wheel FIAT SEDICI 2008 2.G Service Manual
[x] Cancel search | Manufacturer: FIAT, Model Year: 2008, Model line: SEDICI, Model: FIAT SEDICI 2008 2.GPages: 266, PDF Size: 3.25 MB
Page 230 of 266
229
IMPORTANT The steering column is not
strong enough to withstand shocks trans-
mitted from the front wheels during tow-
ing. Always unlock the steering wheel be-
fore towing.
4-WHEEL DRIVE (4WD)
Your vehicle should be towed under one
of the following conditions:
❒With all four wheels on a flat-bed truck.
❒With the front or rear wheels lifted and
a dolly under the other wheels.
IMPORTANT Towing your vehicle with
front and/ or rear wheels on the ground
can result in damage to the automatic
transaxle and/ or the 4WD drive system.
IF THE STARTER DOES
NOT OPERATE
❒Try turning the ignition switch to the
“START” position with the headlights
turned on to determine the battery
condition. If the headlights go exces-
sively dim or go off, it usually means
that either the battery is flat or the bat-
tery terminal contact is poor. Recharge
the battery or correct battery terminal
contact as necessary.
❒If the headlights remain bright, check
the fuses. If the reason for failure of the
starter is not obvious, there may be a
major electrical problem. Have the ve-
hicle inspected by your authorized
Fiat Dealership.
TOWING
If you need to have your vehicle towed,
contact a professional service. Your deal-
er can provide you with detailed towing
instructions.
IMPORTANT To help avoid damage to
your vehicle during towing, proper equip-
ment and towing procedures must be
used.
2-WHEEL DRIVE (2WD)
MANUAL TRANSAXLE
Manual transaxle vehicles may be towed
using either of the following methods.
❒From the front, with the front wheels
lifted and the rear wheels on the
ground. Before towing, make sure that
the parking brake is released.
❒From the rear, with the rear wheels lift-
ed and the front wheels on the ground,
provided the steering and drivetrain are
in operational condition. Before tow-
ing, make sure that transaxle is in neu-
tral, the steering wheel is unlocked (the
ignition key should be in the “ACC” po-
sition), and the steering wheel is se-
cured with a clamping device designed
for towing service.
225-232 Fiat16 New GB 3-09-2008 8:44 Pagina 229
Page 238 of 266
237
When washing the vehicle, park it where
direct sunlight does not fall on it and fol-
low the instructions below:
Flush the underside of body and wheel
housings with pressurized water to remove
mud and debris. Use plenty of water.
IMPORTANT When washing the vehicle,
avoid directing steam or hot water of
more than 80°C (176°F) on plastic parts.
To avoid damaging engine components, do
not use pressurized water in the engine
compartment.Rinse the body to loosen the dirt. Remove
dirt and mud from the body exterior with
running water. You may use a soft sponge
or brush. Do not use hard materials which
can scratch the paint or plastic. Remem-
ber that the headlight covers or lenses are
made of plastic in many cases.
IMPORTANT To avoid damage to the
paint or plastic surface, do not wipe the
dirt off without ample water. Be sure to
follow above procedure.
Wash the entire exterior with a mild de-
tergent or vehicle wash soap using a
sponge or soft cloth. The sponge or cloth
should be frequently soaked in the soap
solution.
IMPORTANT When using a commercial
vehicle wash product, observe the cau-
tions specified by the manufacturer. Nev-
er use strong household detergents or
soaps.
– Never attempt to wash
and wax your vehicle with
the engine running.
– When cleaning the underside of the
body and fender, where there may
be sharp-edged parts, you should
wear gloves and a long sleeved shirt
to protect your hands and arms from
being cut.
– After washing your vehicle, care-
fully test the brakes before driving to
make sure they have maintained
their normal effectiveness.
WARNING
60B212S
233-238 Fiat16 New GB 3-09-2008 8:44 Pagina 237
Page 244 of 266
243
T T
E E
C C
H H
N N
I I
C C
A A
L L
S S
P P
E E
C C
I I
F F
I I
C C
A A
T T
I I
O O
N N
S S
ENGINE .................................................................................. 244
FUEL FEED – IGNITION .................................................... 244
ELECTRICAL COMPONENTS ......................................... 245
BULBS ..................................................................................... 245
TRANSMISSION .................................................................. 246
BRAKES .................................................................................. 246
SUSPENSIONS ...................................................................... 246
STEERING .............................................................................. 246
WHEELS ................................................................................. 247
DIMENSIONS ....................................................................... 247
WEIGHTS .............................................................................. 248
PERFORMANCE .................................................................. 248
CAPACITIES .......................................................................... 248
12
243-248 Fiat16 New GB 3-09-2008 8:42 Pagina 243
Page 247 of 266
246
BRAKES
Service brakes Front
Rear
Parking brake
Vacuum brake
SUSPENSIONS
Front
Rear
STEERING
Type
Minimum steering cycleDisc (Ø 280 mm - 11 in.)
Drum (Ø 220 mm - 8.65 in.)
Controlled by hand lever, it works on rear brakes
10”
Mc Pherson independent wheels
Bent twisting axle
Electric, pinion
11 m (433 in.)
TRANSMISSION
Drive 4WD
Clutch
Gearbox1.6 16V
1.9 Multijet4-wheel drive, electronic-control self-locking differential
Dry single disc, Belleville washer,
hydraulic control
5 forward gears + reverse
6 forward gears + reverse
243-248 Fiat16 New GB 3-09-2008 8:42 Pagina 246
Page 248 of 266
247
205/60 R16
16 x 6J
Tyre inflation pressure values are specified on the label
located on the driver’s door post
10 mm (254 in.)
10 mm (254 in.)
1 ± 1 mm (0.0393 ± 0.0393 in.)
– 0° 23’ ± 1°
– 0° 10’ ± 1°
3° 40’ ± 2°
3° 32’ ± 2°
WHEELS
Tyres
Rims
Tyre pressure
Recommended snow chains Radial thickness:
Axial thickness:
Wheel geometry Toe-in, front
Camber angle, front
2WD
4WD
Caster angle, front
2WD
4WD
4,115 (162)
1,755 (69.1)
1,605 (63.2)
2,500 (98.4)
1,500 (59.1)
1,495 (58.9)
175 (6.9)
895 (35.2)
720 (28.3)
270/6704,115 (162)
1,755 (69.1)
1,620 (63.8)
2,500 (98.4)
1,495 (58.9)
1,495 (58.9)
190 (7.5)
895 (35.2)
720 (28.3)
270/6704,115 (162)
1,755 (69.1)
1,605 (63.2)
2,500 (98.4)
1,500 (59.1)
1,495 (58.9)
175 (6.9)
895 (35.2)
720 (28.3)
270/6704,115 (162)
1,755 (69.1)
1,620 (63.8)
2,500 (98.4)
1,495 (58.9)
1,495 (58.9)
190 (7.5)
895 (35.2)
720 (28.3)
270/670
DIMENSIONS Unit mm (in.) 1.6 16V1.9 Multijet
2WD 4WD 2WD 4WD
Overall length
Overall width
Overall height
Wheelbase
Track Front
Rear
Ground clearance
Overhang Front
Rear
Boot volume dm3
243-248 Fiat16 New GB 3-09-2008 8:42 Pagina 247
Page 249 of 266
248
2WD
4WD
2WD
4WD
2WD
4WD
2WD
4WD1,135 – 1,185 (2,502 – 2,612)
1,195 – 1,245 (2,634 – 2,745)
1,650 (3,638)
1,670 (3,682)
865 (1,907)
870 (1,918)
850 (1,874)
870 (1,918)1,270 – 1,320 (2,800 – 2,910)
1,330 – 1,380 (2,932 – 3,042)
1,790 (3,946)
1,790 (3,946)
980 (2,160)
980 (2,160)
860 (1,896)
860 (1,896)
WEIGHTS kg (lbs) 1.6 16V1.9 Multijet
Kerb weight (including fuel, spare wheel,
tools and accessories)
Gross vehicle weight (GVWR)
Gross front axle weight (GAWR)
Gross rear axle weight (GAWR)
PERFORMANCE 1.6 16V1.9 Multijet
Top admitted speed after initial vehicle use
Pick-up angle
Racing angle
Rise angle170 km/h
20.3°
31.1°
18.1°180 km/h
20.3°
31.1°
18.1°
2WD
4WD
4WD
4WD7.7 litres (13.6 Imp pt)
50 litres (11.0 Imp gal)
3.9 litres (6.9 Imp pt)
(replacement with oil filter)
2.5 litres (4.4 Imp pt)
2.5 litres (4.4 Imp pt)
0.6 litres (1.1 Imp pt)
0.8 litres (1.4 Imp pt)6.5 litres (11.4 Imp pt)
50 litres (11.0 Imp gal)
4.5 litres (7.9 Imp pt)
(replacement with oil filter)
2.5 litres (4.4 Imp pt)
2.5 litres (4.4 Imp pt)
0.6 litres (1.1 Imp pt)
0.8 litres (1.4 Imp pt)
CAPACITIES (indicative values) 1.6 16V1.9 Multijet
Engine cooling system
(including reservoir tank)
Fuel tank
Engine oil
Gearbox oil
Transfer oil
Rear differential oil
243-248 Fiat16 New GB 3-09-2008 8:42 Pagina 248
Page 258 of 266
257
Battery .......................................210-245
Before driving.................................. 9
Bodywork care................................ 233
Brake fluid ............................................ 202
Brake system ....................................... 159
Brakes
– Brake fluid ..................................... 202
– Brake pedal .............................131-203
– Brake system ................................ 246
– Parking brake lever ...............130-204
– Vacuum brake ............................... 160
Bulbs
– Replacement ................................. 217
– Type ................................................ 245
Can holder .......................................... 142
Capacities ......................................10-248
Catalytic converter ............................ 165
Child-proof locks ................................ 22
Children
– Child-proof locks ......................... 22
– Child restraint systems ............... 37
– Installation with Isofix
type anchorages ........................... 42
– Installation with lap-shoulder
seat belts ........................................ 42
Cigar lighter ......................................... 90Clock ..................................................... 98
Clutch .............................................131-205
CO
2emissions .................................... 241
Cup holder ........................................... 142
Daily inspection checklist ................ 150
Dimensions .......................................... 247
Dipped beam headlights .................... 63
– Bulb replacement ......................... 219
Doors
– Central door locking
system ........................................13-19
– Child-proof locks ......................... 22
– Dead lock ...................................... 14
– Keyless Start ................................. 15
– Opening/closing ............................ 12
Drive belt (servicing) ......................... 189
Driving tips....................................... 167
– Driving on hills ............................. 168
– Driving on slippery roads ........... 169
– Highway driving ............................ 168
Emergency service....................... 225
Engine
– Air cleaner ..................................... 198
– Engine coolant .............................. 195
– Engine oil and filter ...................... 189
– If the engine is flooded ............... 230
ABS ...................................................... 160
Air bags ................................................. 47
– Front ............................................... 48
– How the system works .............. 52
– Servicing ......................................... 54
– Side ................................................. 50
Air cleaner ........................................... 198
Air conditioning ...........................99-224
Ashtray ................................................. 90
Assist grips ........................................... 140
Audio systems
– Antenna ...................................112-147
– Anti-theft system ......................... 121
– Cautions on handling .................. 110
– CD Changer ................................. 118
– CD player ...................................... 116
– Error display messages ............... 125
– General .......................................... 112
– Radio .............................................. 113
– RDS (Radio Data System) .......... 115
– Steering wheel controls ............. 126
– System ............................................ 109
– Troubleshooting .......................... 123
Automatic heating and air
conditioning system ......................... 104
– Maintenance ...........................109-224
I I
N N
D D
E E
X X
14
257-264 Fiat16 New GB 3-09-2008 8:25 Pagina 257
Page 260 of 266
259
– Switch ............................................. 66
Rear window wiper
– Blades.............................................. 223
– Control .......................................... 66
Recirculated air.............................102-105
Refuelling/Capacities.....................10-248
Roof rails or roof rack anchors ....... 147
Running-in ............................................ 165
Seat back pocket................................ 145
Seat belts
– Height adjuster ............................. 36
– Pretensioners ............................... 45
– Seat belt hangers .......................... 36
– Seat belt inspection ..................... 37
– Seat belt reminder (S.B.R.) ........ 35
– Use .................................................. 33
– Warnings ....................................... 31
Seats
– Folding rear seats ......................... 145
– Front (adjustment) ...................... 29
– Front seat heater ......................... 139
– Seat back pocket .......................... 145
Service station guide .......................... 3
Snow chains ......................................... 169
Spare tire .......................................144-208
Spark plugs ....................................199-245
Speedometer........................................ 81
Spot light................................................ 138Starting the engine............................... 152
Steering...........................................204-246
Steering column controls.......... 57
Steering wheel
– Adjustment .............................67-204
– Audio controls........................68-126
Sun visors ............................................. 137
Supplement...................................... 249
Suspensions .......................................... 246
Symbols ................................................. 4
Tachometer ........................................ 83
Tailgate .................................................. 23
Technical specifications.............. 243
Theft deterrent light .......................... 93
Thermometer ...................................... 92
Tools ..................................................... 144
Towing the vehicle
– Frame hooks ................................. 135
– Instructions ............................177-229
Trailer towing ...................................... 172
Trailer hitch ......................................... 172
Transaxle
– Gear oil .......................................... 194
– Gear oil change .....................194-248
– Gearshift lever .............................. 132
– Using the transaxle ...................... 156
Transmission ........................................ 246
Trip meter ........................................... 81 Luggage restraint loops ..................... 145
Main beam headlights........................ 63
– Bulb replacement ......................... 220
Manual heating and air
conditioning system.......................... 100
– Maintenance............................104-224
Mirrors
– Defroster ....................................... 88
– Electric mirrors ............................ 28
– Inside rearview mirror ............... 27
– Outside rearview mirror ........... 27
MP3/WMA Player................................ 120
Odometer ........................................... 81
– Illumination cancel switch .......... 89
Operating your vehicle............... 149
Original spare parts ........................... 2
Other controls
and equipment............................. 129
Parking brake lever ........................... 130
Parking lights ........................................ 63
Pedals .................................................... 131
Performance ........................................ 248
Pretensioners for seat belts ............. 45
Radio antenna...............................112-147
Rear door.............................................. 23
Rear fog light......................................... 64
Rear window washer
257-264 Fiat16 New GB 3-09-2008 8:25 Pagina 259
Page 261 of 266
260
– Control .......................................... 65
2WD/4WD switch.......................85-157 Turn signal ............................................ 79
– Bulb replacement ......................... 218
Tires
– Compact spare tire ..............144-208
– Inspection ...................................... 205
– Rotation ......................................... 207
– Technical data ............................... 247
Vacuum brake..................................... 160
Vehicle identification........................... 240
Vehicle loading...................................... 172
Vehicle loading and towing........ 171
Ventilation .....................................101-106
Warning and indicator lights ........... 72
Warning and indicator lights ............. 72
Weights ................................................ 248
Wheels
– Changing ........................................ 209
– Technical data................................ 247
Windows
– Electric window controls ........... 24
– Manual window controls ............ 24
Windshield defroster...................101-107
Windshield washer
– Control .......................................... 65
– Fluid................................................. 198
Windshield wiper
– Blades ............................................. 222
257-264 Fiat16 New GB 3-09-2008 8:25 Pagina 260