light FIAT BARCHETTA 2003 1.G Repair Manual

113
SERVICE SCHEDULE
Use these coupons either every 20,000 km.
Thousands of km20 40 60 80 100 120 140 160 180
Check tyre conditions/wear and check pressure, if required
Check complete light system operation (headlights, direction
indicators, hazard lights, boot lights,
passenger compartment lights, oddment compartment lights,
instrument panel warning lights, etc.)
Check windscreen wiper/washer system and adjust nozzles
Check front wiper blade wear
Check front disc brake wear indicator operation
Check rear disc brake conditions and wear
Visually inspect: conditions of underbody protection, piping
(exhaust - fuel feed - brakes), rubber parts
(boots - sleeves - bushings, etc.),
brake hoses and fuel lines
Visually inspect belt drives
Check handbrake stroke
ççççççççç
ççççççççç
ççççççççç
ççççççççç
ççççççççç
çççç
ççççççççç
çççç
çççç

115
ANNUAL
INSPECTION
SCHEDULE
The following annual inspection
schedule is required for cars travelling
less than 20,000 km a year (e.g. ap-
proximately 10,000 km). The schedule
includes the following operations:
– Check tyre condition and wear and
adjust pressure, if required (including
spare-saver spare wheel).
– Check operation of lights (head-
lights, direction indicators, hazard
lights, boot light, passenger compart-
ment ceiling light, glove compartment
light, instrument panel lights, etc.).
– Check windscreen wiper/washer
and adjust nozzles.
– Check position wear of windscreen
window wiper blades.
ADDITIONAL
OPERATIONS
Every 1,000 kmor before long
trips, check and top up as necessary:
– coolant level
– brake fluid level
– power steering fluid level
– electrolyte level
– windscreen washer liquid level
– tyre condition and pressure.
We advise you to use FL Selenia
products, which have been designed
and produced expressly for the Fiat
vehicles (see the table “Capacities” giv-
en in the “Technical specifications”
section).
Every 3,000 km check and top up
as necessary: engine oil level. – Check rear brake pad conditions
and wear.
– Inspect conditions of. engine, gear-
box, transmission, piping (exhaust - fu-
el feed - brakes), rubber parts (boots
- sleeves - bushings - etc.), brake and
fuel line hoses.
– Check battery charge status.
– Check conditions of various con-
trol belts.
– Check and top up fluid levels (en-
gine coolant, brakes, windscreen
washer, battery, etc.).
– Change engine oil.
– Replace engine oil filter.
– Replace pollen filter (where fitted).

121
Oil consumption is ex-
tremely low: if it needs
topping up after travelling
only a short while, have the sys-
tem checked for leaks at a Fiat
Dealership.
fig. 6
P5S10044m
The level of the fluid in the reservoir
must not exceed the MAXmark.
If you need to add fluid, only use the
type classified DOT 4. You are advised
in particular to use TUTELA TOP 4
with which the braking system was
originally filled. BRAKE FLUID fig. 6
From time to time check the instru-
ment panel warning light by pressing
the reservoir cover (with the ignition
key at MAR): instrument warning pan-
el light xshould come on.
On versions fitted with ABS, the
brake fluid reservoir is positioned as
shown in fig. 6; while on versions
without ABS, the reservoir is posi-
tioned lengthwise.
Make sure the highly
corrosive brake fluid does
not drip onto the paint-
work. If it does, wash it off im-
mediately with water.
Make sure the power steer-
ing fluid does not come in-
to contact with the hot parts of the
engine as is catches fire very easi-
ly.
WARNING

124
USEFUL ADVICE
FOR LENGTHENING THE
LIFE OF YOUR BATTERY
When you park the car, ensure the
doors, boot and bonnet are closed
properly. The courtesy light must be
off.
Do not keep accessories (e.g. radio,
hazard lights etc.) switched on for a
long time when the engine is not run-
ning.
IMPORTANT A battery which is
kept at a charge of less than 50% for
any length of time will be damaged by
sulphation leading to a reduction in
cranking power and a higher risk of
the battery electrolyte freezing (this
may even occur at –10°C).
If the car is inactive for a long peri-
od of time, refer to “Storing the car”
in the “Driving your car” chapter.If, after purchasing your car you
would like to add electrical accessories
that require a permanent power sup-
ply (alarm systems, hands-free phone,
radio navigator with satellite anti-theft
system, etc.), visit a Fiat Dealership.
The staff of experts, besides suggest-
ing the most suitable accessories in the
Lineaccessori range, will also check
whether the car electrical system can
support the required load or if a larg-
er size battery needs to be installed.
These devices will, in fact, run off the
battery even when the key is not in-
serted (car parked) and can deploy the
battery.
Incorrect fitting of elec-
trical and electronic ac-
cessories can seriously
damage the car.Batteries contain sub-
stances that are very
harmful for the environ-
ment. You are advised to have the
battery changed at a Fiat Dealer-
ship. It is properly equipped for
disposing of used batteries in an
environmentally-friendly way that
complies with the law.
Do not attempt to recharge
a frozen battery. Thaw it
first otherwise it could explode. If
the battery froze, make sure the in-
ternal elements are not broken
(short-circuit risk) and that the cas-
ing is not cracked (risk of spilling
the poisonous and corrosive fluid).
WARNING

131
BODY AND UNDERBODY
GUARANTEE
The Fiat barchetta is covered guar-
antee against any original structural or
body part being holed by rust. Refer
to the “Warranty Booklet” for the
general conditions of this guarantee.
TIPS FOR KEEPING THE
BODY IN GOOD CONDITION
Paintwork
The paintwork is not only to make
your car look attractive but also to
protect the steel.
If your car is scuffed or scratched
deeply you are therefore recom-
mended to touch up the paintwork as
necessary to prevent rust from form-
ing.
Only use genuine products when
touching up the paintwork (see the
“Technical Specifications” chapter).To wash the car properly:
1) Soak the body using a low pres-
sure jet of water.
2) Wipe a sponge with a slightly
soapy solution over the body, fre-
quently rinsing the sponge.
3)Rinse well with water and dry
with a jet of air or a chamois leather.
When drying the car, be careful to
get at those parts which are not so
easily seen e.g. the door frames, bon-
net and around the headlights where
water can most readily collect. You
are advised not to take the car into a
closed area immediately but to leave
it out in the open so any water left can
evaporate more easily.
Do not wash the car after it has been
parked in the sun or while the bon-
net is hot: it could take the shine off
the paint. Ordinary maintenance of the paint-
work consists in washing it. The fre-
quency you should do this depends on
the conditions and the environment
the car is driven in. For example, if you
drive in areas with a high level of air
pollution or on roads sprinkled with
road salt, it is a good idea to wash the
car more often.
Detergents pollute wa-
ter. For this reason, the
car must be washed in an
area equipped for the collection
and purification of the liquids
used while washing.

134
If the stain does not come out, use
a special cleaning compound being par-
ticularly careful to follow the instruc-
tions for use.
IMPORTANTNever use alcohol
or alcohol-base products.
PLASTIC PARTS INSIDE
THE CAR
Use special products designed not to
alter the appearance of the compo-
nents.
IMPORTANT Do not use alcohol
or petrol for cleaning the glass of the
instrument panel. CLEANING THE SEATS AND
FABRIC UPHOLSTERY
– Remove the dust with a soft brush
or a vacuum cleaner.
– Rub the seats with a rag moistened
in a solution of water and neutral de-
tergent.
CLEANING LEATHER SEATS
– Remove the dry dirt with a buck-
skin or very slightly moist cloth with-
out exerting too much pressure.
– Remove liquid or grease stains with
a dry absorbent cloth without rubbing.
Then wipe with a buckskin or soft
cloth moistened with water and neu-
tral soap.
Do not keep aerosol cans in
the car. There is the risk
they might explode. Aerosol cans
must never be exposed to a tem-
perature above 50°C. The temper-
ature inside the car might go well
beyond that figure if the car is ex-
posed to the sun.
WARNING

141
WHEELS
RIMS AND TYRES
Pressed steel or alloy wheels (where
applicable), specific bolts (of a differ-
ent size and reciprocally incompatible)
for each of the two types of rim.
Tubeless tyres with radial shell.IMPORTANT Do not use an inner
tube with Tubeless tyres. Do not se-
cure light alloy wheels using bolts de-
signed for steel wheels and vice-versa.
For the compatibility between wheels
and wheel bolts and between these
and the spare wheel, refer to the de-
tailed indications given in the para-
graph “If a tyre is punctured”.
SNOW CHAINS
Do not use snow chains with 195/55
R15 (84V) or 195/45 R16 (80V) tyres
as the chains are likely to interfere
with the plastic wheelarches.
Use only low-profile chains with
185/55 R15 (81H) tyres: maximum
height off the wheel 12 mm. Check the
tautness of the chains after driving
some twenty to thirty yards (twenty
to thirty metres).
Rim Tyre
6 1/2J x15” 195/55 R15 (84V)
6 1/2J x16” 195/45 R16 (80V)
6 J x15” 185/55 R15 (81H)
specific for use
with snow chains
SPARE WHEEL
Pressed-steel rim.
Tubeless tyre.
All homologated tyres are listed in
the Vehicle’s Registration Papers. To
ensure safe driving, make sure that the
tyres are not only of the specified di-
mensions but that all four tyres are of
the same type and make.
Rim Tyre
4.00 Bx14H 135/80 B14

149
ACCESSORY INSTALLATION
Genuine Fiat accessories have been designed with
the Fiat barchetta specifically in mind and have been se-
lected and tested on the car. They are easy to use, re-
liable and practical, qualities that lead to enhanced com-
fort and safety under all driving conditions.
If you wish to give your Fiat barchetta a sportier look,
Fiat has designed light alloy rims, leather panels, spoilers
and sporty bumpers that are fully in keeping with the
car’s line making it more personal and aggressive.
To ensure child safety, the child safety seats offered
by Lineaccessori Fiat meet the requirements of the Eu-
ropean standards currently in force.
You can find accessories from the Fiat line described
in a catalogue available from Fiat Branches, Dealers or
Authorised Workshops. Just ask one of Fiat’s staff to
give you all the details.
The following pages show diagrams and give instruc-
tions for correctly fitting a number of accessories. In-
stallation must always be entrusted to the experts. Fi-
at has specially trained its Dealership staff for work on
the Fiat barchetta.ELECTRONIC CAR ALARM ........................................... 150
TOW HITCH INSTALLATION....................................... 152
HARD TOP .......................................................................... 155
RADIO-FREQUENCY REMOTE CONTROL
MINISTERIAL HOMOLOGATION ............................... 156

150
ELECTRONIC ALARM
WIRING DIAGRAM AND
ADDITIONAL BRANCHES fig. 1
1- Right indicator/hazard lights
branch
fig. 1
P5S00726m
2- Passenger compartment sensor
3- Front right ground
4- Diagnostic socket5- Optional device protection fuse-
box
6- Radio-frequency receiver
7- “Electronic alarm on” led
8- Electronic alarm control unit
9- Bonnet switch
10- Boot switch
11- Ignition switch powering
12- Right door switch
13- Left door switch
14- Indicator light 15A fuse and
branch unit
15 - Left indicator/hazard lights
branch.

151
LOCATION
OF COMPONENTS
IN THE VEHICLE fig. 2
A- Radio-frequency receiver in ceil-
ing light
B - “Bonnet open” signal switch con-
trol (adjustable cap)
C- “Bonnet open” signal switch
D- “Right door open”, “left door
open” and “boot open” signal switch
E- Electronic alarm control unit (in
the engine compartment)
F- “Electronic alarm on” warning led
G- Radio-frequency remote control
H- Passenger compartment protec-
tion sensor (located under the central
tunnel).
fig. 2
P5S10042m