tow GMC ENVOY 1998 Workshop Manual

Maintenance Schedule
I Short Trip/City Intervals I
Every 150,000 Miles (240 000 km): Cooling System
These intervals only summarize maintenance services.
Be sure to follow the complete maintenance schedule on
the following pages. Service
(or every
60 months, whichever occurs first).
1 Long TridHiEhwav Definition
Follow this maintenance schedule only if none of the
conditions from the Short Trip/City Maintenance
Schedule is true. Do not use this schedule
if the vehicle
is used for trailer towing, driven in a dusty area or used
off paved roads. Use the Short TripKity schedule for
these conditions.
Driving a vehicle with a fully warmed engine under
highway conditions causes engine oil
to break
down slower:
Long TridHiehwav Intervals
Every 7,500 Miles (12 500 km): Engine Oil and Filter
Change (or every 12 months, whichever occurs first).
Chassis Lubrication (or every 12 months, whichever
occurs first). Drive Axle Service. Tire Rotation.
Every 15,000 Miles (25 000 km): Automatic
Transmission Service (severe conditions only).
Every 30,000 Miles (50 000 km): Fuel Filter
Replacement. Air Cleaner Filter Replacement.
Every 50,000 Miles (83 000 km): Automatic
Transmission Service (normal conditions).
Every 60,000 Miles (100 000 km): Engine
Accessory Drive Belt Inspection. Fuel Tank, Cap and
Lines Inspection.
Inspection. Spark Plug Replacement. Positive
Crankcase Ventilation (PCV) Valve Inspection.
Every 150,000 Miles (240 000 km): Cooling System
Service (or every
60 months, whichever occurs first).
These intervals only summarize maintenance services.
Be sure to follow the complete maintenance schedule
on
the following pages.
Every 100,000 Miles (166 000 km): Spark Plug Wire
7-6 I
~ 1 I
ProCarManuals.com

Short TripKity Maintenance Schedule I
The services shown in this schedule up to 100,000 miles
( 166 000 km) should be performed after 100,000 miles
( 166 000 km) at the same intervals. The services shown
at
150,000 miles (240 000 km) should be performed at
the same interval after 150,000 miles (240
000 ktn).
See “Owner Checks and Services” and “Periodic
Maintenance Inspections” following.
Footnotes
7 The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure
to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to the
completion
of the vehicle’s ~1sefu1 life. We, however.
urge that all recommended maintenance services be
performed
at the indicated intervals and the maintenance
be recorded.
## Lubricate the front suspension, ball joints, steering
linkage, parking brake cable guides, propshaft splines.
universal joints and brake pedal springs.
+ A ~ood time to check your brakes is during tire
rotation. See “Brake System Inspection” under ”Periodic
Maintenance Inspections”
in Part C of this schedule.
.:. .:, -,-*,- Drive axle service (see “Recommended Fluids and
Lubricants“ in the Index for proper lubricant to use):
Locking Differential -- Drain fluid and refill at first
engine oil change.
At subsequent oil changes. check
fluid level and add fluid
as needed. If driving in
dusty areas or towing a trailer, drain fluid and refill
every 15,000 miles
(25 000 km).
Standard Differential -- Check fluid level and add
fluid
as needed at every oil change. If driving in
dusty areas or towing a trailer. drain fluid and refill
every
15,000 miles (25 000 km).
More frequent lubrication may be required for
hea\jy-duty
or off-l-oad use.
7-7
ProCarManuals.com

1 Short TripKity Maintenance Schedule I
27,000 Miles (45 000 kin) (Continued)
0 Lubricate chassis components (or every 3 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
(See footnote
#.)
velocity
joints and axle seals for leaking. (See footnote **.)
30,000 Miles (50 000 km)
0
0
0
0
Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Control Service.
Lubricate chassis components (or every
3 months, whichever occurs first).
(See footnote
#.)
Check readfront axle fluid level and add fluid as needed. Check constant
velocity joints and axle seals for leaking. (See footnote
**.)
Replace fuel filter.
An Emission Control Service. (See footnote?.)
Replace air cleaner filter.
An Emission Control Service.
Change automatic transmission fluid and filter if the vehicle is mainly driven
under one or more of these conditions:
7-12
In heavy city traffic where the outside temperature regularly reaches 90°F
(32°C) or higher.
In hilly or mountainous terrain.
When doing frequent trailer towing.
I i
DATE I
I MILEAGE ACTUAL I SERVICEDBY: I
ProCarManuals.com

Short TripKity Maintenance Schedule
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 Change automatic transmission fluid and filter if the vehicle is mainly driven
velocity
joints and axle seals for leaking. (See footnote
**.)
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly reaches 90°F
- In hilly or mountainous terrain.
(32 "C) or higher.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do nut use your vehicle under any of these conditions, change the fluid
and filter every 50,000 miles (83 000 km).
Inspect air cleaner filter if you are driving in dusty conditions. Replace filter
if necessary.
An Emission Control Service. (See footnote?.)
48,000 Miles (80 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
Lubricate chassis components (or every 3 months, whichever occurs first).
An Emissiorz Control Service.
(See footnote
#.)
DATE I
(Continued)
7-15
ProCarManuals.com

I Short Trip/City Maintenance Schedule 1
60,000 Miles (100 000 km) (Continued)
0 Lubricate chassis components (or every 3 months, whichever occurs first).
(See footnote
#.)
Check readfront axle fluid level and add fluid as needed. Check constant
velocity joints and axle seals for leaking. (See footnote
**.)
0 Change automatic transmission fluid and filter if the vehicle is mainly driven
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly reaches 90°F
- In hilly or mountainous terrain.
(32°C)
or higher.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
Ifyou do not use your vehicle under any of these conditions, change the fluid
and filter every
50,000 miles (83 000 km).
An Emission Control Service.
Art Emission Control Service. (See footnote?.)
An Emission Control Service.
0 Inspect engine accessory drive belt.
0 Replace fuel filter.
0 Replace air cleaner filter.
7-18
ProCarManuals.com

I Short Trip/City Maintenance Schedule I
75,000 Miles (125 000 km)
0
Change engine oil and filter (or every 3 months, whichever occurs first).
An Emission Control Service.
Lubricate chassis components (or every
3 months, whichever occurs first).
(See footnote
#.)
Change automatic transmission fluid and filter if the vehicle is mainly driven
under one or more of these conditions:
- In heavy city traffic where the outside temperature regularly reaches 90°F
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
Ifyou do not
use your vehicle under any of these conditions, change the fluid
andfilter every
50,000 miles (83 000 km).
Inspect air cleaner filter if you are driving in dusty conditions.
Replace filter if necessary,
An Emission Control Service. (See footnote?.)
Check readfront axle fluid level and add fluid as needed. Check constant
velocity joints and axle seals for leaking. (See footnote
**.)
(32" C) or higher.
DATE 1
I MILEAGE ACTUAL I SERVICEDBY I
7-21
ProCarManuals.com

I Short TripKity Maintenance Schedule I
90,000 Miles (1.50 000 km) (Co1ztimrt.d)
0 Change automatic transmission fluid and filter if the vehicle is mainly driven
under one or more
of these conditions:
- In heavy city traffic where the outside temperature regularly reaches 90°F
- In hilly or mountainous terrain.
(32°C)
or higher.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, change the fluid
and filter every 50,000 miles (83 000 km).
An Emission Control Service. (See footnote?.)
An Emission Control Service.
rotation pattern and additional information. (See footnote
+.)
0 Replace fuel filter.
Replace air cleaner filter.
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
93,000 Miles (155 000 km)
0 Change engine oil and filter (or every 3 months, whichever occurs first).
0 Lubricate chassis components (or every 3 months, whichever occurs first).
An Emission Control Service.
(See footnote
#.)
DATE I
MILEAGE ACTUAL I SERVICED BY:
7-24
ProCarManuals.com

I Long TripMighway Maintenance Schedule I
-
- When doing frequent trailer towing.
2 Uses such as found in taxi, police or delivery service.
lfyo~t do not use your vellicle under any qf these conditions, cnnnge the fluid
and
filter every 50,000 miles (83 000 km).
rotation pattern and additional information. (See footnote +.)
0 Rotate tires. See “Tire Inspection and Rotation’’ in the Index for proper
22,500 Miles (37 500 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
0 Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
An Emission Control Service.
(See footnote
#.)
velocity joints and axle seals for leaking. (See footnote **.)
rotation pattern and additional information. (See footnote +.)
DATE
30,000 Miles (50 000 km)
Change engine oil and filter (or every 12 months, whichever occurs first).
An Emission Control Service. MILEAGE
(Continued)
7-29
ProCarManuals.com

1 Long Tripmighway Maintenance Schedule
30,000 Miles (50 000 km) (Continued)
0 Lubricate chassis components (or every I2 months, whichever occ~lrs first).
(See footnote
#.:)
0 Check readfront axle fluid level and add fluid as needed. Check constant
velocity joints and axle seals for leaking. (See footnote
$’*.)
Change automatic transmission fluid and filter if the vehicle is mainly driven
under one
or more of these conditions:
- In heavy city traffic where the outside temperature regularly reaches 90°F
(32°C) or higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not us(J ~OLII- vel?ic*le uder CIH~ c!f’the.se cmditiolzs, change tl?o md ji’lter every 50,000 wiles (83 000 km).
rotation pattern and additional information. (See footnote +.)
At? Emissiorz CmztroI Service. (See footnote?.)
An Emission Control Service.
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
0 Replace fuel filter.
0 Replace air cleaner filter.
7-30
ProCarManuals.com

I
I Long Tripmighway Maintenance Schedule b
45,000 Miles (75 000 km) (Continued)
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
- Uses such as found in taxi, police or delivery service.
If you do not use your vehicle under any of these conditions, change the fluid
andfilter every
50,000 miles (83 000 km).
rotation pattern and additional information. (See footnote +.)
0 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper
50,000 Miles (83 000 km)
0 If you haven’t used your vehicle under severe conditions listed previously and,
therefore, haven’t changed your automatic transmission fluid, change both the
fluid and filter.
52,500 Miles (87 500 km)
0 Change engine oil and filter (or every 12 months, whichever occurs first).
Lubricate chassis components (or every 12 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid as needed. Check constant
An
Emission Control Service.
(See footnote
#.)
velocity joints and axle seals for leaking. (See footnote **.)
DATE I
MILEAGE SERVICED BY:
I I
~
DATE I
I I I
7-32
ProCarManuals.com