ignition FIAT MULTIPLA 2006 1.G Workshop Manual

231
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
TECHNICAL
SPECIFICATIONS
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
CAR
MAINTENANCE
Windows
Use specific window cleaner products to clean cloths
to avoid scratching the glass or damaging the
transparency.
IMPORTANT The inside of the rear window should
be wiped gently with a cloth in the direction of the
filaments to avoid damaging the heating device.
Engine compartment
At the end of the winter the engine compartment
should be carefully washed, without directing the jet
against electronic control units. Contact a specialised
workshop to have this done.
IMPORTANT Wash with the engine cold and the
ignition key at STOP. After washing make sure that the
various protections (e.g. rubber caps and various
covers) have not been damaged or removed.
Front headlights
IMPORTANT Never use aromatic substances (e.g.:
petrol) or ketones (e.g.: acetone) for cleaning front
headlight plastic lens.
IMPORTANT Wash with the engine cold and the
ignition key at STOP. After washing make sure that the
various protections (e.g. rubber caps and various
covers) have not been damaged or removed.INTERIORS
Periodically check that water is not trapped under the
mats (due to water dripping off shoes, umbrellas, etc.)
which could cause oxidisation of the sheet metal.
CLEANING SEATS AND FABRIC/JERSEY
UPHOLSTERY
❒Use a soft brush or vacuum cleaner to remove dust.
❒Rub the seats with a sponge moistened with a
solution of water and neutral detergent.
PLASTIC PARTS INSIDE THE CAR
Clean the plastic parts inside the car with a cloth
moistened with a solution of water and non-abrasive
neutral detergent. To remove grease or hard stains,
use special solvent-free products designed not to alter
the appearance and colour of components.
IMPORTANT Do not use alcohol or petrol to clean
the instrument panel.
Detergents cause water pollution.
Therefore the engine compartment should
be washed in areas equipped for
collecting and purifying the liquid used in
the washing process.

233
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
T T
E E
C C
H H
N N
I I
C C
A A
L L
S S
P P
E E
C C
I I
F F
I I
C C
A A
T T
I I
O O
N N
S S
IDENTIFICATION DATA ................................................. 234
ENGINE CODES - BODYWORK VERSIONS .............. 236
ENGINE ................................................................................. 237
FUEL FEED/IGNITION ....................................................... 238
TRANSMISSION .................................................................. 238
BRAKES .................................................................................. 239
SUSPENSIONS ..................................................................... 239
STEERING ............................................................................. 239
WHEELS ................................................................................. 240
DIMENSIONS ....................................................................... 244
PERFORMANCE ................................................................... 246
WEIGHTS ............................................................................... 247
CAPACITIES ......................................................................... 249
FLUIDS AND LUBRICANTS ........................................... 250
FUEL CONSUMPTION ....................................................... 252
CO
2EMISSIONS .................................................................. 253
RADIOFREQUENCY REMOTE CONTROL
MINISTERIAL HOMOLOGATION ................................. 254

238
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
TECHNICAL
SPECIFICATIONS
Modifications or repairs to the fuel system that are not carried out properly or do not take the
system technical specifications into account can cause malfunctions leading to the risk of fire.
FUEL FEED/IGNITION
JTD 120
Direct injection
with electronically controlled Multijet
“Common Rail” variable geometry
turbosupercharger and intercooler.100 16V
Multipoint sequential
phased electronic injection,
integral with ignition.
TRANSMISSION
10016V - JTD 120
Gearbox Five forward gears and reverse with synchromesh
for forward gear engagement
Clutch Self-adjusting pedal without idle stroke
Drive Front
Ignition

TECHNICAL
SPECIFICATIONS
258
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
INDEXDASHBOARD
AND CONTROLS
IN AN
EMERGENCY
– adjusting the headlight slant.... 88
– beam adjustment abroad ......... 89
Head restraints ................................ 44
Heated rear window
– control ........................................ 65
Heating and climate
control system ............................. 48-50
– adjustable outlets ...................... 49
– climate control with automatic
temperature control ................ 54
– controls.................................. 50-52-54
– cooling ......................................... 52-57
– demisting................................ 51-53-55
– heating ......................................... 50-55
– heating and ventilation ............. 50
– manual climate control
system .......................................... 52
– recirculation .......................... 51-53-57
– ventilation ................................... 51
If an exterior light burns out ....... 186
If an interior light burns out ......... 192
If the battery is flat .......................... 202
Ignition switch .................................. 15
– key positions .............................. 15
– steering lock ............................... 16
Individual settings ............................ 41– key without remote control... 9
– replacing the batteries ............. 10
Lubricants (specifications)............ 250
Main beam headlights
– bulb replacement ...................... 187
– control ......................................... 59
– flashing the headlights ............. 60
Manual climate control system .... 52
Number plate lights ....................... 191
Paintwork
– identification plate ................... 235
– maintenance .............................. 230
Parking ............................................... 140
– handbrake ................................... 141
Parking sensors
– acoustic signal ............................ 97
– activation ..................................... 97
– failure warnings.......................... 98
– general warnings........................ 98
Performance ..................................... 246
Pollen filter........................................ 220
Power steering ................................. 239
– fluid level ..................................... 218 Instrument panel.............................. 17
Instruments
– clock ............................................. 21
– control buttons ......................... 19
– fuel gauge .................................... 18
– rev counter................................. 18
– speedometer .............................. 21
– tachometer ................................. 18
Interior equipment
– ashtray ......................................... 69
– cigar lighter ................................. 69
– current sockets ......................... 70
– driver's oddment tray .............. 67
– food box...................................... 71
– oddment tray under seat ........ 68
– oddment tray under sun visors 68
– passenger's oddment tray ....... 67
– sun visors .................................... 70
Interiors ............................................. 231
Jacking the car ................................. 203
Keys................................................... 8
– code card .................................... 8
– duplicate ...................................... 10
– key with remote control ......... 9

TECHNICAL
SPECIFICATIONS
259
SAFETY
DEVICES
CORRECT USE
OF THE CAR
WARNING
LIGHTS AND
MESSAGES
CAR
MAINTENANCE
INDEX
DASHBOARD
AND CONTROLS
IN AN
EMERGENCY
Pretensioners ................................... 117
Protecting the environment.......... 109
Radio-frequency remote control 9
– description ................................. 9
– ministerial homologation......... 255
Rear fog lights
– bulb replacement ..................... 190
– control ......................................... 65
Rear window shelf removal .......... 83
Rear window washer
– control ......................................... 62
– fluid level ..................................... 217
Rear window wiper
– blades ........................................... 227
– control ......................................... 62
– nozzle ........................................... 228
Rearview mirrors
– door mirrors .............................. 46
– driving mirror ............................ 46
Reconfigurable multifunction
display ............................................. 22
Remote control
(door locking/unlocking) ............. 9
Reversing light (replacement)....... 190
Rims and tyres ................................. 240– accessories.................................. 106
– aerial............................................. 103
– hands-free kit ............................. 104
– radio transmitters and
cellular telephones .................... 15
– speakers ...................................... 102
– standard equipment .................. 102
Spark plugs ........................................ 237
Speedometer .................................... 21
Starting the engine .......................... 137
– bump starting ............................. 167
– emergency starting ................... 165
– how to warm up the engine
after it has just started ............. 139
– ignition switch ............................ 15
– jump starting .............................. 166
– starting procedure
for diesel versions ..................... 138
– starting procedure
for petrol versions .................... 137
– stopping the engine................... 140
Steering .............................................. 239
Steering column lock ...................... 16
Steering column stalks
– left stalk ....................................... 61
– right stalk .................................... 59 Roof rack/ski rack ........................... 87
Rubber tubing................................... 226Seat belts.......................................... 112
– general instructions .................. 118
– how to keep the seat belts
always in efficient conditions ... 120
– load limiters .............................. 118
– pretensioners ............................. 117
– rear seat belts ........................... 114
– transporting children in safety.. 120
– type Isofix child restraint
system .......................................... 126
Seats ................................................... 41
– cleaning ........................................ 231
– front ............................................. 41
– moving ......................................... 81
– rear ............................................... 42
– removing ..................................... 84
Service Schedule .............................. 207
Side/taillights
– control ......................................... 59
– front bulb replacement ............ 189
– rear bulb replacement ............ 190
Snow chains ...................................... 150
Snow tyres ........................................ 149
Sound system ................................... 102