automatic transmission FORD EXPLORER 2011 5.G Owner's Manual

Perform the services noted in the following table at the specified
time/mileage (km) period either within 3,000 miles (4,800 km) of the
OIL CHANGE REQUIRED message appearing in the message center or
when the time/mileage (km) reading indicates service is due.
Example #1:The OIL CHANGE REQUIRED message comes on at
28,751 miles (46,270 km); perform the 30,000 mile (48,000 km)
automatic transmission fluid replacement.
Example #2:The OIL CHANGE REQUIRED message hasnotcome on
but the odometer reads 30,000 miles (48,000 km); perform the engine air
filter replacement. (i.e., Intelligent Oil Life Monitor™ was reset at
25,000 miles [40,000 km].)
Every 20,000 miles
(32,000 km)Replace cabin air filter (if equipped)
Every 30,000 miles
(48,000 km)Replace climate-controlled seat filter (if
equipped)
Replace engine air filter
Every 100,000 miles
(160,000 km)Change engine coolant
1
Replace spark plugs
Inspect accessory drive belt(s)2
Every 150,000 miles
(240,000 km)Change automatic transmission fluid and filter
(filter not required on 6F35, 6F50, DPS6 and
AWF-21 transmissions); consult dealer for
requirements
Change manual transmission fluid
Change rear axle fluid (RWD vehicles)
Replace accessory drive belt(s) if not replaced
within the last 100,000 miles (160,000 km)
Replace timing belt (Fiesta);failure to replace
belt can cause internal engine damage
1Initial replacement at 100,000 miles (160,000 km) or 72 months; every
50,000 miles (80,000 km) or 36 months thereafter
2Perform a follow-up inspection at 120,000 miles (192,000 km)
Scheduled Maintenance Guide
431
2011 Explorer(exp)
Owners Guide, 1st Printing
USA(fus)

SPECIAL OPERATING CONDITIONS
If you operate your vehicleprimarilyin one of the more demanding
conditions listed below, you will need to have some items maintained
more frequently. If you onlyoccasionallyoperate your vehicle under
these conditions, it is not necessary to perform the additional
maintenance. For specific recommendations, see your dealership service
advisor or technician.
Towing a trailer or using a camper or car-top carrier
As required– Change engine oil and filter as indicated by message
center and perform services listed in the Normal
Scheduled Maintenance chart
Inspect frequently, service as
required– See axle maintenance items under
Exceptions
Every 30,000 miles (48,000 km)– Change automatic transmission fluid (except 6R80
transmission)
Every 60,000 miles (96,000 km)– Change manual transmission fluid
Perform the services noted in the preceding table at the specified
time/mileage (km) period either within 3,000 miles (4,800 km) of the
OIL CHANGE REQUIRED message appearing in the message center or
when the time/mileage (km) reading indicates service is due.
Example #1:The OIL CHANGE REQUIRED message comes on at
28,751 miles (46,270 km); perform the 30,000 mile (48,000 km)
automatic transmission fluid replacement.
Example #2:The OIL CHANGE REQUIRED message hasnotcome on
but the odometer reads 30,000 miles (48,000 km); perform the engine air
filter replacement. (i.e., Intelligent Oil Life Monitor™ was reset at
25,000 miles [40,000 km].)
Scheduled Maintenance Guide
435
2011 Explorer(exp)
Owners Guide, 1st Printing
USA(fus)

Extensive idling and/or low-speed driving for long distances as in heavy
commercial use such as delivery, taxi, patrol car or livery
As required– Change engine oil and filter as indicated by message
center and perform services listed in the Normal
Scheduled Maintenance chart (except Fiesta)
Inspect frequently, service as
required– Replace cabin air filter (if equipped)
– Replace engine air filter
Every 300 hours of engine
operation*– Change engine oil and filter (Fiesta)
Every 30,000 miles (48,000 km)– Change automatic transmission fluid (except Fiesta and
vehicles equipped with a 6R80 transmission)
Every 60,000 miles (96,000 km)– Replace spark plugs
* Engine hour meter installation is recommended for these operating
conditions.
Perform the services noted in the preceding table at the specified
time/mileage (km) period either within 3,000 miles (4,800 km) of the
OIL CHANGE REQUIRED message appearing in the message center or
when the time/mileage (km) reading indicates service is due.
Example #1:The OIL CHANGE REQUIRED message comes on at
28,751 miles (46,270 km); perform the 30,000 mile (48,000 km)
automatic transmission fluid replacement.
Example #2:The OIL CHANGE REQUIRED message hasnotcome on
but the odometer reads 30,000 miles (48,000 km); perform the engine air
filter replacement. (i.e., Intelligent Oil Life Monitor™ was reset at
25,000 miles [40,000 km].)
Scheduled Maintenance Guide
436
2011 Explorer(exp)
Owners Guide, 1st Printing
USA(fus)

Operating in dusty conditions such as unpaved or dusty roads
Inspect frequently, service as
required– Replace cabin air filter (if equipped)
– Replace engine air filter
Every 5,000 miles (8,000 km)– Inspect the wheels and related components for
abnormal noise, wear, looseness or drag
– Rotate tires, inspect tires for wear and measure tread
depth
Every 5,000 miles (8,000 km) or
6 months– Change engine oil and filter
Every 30,000 miles (48,000 km)– Change automatic transmission fluid (except Fiesta and
vehicles equipped with a 6R80 transmission)
Every 50,000 miles (80,000 km)– Change manual transmission fluid
Reset your Intelligent Oil Life Monitor™ after each engine oil and filter
change; refer to theInstrument Clusterchapter.
Exclusive use of E85 (Flex Fuel Vehicles only)
Every oil change interval– If ran exclusively on E85, fill the fuel tank full with
regular unleaded fuel
Scheduled Maintenance Guide
437
2011 Explorer(exp)
Owners Guide, 1st Printing
USA(fus)

A
Accessory delay ..........................99
Active Park Assist .....................303
Adaptive Cruise Control ...........105
AdvanceTrac ..............................277
Airbag supplemental restraint
system ........................197, 206, 208
and child safety seats ............199
description ..............197, 206, 208
disposal ....................................211
driver airbag ............199, 206, 209
indicator light .................205, 210
operation .................199, 206, 209
passenger airbag .....199, 206, 209
side airbag ...............................206
Air cleaner filter .......406–407, 410
Air conditioning ..............63, 66, 68
manual heating and air
conditioning system .................63
All Wheel Drive (AWD),
driving off road .........................316
Ambulance packages ....................7
Antifreeze
(see Engine coolant) ................385
Anti-lock brake system
(see Brakes) ......................274–275
Anti-theft system ..............154, 158
arming the system ..........154, 158
disarming a triggered
system .....................................158
Automatic transmission
driving an automatic
overdrive .................................288
fluid, adding ............................404
fluid, checking ........................404
fluid, refill capacities ..............411
fluid, specification ..................411Selectshift (SST) ....................291
Auxiliary input jack (Line in) ....60
Auxiliary power point .................96
Axle
lubricant specifications ..........411
refill capacities ........................411
B
Battery .......................................382
acid, treating emergencies .....382
jumping a disabled battery ....354
maintenance-free ....................382
replacement, specifications ...410
servicing ..................................382
Belt-Minder.............................193
Blind Spot Information
System .......................................310
Blind spot mirror ......................309
Booster seats .............................228
Brakes ........................................274
anti-lock ...........................274–275
anti-lock brake system (ABS)
warning light ...........................275
fluid, checking and adding ....404
fluid, refill capacities ..............411
fluid, specifications .................411
lubricant specifications ..........411
parking ....................................276
shift interlock ..........................287
C
Capacities for refilling fluids ....411
Car2UHome Automation
System .......................................116
Cargo net ...................................122
Cell phone use ............................10
Index
442
2011 Explorer(exp)
Owners Guide, 1st Printing
USA(fus)

Changing a tire .........................336
Child safety seats ......................216
in front seat ............................217
in rear seat ..............................217
LATCH .....................................222
recommendations ...................214
tether anchorage hardware ...224
Child safety seats - booster
seats ...........................................228
Cleaning your vehicle
engine compartment ..............369
instrument panel ....................370
interior .....................................371
plastic parts ............................369
washing ....................................367
waxing .....................................368
wheels ......................................368
wiper blades ............................370
Climate control
(see Air conditioning or
Heating) ...........................63, 66, 68
Clock ............................................52
Collision Warning System .........300
Console ..................................95–96
overhead ....................................95
rear ............................................96
Controls
power seat ...............................163
steering column ......................113
Coolant
checking and adding ..............385
refill capacities ................388, 411
specifications ..........................411
Cross Traffic Alert ....................310
Cruise control
(see Speed control) ..................103
Customer Assistance ................325Ford Extended Service
Plan ..................................419, 422
Getting assistance outside
the U.S. and Canada ..............363
Getting roadside assistance ...325
Getting the service you
need .........................................359
Ordering additional owner’s
literature .................................365
Utilizing the
Mediation/Arbitration
Program ...................................363
D
Daytime running lamps
(see Lamps) ................................79
Defrost
rear window ..............................75
Dipstick
automatic transmission
fluid ..........................................404
engine oil .................................380
Driving under special
conditions ..................293, 317, 320
sand .........................................319
snow and ice ...........................321
through water .................319, 324
E
Electronic message center ...23, 34
Emergencies, roadside
jump-starting ..........................354
running out of fuel .........353, 396
Emission control system ..........401
Engine ........................................414
cleaning ...................................369
coolant .....................................385
fail-safe cooling .......................390
Index
443
2011 Explorer(exp)
Owners Guide, 1st Printing
USA(fus)

Scheduled Maintenance Guide
Normal Scheduled
Maintenance and Log .............429
Seats ..........................................160
child safety seats ....................216
cleaning ...................................373
climate control ........................167
easy access/easyout feature ..169
front seats .......................162, 166
heated ......................................165
memory seat ...................145, 168
second row seats ............171, 174
third row seats ........174, 176–177
Second-row power fold seat ....174
SecuriCode keyless entry
system ........................................152
SecuriLock passive anti-theft
system ........................................154
Setting the clock .........................52
Snowplowing .................................7
SOS Post Crash Alert ...............211
Spare tire
(see Changing the Tire) ...........339
Spark plugs,
specifications .....................410, 414
Special notice
ambulance conversions ..............7
utility-type vehicles ....................7
Specification chart,
lubricants ...................................411
Speed control ............................103
Starting your vehicle ........267–269
jump starting ..........................354
push button start system .......270
Steering wheel
controls ....................................113
tilting .........................................94T
Temporary mobility kit .............344
Third-row power fold seat .......179
Tilt steering wheel ......................94
Tire Pressure Monitoring
System (TPMS)
Tires, Wheels and Loading ....250
Tires ...........................235–236, 336
alignment ................................243
care ..........................................239
changing ..................336, 339, 341
checking the pressure ............239
inflating ...................................237
label .........................................249
replacing ..................................241
rotating ....................................244
safety practices .......................243
sidewall information ...............244
snow tires and chains ............254
spare tire .................................337
Temporary mobility kit ..........344
terminology .............................236
tire grades ...............................236
treadwear ........................235, 240
Touchscreen features
(climate) ......................................71
Towing .......................................262
recreational towing .................265
trailer towing ..........................262
wrecker ....................................357
Transmission .............................288
brake-shift interlock (BSI) ....287
fluid, checking and adding
(automatic) .............................404
fluid, refill capacities ..............411
lubricant specifications ..........411
Turn signal ..................................82
Index
447
2011 Explorer(exp)
Owners Guide, 1st Printing
USA(fus)