headlight FIAT CROMA 2009 2.G Owner's Manual

213
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
Rear window wiper fig. 21
Rear window washer jets can be adjust-
ed in the same way.
The nozzle holder is on the rear window.
HEADLIGHT WASHERS
Regularly check that the spray jets are in-
tact and clean.
The headlight washers are automatically
switched on when the windscreen wash-
er is operated and the headlights are on.
BODYWORK
PROTECTION FROM
ATMOSPHERIC AGENTS
The main causes of corrosion are the fol-
lowing:
❒atmospheric pollution;
❒salty air and humidity (coastal areas,
or hot humid climates);
❒seasonal environment conditions.
Not to be underestimated is also the abra-
sive action of wind-borne atmospheric
dust and sand and mud and gravel raised
by other cars.
On your Fiat Croma, Fiat implemented
the best manufacturing technologies to ef-
fectively protect the bodywork against
corrosion.
These include:
❒Painting products and systems which
give the car particular resistance to
corrosion and abrasion;
❒Use of galvanised (or pretreated) steel
sheets, with high resistance to corro-
sion; SPRAY NOZZLES
Windscreen wiper fig. 20
If the jet of fluid is inadequate, firstly check
that there is fluid in the reservoir: see
“Checking fluid levels” in this section).
Then check that the nozzle holes are not
clogged, if necessary use a needle.
Fluid jets shall be directed at about 1/3
height from the window upper edge.
fig. 20F0L0152mfig. 21F0L0151m
193-216 Croma TRW GB 28-07-2009 12:16 Pagina 213

214
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
ADVICE FOR PRESERVING
THE BODYWORK
Paint
Paintwork does not only serve an aesteth-
ic purpose, but also protects the under-
lying sheet metal.
In the case of deep scrapes or scores, you
are advised to have the necessary touch-
ing up carried out immediately to avoid
the formation of rust. Use only original
paint products for touching up (see “Body-
work paint identification plate” in section
“Technical specification”). Normal paint
maintenance consists in washing at inter-
vals depending on the conditions and en-
vironment of use. For example, in highly
polluted areas, or if the roads are sprayed
with salt, it is wise to wash the car more
frequently.
For a correct wash of the vehicle proceed
as follows:
❒soak the body with a low pressure wa-
ter jet;
❒pass on the body a sponge with a li-
ght cleansing solution, frequently rin-
sing the sponge;
❒rinse accurately with water and dry
with air jet or suede.If the vehicle is washed in an automatic car
wash, follow these recommendations:
– remove the antenna from the roof to
avoid damages;
– water with a cleansing solution must be
used for washing;
– rinse accurately to avoid cleansing so-
lution residues which may remain on the
body or hidden parts.
❒Spraying the underbody, engine com-
partment, wheelhouse internal parts
and other parts with highly protective
wax products;
❒Spraying of plastic parts, with a pro-
tective function, in the more exposed
points: underdoor, inner fender parts,
edges, etc.;
❒Use of “open” boxed sections to pre-
vent condensation and pockets of
moisture from triggering rust inside.
BODY AND UNDERBODY
WARRANTY
Your car is covered by warranty against
perforation due to rust of any original el-
ement of the structure or body. For the
general terms of this warranty, refer to
the Fiat Warranty booklet.
When drying, take particular care with the
less visible parts like door surrounds, bon-
net and around the headlights where wa-
ter may stagnate. The car should not be
taken to a closed area immediately, but left
in the open so that residual water can eva-
porate. Do not wash the car after it has
been left in the sun or with the bonnet
hot: this may alter the shine of the
paintwork.Some automatic systems pro-
vided with old generation
and/or not correctly maintai-
ned brushes may damage the
varnish, easing the creation of micro-
scratches, especially on dark colours.
To remove those scratches, slightly po-
lish with a specific product.
193-216 Croma TRW GB 28-07-2009 12:16 Pagina 214

234
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
CAPACITIES
Fuel tank:
including a reserve of:
Engine cooling system– with climate control:
Engine sump and filter:
Mechanical gearbox and
differential:
Automatic transmission
Hydraulic brake circuit
with ABS:
Electrohydraulic power
steering circuit:
Windscreen/rear window
/headlight washer fluid reservoir: (*)
(*) The values in brackets refer to versions with headlight washers.
(▲) For particularly hard climate conditions, we recommend use of a 60% PARAFLU UPand 40% demineralized water mixture.
(
●) Total quantity of oil in the gearbox.
1.8
litres kg
62 –
7 - 9 –
7.4 –
4.5 –
1.6 1.3
––
– 0.750
0.7 0.59
3 (5) –2.2
litres kg
62 –
7 - 9 –
7.4 –
5–
1.8 1.5
––
– 0.750
0.9 0.75
3 (5) –2.2 a.t.
litres kg
62 –
7 - 9 –
7.4 –
5–
––
– 6.400(
●)
– 0.750
0.9 0.75
3 (5) –Recommended products and
genuine lubricants
Unleaded petrol
with no less than 95 R.O.N
(EN228 Specification)
Mixture of 50% demineralised wa-
ter and 50% PARAFLU UP
(▲)
SELENIA K P.E.
TUTELA CAR MATRIX
TUTELA GI/V
TUTELA TOP 4
TUTELA GI/R
TUTELA PROFESSIONAL
SC 35
217-242 Croma TRW GB 10-11-2008 13:16 Pagina 234

235
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
Fuel tank:including a reserve of:
Engine cooling
system
– with climate control:
Engine sump and filter:
Mechanical gearbox and
differential:
Automatic transmission
Hydraulic brake circuit
with ABS:
Electrohydraulic power
steering circuit:
Windscreen/rear window/
headlight washer
fluid reservoir: (*)
(*) The values in brackets refer to versions with headlight washers.
(▲) For particularly hard climate conditions, we recommend use of a 60% PARAFLU UPand 40% demineralized water mixture.
(
●) Total quantity of oil in the gearbox.
(❑) Versions pur-O2.
Recommended products and
genuine lubricants
Diesel fuel for motor vehicles
(Specification EN 590)
Mixture of 50% demineralised
water and 50% PARAFLU UP
SELENIA WR/WR P.E. (
❑)
TUTELA CAR MATRIX
TUTELA GI/VI
TUTELA TOP 4
TUTELA GI/R
TUTELA PROFESSIONAL
SC 35 1.9 Multijet
8V
litres kg
62 –
7 - 9 –
7.7 –
4.5 –
1.9 1.6
––
– 0.750
0.7 0.59
3 (5) –1.9 Multijet
16V
litres kg
62 –
7 - 9 –
7.7 –
4.5 –
1.9 1.6
––
– 0.750
0.7 0.59
3 (5) –1.9 Multijet
16Va.t.
litres kg
62 –
7 - 9 –
7.7 –
4.5 –
––
–
6.110(●)
– 0.750
0.7 0.59
3 (5) –2.4 Multijet
20V a.t.
litres kg
62 –
7 - 9 –
8.4 –
5.4 –
––
–
6.110(●)
– 0.750
0.7 0.59
3 (5) –
217-242 Croma TRW GB 10-11-2008 13:16 Pagina 235

237
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
Lubricants
and greases for
transmissions
Protective
agent
for radiators
Windscreen/
rear window/
headlight
washer fluid Brake
fluid
Additive for
diesel fuelSynthetic-based oil, grade SAE 75W-85 that passes API GL-4
specifications
Special lubricant for 5 seed automatic transmissions with limited
slip torque converter.
Specification FIAT 9.55550-AV1
Special lubricant for 6 speed automatic transmissionswith limited
slip torque converter.
Specification FIAT 9.55550-AV2
Specifc grease to be used for constant-velocity joints with low
friction coefficient. N.L.G.I. 0-1 consistency.
Grease containing Molybdenum bisulphide for high temperature
appliances. N.L.G.I. 1-2 consistency.
Synthetic fluid for hydraulic and electrohydraulic systems.
Specification FIAT 9.55550-AG3
Synthetic fluid, FMVSS n° 116 DOT 4, ISO 4925 SAE J1704,
CUNA NC 956-01
Protective with antifreeze action, red colour based on inhibited
monoethylen glycol and organic formula, that passes
CUNA NC 956-16, ASTM D 3306 specifications.
Additive for diesel fuels with protective action for Diesel engines
Mixture of alcohol and surfactants CUNA NC 956-11Mechanical gearbox
and differential
5 speed automatic gearboxes
6 speed automatic gearboxes
CV joints on differential side
CV joints on wheel side
Electrohydraulic
power steering
Brake and clutch hydraulic
controls
Radiator antifreeze
proportion:
50% distilled water and
50% PARAFLU UP(❑)
To be used diluted
or undiluted
To be mixed with diesel fuel
(25 cc per 10 litres) TUTELA CAR
MATRYX
Contractual Technical
Reference N. F108.F02
TUTELA CAR GI/V
Contractual Technical
Reference N. F333.I05
TUTELA CAR GI/VI
Contractual Technical
Reference N. F336.G05
TUTELA STAR 700
Contractual Technical
Reference N. F701.C07
TUTELA ALL STAR
Contractual Technical
Reference N. F702.G07
TUTELA CAR GI/R
Contractual Technical
Reference N. F428.H04
TUTELA TOP 4
Contractual Technical
Reference N. F001.A93
PARAFLU UP (●)
Contractual Technical
Reference N. F101.M01
TUTELA DIESEL ART
Contractual Technical
Reference N. F601.L06
TUTELA
PROFESSIONAL SC 35
Contractual Technical
Reference N. F201.D02
Use Fluid and lubricant specifications Genuine fluids Applicationsfor correct car operation and lubricants
(●) IMPORTANT Do not add or mix fluids having different specifications from that already existing.
(❑) For particularly hard climate conditions, we recommend use of a 60% PARAFLU UPand 40% demineralized water mixture.
217-242 Croma TRW GB 10-11-2008 13:16 Pagina 237

245
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IINDEX
Identification data................................ 218
Ignition device....................................... 19
In an emergency................................... 157
Injection system
– EOBD engine control system
failure warning light....................... 149
– injection system failure warning
light................................................... 149
Instrument dashboard......................... 5
Instrument panel.................................. 6
Interior equipment.............................. 74
Interiors
– maintenance.................................... 215
Isofix Universal (car seat) .................. 117
“Isofix Universale” car seat ............... 117
– installation presetting.................... 117
– suitability of use ............................. 118
Keys ....................................................... 10
– emergency key.................................. 13
– key with remote control................ 11
Lamps (replacement)
– exterior lamp replacement.......... 173
– general information....................... 169
– interior lamp replacement........... 178
– lamp types....................................... 170
Level checks.......................................... 198
Levels
– level checks..................................... 198
License plate lights
– lamp replacement.......................... 178
3rd stop lights....................................... 177
Liquids and lubricants......................... 236Load (anchoring).................................. 89
Long vehicle inactivity......................... 144
Low beams
– control............................................. 62
– Follow Me Home........................... 154
– lamp replacement.......................... 173
– low beam light warning light ....... 154
Lubricants.............................................. 236
Maintenance and care
– Demanding vehicle use................. 197
– periodical checks........................... 197
– planned maintenance.................... 194
– Scheduled Maintenance Plan ....... 195
Manual air conditioner........................ 49
Maximum speed................................... 231
Money holder....................................... 76
Multifunctional display ....................... 22
– control buttons.............................. 22
– display functions............................. 28
– setup menu .................................... 23
– standard screen.............................. 22
On board instruments....................... 20
Paint (maintenance)........................... 214
Parking brake........................................ 131
– parking brake engaged warning
light-.................................................. 146
Parking lights......................................... 72
Parking sensors.................................... 102
Parking.................................................... 131
– parking brake.................................. 131
Passenger compartment air
diffusers............................................... 48 Fuel level indicator.............................. 21
Fuel reserve
– fuel reserve warning light ........... 150
Fuel tank plug........................................ 104
Fuses
– fuse replacement........................... 181
– fuse table......................................... 186
Generic warning light........................ 152
Glasses holder...................................... 76
Glove compartment light................... 179
Glove compartment............................ 75
– ceiling light lamp replacement..... 179
Head rests
– front................................................. 42
– rear .................................................. 42
Headlamps............................................. 93
– headlamp adjustment overseas... 94
– headlamp stability corrector ....... 93
– light beam orientation.................. 93
Headlight washer-wiper
– control............................................. 67
– liquid level....................................... 205
Heated rear window
– heated rear window warning
light................................................... 151
Heating and air conditioning............. 47
Heating/air conditioning system....... 47
High-beam headlights
– control............................................. 62
– flashing............................................. 63
– high beam light warning light....... 155
– lamp replacement.......................... 174
243-256 Croma TRW GB 28-07-2009 12:15 Pagina 245

Transmission
– Technical data................................ 223
Transporting children safely.............. 112
Trip computer...................................... 36
Turn signals
– control............................................. 63
– cornering lights.............................. 63
– front lamp replacement................ 174
– lane change function..................... 63
– left turn signal warning light ........ 154
– rear lamp replacement................. 176
– right turn signal warning light ..... 154
– side lamp replacement.................. 175
Tyre pressure....................................... 228
Tyres
– correct tyre reading...................... 225
– provided ......................................... 227
– snow................................................. 142
– wheel replacement........................ 159
User purchased accessories............ 101
Vehicle inactivity................................. 144
Vehicle lifting......................................... 190
Vehicle refuelling.................................. 103
Vehicle towing...................................... 191
Volumetric protection........................ 15
Warning lights and messages .......... 145
– general warnings............................ 146
Weight................................................... 232
Wheel
– Fix & go automatic rapid tyre
repair kit ......................................... 165– replacement.................................... 159
– spare (characteristics).................. 227
Wheel alignment.................................. 225
Wheel rims
– correct rim reading....................... 226
Wheels and tyres................................. 210
– cold inflating pressure................... 228
– correct rim reading....................... 226
– correct tyre reading...................... 225
– rims and tyres................................ 225
– rims and tyres................................ 227
– spare wheel..................................... 225
– wheel alignment............................. 225
Window cleaning................................. 65
Windows (cleaning)............................ 215
Windscreen washer
– control............................................. 65
– liquid level....................................... 205
Windscreen washer/rear window
washer-wiper/headlight
washer-wiper liquid
– level check....................................... 205
Windscreen washer/rear window
washer-wiper/headlight
washer-wiper liquid level................. 205
Windscreen wiper
– brushes............................................ 212
– control............................................. 65
– rain sensor...................................... 66
– sprayers........................................... 213
Windscreen wiper and rear window
wiper brushes.................................... 212 Starting the engine............................... 128
– coasting startup.............................. 159
– heating the just started engine.... 130
– ignition device................................ 17
– procedure for gasoline versions ... 128
– procedure for Multijet versions ... 129
– startup with an auxiliary battery... 158
– turning off the engine................... 130
Steering (characteristics).................... 224
Steering lock......................................... 19
Steering wheel (adjustment).............. 43
Storage box........................................... 76
Sun roof................................................. 78
Sun visor................................................ 77
Suspensions (characteristics)............. 224
Symbols.................................................. 8
T.P.M.S. system
(tyre pressure control).................... 99
Table (seat)........................................... 40
Tachometer.......................................... 20
Technical data....................................... 217
Trailer towing....................................... 139
– assembly diagram........................... 141
– tow hook installation.................... 140
– warnings........................................... 139
Transmission
– automatic transmission failure
warning light................................... 155
– maximum automatic transmission
oil temperature warning light ..... 155
– using the automatic electronic
transmission.................................... 133
– using the manual transmission .... 132
247
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IINDEX
243-256 Croma TRW GB 28-07-2009 12:15 Pagina 247