load FIAT DUCATO 244 2005 3.G Owner's Guide

176VEHICLE MAINTENANCE
Furthermore, remember that high in-
take electric devices (such as baby bot-
tle warmers, vacuum cleaners, cellular
phones, mini-fridges, etc.) powered
when the engine is offcan deploy
the battery.
IMPORTANTWhen installing ad-
ditional systems on the vehicle, bear
in mind that improper branches on
connections of the vehicle wiring are
dangerous, particularly if safety devices
are involved.
Battery
60 Ah
88 Ah
100 Ah
The total intake of these systems
(factory and after-market) must be
less than 0.6 mA x Ah (of the bat-
tery) as shown in the following table:
Maximum
admitted stand-by
intake
36 mA
52.8 mA
60 mA
If the vehicle is inactive for a long pe-
riod of time, refer to the “Vehicle stor-
age” paragraph in section “Getting the
best out of you vehicle”.
Before performing any operation on
the electrical system, disconnect the
battery negative cable.
Battery terminals shall always be
perfectly separated.
If you want to add accessories after
buying the vehicle (antitheft system,
free-hand phone kit, radio navigator,
etc.) visit a Fiat Dealership. They
can suggest the most suitable acces-
sories to get and check whether the
electric system can support the
required load or whether a higher
capacity battery is required.
These devices will, in fact, run off
the battery even when the key is not
inserted (vehicle parked, engine off).

178VEHICLE MAINTENANCE
WHEELS AND
TYRES
Check the pressure of each tyre, in-
cluding the spare, every two weeks
and before long journeys.
The pressure must be checked when
the tyre is rested and cold.
It is normal for pressure to rise
when you are driving. If you have to
check or restore the pressure when
the tyres are warm, remember that
the pressure value must be 0.3 bar
above the specified value.
See “Wheels” in “Technical specifi-
cations” chapter for the correct tyre
inflation pressure.Wrong pressure causes uneven
wear of the tyres fig. 17:
A- correct pressure: tyre wears
evenly
B- under-inflated tyre: shoulder
tread wear
C- over-inflated tyre: centre tread
wear.IMPORTANTAs far as possible
avoid sharp braking and screech starts.
Be careful not to hit the kerb, pot-
holes or other obstacles. Driving for
long stretches over bumpy roads can
damage the tyres.
Periodically check that the tyres have
no cuts in the side wall, abnormal
swelling or irregular tyre wear. If any
of these occur, have the vehicle seen
to at a Fiat Dealership.
Avoid overloading your vehicle: this
can seriously damage wheels or tyres.
If you get a flat tyre, stop immedi-
ately and change it so as not to dam-
age the tyre, the wheel, the suspen-
sion and the steering.
fig. 17
F0D0027m
If the pressure is too low,
the tyre overheats and this
can cause it serious damage.
WARNING
Tyre pressure must be cor-
rect to ensure good road
holding.
WARNING
Tyres must be replaced when the
tread wears down to 1.6 mm. In any
case, comply with the laws in the coun-
try where the vehicle is being driven.

186TECHNICAL SPECIFICATIONS
E- Maximum vehicle weight fully
loaded
F - Maximum vehicle weight fully
loaded with trailer
G - Maximum vehicle weight on
front axle
H - Maximum vehicle weight on rear
axle
I - Engine type
L - Body version code
M - Smoke opacity index (for diesel
engines).
This plate is fastened to the front
crossmember in the engine compart-
ment A-fig. 3.BODYWORK PAINT
IDENTIFICATION PLATE
The plateA-fig. 4 is set on the left-
hand inner side of the bonnet.It bears the following data fig. 5:
A - Paint manufacturer
B - Colour name
C - Fiat colour code
D- Respray and touch up code.
fig. 3
F0D0188m
fig. 4
F0D0189m
fig. 5
F0D0025m

187TECHNICAL SPECIFICATIONS
ENGINE CODES - BODYWORK VERSIONS
Version 11
Van short wheelbase
Van short wheelbase
Van medium wheelbase
Van high sided medium wheelbase
Van high sided medium wheelbase
Truck medium wheelbase
Truck short wheelbase
Chassis cab short wheelbase
Chassis cab short wheelbase Camping Car
Chassis cab medium wheelbase
Chassis cab medium wheelbase Camping Car
Transport ambulance short wheelbase
Panorama short wheelbase
Combi 6 seater short wheelbase
Chassis cab with load bed short wheelbase
Chassis cab with load bed short wheelbase Camping Car
Chassis cab with load bed medium wheelbase
Chassis cab with load bed medium wheelbase Camping Car
Van short wheelbase
Van short wheelbase
Van medium wheelbaseEngine
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0 JTD
2.0 JTD
2.0 JTDEngine
code
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RHV
RHV
RHVBodywork
version
244ATMFA AX
244ATMFA BX
244ATMFB AX
244ATMNB AX
244ATMNB BX
244ATMDB AX
244ATMDA AX
244ATMAA AX
244ATMAA AXC
244ATMAB AX
244ATMAB AXC
244ATMTA AX
244ATMPA 00
244ATMRA 01
244ATMCA AX
244ATMCA AXC
244ATMCB AX
244ATMCB AXC
244AAMFA AX
244AAMFA BX
244AAMFB AX

188TECHNICAL SPECIFICATIONS
Version 11
Van high sided medium wheelbase
Van high sided medium wheelbase
Chassis cab short wheelbase
Chassis cab short wheelbase Camping Car
Truck short wheelbase
Chassis cab with load bed short wheelbase
Chassis cab with load bed short wheelbase Camping Car
Chassis cowl short wheelbase
Chassis cowl short wheelbase Camping Car
Chassis cab medium wheelbase
Chassis cab medium wheelbase Camping Car
Truck medium wheelbase
Chassis cab with load bed medium wheelbase
Chassis cab with load bed medium wheelbase Camping Car
Panorama short wheelbase
Combi 6 seater short wheelbase
Combi short wheelbase low roof
Combi medium wheelbase low roof
Chassis cowl short wheelbase “city centre”
Chassis cab with load bed short wheelbase “city centre”
Truck short wheelbase “city centre”
Chassis cab with load bed medium wheelbase “city centre”
Truck medium wheelbase “city centre”
Van short wheelbase low roof “city centre”
Van short wheelbase high roof “city centre”
Van medium wheelbase low roof “city centre”
Van medium wheelbase high sided “city centre”
Van medium wheelbase extra high “city centre”
Van short wheelbase low roof (9 q)Engine
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTDEngine
code
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHVBodywork
version
244AAMNB AX
244AAMNB BX
244AAMAA AX
244AAMAA AXC
244AAMDA AX
244AAMCA AX
244AAMCA AXC
244AAMBA AX
244AAMBA AXC
244AAMAB AX
244AAMAB AXC
244AAMDB AX
244AAMCB AX
244AAMCB AXC
244AAMPA 02
244AAMRA 03
244AAMFA ZX
244AAMRB 26
244AAMRA 03
244DAMBA AX
244DAMCA AX
244DAMDA AX
244DAMCB AX
244DAMDB AX
244DAMFA AX
244DAMFA BX
244DAMFB AX
244DAMNB AX
244DAMNB BX

191TECHNICAL SPECIFICATIONS
Version 15
Truck medium wheelbase crew cab
Chassis cab long wheelbase crew cab
Chassis cab long wheelbase crew cab Camping Car
Chassis cab with load bed long wheelbase
Chassis cab with load bed long wheelbase Camping Car
Chassis cab with load bed short wheelbase
Chassis cab with load bed short wheelbase Camping Car
Chassis cab with load bed medium wheelbase
Chassis cab with load bed medium wheelbase Camping Car
Transport ambulance medium wheelbase
Aid ambulance medium wheelbase
Panorama medium wheelbase
Combi 6 seater medium wheelbase
Combi 6 seater medium wheelbase
Van high sided medium wheelbase Bipower
Van high sided medium wheelbase Bipower (extra high)
Van high sided medium wheelbase petrol/LPG
Van high sided medium wheelbase petrol/LPG (extra high)
Van high sided long wheelbase Bipower
Van high sided long wheelbase Bipower (extra high)
Van high sided long wheelbase petrol/LPG
Van high sided long wheelbase petrol/LPG (extra high)
Van short wheelbase
Van short wheelbase
Van medium wheelbase
Van high sided medium wheelbase
Van high sided medium wheelbaseEngine
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTDEngine
code
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RFL
RHV
RHV
RHV
RHV
RHVBodywork
version
244BTMGB AX
244BTMHC AX
244BTMHC AXC
244BTMCC AX
244BTMCC AXC
244BTMCA AX
244BTMCA AXC
244BTMCB AX
244BTMCB AXC
244BTMTB AX
244BTMSB AX
244BTMPB 09
244BTMRB 10
244BTMRB 10B
244BTMNB AM
244BTMNB BM
244BTM NB AG
244BTMNB BG
244BTMNC AM
244BTMNC BM
244BTMNC AG
244BTMNC BG
244BAMFA AX
244BAMFA BX
244BAMFB AX
244BAMNB AX
244BAMNB BX

192TECHNICAL SPECIFICATIONS
Version 11
Van long wheelbase high sided without EGR
Van long wheelbase extra high without EGR
Chassis cab short wheelbase
Chassis cab short wheelbase Camping Car
Truck short wheelbase
Chassis cab with load bed short wheelbase
Chassis cab with load bed short wheelbase Camping Car
Chassis cowl short wheelbase
Chassis cowl short wheelbase Camping Car
Chassis cab medium wheelbase
Chassis cab medium wheelbase Camping Car
Truck medium wheelbase
Chassis cab with load bed medium wheelbase
Chassis cab with load bed medium wheelbase Camping Car
Chassis cowl medium wheelbase
Chassis cowl medium wheelbase Camping Car
Truck medium wheelbase crew cab
Chassis cab medium wheelbase crew cab
Chassis cab medium wheelbase crew cab Camping Car
Chassis cab long wheelbase
Chassis cab long wheelbase Camping Car
Truck long wheelbase
Chassis cab with load bed long wheelbase
Chassis cab with load bed long wheelbase Camping Car
Chassis cowl long wheelbase
Chassis cowl long wheelbase Camping Car
Truck long wheelbase crew cabEngine
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTD
2.0 JTDEngine
code
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV
RHV Bodywork
version
244BAMNC AX
244BAMNC BX
244BAMAA AX
244BAMAA AXC
244BAMDA AX
244BAMCA AX
244BAMCA AXC
244BAMBA AX
244BAMBA AXC
244BAMAB AX
244BAMAB AXC
244BAMDB AX
244BAMCB AX
244BAMCB AXC
244BAMBB AX
244BAMBB AXC
244BAMGB AX
244BAMHB AX
244BAMHB AXC
244BAMAC AX
244BAMAC AXC
244BAMDC AX
244BAMCC AX
244BAMCC AXC
244BAMBC AX
244BAMBC AXC
244BAMGC AX

193TECHNICAL SPECIFICATIONS
Version 15
Chassis cab long wheelbase crew cab
Chassis cab long wheelbase crew cab Camping Car
Combi 6 seater medium wheelbase
Combi medium wheelbase high sided
Panorama medium wheelbase high sided
Ambulance van medium wheelbase high sided
Van short wheelbase without EGR
Van short wheelbase without EGR
Van medium wheelbase without EGR
Van high sided medium wheelbase without EGR
Van high sided medium wheelbase without EGR
Van high sided medium wheelbase
Van high sided long wheelbase without EGR
Van high sided long wheelbase without EGR
Chassis cab short wheelbase without EGR
Chassis cab short wheelbase Camping Car without EGR
Truck short wheelbase without EGR
Chassis cab with load bed short wheelbase without EGR
Chassis cab with load bed short wheelbase Camping Car without EGR
Chassis cab with load bed short wheelbase Camping Car without EGR
Chassis cab with load bed medium wheelbase special Camping car without EGR
Chassis cab with load bed long wheelbase special
Camping car without EGR
Chassis cowl short wheelbase without EGR
Chassis cowl short wheelbase Camping Car without EGR
Chassis cowl short wheelbase special Camping Car without EGREngine
2.0 JTD
2.0 JTD
2.0 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTDEngine
code
RHV
RHV
RHV
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481CBodywork
version
244BAMHC AX
244BAMHC AXC
244BAMRB 11
244BAMRB 11C
244BAMPB 27
244BSMNB AX
244BSMFA AY
244BSMFA BY
244BSMFB AY
244BSMNB AY
244BSMNB BY
244BSMNB AX
244BSMNC AY
244BSMNC BY
244BSMAA AY
244BSMAA AYC
244BSMDA AY
244BSMCA AY
244BSMCA AYC
244BSMCA BYC
244BSMCB BYC
244BSMCC BYC
244BSMBA AY
244BSMBA AYC
244BSMBA BYC

194TECHNICAL SPECIFICATIONS
Version 15
Chassis cab medium wheelbase without EGR
Chassis cab medium wheelbase Camping Car without EGR
Truck medium wheelbase without EGR
Chassis cab with load bed medium wheelbase without EGR
Chassis cab with load bed medium wheelbase
Camping Car without EGR
Chassis cowl medium wheelbase without EGR
Chassis cowl medium wheelbase Camping Car without EGR
Chassis cowl medium wheelbase special Camping Car without EGR
Chassis cab long wheelbase without EGR
Chassis cab long wheelbase Camping Car without EGR
Truck long wheelbase without EGR
Chassis cab with load bed long wheelbase without EGR
Chassis cab with load bed long wheelbase Camping Car without EGR
Chassis cowl long wheelbase without EGR
Chassis cowl long wheelbase Camping Car without EGR
Chassis cowl long wheelbase special Camping Car without EGR
Chassis cab 4050 wheelbase without EGR
Chassis cab 4050 wheelbase Camping Car without EGR
Truck 4050 wheelbase without EGR
Chassis cowl 4050 wheelbase without EGR
Chassis cowl 4050 wheelbase Camping Car without EGR
Chassis cowl 4050 wheelbase special Camping Car without EGR
Chassis cab medium wheelbase crew cab without EGR
Chassis cab medium wheelbase crew cab Camping Car without EGR
Chassis cab 4050 wheelbase crew cab without EGR
Chassis cab 4050 wheelbase crew cab without EGR
Truck 4050 wheelbase without EGR
Truck 4050 wheelbase crew cab without EGREngine
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTD
2.3 JTDEngine
code
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481C
F1AE0481CBodywork
version
244BSMAB AY
244BSMAB AYC
244BSMDB AY
244BSMCB AY
244BSMCB AYC
244BSMBB AY
244BSMBB AYC
244BSMBB BYC
244BSMAC AY
244BSMAC AYC
244BSMDC AY
244BSMCC AY
244BSMCC AYC
244BSMBC AY
244BSMBC AYC
244BSMBC BYC
244BSMAG AY
244BSMAGAYC
244BSMDG AY
244BSMBG AY
244BSMBG AYC
244BSMBG BYC
244BSMHB AY
244BSMHB AYC
244BSMHG AY
244BSMHG AYC
244BSMDG AY
244BSMGG AY

196TECHNICAL SPECIFICATIONS
Version 11
Chassis cab short wheelbase Camping Car without EGR
Truck short wheelbase without EGR
Chassis cab medium wheelbase without EGR
Chassis cab medium wheelbase Camping Car without EGR
Truck medium wheelbase without EGR
Chassis cab with load bed short wheelbase low roof automatic gearbox
Chassis cab with load bed short wheelbase low roof Camping Car automatic gearbox
Chassis cab with load bed medium wheelbase without EGR
Chassis cab with load bed medium wheelbase
Camping Car without EGR
Chassis cowl short wheelbase without EGR
Chassis cowl short wheelbase Camping Car without EGR
Chassis cowl medium wheelbase without EGR
Chassis cowl medium wheelbase Camping Car without EGR
Chassis cab with load bed short wheelbase without EGR
Chassis cab with load bed short wheelbase Camping Car without EGR
Chassis cab with load bed short wheelbase special Camping car without EGR
Chassis cab with load bed medium wheelbase special
Camping car without EGR
Chassis cab with load bed long wheelbase special
Camping car without EGR
Chassis cab long wheelbase without EGR
Chassis cab long wheelbase Camping Car without EGR
Truck long wheelbase without EGR
Chassis cab with load bed long wheelbase without EGR
Chassis cab with load bed long wheelbase Camping Car without EGR
Chassis cowl long wheelbase without EGR
Chassis cowl long wheelbase Camping Car without EGR
Chassis cab 4050 wheelbase without EGREngine
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTD
2.8 JTDEngine
code
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43S
8140.43SBodywork
version
244BPMAA AYC
244BPMDA AY
244BPMAB AY
244BPMAB AYC
244BPMDB AY
244BPACA AXC
244BPACA AXC
244BPMCB AY
244BPMCB AYC
244BPMBA AY
244BPMBA AYC
244BPMBB AY
244BPMBB AYC
244BPMCA AY
244BPMCA AYC
244BPMCA BYC
244BPMCB BYC
244BPMCC BYC
244BPMAC AY
244BPMAC AYC
244BPMDC AY
244BPMCC AY
244BPMCC AYC
244BPMBC AY
244BPMBC AYC
244BPMAG AY