lock FIAT BARCHETTA 2003 1.G Service Manual

129
Some simple steps can reduce po-
tential damage to the blades:
– If the temperature falls to below
zero, make sure the rubber blade is
not frozen to the windscreen. If nec-
essary, free it with a de-icing com-
pound.
– Remove any snow that has settled
on the glass: besides saving the blades
you will avoid straining the electric
windscreen wiper motor and causing
it to overheat.
– Do not operate the windscreen
wipers on dry glass.SPRAY NOZZLES
If there is no jet of liquid, first make
sure that there is liquid in the reser-
voir: see “Checking fluid levels” in this
chapter.
Then make sure that the holes in the
nozzles fig. 12 are not clogged up.
Use a pin for this if necessary.
The jets of the windscreen washer
are directed by adjusting the nozzles
in such a way that the jets are direct-
ed at the highest point reached by the
wiper blades when operating. Changing the windscreen
wiper blade fig. 11
1)Lift windscreen wiper armAand
position the blade to form a right an-
gle with the arm.
2) Press tab Bof the coupling spring
and remove the blade to be replaced
from the arm.
3)Fit the new blade by inserting the
tab into the special hole in the arm.
Make sure it is locked into place.
fig. 12
P5S00711m
fig. 11
P5S00710m

136
IDENTIFICATION DATA
MODEL PLATE fig. 3
The plate shows the following iden-
tification data:
A- Manufacturer’s name
B- Homologation number
C- Vehicle ID code
D- Chassis serial number
E- Maximum vehicle weight fully
laden
F- Maximum train weight (fully-laden
vehicle plus trailer)
fig. 2
P5S10041m
fig. 3
P5S00686m
fig. 1
P5S00688m
G- Maximum vehicle weight on first
(front) axle
H- Maximum vehicle weight on sec-
ond (rear) axle
I - Engine model code
L- Body version code
M- Number for spares
N- Smoke opacity index (for diesel
engines)
The plate is fastened to the front
cross member of the engine com-
partment at position B-fig. 2. CHASSIS MARKING fig. 1
This is stamped on the passenger
cabin floor pan near the right-hand
front seat and includes:
– vehicle model ZFA 183000
– chassis serial number.
ENGINE MARKING fig. 2
Marking Ais stamped on the cylin-
der block and includes the model and
serial number.

140
SUSPENSIONS
FRONT
Independent wheel, MacPherson-
type with ferritic cast-iron wishbone
anchored to an auxiliary cross-mem-
ber.
Off-set coil springs and double-action
telescopic gas dampers.
Anti-roll bar.
REAR
Independent wheels with spheroidal
cast-iron wishbones.
Coil springs and gas dampers with
vulcanised bushings.
Anti-roll bar.
Auxiliary rigid H-shaped frame con-
sisting of a tubular cross structure and
two pressed steel long members weld-
ed to it.
STEERING
Energy-absorbing jointed steering
column with rake adjustment system.
Permanently lubricated rack and pin-
ion control.
Hydraulic power steering.
Permanently lubricated joints.
Minimum turning circle: 10.5 metres.
Number of steering wheel turns lock
to lock: approx. 2.5.
WHEEL
GEOMETRY
Wheel toe-in measured from rim to
rim: 0±1 mm.
The figures refer to the car in full
running order.
PERFORMANCE
Maximum speeds after running in, in km/h:
1st2nd3rd 4th5th”Reverse
55 97 143 188 More 55
than 200

159
INDEX
ABS ........................................... 56
Accessories purchased
by the owner .............................. 82
Accessory installation......... 149
Air cleaner................................... 122
Air recirculation ......................... 36
Airbags
– general information ............ 60
– switching the passenger side
airbag off .............................. 59
Ashtray ......................................... 43
Battery
– jump starting ................ 85-105
– liquid level ............................ 123
– recharging ............................. 105
Bodywork
– maintenance ......................... 130
– paint identification plate .... 137
– versions ............................... 137
Bonnet .......................................... 53
Boot
– opening/closing.................... 55
Brake fluid level .......................... 121Brake lights .................................. 96
Brakes
– fluid level............................... 121
– service and emergency
brakes .................................... 139
Bulb replacement ....................... 91
Car maintenance................. 111
Capacities ............................. 64-144
Catalytic converter .................. 66
Ceiling light.................................. 42
– bulb replacement ............... 98
Cellular phone setup................. 63
Central door locking................. 44
Cheap running ............................ 78
Children (safety) ........................ 24
Cigar lighter ................................ 43
Climate control system ............ 36
– controls................................. 36
– maintenance ......................... 130
Clutch ........................................... 139
CO
2emissions ........................... 147
Containing running costs
and pollution ........................... 76
Dashboard ................................ 7Defrosting.................................... 35
Demisting..................................... 35
Digital clock ................................ 29
Dimensions ................................ 142
Dipped-beam headlights
– controls ............................... 38
– bulb replacement ............... 93
Direction indicators
– controls ............................... 39
– front bulb replacement ..... 94
– rear bulb replacement ...... 95
– side bulb replacement ...... 95
Doors ........................................... 44
Driving your car..................... 67
Electric windows ..................... 45
Electronic alarm.................. 13-150
Electronic control units............ 125
Engine
– cooling................................... 138
– fuel feed/ignition ................. 138
– identification code .............. 136
– lubrication ............................ 138
– specifications........................ 137
Engine compartment washing . 132

161
– homologation codes....... 156
Rear fog lights
– controls ............................ 41
– bulb replacement ........... 97
Rear windowing (cleaning) . 133
Rearview mirrors
– electric............................... 20
– external ............................. 20
– internal .............................. 20
Rev counter............................. 28
Repeated checks ................... 82
Reversing lights ....................... 97
Rubber piping .......................... 128
Safe driving
– driving at night ................. 73
– driving in the rain ............ 74
– before getting behind
the wheel .......................... 72
– driving in fog .................... 74
– driving in the mountains 75
– driving on snow and ice 75
– driving with ABS.............. 75
– when travelling ................ 72
Seat belts
– general information ........ 22– maintenance ..................... 23
– use ...................................... 21
Seats
– adjustment ........................ 18
– cleaning.............................. 134
Servicing ................................... 111
– additional operations ..... 115
– annual inspection schedule 115
– scheduled service............ 112
– Service Schedule ............. 113
Side/taillights
– controls ............................ 38
– front bulb replacement 93
– rear bulb replacement .. 96
Snow tyres ............................... 80-141
Spark plugs............................... 126
Specifications ........................... 135
Speedometer........................... 28
Starting the engine
– jump starting .................... 85
– bump starting ................... 86
– emergency start-up ........ 84
– ignition switch.................. 17
– stopping the engine ........ 69
– warming up a recently
started engine .................. 69Steering column lock............. 18
Steering column stalks
– left-hand stalk .................. 38
– right-hand stalk................ 39
Steering wheel ........................ 19
Steering..................................... 140
Storing the car ........................ 81
Sun visors ................................. 43
Suspensions ............................. 140
Symbols .................................... 9
Technical specifications.... 135
Third brake light
(bulb replacement) ............... 96
Tools............................................. 88
Top speeds .................................. 140
Towing a trailer
– tow hitch installation ......... 152
– warnings................................ 79
Towing the car ........................... 108
Transmission (ratios) ................ 139
Transporting children
in safety .................................... 24
Tyre pressure ............................. 148
Tyres ..................................... 126-148