warning FORD MUSTANG 2004 4.G Owner's Manual

2. Insert the key and turn it to OFF.Apply the
brake pedal and shift to N (Neutral).
When the key is in the ignition and in the
OFF position, the automatic transmission
shift lever can be moved from the P (Park)
position without the brake pedal depressed. To
avoid unwanted vehicle movement, always set the
parking brake.
3. Start the vehicle.
If it is necessary to use the above procedure to
move the gearshift lever, it is possible that a fuse
has blown or the vehicle’s brakelamps are not
operating properly. Refer toFuses and relaysin the
Roadside emergencieschapter.
Do not drive your vehicle until you verify
that the brakelamps are working.
Always set the parking brake fully and make
sure the gearshift is latched in P (Park).
Turn the ignition to the LOCK position and remove
the key whenever you leave your vehicle.
If the parking brake is fully released, but the
brake warning lamp remains illuminated, the
brakes may not be working properly. See your
dealer or a qualified service technician.
Driving with an automatic overdrive
transmission with console gearshift and O/D off
switch
Your transmission is equipped with an adaptive
learning strategy found in the vehicle computer. This
feature is designed to increase durability and
provide consistent shift feel over the life of the
vehicle. A new vehicle or transmission may have firm
and/or soft shifts. This operation is considered
2004 Mustang(mus)
Owners Guide (post-2002-fmt)
USA English(fus)
Driving
109

Use the following guidelines to avoid static build-up
when filling an ungrounded fuel container:
•Place approved fuel container on the ground.
•DO NOT fill a fuel container while it is in the
vehicle (including the cargo area).
•Keep the fuel pump nozzle in contact with the
fuel container while filling.
•DO NOT use a device that would hold the fuel
pump handle in the fill position.
Fuel Filler Cap
Your fuel tank filler cap has an indexed design with
a 1/8 turn on/off feature.
When fueling your vehicle:
1. Turn the engine off.
2. Carefully turn the filler cap counterclockwise 1/8
of a turn until it stops.
3. Pull to remove the cap from the fuel filler pipe.
4. To install the cap, align the tabs on the cap with
the notches on the filler pipe.
5. Turn the filler cap clockwise 1/8 of a turn until it
stops.
“Check Fuel Cap”illuminates when the ignition is
turned to the ON position to ensure your bulb is
working. When this light turns on, check the fuel
filler cap. Continuing to operate the vehicle with the
Check Fuel Cap light on, can activate the Service
Engine Soon warning. When the fuel filler cap is
properly re-installed, the light(s) will turn off after a
period of normal driving.It may take a long
period of time for the system to detect an
improperly installed fuel filler cap.
If you must replace the fuel filler cap, replace
it with a fuel filler cap that is designed for
your vehicle. The customer warranty may be
void for any damage to the fuel tank or fuel
system if the correct genuine Ford or
Motorcraft fuel filler cap is not used.
2004 Mustang(mus)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
184

•Have the items listed in your scheduled
maintenance guide performed according to the
specified schedule.
The scheduled maintenance items listed in the
scheduled maintenance guide are essential to the life
and performance of your vehicle and to its emissions
system.
If other than Ford, Motorcraft or Ford-authorized
parts are used for maintenance replacements or for
service of components affecting emission control,
such non-Ford parts should be equivalent to genuine
Ford Motor Company parts in performance and
durability.
Do not park, idle, or drive your vehicle in
dry grass or other dry ground cover. The
emission system heats up the engine compartment
and exhaust system, which can start a fire.
Illumination of the“Service Engine Soon”light,
charging system warning light or the temperature
warning light, fluid leaks, strange odors, smoke or
loss of engine power, could indicate that the
emission control system is not working properly.
Exhaust leaks may result in entry of harmful
and potentially lethal fumes into the
passenger compartment.
Do not make any unauthorized changes to your
vehicle or engine. By law, vehicle owners and anyone
who manufactures, repairs, services, sells, leases,
trades vehicles, or supervises a fleet of vehicles are
not permitted to intentionally remove an emission
control device or prevent it from working.
Information about your vehicle’s emission system is
on the Vehicle Emission Control Information Decal
located on or near the engine. This decal identifies
engine displacement and gives some tune up
specifications.
Please consult yourWarranty Guidefor complete
emission warranty information.
2004 Mustang(mus)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
192

On board diagnostics (OBD-II)
Your vehicle is equipped with a computer that
monitors the engine’s emission control system. This
system is commonly known as the On Board
Diagnostics System (OBD-II). This OBD-II system
protects the environment by ensuring that your
vehicle continues to meet government emission
standards. The OBD-II system also assists the
service technician in properly servicing your vehicle.
When theCheck Engine/Service Engine Soonlight
illuminates, the OBD-II system has detected a
malfunction. Temporary malfunctions may cause
yourCheck Engine/Service Engine Soonlight to
illuminate. Examples are:
1. The vehicle has run out of fuel. (The engine may
misfire or run poorly.)
2. Poor fuel quality or water in the fuel.
3. The fuel cap may not have been securely
tightened.
These temporary malfunctions can be corrected by
filling the fuel tank with good quality fuel and/or
properly tightening the fuel cap. After three driving
cycles without these or any other temporary
malfunctions present, theCheck Engine/Service
Engine Soonlight should turn off. (A driving cycle
consists of a cold engine startup followed by mixed
city/highway driving.) No additional vehicle service is
required.
If theCheck Engine/Service Engine Soonlight
remains on, have your vehicle serviced at the first
available opportunity.
Readiness for Inspection/Maintenance (I/M)
testing
In some localities, it may be a legal requirement to
pass an I/M test of the on-board diagnostics system.
If your“Check Engine/Service Engine Soon”light is
on, refer to the description in theWarning lights
and chimessection of theInstrument cluster
chapter. Your vehicle may not pass the I/M test with
the“Check Engine/Service Engine Soon”light on.
2004 Mustang(mus)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
193

BRAKE FLUID RESERVOIR
The fluid level will drop
slowly as the brakes
wear, and will rise
when the brake
components are
replaced. Fluid levels below the“MAX”line that do
not trigger the brake system warning lamp are
within the normal operating range, there is no need
to add fluid. If the fluid levels are outside of the
normal operating range, the performance of your
brake system could be compromised, seek service
from your dealer immediately.
CLUTCH ADJUSTMENT (IF EQUIPPED)
Check the clutch
adjustment. Refer to
the scheduled
maintenance guide for
the service interval
schedules.
The clutch on your
vehicle is operated by a
cable. As necessary, adjust the clutch as described
below.
1. Turn the engine off and shift into 1 (First).
2. Put your foot under the clutch pedal and gently
pull it up until the pedal stops.
3. Push the clutch pedal down slowly. You will hear a
click as the clutch adjusts itself.
TRANSMISSION FLUID
Checking automatic transmission fluid
(if equipped)
Refer to your scheduled maintenance guide for
scheduled intervals for fluid checks and changes.
Your transmission does not consume fluid. However,
the fluid level should be checked if the transmission
is not working properly, i.e., if the transmission slips
or shifts slowly or if you notice some sign of fluid
leakage.
M
A
X
2004 Mustang(mus)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
196

tire graded 150 would wear one and one-half
(11⁄2) times as well on the government course as a
tire graded 100.
•Traction:The traction grades, from highest to
lowest are AA, A, B, and C. The grades represent
the tire’s ability to stop on wet pavement as
measured under controlled conditions on specified
government test surfaces of asphalt and concrete.
A tire marked C may have poor traction
performance.
•Temperature:The temperature grades are A
(the highest), B and C, representing the tire’s
resistance to the generation of heat and its ability
to dissipate heat when tested under controlled
conditions on a specified indoor laboratory test
wheel.
13.Maximum Permissible Inflation Pressure:
Tire manufactures maximum permissible pressure
and/or the pressure at which the maximum load can
be carried by the tire. This pressure is normally
higher than the manufacturer’s recommended cold
inflation pressure which can be found on either the
tire label or certification label which is located on
the structure by the trailing edge of the driver’s door
or the edge of the driver’s door. The cold inflation
pressure should never be set lower than the
recommended pressure on the label.
Note:You may not find this information on all tires
because it is not required by federal law.
The tire suppliers may have additional markings,
notes or warnings such as standard load, radial
tubeless, etc.
2004 Mustang(mus)
Owners Guide (post-2002-fmt)
USA English(fus)
Maintenance and Specifications
206

A
Air bag supplemental
restraint system .. 79–80
and child safety
seats ......................... 81
description .............. 80
disposal .................... 84
driver air bag .......... 82
indicator light ......... 83
operation ................. 82
passenger air bag ... 82
Air cleaner filter ..... 215
Antifreeze (see
Engine coolant) ...... 174
Anti-lock brake system
(see Brakes) .... 104–105
Audio system
(see Radio) .... 18, 20, 25
Automatic
transmission ............ 108
driving an automatic
overdrive ............... 111
fluid, adding .......... 196
fluid, checking ...... 196
fluid, refill
capacities ............... 215
fluid,
specification .......... 221
Auxiliary power
point ........................... 45
Axle
lubricant
specifications. 218, 221
refill capacities ...... 215
traction lok ............ 108
B
Battery ..................... 171acid, treating
emergencies .......... 171
jumping a disabled
battery ................... 136
maintenance-free .. 171
replacement,
specifications ........ 215
servicing ................ 171
BeltMinder ................. 74
Brakes .............. 104–105
anti-lock ......... 104–105
anti-lock brake
system (ABS)
warning light ......... 104
fluid, checking and
adding .................... 196
fluid, refill
capacities ............... 215
fluid,
specifications. 218, 221
lubricant
specifications 218, 221
parking .................. 106
shift interlock ........ 108
Bulbs .......................... 38
C
Capacities for
refilling fluids .......... 215
Cargo net ................... 44
Cassette tape
player ................... 18, 25
CD-single premium ... 20
Cell phone use .......... 49
Child safety
restraints ................... 85
child safety belts .... 85
Child safety seats ...... 88
2004 Mustang(mus)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
228

turning on and off .. 35
Heating
heating and air
conditioning system.33
Hood ........................ 162
I
Ignition ............... 99, 221
Infant seats (see
Safety seats) ............. 88
Inspection/maintenance
(I/M) testing ............ 193
Instrument panel
cleaning ................. 157
cluster ...................... 10
lighting up panel
and interior ............. 36
J
Jump-starting your
vehicle ...................... 136
K
Keys
positions of the
ignition .................... 99
L
Lamps
bulb replacement
specifications
chart ........................ 39
daytime running
light .......................... 35
fog lamps ................. 35
headlamps ......... 35, 40headlamps, flash
to pass ..................... 36
instrument panel,
dimming ................... 36
interior lamps ... 38–39
replacing
bulbs ............ 38, 40–42
Lane change indicator
(see Turn signal) ...... 38
Lights, warning and
indicator .................... 10
anti-lock brakes
(ABS) .................... 104
Limited slip axle
(see Traction Loc) .. 108
Load limits ............... 117
Locks
doors ........................ 54
Lubricant
specifications ... 218, 221
Lug nuts, anti-theft . 134
Lumbar support,
seats ........................... 65
M
Manual transmission. 114
fluid capacities ...... 215
lubricant
specifications ........ 221
reverse ................... 115
Mirrors
side view mirrors
(power) ................... 46
Motorcraft
parts ................. 187, 215
O
Octane rating .. 185–186
2004 Mustang(mus)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
231

Oil (see
Engine oil) ............... 167
Overdrive ................. 109
P
Parking brake .......... 106
Parts (see Motorcraft
parts) ....................... 215
Power distribution box
(see Fuses)
............. 128
Power door locks
...... 54
Power mirrors
........... 46
Power point
............... 45
Power steering
........ 106
fluid, checking and
adding
.................... 194
fluid, refill
capacity
................. 215
fluid,
specifications. 218, 221
Power Windows
......... 45
R
Radio
.............. 18, 20, 25
Relays
...................... 125
Remote entry
system
........................ 57
illuminated entry
.... 60
locking/unlocking
doors
........................ 54
opening the trunk
... 57
Roadside
assistance
................ 122S
Safety Belt
Maintenance .............. 78
Safety belts (see Safety
restraints) ............ 68–72
Safety defects,
reporting .................. 152
Safety restraints .. 68–72
belt minder ............. 74
extension
assembly .................. 78
for adults ........... 69–72
for children ....... 84–85
safety belt
maintenance ............ 78
warning light and
chime ................. 73–74
Safety seats for
children ...................... 88
Seat belts (see Safety
restraints) .................. 68
Seats .......................... 64
child safety seats .... 88
front seats ............... 64
Servicing your
vehicle ...................... 161
Setting the clock
AM/FM/In-dash
6 CD ......................... 30
MACH MP3
system ..................... 23
Spare tire (see
Changing the Tire) . 130
Spark plugs,
specifications ... 215, 221
Specification chart,
lubricants ......... 218, 221
2004 Mustang(mus)
Owners Guide (post-2002-fmt)
USA English(fus)
Index
232

Speed control ............ 46
Starting your
vehicle ........ 99–100, 103jump starting ........ 136
Steering wheel tilting ....................... 44
T
Tilt steering wheel .... 44
Tires ................. 200–201 changing 130–132, 135
snow tires and
chains .................... 214
tire grades ............. 201
treadwear .............. 201
Towing ..................... 120 recreational
towing .................... 120
trailer towing ........ 120
wrecker .................. 141
Traction control ...... 107
Traction-lok rear
axle .......................... 108
Transmission automatic
operation ............... 108
brake-shift interlock
(BSI) ...................... 108
fluid, checking
and adding
(automatic) ........... 196
fluid, checking and
adding (manual) ... 199 fluid, refill
capacities ............... 215
lubricant
specifications. 218, 221
manual operation .. 114
Trunk ......................... 54 remote release .. 50, 57
Turn signal ................ 38
V
Vehicle dimensions . 221
Vehicle Identification
Number (VIN) ......... 222
Vehicle loading ........ 117
Ventilating your
vehicle ...................... 104
W
Warning lights
(see Lights) ............... 10
Washer fluid ............ 167
Water, Driving
through .................... 116
Windows power ....................... 45
Windshield washer
fluid and wipers ........ 43 checking and
adding fluid ........... 167
replacing wiper
blades ...................... 43
Wrecker towing ....... 141
2004 Mustang (mus)
Owners Guide (post-2002-fmt)
USA English (fus)
Index
233