oil temperature FIAT CROMA 2009 2.G Owners Manual

When stopping the car with a gear high-
er than 1st gear, transmission will set au-
tomatically at 1st gear.
When stopping the car under poor grip
conditions (snow, ice), at next starting the
transmission control unit could engage a
gear higher than 1st gear to prevent wheel
slipping. This shall not be considered as a
fault
IMPORTANT: in the event of excessive
oil temperatures (see section “Warning
lights and messages”), the electronic con-
trol intervenes excluding sequential mode
and activating automatic mode in order to
safeguard transmission life. Sequential
mode will be resumed as soon as regular
operating temperatures are restored.AUTOMATIC MODE
D can be selected from sequential mode
under whatever driving condition.
When passing from sequential mode to D,
the gear to engage is selected by trans-
mission control unit according to engine
rpm and speed (accelerator pedal posi-
tion).
Low engine power demand will result in
long gears engagement and reduced fuel
consumption. Increasing speed by press-
ing the accelerator will automatically en-
gage short gears that will result in im-
proved performance as to pickup and ac-
celeration: in this case fuel consumption
will increase.
For speedy pickup:
❒press the accelerator pedal flat-out,
the kick-down device will cut in to ob-
tain max. performance in terms of
pickup and acceleration. In this case fu-
el consumption will obviously increase.
IMPORTANT When driving under poor
grip conditions (snow, ice, etc.) avoid to
engage the kick-down device. SEQUENTIAL MODE
In sequential mode, the electronic auto-
matic transmission works like a fixed gear
sequential gearbox.
From position D move the gear lever left-
wards:
❒move gear lever to +: to upshift;
❒move gear lever to –: to downshift.
Gears are displayed by digits on the in-
strument panel. Non-stop monitoring car-
ried out by transmission control unit ex-
cludes whatever possibility of error.
Downshifting (or upshifting) is only pos-
sible if engine rpm enables it.
In sequential mode, electronic transmis-
sion control can however intervene in self-
adapting mode by shifting gears automat-
ically when engine rpm exceeds or falls be-
low the admitted rpm limit.
136
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
127-144 Croma TRW GB 28-05-2008 16:32 Pagina 136

Roof rack/ski rack
Remove the roof rack or the ski rack from
the roof as soon as they are no longer
used. These accessories lower air pene-
tration and adversely affect consumption
levels. When needing to carry particular-
ly voluminous objects, preferably use a
trailer.
Electric devices
Use electric devices only for the amount
of time needed. Rear heated window, ad-
ditional headlights, windscreen wipers and
heater fan need a considerable amount of
energy, therefore increasing the require-
ment of current increases fuel consump-
tion (up to +25% in the urban cycle).
Climate control
The air conditioner is an additional load
which greatly affects the engine leading to
higher consumption (on average up to
+20%). When the temperature outside
the car permits it, use the air vents where
possible.
Spoilers
The use of non-certified aerodynamic
items may adversely affect air drag and
consumption levels.DRIVING STYLE
Starting
Do not warm the engine with the car at
a standstill or at idle or high speed: under
these conditions the engine warms up
much more slowly, increasing electrical
consumption and emissions. It is therefore
advisable to move off immediately, slow-
ly, avoiding high speeds. This way the en-
gine will warm faster.
Unnecessary actions
Avoid accelerating when waiting at traffic
lights or before switching off the engine.
This and also double declutching is ab-
solutely pointless on modern cars and al-
so increase consumption and pollution.
Gear selection
As soon as the conditions of the traffic and
road allow, use a higher gear. Using a low
gear to obtain brilliant performance in-
creases consumption.
In the same way improper use of a high
gear increases consumption, emissions an
engine wear.CONTAINING
RUNNING COSTS
Here are some suggestions which may
help you to keep the running costs of your
car down and lower the amount of toxic
emissions released into the atmosphere.
GENERAL CONSIDERATIONS
Car maintenance
Have checks and adjustments carried out
in accordance with the “Service schedule”.
Tyres
Check the pressure of the tyres routine-
ly at an interval of no more than 4 weeks:
if the pressure is too low, consumption
levels increase as resistance to rolling is
higher.
Unnecessary loads
Do not travel with too much luggage
stowed in the boot. The weight of the car
(especially when driving in town) and its
trim greatly affects consumption and sta-
bility.
138
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
127-144 Croma TRW GB 28-05-2008 16:33 Pagina 138

145
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
GENERAL WARNINGS ...................................................... 146
INSUFFICIENT BRAKE LIQUID ....................................... 146
HAND BRAKE ENGAGED ............................................... 146
AIR BAG FAILURE................................................................ 146
PASSENGER SIDE FRONT AND SIDE CHEST
PROTECTION AIR BAGS (SIDE BAGS) OFF ............... 147
SEAT BELTS NOT FASTENED ......................................... 147
EXCESSIVE ENGINE COOLANT TEMPERATURE ..... 148
INSUFFICIENT BATTERY RECHARGING .................... 148
ABS SYSTEM FAILURE ........................................................ 148
EBD FAILURE......................................................................... 148
INSUFFICIENT ENGINE OIL PRESSURE........................ 149
DEGRADED OIL................................................................... 149
POWER STEERING FAILURE ........................................... 149
INCOMPLETE DOOR CLOSURE .................................... 149
INJECTION SYSTEM FAILURE ......................................... 149
ENGINE CONTROL SYSTEM FAILURE (EOBD) ........ 149
FUEL RESERVE ..................................................................... 150
SPARK PLUG PREHEATING ............................................. 150
SPARK PLUG PREHEATING FAILURE ........................... 150
WATER IN DIESEL FILTER ................................................ 151
FIAT CODE - VEHICLE PROTECTION
SYSTEM FAILURE ................................................................ 151
ALARM FAILURE .................................................................. 151
BREAK-IN ATTEMPT .......................................................... 151
ELECTRONIC KEY NOT RECOGNISED ..................... 151
EXTERIOR LIGHT FAILURE .............................................. 152
REAR FOG LIGHTS ............................................................. 152GENERIC SIGNALLING ..................................................... 152
ESP SYSTEM FAILURE ......................................................... 154
HILL HOLDER FAILURE .................................................... 154
POSITION LIGHTS AND LOW BEAMS ........................ 154
FOLLOW ME HOME ........................................................... 154
FOG LIGHTS ......................................................................... 154
LEFT TURN SIGNAL ........................................................... 154
RIGHT TURN SIGNAL ....................................................... 154
HIGH BEAMS ......................................................................... 155
POSSIBILITY OF ICE ON ROADS ................................... 155
LIMITED RANGE .................................................................. 155
ASR SYSTEM .......................................................................... 155
AUTOMATIC TRANSMISSION FAILURE ..................... 155
MAXIMUM AUTOMATIC TRANSMISSION OIL
TEMPERATURE .................................................................... 155
SET SPEED LIMIT EXCEEDANCE .................................... 156
CONSTANT SPEED REGULATOR
(CRUISE CONTROL) .......................................................... 156
BRAKE PAD WEAR ............................................................. 156
MINIMUM ENGINE OIL LEVEL ....................................... 156
REAR SIDE CHEST PROTECTION AIR BAGS
(REAR SIDE BAGS) OFF ..................................................... 156
TURNING OFF A MOVING VEHICLE ........................... 156
STARTING PROCEDURE DISPLAY INFORMATION
MESSAGES (AUTOMATIC TRANSMISSION)............... 156
STARTING PROCEDURE DISPLAY INFORMATION
MESSAGES (MANUAL TRANSMISSION) ...................... 156
WW W
A A
R R
N N
I I
N N
G G
L L
I I
G G
H H
T T
S S
A A
N N
D D
M M
E E
S S
S S
A A
G G
E E E
S S
145-156 Croma TRW GB 28-05-2008 15:18 Pagina 145

HIGH GEARBOX OIL
TEMPERATURE
The warning light comes on
(together with the message o the
display and the warning buzzer) glowing
steadily to indicate that the temperature
of the automatic transmission oil is too
high.Contact immediately Fiat
Dealership in case of trans-
mission failure to have the
system checked.AUTOMATIC
TRANSMISSION
FAILURE
Turning the ignition key to ON,
the warning light on the dial shall turn on
and then go off after a few seconds.
The warning light (together with the mes-
sage o the display and the warning buzzer)
flashes to indicate a transmission failure.
155
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
MAIN BEAMS (blue)
The warning light turns on
when the main beams are
turned on.
1
LIMITED RANGE
(versions with reconfigurable
multifunction display)
The display will show the dedicated mes-
sage to warn the driver that the cruising
range is less than 50 km.
ASR SYSTEM (versions with recon-
figurable multifunction display)
The ASR system can be turned off by
pressing the button ASR OFF.
The display will show the dedicated mes-
sage to warn the driver that the system
is off; at the same time the button led will
turn on.
Pressing again button ASR OFFwill turn
off the button led and the display will show
the dedicated message to warn the dri-
ver that the system is active again. POSSIBLE PRESENCE OF ICE
ON THE ROAD
(versions with reconfigurable
multifunction display)
This indication starts flashing when the
outside temperature reaches or falls be-
low 3°C to warn the driver of the possi-
ble presence of ice on the road.
The display will show the dedicated mes-
sage.
t
t
145-156 Croma TRW GB 28-05-2008 15:18 Pagina 155

216
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
STEERING WHEEL/GEAR LEVER
KNOB WITH GENUINE
LEATHER COVERING
These components shall only be cleaned
with water and neutral soap. Never use
spirit or alcohol-based products.
Before using special products for clean-
ing interiors, read carefully label instruc-
tions and indications to make sure they
are free from spirit and/or alcohol-based
substances.
If when cleaning the windscreen with spe-
cial glass products, some drops fall on the
leather covering of the steering wheel/gear
lever knob remove them immediately and
then clean with water and neutral soap.
IMPORTANT Take the utmost care when
engaging the steering lock to prevent
scratching the leather covering.INTERIOR PLASTIC PARTS
Use appropriate products designed to
preserve the appearance of components.
IMPORTANT Never use spirit or petro-
leum to clean the instrument panel. If the stain persists, use specific products,
carefully following the instructions for use.
IMPORTANT Never use spirit or alcohol-
based products.
Never use flammable prod-
ucts like oil ether or rectified
petrol for cleaning car interiors. Elec-
trostatic discharges generated by rub-
bing during cleaning operations could
cause fire.
WARNING
Do not keep aerosol cans in
the car: they might explode.
Aerosol cans must never be exposed
to a temperature above 50°C. The
temperature inside the car exposed
to the sun may go well beyond that
figure.
WARNING
193-216 Croma TRW GB 28-07-2009 12:16 Pagina 216

237
WARNING
LIGHTS AND
MESSAGES
INDEX
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
Lubricants
and greases for
transmissions
Protective
agent
for radiators
Windscreen/
rear window/
headlight
washer fluid Brake
fluid
Additive for
diesel fuelSynthetic-based oil, grade SAE 75W-85 that passes API GL-4
specifications
Special lubricant for 5 seed automatic transmissions with limited
slip torque converter.
Specification FIAT 9.55550-AV1
Special lubricant for 6 speed automatic transmissionswith limited
slip torque converter.
Specification FIAT 9.55550-AV2
Specifc grease to be used for constant-velocity joints with low
friction coefficient. N.L.G.I. 0-1 consistency.
Grease containing Molybdenum bisulphide for high temperature
appliances. N.L.G.I. 1-2 consistency.
Synthetic fluid for hydraulic and electrohydraulic systems.
Specification FIAT 9.55550-AG3
Synthetic fluid, FMVSS n° 116 DOT 4, ISO 4925 SAE J1704,
CUNA NC 956-01
Protective with antifreeze action, red colour based on inhibited
monoethylen glycol and organic formula, that passes
CUNA NC 956-16, ASTM D 3306 specifications.
Additive for diesel fuels with protective action for Diesel engines
Mixture of alcohol and surfactants CUNA NC 956-11Mechanical gearbox
and differential
5 speed automatic gearboxes
6 speed automatic gearboxes
CV joints on differential side
CV joints on wheel side
Electrohydraulic
power steering
Brake and clutch hydraulic
controls
Radiator antifreeze
proportion:
50% distilled water and
50% PARAFLU UP(❑)
To be used diluted
or undiluted
To be mixed with diesel fuel
(25 cc per 10 litres) TUTELA CAR
MATRYX
Contractual Technical
Reference N. F108.F02
TUTELA CAR GI/V
Contractual Technical
Reference N. F333.I05
TUTELA CAR GI/VI
Contractual Technical
Reference N. F336.G05
TUTELA STAR 700
Contractual Technical
Reference N. F701.C07
TUTELA ALL STAR
Contractual Technical
Reference N. F702.G07
TUTELA CAR GI/R
Contractual Technical
Reference N. F428.H04
TUTELA TOP 4
Contractual Technical
Reference N. F001.A93
PARAFLU UP (●)
Contractual Technical
Reference N. F101.M01
TUTELA DIESEL ART
Contractual Technical
Reference N. F601.L06
TUTELA
PROFESSIONAL SC 35
Contractual Technical
Reference N. F201.D02
Use Fluid and lubricant specifications Genuine fluids Applicationsfor correct car operation and lubricants
(●) IMPORTANT Do not add or mix fluids having different specifications from that already existing.
(❑) For particularly hard climate conditions, we recommend use of a 60% PARAFLU UPand 40% demineralized water mixture.
217-242 Croma TRW GB 10-11-2008 13:16 Pagina 237

244
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
INDEX
– excessive temperature warning
light................................................... 148
– level check....................................... 204
Engine cooling system liquid level .... 204
Engine hood.......................................... 90
Engine oil
– characteristics................................ 236
– consumption................................... 204
– degraded oil warning light ........... 149
– insufficient engine oil pressure
warning light................................... 149
– level check....................................... 203
– minimum engine oil level warning
light................................................... 156
Engine oil level...................................... 203
Environmental protection.................. 105
EOBD (system).................................... 98
EOBD system....................................... 98
ESP (system)......................................... 96
ESP system............................................ 96
– ESP system failure warning light . 154
Exterior lamp replacement................ 173
Exterior lights
– control............................................. 62
– exterior lights failure warning
light................................................... 152
Fiat CODE (system).......................... 9
– electronic key not recognised
warning light................................... 151
– vehicle protection system failure
warning light................................... 151
Fiat CODE system............................... 9
Fix & go automatic
(rapid tyre repair kit) ...................... 165Flashing................................................... 63
Fog light
– orientation...................................... 94
Follow me home (device).................. 64
Front air bags........................................ 118
– front driver’s side air bag............. 119
– front passenger’s side air bag ...... 120
– driver’s side knee air bag ............. 120
– general warnings............................ 124
– turning off the passenger side
front and side chest protection
air bags (Side Bags) ...................... 121
– passenger side front and side
chest protection air bag warnings
light (Side Bag) off ........................ 147
Front armrest with storage box
and cooled compartment................ 74
Front ceiling lights
– control............................................. 70
– lamp replacement.......................... 178
Front fog lights
– control............................................. 71
– fog lights warning light .................. 154
– lamp replacement.......................... 175
Front optical units
– lamp replacement.......................... 173
Fuel
– consumption................................... 238
– fuel block switch ........................... 72
– fuel reserve warning light ........... 150
– level indicator................................. 21
– saving fuel ....................................... 138
Fuel block switch and electric power
supply ................................................. 72
Fuel hatch.............................................. 104 Cup holder compartments................ 76
Cup/can holder.................................... 76
Dashboard and controls ................... 4
Dead lock (device).............................. 16
Diesel filter
– condensate water drain ............... 207
– water in diesel filter warning
light................................................... 151
Diesel Particulate Filter ..................... 106
Dimensions........................................... 230
Door clearance/puddle light.............. 180
Doors..................................................... 81
– centralized closing......................... 81
– child safety device.......................... 81
– emergency closing......................... 13
– emergency opening....................... 13
– incomplete door closure
warning light................................... 149
EBD (system)
– EBD system failure warning light 148
Electric socket...................................... 77
Electric window regulators
– controls........................................... 82
Emergency lights.................................. 71
Engine
– identification code......................... 220
– marking............................................ 219
– typical data...................................... 221
Engine compartment (washing)........ 215
Engine coolant temperature indicator 21
Engine cooling system liquid
243-256 Croma TRW GB 28-07-2009 12:15 Pagina 244

Transmission
– Technical data................................ 223
Transporting children safely.............. 112
Trip computer...................................... 36
Turn signals
– control............................................. 63
– cornering lights.............................. 63
– front lamp replacement................ 174
– lane change function..................... 63
– left turn signal warning light ........ 154
– rear lamp replacement................. 176
– right turn signal warning light ..... 154
– side lamp replacement.................. 175
Tyre pressure....................................... 228
Tyres
– correct tyre reading...................... 225
– provided ......................................... 227
– snow................................................. 142
– wheel replacement........................ 159
User purchased accessories............ 101
Vehicle inactivity................................. 144
Vehicle lifting......................................... 190
Vehicle refuelling.................................. 103
Vehicle towing...................................... 191
Volumetric protection........................ 15
Warning lights and messages .......... 145
– general warnings............................ 146
Weight................................................... 232
Wheel
– Fix & go automatic rapid tyre
repair kit ......................................... 165– replacement.................................... 159
– spare (characteristics).................. 227
Wheel alignment.................................. 225
Wheel rims
– correct rim reading....................... 226
Wheels and tyres................................. 210
– cold inflating pressure................... 228
– correct rim reading....................... 226
– correct tyre reading...................... 225
– rims and tyres................................ 225
– rims and tyres................................ 227
– spare wheel..................................... 225
– wheel alignment............................. 225
Window cleaning................................. 65
Windows (cleaning)............................ 215
Windscreen washer
– control............................................. 65
– liquid level....................................... 205
Windscreen washer/rear window
washer-wiper/headlight
washer-wiper liquid
– level check....................................... 205
Windscreen washer/rear window
washer-wiper/headlight
washer-wiper liquid level................. 205
Windscreen wiper
– brushes............................................ 212
– control............................................. 65
– rain sensor...................................... 66
– sprayers........................................... 213
Windscreen wiper and rear window
wiper brushes.................................... 212 Starting the engine............................... 128
– coasting startup.............................. 159
– heating the just started engine.... 130
– ignition device................................ 17
– procedure for gasoline versions ... 128
– procedure for Multijet versions ... 129
– startup with an auxiliary battery... 158
– turning off the engine................... 130
Steering (characteristics).................... 224
Steering lock......................................... 19
Steering wheel (adjustment).............. 43
Storage box........................................... 76
Sun roof................................................. 78
Sun visor................................................ 77
Suspensions (characteristics)............. 224
Symbols.................................................. 8
T.P.M.S. system
(tyre pressure control).................... 99
Table (seat)........................................... 40
Tachometer.......................................... 20
Technical data....................................... 217
Trailer towing....................................... 139
– assembly diagram........................... 141
– tow hook installation.................... 140
– warnings........................................... 139
Transmission
– automatic transmission failure
warning light................................... 155
– maximum automatic transmission
oil temperature warning light ..... 155
– using the automatic electronic
transmission.................................... 133
– using the manual transmission .... 132
247
WARNING
LIGHTS AND
MESSAGES
DASHBOARD
AND CONTROLS
SAFETY
DEVICES
CORRECT USE
OF THE CAR
IN AN
EMERGENCY
CAR
MAINTENANCE
TECHNICAL
SPECIFICATIONS
IINDEX
243-256 Croma TRW GB 28-07-2009 12:15 Pagina 247