Lamps....................8W-50
Siren...............................8W-39
Speakers............................8W-47
Splice Information.....................8W-70
Sunroof Control Module................8W-64
Sunroof Motor........................8W-64
PL8W - 02 COMPONENT INDEX 8W - 02 - 1
Page 412 of 1285

8W-10 POWER DISTRIBUTION
Component Page
A/C Compressor Clutch Relay........8W-10-7, 16
Automatic Shut Down Relay...........8W-10-16
Battery............................8W-10-7
Brake Lamp Switch................8W-10-7, 18
Cargo Lamp.......................8W-10-12
Center High Mounted Stop Lamp.......8W-10-18
Cigar Lighter/Power Outlet............8W-10-8
Circuit Breaker No. 1 (FB).............8W-10-9
Circuit Breaker No. 2 (FB).............8W-10-9
Combination Flasher.................8W-10-13
Controller Anti-Lock Brake.......8W-10-7, 11, 18
Data Link Connector.................8W-10-16
Dome Lamp.......................8W-10-12
Dome Lamp/Intrusion Sensor..........8W-10-12
Engine Starter Motor.................8W-10-8
Engine Starter Motor Relay........8W-10-7, 8, 10
Front Fog Lamp Switch..............8W-10-14
Fuel Injector No. 1..................8W-10-17
Fuel Injector No. 2..................8W-10-17
Fuel Injector No. 3..................8W-10-17
Fuel Injector No. 4..................8W-10-17
Fuel Pump Module..................8W-10-16
Fuel Pump Relay...................8W-10-16
Fuse 1 (FB)........................8W-10-10
Fuse 2 (FB)........................8W-10-10
Fuse 5 (PDC).......................8W-10-7
Fuse 6 (FB).........................8W-10-9
Fuse 6 (PDC).....................8W-10-7, 11
Fuse 7 (FB).........................8W-10-9
Fuse 8 (FB).........................8W-10-9
Fuse 8 (PDC).....................8W-10-7, 11
Fuse 9 (FB)........................8W-10-10
Fuse 9 (PDC)......................8W-10-7, 8
Fuse 10 (FB).......................8W-10-10
Fuse 10 (PDC)....................8W-10-7, 11
Fuse 11 (FB).......................8W-10-10
Fuse 12 (FB).......................8W-10-10
Fuse 13 (PDC)....................8W-10-7, 12
Fuse 14 (FB)........................8W-10-9
Fuse 14 (PDC).....................8W-10-7, 8
Fuse 15 (FB)........................8W-10-9
Fuse 15 (PDC)....................8W-10-7, 13
Fuse 16 (FB)........................8W-10-9Component Page
Fuse 18 (PDC)....................8W-10-7, 13
Fuse 20 (FB).......................8W-10-11
Fuse 20 (PDC)....................8W-10-7, 14
Fuse 21 (PDC)....................8W-10-7, 16
Fuse 22 (PDC)....................8W-10-7, 16
Fuse 23 (PDC)....................8W-10-7, 18
Fuse Block....................8W-10-9, 10, 11
Generator.........................8W-10-17
Glove Box Lamp/Switch..............8W-10-12
Headlamp Switch...................8W-10-14
High Note Horn....................8W-10-13
Horn Relay......................8W-10-7, 13
Ignition Coil.......................8W-10-17
Ignition Switch................8W-10-7, 8, 9, 10
Instrument Cluster.............8W-10-8, 12, 14
Instrument Panel Drivers.............8W-10-14
Left Front Fog Lamp..............8W-10-14, 15
Left Tail/Stop Lamp.................8W-10-18
Left Tail/Stop/Turn Signal Lamp........8W-10-19
Left Visor/Vanity Lamp...............8W-10-12
Low Note Horn.....................8W-10-13
Map/Reading Lamps.................8W-10-12
Multi-Function Switch......8W-10-7, 13, 14, 15, 19
Noise Suppressor...................8W-10-17
Oxygen Sensor 1/1 Upstream..........8W-10-17
Oxygen Sensor 1/2 Downstream........8W-10-17
Power Distribution Center.....8W-10-2, 3, 4, 7, 8,
9, 11, 12, 13, 14, 16, 18
Powertrain Control Module.........8W-10-16, 17
Radiator Fan Motor.................8W-10-11
Radiator Fan Relay................8W-10-7, 11
Radio.............................8W-10-12
Rear Window Defogger...............8W-10-11
Rear Window Defogger Switch.........8W-10-11
Remote Keyless Entry Module.........8W-10-12
Right Front Fog Lamp...............8W-10-15
Right Rear Fog Lamp................8W-10-14
Right Tail/Stop Lamp................8W-10-18
Right Tail/Stop/Turn Signal Lamp......8W-10-19
Right Visor/Vanity Lamp..............8W-10-12
Sentry Key Immobilizer Module........8W-10-12
Siren.............................8W-10-12
Underhood Lamp...................8W-10-12
PL8W - 10 POWER DISTRIBUTION 8W - 10 - 1
Page 413 of 1285

POWER DISTRIBUTION CENTER
NOT
USED
FAN RADIATOR
RELAY
USEDNOT NOT
USEDFUEL
PUMP
NOT
USED
USEDNOT
RELAYHORN RELAY
USEDNOT
NOT
USED FUSE
10 FUSE 22 FUSE 23
FUSE 20 FUSE 21
FUSE 18 FUSE 19
FUSE 16 FUSE 17
FUSE 14 FUSE 15
FUSE 12 FUSE 13
11 FUSE
9 FUSE FUSE
8
FUSE
67FUSE
FUSE
45FUSE
FUSE
23FUSE
ENGINE
STARTER
MOTOR
RELAY RELAY CLUTCH COMPRESSORA/C RELAY SHUT DOWNAUTOMATIC
8W - 10 - 2 8W-10 POWER DISTRIBUTIONPL
008W-10PLI01002
Page 416 of 1285

-
CIRCUIT CAVITY FUNCTION
-
33
FUSED B(+) A14 18RD/WT
34
IGNITION SWITCH OUTPUT (START) A41 14YL 24AUTOMATIC SHUT DOWN RELAY CONTROL K51 18DB/YL 38FUSED IGNITION SWITCH OUTPUT (ST-RUN) F12 18DB/WT
ENGINE STARTER MOTOR RELAY CONTROL 28 K90 20TNFUSED B(+) 25 A1 14RD 29 A/C COMPRESSOR CLUTCH RELAY CONTROL
C3 20DB/BK 31 A/C COMPRESSOR CLUTCH RELAY OUTPUT
A14 18RD/WT 35 FUSED B(+)
36A142 18DG/OR
T40 14BR ENGINE STARTER MOTOR RELAY OUTPUT 26 30C28 18DB/OR
A17 20RD/BK FUSED B(+)
AUTOMATIC SHUT DOWN RELAY OUTPUT
CAVITYFUNCTION CIRCUIT
--
- -
CIRCUIT FUNCTIONCAVITY
32
37
27
AUTOMATIC
SHUT
DOWN
RELAY RELAY CLUTCH COMPRESSORA/C
RELAY MOTOR STARTERENGINE
PL8W-10 POWER DISTRIBUTION 8W - 10 - 5
PLI01005008W-10
Page 418 of 1285

POWER
DISTRIBUTION
CENTER
18FUSE15A23FUSE15A
20A
FUSE
14
8FUSE
40A
40A
FUSE
1013FUSE15A 30A
FUSE
9
8RD A0
5FUSE30A 30A
FUSE
64FUSE40A 40A
FUSE
3
BATTERY
A3
12
RD/WTA2
12
PK/BKA20
12
RD/DBA16
14
GY
A1
14
RDA4
10
BK/RDF1
16
DBM1
20
PK
WT18 A15
15FUSE15A
F32
18
PK/DBF62
18
RDF62
18
RD
RD/WT14 A14
21FUSE20A20A
FUSE
22
A17
20
RD/BK
IGNITION
SWITCH
TO
ENGINE
STARTER
MOTOR
RELAY
TO TO
S224 IGNITION
SWITCH
TOTOBRAKE ANTI-LOCK CONTROLLER RADIATOR
FAN
RELAY
TO TO
BRAKE ANTI-LOCK CONTROLLER
RD/DG12 A10
TO
S132
TO
S103 IGNITION
SWITCH
TO
HORN
RELAY
TO TO
RELAYHORN
TO
RELAY CLUTCH COMPRESSORA/C
3456 8
C23C104C1042322
C22
(IN PDC)
910131415
C10324
B24
(IN PDC)
C104 C1037
C7 B66
23 18 21 22
(IN PDC) (IN PDC)
(IN PDC)
PK/BK12 A2
TO
SWITCH FUNCTIONMULTI- BRAKE
LAMP
SWITCH
TO TOS106
20
F61
16
WT/OR
C14C10414
20FUSE
25A
A15
20
WT
BUILT-
UP-EXPORT UP-EXPORTBUILT- EXCEPT
MULTI-
FUNCTION
SWITCH
TO
NOT
USED14C104
(8W-10-2)
(8W-10-3)
(8W-10-13)(8W-10-18)(8W-10-8)(8W-10-11)
(8W-10-11) (8W-10-12) (8W-10-8)(8W-10-11) (8W-10-11) (8W-10-8) (8W-10-9) (8W-20-2)
(8W-10-13)
(8W-10-16) (8W-10-16) (8W-10-8)
(8W-21-2) (8W-10-9)
(8W-10-8)(8W-35-2)
(8W-42-5)(8W-35-2)
(8W-10-11)
(8W-10-12)
(8W-10-8)
(8W-41-2)
(8W-41-3)(8W-41-2)
(8W-41-3)
(8W-42-2)(8W-52-3)
(8W-52-4) (8W-30-13) (8W-10-16) (8W-10-14)
(8W-50-4)
PL8W-10 POWER DISTRIBUTION 8W - 10 - 7
PLI01007008W-10
Page 419 of 1285

9FUSE30A4FUSE40A
94
POWER
DISTRIBUTION
CENTER BATT A0
T40
14
BR
4C102
T40
14
BR
ENGINE
STARTER
MOTOR
A1
14
RD
B24C103
A1
14
RD
9
8 1
72
SWITCH IGNITION
A31
14
BK/WT
RUN-ACC A31
ST-RUN A21
A21
14
DBA22
12
BK/OR
RUN A22
6
A41
14
YL3
4
3 LOCK 0 OFF
1 START
2 RUN ENGINE
STARTER
MOTOR
RELAY
14
20A
FUSE
14
24
227C104
A1
14
RDA2
12
PK/BK
A2
12
PK/BKF1
16
DB
F1
16
DB
5G26
22
LB
23
OUTLET POWER
LIGHTER/
CIGAR
C103B23
1
CLUSTER INSTRUMENT
F30
16
RD
SWITCH IGNITION
KEY-IN C22 C7
234 ACC
ST A41
25
26
3
0 2
14 41
2
033
0 2
144 1
2
03
(8W-21-2)
(8W-10-9) (8W-10-7)
(8W-10-2)
(8W-10-3)
(8W-10-10)(8W-10-10)(8W-21-2)
(8W-41-4)(8W-40-7)
(8W-40-8)
(8W-10-10)
8W - 10 - 8 8W-10 POWER DISTRIBUTIONPL
008W-10PLI01008
Page 420 of 1285

3FUSE40A
3
BATT A0
A3
12
RD/WT
23C104
A3
12
RD/WT
15FUSE15A16FUSE5A
BLOCK
FUSE
A3
12
RD/WT
S224 POWER
DISTRIBUTION
CENTER
3536
8
BATT A2
A22
12
BK/OR
S222
2510A FUSE
527
10A
FUSE
7
26
20A
FUSE
6
41
42
A22
12
BK/OR
BK/OR12 A22
(LHD) 10A 20A
FUSE
BLOCK
3420A
FUSE
14
5
67
161514
BK/OR12 A22
WINDOWSPOWER
OTHERC23
43
44
A3
12
RD/WT
CIRCUIT
BREAKER
NO. 2
25A
30A NO. 1
BREAKER
CIRCUIT
8
8FUSE
10A
28
(RHD)
3
0 2
14
4 ACC 3 LOCK 2 RUN
1 START
0 OFF
IGNITION
SWITCH
LHD
RHD
(8W-11-13)
(8W-11-14)(8W-11-13)
(8W-11-14)(8W-11-2)
(8W-11-3) (8W-10-2)
(8W-10-3) (8W-10-8)
(8W-11-2)
(8W-11-3) (8W-10-7)
(8W-11-13)
(8W-11-14)(8W-11-18)
(8W-11-17)
(8W-11-7)(8W-11-8) (8W-10-8)
(8W-11-7)
(8W-11-8) (8W-11-7)
(8W-11-8)
PL8W-10 POWER DISTRIBUTION 8W - 10 - 9
PLI01009008W-10
Page 421 of 1285

ENGINE
STARTER
MOTOR
RELAY
(IN PDC)
A41
14
YL
C10323
28
24
30
BLOCK FUSE
2
BATT A1
A21
14
DB
A41
14
YL
67
BK/WT14
3129
10A
FUSE
9
1FUSE10A
2122
10A
FUSE
2
FUSE
BLOCK
A31
91011
12
B23
(LHD)(RHD) 12
12FUSE10A
32
3
3FUSE20A
2324
10A
FUSE
4
4
4 ACC 3 LOCK 2 RUN
1 START
0 OFF
IGNITION
SWITCH
15A FUSE
10
10A10A FUSE
11
15A
RHD LHD
3
0 2
14 41
2
03
(8W-21-2)(8W-11-2)
(8W-11-3) (8W-10-8)
(8W-11-11)
(8W-11-6) (8W-11-6)(8W-11-2)
(8W-11-3) (8W-11-12)
(8W-11-6) (8W-11-6)(8W-10-8)
(8W-11-10)
(8W-11-11)(8W-11-10)
(8W-11-12)
8W - 10 - 10 8W-10 POWER DISTRIBUTIONPL
008W-10PLI01010
Page 470 of 1285

8W-20 CHARGING SYSTEM
Component Page
Automatic Shut Down Relay............8W-20-2
Battery............................8W-20-2
Engine Starter Motor.................8W-20-2
Fuse 21 (PDC)......................8W-20-2
Fusible Link........................8W-20-2
G104..............................8W-20-2Component Page
G105..............................8W-20-2
Generator..........................8W-20-2
Inlet Air Temperature Sensor...........8W-20-2
Power Distribution Center.............8W-20-2
Powertrain Control Module............8W-20-2
PL8W - 20 CHARGING SYSTEM 8W - 20 - 1