ESP FIAT CROMA 2006 2.G Owner's Guide
[x] Cancel search | Manufacturer: FIAT, Model Year: 2006, Model line: CROMA, Model: FIAT CROMA 2006 2.GPages: 240, PDF Size: 7.41 MB
Page 193 of 240

193
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
fig. 6 - 2.2 versionsF0L0198mfig. 7 - 1.9 Multijet 8VversionsF0L0211mfig. 9 - 1.8 versionsF0L0321m
fig. 8 - 1.9 Multijet 16VversionsF0L0210mfig. 10- 2.4 Multijet 20V versionsF0L0316m
ENGINE OIL
Checking engine oil
Check the oil level a few minutes (about
5) after the engine has stopped, with the
car parked on level ground.
Remove the dipstick Aand clean it, put
it back in completely, remove it and check
that the level is within the MIN and MAX
marks on the dipstick. The gap between
the MIN and MAX marks corresponds to
about one litre of oil.
Topping up engine oil
If the oil level is near or even below the
MIN mark, add oil through the filler neck
B, until reaching the MAX mark.
Oil level shall never exceed the MAX
mark.IMPORTANT If a routine check reveals
that the oil level is above the MAX mark,
contact Fiat Dealership to have the cor-
rect level restored.
IMPORTANT After adding or changing
the oil, let the engine turn over for a few
seconds and wait a few minutes after turn-
ing it off before you check the level.
When the engine is hot, take
care when working inside the
engine compartment to avoid burns.
Remember that when the engine is
hot, fan may cut in: danger of injury.
Scarves, ties and other loose cloth-
ing might be pulled by moving parts.
WARNING
183-206 Croma TRW GB 20-11-2006 15:03 Pagina 193
Page 199 of 240

199
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
USEFUL ADVICE FOR
LENGTHENING THE LIFE OF
YOUR BATTERY
To avoid draining your battery and length-
en its life, observe the following indica-
tions:
❒when you park the car, ensure the
doors, tailgate and bonnet are closed
properly;
❒the ceiling lights must be off. The car
is however provided with an auto-
matic system for switching off internal
lights;
❒do not keep accessories (e.g.: sound
system, hazard lights, etc.) switched on
for a long time when the engine is not
running;
❒before performing any operation on
the electrical system, disconnect the
battery negative cable;
❒battery terminals shall always be per-
fectly tightened. Batteries contain substances
that are very harmful for the
environment. You are advised
to have the battery changed
at a Fiat Dealership, which is properly
equipped for disposing of used batter-
ies respecting nature and the law.
If the car is left inactive for
long periods at cold, remove
the battery and store it in a warm
place to prevent freezing.
WARNING
When working on the bat-
tery or near it, always wear
the proper goggles.
WARNING
IMPORTANT A battery which is kept at
a charge of less than 50% (optical indica-
tor with dark colour without green area
in the middle) for any length of time will
be damaged by sulphation leading to a re-
duction in cranking power.
Moreover, this might lead to a higher risk
of the battery electrolyte freezing (this
may even occur at -10°C). If the car is in-
active for a long period of time, refer to
“Car inactivity”, in section “Correct use
of the car”.
If after buying the car, you want to install
electric accessories which require per-
manent electric supply (alarm, etc.) con-
tact Fiat Dealership whose qualified per-
sonnel, in addition to suggesting the most
suitable devices, will evaluate the overall
electric absorption, checking whether the
car’s electric system is capable of with-
standing the load required, or whether it
should be integrated with a more power-
ful battery.
183-206 Croma TRW GB 20-11-2006 15:03 Pagina 199
Page 209 of 240

ENGINE MARKING
Engine marking is stamped on the cylinder
block and includes the model and the
chassis number.
BODYWORK PAINT
IDENTIFICATION PLATE fig. 3
The plate is applied inside the bonnet and
it bears the following data:
APaint manufacturer.
BColour name.
CFiat colour code.
DRespray and touch up code.
209
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
CHASSIS MARKING fig. 2
It is printed on the passenger compart-
ment floor, near the right-hand front seat.
It can be reached by lifting the special flap
in the carpeting and includes the following
data:
❒car model;
❒chassis number.
fig. 2F0L0204mfig. 3F0L0161m
207-231 Croma TRW GB 20-11-2006 15:04 Pagina 209
Page 211 of 240

211
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
ENGINE
1.8 2.2 2.2 a.t.
GENERAL FEATURES
Engine code
Cycle
Number and layout of cylinders
Piston bore and stroke mm
Total displacement cm3
Compression ratio
Maximum power (EEC) kW
HP
corresponding ratio rpm
Maximum torque (EEC) Nm
kgm
corresponding ratio rpm
Spark plugs
Fuel
939A4000
Otto
4 in line
80.5 x 88.2
1796
10.5 : 1
103
140
6300
175
17.8
3800
BOSCH FQR 8 LEU2
Unleaded
petrol 95 RON
(Specification EN228)194A1000
Otto
4 in line
86 x 94.6
2198
10.0 : 1
108
147
5800
203
20.7
4000
AC DELCO HLR8STEX
Unleaded
petrol 95 RON
(Specification EN228)194A1000
Otto
4 in line
86 x 94.6
2198
10.0 : 1
108
147
5800
203
20.7
4000
AC DELCO HLR8STEX
Unleaded
petrol 95 RON
(Specification EN228)
207-231 Croma TRW GB 20-11-2006 15:04 Pagina 211
Page 212 of 240

212
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
GENERAL FEATURES
Engine code
Cycle
Number and layout of cylinders
Piston bore and stroke mm
Total displacement cm3
Compression ratio
Maximum power (EEC) kW
HP
corresponding ratio rpm
Maximum torque (EEC) Nm
kgm
corresponding ratio rpm
Fuel
1.9 Multijet 8V
939A1000
Diesel
4 in line
82 x 90.4
1910
18.0 : 1
88
120
4000
280
28.6
2000
Diesel fuel for
motor vehicles
(Specification EN590)1.9 Multijet
16V
939A2000
Diesel
4 in line
82 x 90.4
1910
17.5 : 1
110
150
4000
320
32.6
2000
Diesel fuel for
motor vehicles
(Specification EN590)1.9 Multijet
16Va.t.
939A2000
Diesel
4 in line
82 x 90.4
1910
17.5 : 1
110
150
4000
320
32.6
2000
Diesel fuel for
motor vehicles
(Specification EN590)2.4 Multijet 20Va.t.
939A3000
Diesel
5 in line
82 x 90.4
2387
17.0 : 1
147
200
4000
400
40.8
2000
Diesel fuel for
motor vehicles
(Specification EN590)
207-231 Croma TRW GB 20-11-2006 15:04 Pagina 212
Page 216 of 240

Maximum speed rating
Q= up to 160 km/h.
R= up to 170 km/h.
S= up to 180 km/h.
T= up to 190 km/h.
U= up to 200 km/h.
H= up to 210 km/h.
V= up to 240 km/h.
W= up to 270 km/h.
Y= up to 300 km/h.
Maximum speed rating
for snow tyres
QM + S= up to 160 km/h.
TM + S= up to 190 km/h.
HM + S= up to 210 km/h.UNDERSTANDING RIM
MARKING
Example: 6 1/2 J x 16 H2 ET41
6 1/2 = rim width in inches (1).
J = rim drop center outline (side
projection where the tyre bead
rests) (2).
16 = rim nominal diameter in inches
(corresponds to diameter of the
tyre to be mounted) (3 = Ø).
H2 = “hump” shape and number (re-
lief on the circumference hold-
ing the Tubeless tyre bead on
the rim).
ET 41 = wheel camber angle (distance
between the disc/rim supporting
plane and the wheel rim centre
line). Load rating (capacity)
60= 250 kg 84= 500 kg
61= 257 kg 85= 515 kg
62= 265 kg 86 = 530 kg
63= 272 kg 87= 545 kg
64= 280 kg 88= 560 kg
65= 290 kg 89= 580 kg
66= 300 kg 90= 600 kg
67 = 307 kg 91= 615 kg
68= 315 kg 92= 630 kg
69 = 325 kg 93 = 650 kg
70 = 335 kg 94= 670 kg
71 = 345 kg 95= 690 kg
72= 355 kg 96 = 710 kg
73= 365 kg 97= 730 kg
74 = 375 kg 98= 750 kg
75= 387 kg
99= 775 kg
76 = 400 kg 100= 800 kg
77= 412 kg 101= 825 kg
78= 425 kg 102= 850 kg
79= 437 kg 103= 875 kg
80= 450 kg 104= 900 kg
81= 462 kg 105= 925 kg
82= 475 kg 106 = 950 kg
83= 487 kg
216
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
207-231 Croma TRW GB 20-11-2006 15:04 Pagina 216
Page 217 of 240

217
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
VERSIONS RIMS TYRES Space-saver spare wheel
Standard tyres Snow tyres Rim Tyre
1.86.5J x 16” - ET 41 205/55 R16 91V 205/55 R16 91 H (M+S)
6.5J x 16” - ET 41 215/55 R16 93W 215/55 R16 93 H (M+S)
7J x 17” - ET 41 215/50 R17 91W 215/50 R17 91 H (M+S)4J R16 - ET 41115/70 R16 92 M
7.5J x 18” - ET 41 225/45 R18 95Y (*) (Ô) 225/45 R18 95 H (M+S) (*)
2.26.5J x 16” - ET 41 205/55 R16 91V 205/55 R16 91 H (M+S)
6.5J x 16” - ET 41 215/55 R16 93W 215/55 R16 93 H (M+S)
7J x 17” - ET 41 215/50 R17 91W 215/50 R17 91 H (M+S)4J R16 - ET 41115/70 R16 92 M
7.5J x 18” - ET 41 225/45 R18 95Y (*) (Ô) 225/45 R18 95 H (M+S) (*)
2.2 a.t.6.5J x 16” - ET 41 205/55 R16 91V 205/55 R16 91 H (M+S)
6.5J x 16” - ET 41 215/55 R16 93W 215/55 R16 93 H (M+S)
7J x 17” - ET 41 215/50 R17 91W 215/50 R17 91 H (M+S)4J R16 - ET 41115/70 R16 92 M
7.5J x 18” - ET 41 225/45 R18 95Y (*) (Ô) 225/45 R18 95 H (M+S) (*)
1.9 Multijet
8V6.5J x 16” - ET 41 205/55 R16 91V 205/55 R16 91 H (M+S)
6.5J x 16” - ET 41 215/55 R16 93W 215/55 R16 93 H (M+S)
7J x 17” - ET 41 215/50 R17 91W 215/50 R17 91 H (M+S)4J R16 - ET 41115/70 R16 92 M
7.5J x 18” - ET 41 225/45 R18 95Y (*) (Ô) 225/45 R18 95 H (M+S) (*)
1.9 Multijet
16V6.5J x 16” - ET 41 205/55 R16 91V 205/55 R16 91 H (M+S)
6.5J x 16” - ET 41 215/55 R16 93W 215/55 R16 93 H (M+S)
7J x 17” - ET 41 215/50 R17 91W 215/50 R17 91 H (M+S)4J R16 - ET 41115/70 R16 92 M
7.5J x 18” - ET 41 225/45 R18 95Y (*) (Ô) 225/45 R18 95 H (M+S) (*)
1.9 Multijet 16Va.t.6.5J x 16” - ET 41 205/55 R16 91V 205/55 R16 91 H (M+S)
6.5J x 16” - ET 41 215/55 R16 93W 215/55 R16 93 H (M+S)
7J x 17” - ET 41 215/50 R17 91W 215/50 R17 91 H (M+S)4J R16 - ET 41115/70 R16 92 M
7.5J x 18” - ET 41 225/45 R18 95Y (*) (Ô) 225/45 R18 95 H (M+S) (*)
2.4 Multijet 20Va.t.7J x 17” - ET 41 215/50 R17 95W 215/50 R17 91 H (M+S)
4J R16 - ET 41115/70 R16 92 M7.5J x 18” - ET 41 225/45 R18 95Y (Ô) 225/45 R18 95 H (M+S)
(*) Only for versions with ESP
(Ô) Tyres that cannot be fitted with snow chains
207-231 Croma TRW GB 20-11-2006 15:04 Pagina 217
Page 222 of 240

222
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
1.8
1430
520
1100
1030
1950
1500
700
80
702.2
1510
520
1100
1030
2030
1500
700
80
702.2 a.t.
1530
520
1100
1030
2050
1500
700
80
70
WEIGHTS
Weights (kg)
Kerb weight (including all fluids,
fuel tank at 90% and with no optional)
Payload (*) including the driver:
Maximum admitted loads (**)
– front axle:
– rear axle:
– total:
Towable loads
– trailer with brakes:
– trailer without brakes:
Maximum load on roof (***):
Maximum load on tow hitch
(trailer with brakes):
(*) If special equipment is fitted (sunroof, tow hitch, etc.) the unladen car weight increases
thus reducing the specified payload.
(**) Loads not to be exceeded. The driver is responsible for arranging the loads in the boot an/or on the roof so that they com-
ply with these limits.
(***) Lineaccessori Fiat roof rack, max capacity: 50 kg.
207-231 Croma TRW GB 20-11-2006 15:04 Pagina 222
Page 223 of 240

223
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
1.9 Multijet 8V
1520
520
1150
1030
2040
1500
700
80
701.9 Multijet
16V
1530
520
1150
1030
2050
1500
700
80
701.9 Multijet
16Va.t.
1540
520
1150
1030
2060
1500
700
80
702.4 Multijet 20Va.t.
1650
520
1200
1030
2170
1500
700
80
70Weights (kg)
Kerb weight (including all fluids,
fuel tank at 90% and with no optional)
Payload (*)
including the driver:
Maximum admitted
loads (**)
– front axle:
– rear axle:
– total:
Towable loads
– trailer with brakes:
– trailer without brakes:
Maximum load on roof (***):
Maximum load on tow hitch
(trailer with brakes):
(*) If special equipment is fitted (sunroof, tow hitch, etc.) the unladen car weight increases
thus reducing the specified payload.
(**) Loads not to be exceeded. The driver is responsible for arranging the loads in the boot an/or on the roof so that they com-
ply with these limits.
(***) Lineaccessori Fiat roof rack, max capacity: 50 kg.
207-231 Croma TRW GB 20-11-2006 15:04 Pagina 223
Page 233 of 240

233
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IINDEX
Gearbox
– use of the automatic gearbox ..... 125
– use of the manual gearbox ......... 124
Glass/can holders ................................ 68
Glove compartment/oddment
compartment ..................................... 68
Glove compartment light ................... 167
Handbrake ........................................... 123
Hazard lights ......................................... 63
Headlight washer
– control ............................................. 59
– fluid level ......................................... 195
Headlights ............................................... 85
– aiming device ................................... 85
– beam adjustment ........................... 85
Head restraints
– front ................................................. 34
– rear ................................................... 34
Heating and ventilation ...................... 39
Heating and ventilation system ........ 39
Identification data ............................... 208
Ignition switch ...................................... 17
In an emergency .................................. 149
Instrument panel
(left hand drive) ................................. 6
Instrument panel
(right hand drive) .............................. 236
Instruments ........................................... 18
Interior fittings ..................................... 66
Interiors ................................................. 205
Jacking the car ..................................... 180
Key with remote control ................. 9
Keys ........................................................ 8
Levels
– checking ........................................... 188
Load limiters ......................................... 102
Main beam headlights
– bulb replacement .......................... 162
– control ............................................. 55
– flashing ............................................. 55
Manual climate control system ......... 41
Multifunction display ........................... 20
Number plate light ............................ 165
Oddment compartments ................. 67
Paint ...................................................... 204
Parking ................................................... 123
Parking sensors .................................... 94
Performance ......................................... 221
Plates
– body paint ........................................ 209
– identification data ........................... 208
Pollen filter ............................................. 197
Power steering fluid level ................... 195
Power windows
– controls ........................................... 75
Presetting for mounting the
"Universal Isofix" child
restraint system ................................. 109
Pretensioners......................................... 102
Protecting the environment ............. 97
Puddle light/door light ........................ 168
Radio frequency remote control:
Ministerial Certifications ................. 230
Radio transmitters and cellular
telephones ........................................... 93
Rain sensor ........................................... 58
Emergency key..................................... 11
Engine
– identification code.......................... 210
– marking ............................................ 209
– specifications .................................. 211
Engine compartment
– washing ............................................ 205
Engine coolant gauge .......................... 6
Engine coolant level ............................ 194
Engine oil
– checking level ................................. 193
– consumption .................................. 194
– technical data................................... 226
EOBD system ....................................... 90
ESP system ............................................ 88
Extending the boot .............................. 77
External lights ........................................ 54
Eyeglasses holder .................................. 68
Fiat CODE system ............................. 7
Flashing the headlights ........................ 55
Fluids and lubricants ........................... 226
Follow me home (device) ................. 56
Front ceiling lights
– bulb replacement .......................... 166
– control .............................................. 62
Front fog lights
– bulb replacement .......................... 163
– control button ............................... 63
Fuel
– fuel cut-off switch ......................... 64
– gauge ................................................ 6
Fuel consumption ................................ 228
Fuel cut-off switch ............................... 64
Fuel filler cap ........................................ 96
Fuel gauge .............................................. 6
Fuses (replacement) ........................... 169
232-240 Croma TRW GB 17-11-2006 11:09 Pagina 233