automatic gearbox FIAT DUCATO 2010 Owner handbook (in English)

81
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
INCREASING THE MEMORISED SPEED
This can be done in two ways:
❒by pressing the accelerator and then memorising the
new speed reached;
or
❒by moving the lever upwards (+).
Each operation of the lever will correspond to a slight
increase in speed of about 1 km/h, while keeping the
lever upwards will correspond to a continuous speed
increase.
REDUCING THE MEMORISED SPEED
This can be done in two ways:
❒by turning the device off and then storing a new
speed;
or
❒by moving the stalk downwards (–) until reaching the
new speed which will be memorised automatically.
Each movement of the lever will correspond to a slight
reduction in speed of about 1 km/h, while keeping the
lever held downwards will correspond to a continuous
speed reduction.SWITCHING THE DEVICE OFF
The device can be switched off by the driver in the
following ways:
❒turning the ring nut A to the OFFposition;
❒turning the engine off;
❒pressing the brake pedal or operating the handbrake;
❒pressing the clutch pedal;
❒requesting a gear change with an automatic gearbox
in sequential mode;
❒with vehicle speed below the set limit;
❒by pressing the accelerator pedal; in this case the
system is not really switched off but the request for
acceleration takes priority over the system. The
cruise control is, however, active and it will not be
necessary to press the RES button to restore the
previous conditions after the acceleration is over.
The device is automatically switched off in the following
cases:
❒if the ABSor ESPsystems cut in;
❒if there is a system failure.
037-128 DUCATO LUM EN 7ed 6/21/10 2:10 PM Page 81

117
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
❒downhill: vehicle stationary on a road with a gradient
higher than 5%, engine running, clutch and brake
pedal pressed and reverse gear engaged.
At pickup the
ESPsystem control unit will maintain the
braking pressure at the wheels until the necessary torque
for starting is reached or, in any case, for a maximum of
2 seconds in order to move easily from the brake pedal
to the accelerator pedal. When two seconds have
elapsed, without starting, the system is automatically
deactivated, gradually releasing the braking pressure.
During this release stage, the typical brake
disengagement noise indicating that the vehicle is going
to move imminently will be heard.
Failure warning
The
áwarning light in the instrument panel will come
on in the event of a failure (see “Warning lights and
messages” section).
IMPORTANT The Hill Holder system is not a parking
brake; therefore, never leave the vehicle without having
engaged the handbrake, turned the engine off and
engaged first gear. FAILURE WARNING
In the event of a failure, the ESP will be automatically
switched off and the áwarning light will come on
constantly in the instrument panel along with a message
in the multifunction display (for versions/markets where
provided) (see “Warning lights and messages” section).
The LED in the ASR OFF button will light up. Contact
a Fiat Dealership as soon as possible if this happens.
Do not take unnecessary risks, even if
your vehicle is fitted with an ESP system.
Your driving style must always be suited to the
road conditions, visibility and traffic. The driver
is ultimately responsible for road safety.
WARNING
HILL HOLDER SYSTEM
This system is an integral part of the
ESPsystem and it is
provided to facilitate starting on hills.
It is automatically activated in the following conditions:
❒uphill: vehicle stationary on a road with a gradient
higher than 5%, engine running, clutch and brake
pedal pressed, gearbox in neutral or gear other than
reverse engaged;
For the correct operation of the ESP and
ASR systems, the tyres must absolutely be
the same make and type on all wheels, in perfect
condition and, above all, of the type, make and
size specified.
WARNING
037-128 DUCATO LUM EN 7ed 6/21/10 2:11 PM Page 117

233
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
ENGINE CODES – BODYWORK VERSIONS
Versions Engine type code
100 Multijet4HV
120 MultijetSOFIM F1AE0481D
130 MultijetSOFIM F1AE0481N
160 MultijetSOFIM F1CE0481D
There is an example of a bodywork version code below
by way of explanation with a key which is valid for all
bodywork version codes:
Key 250 A A M F A AX
MODEL
PAYLOAD
ENGINE
ENGINE TRANSMISSION/AXLES
BODYWORK
WHEELBASE
VERSION
PAYLOAD
A3000 kg
B3300 kg
C3500 kg LIGHT
D3500 kg HEAVY
E4005 kg
TRANSMISSION
MManual gearbox
AAutomatic
transmissionENGINE
A100 Multijet
C120 Multijet
D160 Multijet
E130 Multijet
WHEELBASE
AShort wheelbase
BMedium wheelbase
CLong wheelbase
DMedium-long
wheelbase
BODYWORK
AChassis cab frame
BPlatform frame without drive cab
CPlatform chassis cab
DFlatbed truck
EPrimary school bus
FVan
GLong cab trailer
HLong cab frame
LSecondary school bus
MMinibus
PPanorama
R6/9 seater crew cab
UChassis without „floor“ cab
231-276 DUCATO LUM EN 9ed 15-04-2011 8:20 Pagina 233

268
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
According to
Scheduled
Servicing Plan
Manual gearbox
and differential
Manual gearbox
and differential
Wheel side
constant velocity
joints
Differential side
constant velocity
joints
Differential side
constant velocity
joints
Hydraulic power
steering
Lubricants
(▲)
For diesel engines, in the event of an emergency in which the original products are not available, lubricants with at least ACEA C2
performance are acceptable; however, in this case optimum engine performance is not guaranteed and the lubricants should be replaced
with recommended products as soon as possible at a Fiat Dealership.
The use of products with lower specifications than ACEA C2 could cause damage to the engine not covered by the warranty.
For particularly harsh climate conditions, ask a Fiat Dealership for the appropriate product from PETRONAS LUBRICANTS.
SAE 5W-30 grade synthetic base lubricant.
FIAT 9.55535-S1 certification.
Synthetic base lubricant, SAE 75W-80 grade
that exceeds API GL-4 specifications
Synthetic base lubricant, SAE 75W-85 grade
that exceeds API GL-4 specifications
Lithium soap grease with molybdenum
disulphide. NI.GI. 2 consistency
Lithium-based grease
NI.GI. 0 consistency
Poly-urea synthetic-based grease suitable for
high temperatures. NI.GI. 2 consistency
Lubricant for power steering and automatic
transmissions. Exceeds
ATF DEXRON IIISELENIA WR P.E.(▲)
Contractual Technical
Reference No. 510.D07
TUTELA CAR EXPERYA
Contractual Technical
Reference No. F178.B06
TUTELA CAR MATRYX
Contractual Technical
Reference No. F108.F02
TUTELA STAR 500
TUTELA MRM ZERO
TUTELA STAR 325
Contractual Technical
Reference No. F301.D03
TUTELA GI/E
Contractual Technical
Reference No. F001.C94Diesel engine
lubricants
Lubricants
and greases
for motion
transmission
FLUIDS AND LUBRICANTS
SPECIFICATIONS AND RECOMMENDED PRODUCTS
Use Quality specifications of fluids and lubricants Genuine lubricants Replacement for correct vehicle operation and fluids interval
231-276 DUCATO LUM EN 9ed 15-04-2011 8:21 Pagina 268

280
KNOWING
YOUR CAR
SAFETY
STARTING
AND
DRIVING
WARNING
LIGHTS AND
MESSAGES
IN AN
EMERGENCY
MAINTENANCE
AND CARE
TECHNICAL
SPECIFICATIONS
INDEX
Gearbox
– using the manual
gearbox ................................ 150
General warnings ..................... 2
Glove compartment ................ 91
Handbrake ................................149
Handbrake lever ...................... 149
Hazard lights ............................. 85
Headlight alignment
corrector ................................ 113
Headlight washers
– control ................................. 79
– maintenance ........................ 227
Headlights ..................................113
– adjusting headlights
abroad .................................. 114
– beam orientation ............... 113
– bulb replacement ............... 188
– headlight alignment
corrector ............................. 113Headlights
(warning for cleaning) ........... 229
Headrests .................................. 46
Heated rear window ............... 86
Heating and ventilation ........... 51
– automatic climate
control ................................. 60
– controls ................................ 52
– front window rapid
defrosting/demisting .. 54-57-65
– heated rear window
and external rear view
mirror defrosting/
demisting .....................54-59
– interior air recirculation ... 55
– passenger compartment
air vents ............................... 52
– manual climate control ...... 55
Heavy use of the vehicle
servicing ................................... 212
Hill Holder system .................. 117
Identification plates ................. 233
– body paintwork .................. 232
– identification data ............... 234
Ignition switch .......................... 12
– steering lock ........................ 13
In an emergency ....................... 173
Installation of electrical/
electronic devices .................. 125
Installing the tow hook ...........155
– assembly diagrams ..... 157-158
Instrument panel ...................... 14
Interior fittings ......................... 90
Interiors (maintenance) .......... 222
Isofix (child seat) ...................... 138
Keys ........................................... 5
– Code card ........................... 5
– key with remote control .. 6
– key without remote
control ................................. 8
– replacing the battery ......... 8
277-284 DUCATO LUM EN 9ed 15-04-2011 8:32 Pagina 280