trailer FORD E SERIES 2013 4.G Owner's Guide

Fuse/Relay
LocationFuse Amp
RatingProtected Components
33 10A Trailer brake controller
34 5A Not used (spare)
35 10A Reverse park aid, Rear video camera,
Cutaway run/start
36 5A Passive anti-theft system radio
frequency module
37 10A Climate control, Stripped chassis
instrument panel #1 run/start
38 20A Not used (spare)
39 20A Radio, Navigation
40 20A Amplifier
41 15A Radio, Switch illumination, Reverse
camera mirror, Automatic dimming rear
view mirror, Inverter
42 10A Upfitter switch
43 10A Stripped chassis instrument panel
connector #1
44 10A Trailer tow battery charge relay
45 5A Wipers, Stripped chassis Engine
connector 3
46 7.5A Passenger airbag deactivation indicator
47 30A circuit
breakerWindows accessory delay
48 Relay Delayed accessory
Fuses199
2013 Econoline(eco)
Owners Guide gf, 1st Printing
USA(fus)

TRANSMISSION FLUID CHECK
Checking Automatic Transmission Fluid (If Equipped)
Refer to yourscheduled maintenance informationfor scheduled
intervals for fluid checks and changes. Your transmission does not
consume fluid. However, the fluid level should be checked if the
transmission is not working properly, i.e., if the transmission slips or
shifts slowly or if you notice some sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is at normal operating
temperature (approximately 20 miles [30 kilometers]). If your vehicle has
been operated for an extended period at high speeds, in city traffic
during hot weather or pulling a trailer, the vehicle should be turned off
for about 30 minutes to allow fluid to cool before checking.
1. Drive the vehicle 20 miles (30 kilometers) or until it reaches normal
operating temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the engine running, parking brake engaged and your foot on the
brake pedal, move the gearshift lever through all of the gear ranges.
Allow sufficient time for each gear to engage.
4. Latch the gearshift lever in P (Park) and leave the engine running.
5. Remove the dipstick, wiping it clean with a clean, dry lint free rag.
6. Install the dipstick making sure it is fully seated in the filler tube.
7. Remove the dipstick and inspect the fluid level. The fluid should be in
the designated area for normal operating temperature or ambient
temperature.
210Maintenance
2013 Econoline(eco)
Owners Guide gf, 1st Printing
USA(fus)

A dissimilar spare tire and wheel assembly is defined as a spare tire or
wheel that is different in brand, size or appearance from the road tires
and wheels and can be one of three types:
1.T-type mini-spare:This spare tire begins with the letter T for tire
size and may have Temporary Use Only molded in the sidewall.
2.Full-size dissimilar spare with label on wheel:This spare tire has
a label on the wheel that states: THIS TIRE AND WHEEL FOR
TEMPORARY USE ONLY
When driving with one of the dissimilar spare tires listed above, do not:
•exceed 50 mph (80 km/h).
•load the vehicle beyond maximum vehicle load rating listed on the
Safety Compliance Label.
•tow a trailer.
•use snow chains on the end of the vehicle with the dissimilar spare
tire.
•use more than one dissimilar spare tire at a time.
•use commercial car washing equipment.
•try to repair the dissimilar spare tire.
Use of one of the dissimilar spare tires listed above at any one wheel
location can lead to impairment of the following:
•Handling, stability and braking performance
•Comfort and noise
•Ground clearance and parking at curbs
•Winter weather driving capability
•Wet weather driving capability
•All-wheel driving capability (if applicable)
3.Full-size dissimilar spare without label on wheel
When driving with the full-size dissimilar spare tire and wheel assembly,
do not:
•exceed 70 mph (113 km/h).
•use more than one dissimilar spare tire and wheel at a time.
•use commercial car washing equipment.
•use snow chains on the end of the vehicle with the dissimilar spare
tire and wheel.
270Wheels and Tires
2013 Econoline(eco)
Owners Guide gf, 1st Printing
USA(fus)

The usage of a full-size dissimilar spare tire and wheel assembly can lead
to impairment of the following:
•Handling, stability and braking performance
•Comfort and noise
•Ground clearance and parking at curbs
•Winter weather driving capability
•Wet weather driving capability
•All-wheel driving capability (if applicable)
•Load leveling adjustment (if applicable)
When driving with the full-size dissimilar spare tire and wheel assembly,
additional caution should be given to:
•towing a trailer.
•driving vehicles equipped with a camper body.
•driving vehicles with a load on the cargo rack.
Drive cautiously when using a full-size dissimilar spare tire and wheel,
and seek service as soon as possible.
Tire Change Procedure
WARNING:When one of the front wheels is off the ground, the
transmission alone will not prevent the vehicle from moving or
slipping off the jack, even if the transmission selector lever is in
positionP.
WARNING:To help prevent the vehicle from moving when you
change a tire, be sure to place the transmission selector lever in
positionP, set the parking brake and block (in both directions) the
wheel that is diagonally opposite (other side and end of the vehicle) to
the tire being changed.
WARNING:Never get underneath a vehicle that is supported
only by a jack. If the vehicle slips off the jack, you or someone
else could be seriously injured.
Wheels and Tires271
2013 Econoline(eco)
Owners Guide gf, 1st Printing
USA(fus)

ACCESSORIES
For a complete listing of the accessories that are available for your
vehicle, please contact your dealer or visit our online store at:
Accessories.Ford.com(U.S. only).
Ford Custom Accessories are available for your vehicle through your
local Ford or Ford of Canada dealer. Ford Motor Company will repair or
replace any properly dealer-installed Ford Custom Accessories found to
be defective in factory-supplied materials or workmanship during the
warranty period, as well as any component damaged by the defective
accessories. The accessories will be warranted for whichever provides
you the greatest benefit:
•12 months or 12,000 miles (20,000 km) (whichever occurs first), or
•the remainder of your new vehicle limited warranty.
Contact your dealer for details and a copy of the warranty.
Exterior style
•Bug shields•Running boards
•Deflectors•Splash guards
Interior style
•Floor mats•Cargo organization
•Electrochromic compass/temperature interior mirrors
Lifestyle
•Racks and carriers*•Trailer hitches and towing
accessories
Peace of mind
•Keyless entry keypad•Back up alarm*
•Remote start•Hitch mounted parking sensor*
•Vehicle security systems
•Bumper mounted parking sensors*
*Ford Licensed Accessories (FLA) are warranted by the accessory
manufacturer’s warranty. Ford Licensed Accessories are fully designed
and developed by the accessory manufacturer and have not been
designed or tested to Ford Motor Company engineering requirements.
Contact your Ford dealer for details regarding the manufacturer’s limited
warranty and/or a copy of the FLA product limited warranty offered by
the accessory manufacturer.
Accessories289
2013 Econoline(eco)
Owners Guide gf, 1st Printing
USA(fus)

SPECIAL OPERATING CONDITIONS
If you operate your vehicleprimarilyin one of the more demanding
conditions listed below, you need to have some items maintained more
frequently. If you onlyoccasionallyoperate your vehicle under these
conditions, it is not necessary to perform the additional maintenance. For
specific recommendations, see your dealership service advisor or technician.
Towing a Trailer or Car-top Carrier
Inspect frequently,
service as requiredInspect and lubricate U-joints, if equipped with
grease fittings.
See axle maintenance items underExceptions.
Every 5000 miles
(8000 km)Inspect the wheels and related components for
abnormal noise, wear, looseness or drag.
Rotate tires*, inspect tires for wear and measure
tread depth.
Every 5000 miles
(8000 km) or six
monthsChange engine oil and filter.
Inspect and lubricate U-joints, if equipped with
grease fittings.
Every 30000 miles
(48000 km)Change automatic transmission fluid on 4–speed
transmission.
Replace front wheel bearing grease and grease
seals if non-sealed bearings are used.
*Vehicles equipped with dual rear wheels should rotate the front wheels
when specified; rear wheels only if unusual wear is noted.
Extensive Idling or Low-speed Driving for Long Distances as in
Heavy Commercial Use (i.e., Delivery, Taxi, Patrol Car or Livery)
Every 5000 miles
(8000 km)Inspect brake system.
Inspect wheels and related components for
abnormal noise, wear, looseness or drag.
Lubricate control arm and steering ball joints if
equipped with grease fittings.
Rotate tires*, inspect tires for wear and measure
tread depth.
Every 5000 miles
(8000 km) or six
monthsChange engine oil and filter.
Inspect and lubricate U-joints, if equipped with
grease fittings.
304Scheduled Maintenance
2013 Econoline(eco)
Owners Guide gf, 1st Printing
USA(fus)

EXCEPTIONS
Normal vehicle axle maintenance:Rear axles and power take-off
(PTO) units with synthetic fluid and light-duty trucks equipped with
Ford-design axles are lubricated for life; do not check or change fluid
unless a leak is suspected, service is required or the assembly has been
submerged in water. During long periods of trailer towing with outside
temperatures above 70°F (21°C) and at wide-open throttle for long
periods above 45 mph (72 km/h), non-synthetic rear axle fluids should
be changed every 3000 miles (4800 kilometers) or three months,
whichever comes first. This interval can be waived if the axle is filled
with 75W140 synthetic gear fluid meeting Ford specification
WSL-M2C192-A, part number F1TZ-19580-B or equivalent. Add friction
modifier XL-3 (EST-M2C118-A) or equivalent for complete refill of
Traction-Lok rear axles (seeTechnical specificationsin theCapacities
and Specificationschapter for details).
Police/Taxi/Livery vehicle axle maintenance:Change rear axle fluid
every 100000 miles (160000 kilometers). Rear axle fluid change may be
waived if the axle was filled with 75W140 synthetic gear fluid meeting
Ford specification WSL-M2C192-A, part number FITZ-19580-B or
equivalent. Add four ounces (118 mL) of additive friction modifier XL-3
(EST-M2C118-A) or equivalent for complete refill of Traction-Lok rear
axles. The axle fluid should be changed anytime the axle has been
submerged in water.
California fuel filter replacement:If the vehicle is registered in
California, the California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify the emission
warranty or limit recall liability prior to the completion of the vehicle’s
useful life. Ford Motor Company, however, urges you to have all
recommended maintenance services performed at the specified intervals
and to record all vehicle service.
Hot climate oil change intervals:Vehicles operating in the Middle
East, North Africa, Sub-Saharan Africa or locations with similar climates
using an American Petroleum Institute (API) Certified for Gasoline
Engines (Certification mark) oil of SM or SN quality, the normal oil
change interval is 5000 miles (8000 kilometers).
If the available API “SM” or “SN” oils are not available, then the oil
change service interval is 3000 miles (4800 kilometers).
Engine air filter replacement:Engine air filter life is dependent on
exposure to dusty and dirty conditions. Vehicles operated in these
conditions require frequent inspection and replacement of the engine air
filter.
308Scheduled Maintenance
2013 Econoline(eco)
Owners Guide gf, 1st Printing
USA(fus)

fluid, checking and adding ....216
fluid, refill capacities ..............280
fluid, specifications .................280
lubricant specifications ..........280
parking ....................................138
shift interlock ..........................134
trailer .......................................164
C
Capacities for refilling
fluids ..........................................280
CD ..........................................91–92
CD player ....................................89
CD voice commands ................378,
381–382
Cell phone use ............................15
Changing a tire .........................269
Child safety seats
automatic locking mode
(retractor) .................................38
LATCH .......................................27
tether anchorage hardware .....33
Child safety seats -
booster seats ...............................22
Cleaning the touchscreen ........361
Cleaning your vehicle ...............233
engine compartment ..............235
instrument panel ....................237
interior .....................................236
plastic parts ............................234
washing ....................................233
waxing .....................................235
wheels ......................................238
wiper blades ............................236
Climate control
(see Air conditioning or
Heating) ...............................99–100Clock ......................................91–92
Coolant ......................................205
checking and adding ..............205
refill capacities ........................280
specifications ..........................280
Creating a playlist .....................384
Cruise control ...........................149
Customer Assistance ................178
Ford Extended Service
Plan ..................................291, 293
Getting assistance outside
the U.S. and Canada ..............188
Getting roadside assistance ...178
Getting the service you
need .........................................184
Ordering additional
owner’s literature ...................190
Utilizing the
Mediation/Arbitration
Program ...................................188
Customizing your home
screen ........................................359
D
Daytime running lamps
(see Lamps) ................................69
Defrost .................................99–100
Dipstick
automatic transmission
fluid ..........................................210
engine oil .................................204
Drivebelt ....................................279
Driveline universal joint and
slip yoke ....................................216
Driving under special
conditions ..................................135
through water .........................175
Index411
2013 Econoline(eco)
Owners Guide gf, 1st Printing
USA(fus)

Safety restraints -
LATCH anchors ...........................27
Safety seats for children ......19, 24
Safety Compliance
Certification Label ....................287
Satellite Radio ...........................376
Scheduled Maintenance Guide
Normal Scheduled
Maintenance and Log .............299
SD card ......................................389
Seats
child safety seats ................19, 24
front seats .......................104, 106
SecuriLock passive anti-theft
system ..........................................63
Selecting your media source
(USB, Line in, BT audio) .........341
Setting a destination ................389
Setting the clock ...................91–92
SIRIUSsatellite radio .....373, 389
SIRIUS satellite radio
voice commands .......................375
SIRIUS Travel Link ...................385
SOS Post Crash Alert .................45
Spark plugs,
specifications .............278–279, 285
Special notice
ambulance conversions ............14
utility-type vehicles ..................14
Specification chart,
lubricants ...................................280
Stability system .........................141
Starting a flex fuel vehicle .......116
Starting your vehicle ........115–116
jump starting ..........................181Status bars ................................359
Steering wheel ............................66
tilting .........................................66
Supplemental Restraint System
(SRS) (see airbags) ....................46
SYNCAppLink™ ....................336
SYNCcustomer support .........311
SYNCServices .........................334
System overview .......................356
T
Temperature control
(see Climate control) .........99–100
Text messaging .........................322
Text messaging (sending,
downloading, deleting) .....322, 324
Tilt steering wheel ......................66
Tires ...........................244–245, 269
alignment ................................259
care ..........................................244
changing ..........................269, 271
checking the pressure ............254
inflating ...................................252
label .........................................251
replacing ..........................257, 274
rotating ....................................260
safety practices .......................259
sidewall information ...............247
snow tires and chains ............261
spare tire .................................269
terminology .............................245
tire grades ...............................245
treadwear ........................244, 256
Towing ...............................159, 170
recreational towing .................171
Trailer Brake
Controller-Integrated ..............164
Index415
2013 Econoline(eco)
Owners Guide gf, 1st Printing
USA(fus)

trailer towing ..........................159
wrecker ....................................170
Traction control ........................139
Traction-lok rear axle ...............136
Traffic, Directions and
Information ................................334
Trailer Brake
Controller-Integrated ................164
Transmission .............................129
brake-shift interlock (BSI) ....134
fluid, checking and adding
(automatic) .............................210
fluid, refill capacities ..............280
lubricant specifications ..........280
Troubleshooting ........................397
Turn signal ..................................69
U
Upfitter controls .......................200
USB port ......................................95
Using privacy mode ..................319
V
Vehicle health report ................332Vehicle Identification Number
(VIN) ..........................................286
Vehicle loading ..........................152
Ventilating your vehicle ...........117
Voice commands in media
mode ..........................................339
Voice commands in phone
mode ..........................................316
Voice recognition ......................361
W
Warning lights (see Lights) .......77
Washer fluid ..............................217
Water, Driving through .............175
Where am I? ..............................385
Windows
power .........................................71
Windshield washer fluid and
wipers ..........................................67
checking and adding fluid .....217
replacing wiper blades ...........221
Wrecker towing .........................170
416Index
2013 Econoline(eco)
Owners Guide gf, 1st Printing
USA(fus)