key DODGE SPRINTER 2008 2.G Manual PDF

545 Practical hints
Replacing the wiper blades
5
\3 Replacing the wiper blades
\1
Apply the handbrake (
\2
page 191).
1Wiper blade
2Retaining clips
3Wiper arm\1
Fold the wiper arms away from the
windshield.
!
CAUTION
Do not open the hood while the wiper
arms are folded away from the wind-
shield. You would damage the hood
and the wiper arms.
Do not fold the wiper arms onto the
windshield without wiper blades be-
ing attached. You could scratch the
windshield.
For your own convenience, have this
work carried out at an authorized
Sprinter Dealer.
Removing the wiper bladesWarning
G
When the windshield wipers are set to in-
termittent wipe or the rain sensor is ac-
tive, the windshield wipers could move at
any time and injure yourself or others
upon contact with them.
Always remove the key from the ignition
lock before replacing the wiper blades.
nf_BA.book Page 545 Friday, January 25, 2008 3:53 PM

570 Practical hintsFlat tire
5
After filling with tire sealant
\1
Turn the pressure release screw on
pressure gauge
5
counterclock-
wise and bleed the system.
\1
Turn the key to position
0 in the igni-
tion lock (
\2
page 111).
\1
Pull the electric air pump connector
out of the 12 V socket.
\1
Store the electric air pump, tire seal-
ant bottle
8
with valve core
extractor
c
and, if used, the warn-
ing triangle and hazard warning
lamps inside the vehicle.
\1
Unscrew and remove angle bracket 2
from valve
7
on tire sealant bot-
tle
8
and screw the valve cap onto
the valve.
\1
Pull away immediately.This enables the tire sealant to dis-
tribute inside the tire and create a
more effective seal.
\1
Stop after about 3 minutes and
check the tire pressure using the
electric air pump, for example.
Warning
G
Do not exceed the maximum speed of
50 mph (80 km/h).
The "max. 50 mph (80 km/h)" sticker
must be affixed within the driver's field of
vision.
The vehicle’s handling characteristics
may be affected.
iYou must connect the angle bracket
on hose
3
of the electric air pump
directly to the tire valve on the tire.
nf_BA.book Page 570 Friday, January 25, 2008 3:53 PM

575 Practical hints
Battery
5
\1
Switch off all electrical consumers.
Disconnecting the starter batteryThe starter battery is in the battery re-
cess in the driver’s footwell.Removing/installing the floor cover-
ing in the driver's footwell
1Floor covering
2Trim
3Securing screws\1To remove:
undo screws
3
and re-
move trim
2
.
\1
Remove floor covering
1
.
!
CAUTION
Switch off the engine and take the
key out of the ignition lock before
you loosen or disconnect the termi-
nal clamps. You may otherwise de-
stroy electronic components such as
the alternator.
Always disconnect the starter bat-
tery in the battery recess in the driv-
er’s footwell first.
nf_BA.book Page 575 Friday, January 25, 2008 3:53 PM

582 Practical hintsJump-starting
5
\1
Make sure that the two vehicles do
not touch.
\1
Apply the handbrake or move the se-
lector lever to position
P.
\1
Switch off all electrical consumers.
\1
Switch on the battery isolating
switch* if necessary (
\2
page 338).
\1
Remove the key from the ignition
lock.
\1
Open the hood (
\2
page 318).
The jump-starting connection point is on
the left-hand side of the air cleaner in
the engine compartment when looking
in the direction of travel.
Jump-starting connection point
1Positive terminal clamp of jumper cable\1
Remove the positive terminal cover
from the donor battery.
\1
Connect positive terminal of donor
battery
2
to jump-starting connec-
tion point 1
with the jumper cable.
Start with the donor battery.
\1
Using red positive terminal clamp
1

of the jumper cable, slide the red
protective cap of the jump-starting
connection point back with a clock-
wise turn and connect the positive
terminal clamp of the jumper cable
to the positive terminal of the jump-
starting connection point.
nf_BA.book Page 582 Friday, January 25, 2008 3:53 PM

585 Practical hints
Towing
5
\3 Towing
Comply with legal regulations when tow-
ing.Having the vehicle carried away on a
transporter or trailer is preferable to
towing it away. We recommend the use
of a rigid towing bar if towing is neces-
sary.
The fixture for the front towing eye is lo-
cated behind the cover in the bumper on
the right-hand side when viewed in the
direction of travel.
Warning
G
Tow the vehicle using a rigid towing bar if:the engine is not running,there is a malfunction in the power supply
or the vehicle’s electrical system.There is no power assistance for the
steering and braking when the engine is
not running. You must then use signifi-
cantly greater force to steer the vehicle
and brake.
Continued
Warning (Continued)
G
Do not tow the vehicle if the key cannot
be turned in the ignition lock. The steering
is then locked and it will not be possible
to steer the vehicle.When towing another vehicle, its weight
should not be greater than the permissi-
ble gross weight of your vehicle.
Installing / removing the towing
eye
nf_BA.book Page 585 Friday, January 25, 2008 3:53 PM

588 Practical hintsTowing
5
With front axle damage
\1
Turn the key to position
1 in the igni-
tion lock(
\2
page 111).
In the event of a malfunction in the
electrical systemIf the battery is malfunctioning, the auto-
matic transmission will be locked in
position
P. To shift the automatic trans-
mission to position
N, you must provide
power to the vehicle’s electrical system
in the same way as jump-starting
(
\2
page 581).
Have the vehicle transported on a trans-
porter or trailer.The towing eye can be used to pull the
vehicle onto a special transporter or
trailer for transportation.
\1
Shift the transmission to neutral or
move the selector lever to
position
N.
!
CAUTION
The vehicle must not be towed with
its front wheels raised and with the
key in position
2 in the ignition lock.
Active brake intervention by ESP
® or
ASR could otherwise lock the wheels
and damage the brake system.
Transporting the vehicle!
CAUTION
Only secure the vehicle at the
wheels / rims. Your vehicle could oth-
erwise be damaged.
nf_BA.book Page 588 Friday, January 25, 2008 3:53 PM

632 *Technical dataVehicle identification labels
6
\3 Vehicle identification labels
Base of the driver’s seat
1Vehicle safety certification label
or
Incomplete vehicle safety certification la-
bel
iFor certain vehicles, vehicle data
cards are delivered with the vehicle.
These vehicle data cards contain all
the important details of your vehicle,
e.g. vehicle identification number,
engine number and subassembly
numbers together with the model
and optional equipment codes.
This data is required when ordering
parts and for questions of a technical
nature.
For reasons of security, card 1 must
not be kept in the vehicle. It contains
the key number required for obtain-
ing replacement keys.
Handing cards 2 and 3 to an autho-
rized Sprinter Dealer will simplify or-
der processing.
nf_BA.book Page 632 Friday, January 25, 2008 3:53 PM

639 Index
stopping . . . . . . . . . . . . . . . . . . . 206
towing . . . . . . . . . . . . . . . . . . . . 587
trailer towing . . . . . . . . . . . . . . . 207
working on the vehicle . . . . . . . . 207Auxiliary heating
. . . . . . . . . . . . . 236
heater booster function . . . . . . . 234
malfunctions . . . . . . . . . . . . . . . 453
with water heater
changing the remote control
batteries . . . . . . . . . . . . . . . . . 541
remote control . . . . . . . . . . . . 239
selecting a switch-on time . . . 240
setting the switch-on time . . . 242
B
Bar
. . . . . . . . . . . . . . . . . . . . . . . . 394
BASsee Brake AssistBatteryauxiliary . . . . . . . . . . . . . . . . . . . 577
charge indicator lamp . . . . . . . . 469
check lamp (auxiliary heating
remote control) . . . . . . . . . . . . . 240
display message . . . . . . . . . . . . 497
in the auxiliary heating remote
control . . . . . . . . . . . . . . . . . . . . 541
in the engine compartment . . . . 577
in the key . . . . . . . . . . . . . . . . . . 540
indicator lamp (key) . . . . . . . . . . . 86
isolating switch . . . . . . . . . 338
,339
recharging . . . . . . . . . . . . . . . . . 579
reconnecting . . . . . . . . . . . . . . . 580
removing . . . . . . . . . . . . . . . . . . 578safety notes . . . . . . . . . . . . . . . . 335
starter battery
disconnecting . . . . . . . . . . . . 575
Bead
. . . . . . . . . . . . . . . . . . . . . . . 394
Belt force limiters
. . . . . . . . . . . . .44
Bi-xenon headlamps
. . . . . . . . . . 527
driving abroad . . . . . . . . . . . . . . 311
Body builder guideline
. . . . . . . . . .11
Bottle holdersee Cup holdersBrake Assist (BAS)
. . . . . . . . . . . . .71
display message . . . . . . . . 500
–501
indicator lamp . . . . . . . . . . 462,465
malfunction . . . . . . . . . . . . . . . . 465
Brake fluid
. . . . . . . . . . . . . . . . . . 617
checking the brake fluid level . . 331
display message . . . . . . . . . . . . 498
B
nf_BA.book Page 639 Friday, January 25, 2008 3:53 PM

644 IndexE
EBVsee Electronic brake force distributionElectric sliding door
. . . . . . . . 92
,98
programming the key . . . . . . . . . . 97
programming the remote control . 97
reset . . . . . . . . . . . . . . . . . . . . . . . 98
unlocking mechanism for the
electric drive . . . . . . . . . . . . . . . . 96
Electrical heater booster
system
. . . . . . . . . . . . . . . . . . . . . 235
Electrical systemfuses . . . . . . . . . . . . . . . . . . . . . 589
switching on/off . . . . . . . . . . . . 339Electrical/electronic
equipment
. . . . . . . . . . . . . . . . . . 315
retrofitting . . . . . . . . . . . . . . . . . 602
Electronic
brake force distribution (EBV)
. . . 76
display message . . . . . . . . 498–499
indicator lamps . . . . . . . . . . . . . . 76
malfunction . . . . . . . . . . . . . . . . 462
Electronic Stability
Program (ESP
®)
display message . . . . . . . . . . . . 493
indicator lamp . . . . . . . . . . 462, 468
malfunction . . . . . . . . . . . . . . . . 468
warning lamp . . . . . . . . . . . . . . . 461
Emergency exit window
. . . . . . . . 66
Emergency modeautomatic transmission . . . . . . . 441Emergency tensioning
retractors
. . . . . . . . . . . . . . . . . . . 44
Emission control
. . . . . . . . . . . . . 314
Enginediagnostic, indicator lamp . . . . . 477engine power output, modifying . . . . 10malfunctions . . . . . . . . . . . . . . . 436
not running smoothly . . . . . . . . 438
number . . . . . . . . . . . . . . . . . . . 632
operating safety . . . . . . . . . . . . . . 10
starting . . . . . . . . . . . . . . . . . . . 111
starting problems . . . . . . . . . . . 437
switching off . . . . . . . . . . . . . . . 193Engine cleaning
. . . . . . . . . . . . . . 420
Engine electronicstampering with . . . . . . . . . . . . . 602Engine oil
. . . . . . . . . . . . . . . 322
,606
adding . . . . . . . . . . . . . . . . . . . . 328
checking the level . . . . . . . . . . . 323
display message . . . . . . . . 508–510
warning lamp . . . . . . . . . . . . . . . 471
M E
nf_BA.book Page 644 Friday, January 25, 2008 3:53 PM

649 Index
K
Keybattery check lamp . . . . . . . . . . . 86
buttons . . . . . . . . . . . . . . . . . . . . 85
changing the batteries . . . . 539
,540
lost . . . . . . . . . . . . . . . . . . . . . . . 448
malfunction . . . . . . . . . . . . 446–449
problems . . . . . . . . . . . . . . . . . . 445
Key no.
. . . . . . . . . . . . . . . . . . . . . 632
Key positions
Kickdown
. . . . . . . . . . . . . . . . . . . 206
Kilopascal
. . . . . . . . . . . . . . . . . . 396
L
Lamp failure monitor
. . . . . . . . . 129
Languagedisplay
(vehicles with steering wheel
buttons) . . . . . . . . . . . . . . . . . . . 166Lashing eyes
. . . . . . . . . . . . . . . . 280
mounting . . . . . . . . . . . . . . . . . . 284
permissible tensile load . . . . . . . 629
Lashing eyes/rails
. . . . . . . . . . . 280
Lashing pointsmaximum load-bearing capacity . . 629Lashing points and aids
. . . . . . . 280
permissible tensile load . . . . . . . 629
LATCH type child restraint
system
. . . . . . . . . . . . . . . . . . . . . . 61
License plate lamp
. . . . . . . 530
,531
changing bulbs . . . . . . . . . . . . . 534
Light-alloy wheels
. . . . . . . . . . . 420
Lighting
. . . . . . . . . . . . . . . . . . . . 129
changing bulbs . . . . . . . . . . . . . 525
exterior – see Exterior lighting
instrument . . . . . . . . . . . . . . . . . 144
interior, front . . . . . . . . . . . . . . . 137
interior, rear . . . . . . . . . . . . . . . 138
lamp failure monitor . . . . . . . . . 129
Lightsautomatic headlamp control . . . 132
front foglamp indicator lamp . . . 130
headlamp flasher . . . . . . . . . . . . 131
low-beam headlamps . . . . . . . . 130
reading lamp . . . . . . . . . . . . . . . 138
rear foglamp indicator lamp . . . 130
L
K
nf_BA.book Page 649 Friday, January 25, 2008 3:53 PM