wheel GMC SAVANA 1996 Workshop Manual

Tire Chains
NOTICE:
Use tire chains only where legal and only when you
must. Use chains that are the proper size for your
tires. Install them on the tires of the rear axle.
Tighten them
as tightly as possible with the ends
securely fastened. Drive slowly and follow the chain
manufacturer's instructions. If you can hear the
chains contacting your vehicle, stop and retighten
~ them. If the contact continues, slow down until it
stops. Driving too fast or spinning the wheels with
I chains on will damage your vehicle.
Appearance Care
Remember, cleaning products can be hazardous. Some
are toxic. Others can burst into flame
if you strike a
match or get them on a hot part of the vehicle. Some are
dangerous
if you breathe their fumes in a closed space.
When you use anything from
a container to clean your
vehicle, be sure to follow the n1anufacturer's warnings
and instructions. And always open your doors or
windows when you're cleaning the inside.
0 Gasoline
0 Benzene
Naphtha
0 Carbon Tetrachloride
0 Acetone
0 Paint Thinner
0 Turpentine
0 Lacquer Thinner
0 Nail Polish Remover
They
can all be hazardous -- some Inore than
others
-- and they can all damage your vehicle, too.
Don't use any of these unless this manual says you can.
In many uses, these will darnage your vehicle:
0 Alcohol
0 Laundry Soap
0 Bleach
0 Reducing Agents
6-50
ProCarManuals.com

Aluminum Wheels (If So Equipped)
beep your wheels clean using a soft clean cloth with
mild soap and water. Rinse with clean water. After
rinsing thoroughly, dry with a soft clean towel.
A wax
may then be applied.
The surface
of these wheels is similar to the painted
surface
of your vehicle. Don’t use strong soaps,
chemicals, abrasive polishes, abrasive cleaners or
abrasive cleaning brushes on them because you could
damage the surfxe.
Don‘t take your vehicle through an automatic vehicle wash
that has silicon carbide tire cleaning brushes. These
brushes can also damage the surfxe
of these wheels.
Tires
To clean your tires, use a stiff brush with a tire cleaner.
Sheet Metal Damage
If your vehicle is damaged and requires sheet metal
repair or replacement, make sure the body repair shop
applies anti-corrosion material to the parts repaired or
replaced to restore corrosion protection.
Finish Damage
Any stone chips, fractures or deep scratches in the finish
should be repaired right away. Bare metal will corrode
quickly and may develop into a major repair expense.
Minor chips and scratches can be repaired with touch-up
materials available from your dealer or other service
outlets. Larger areas
of finish damage can be corrected
in your dealer’s body and paint shop.
I NOTICE:
When applying a tire dressing always take care to
wipe off any overspray
or splash from all painted
surfaces on the body
or wheels of the vehicle.
Petroleum-based products may damage the
paint
finish.
6-57
ProCarManuals.com

Appearance Care Materials Chart
I I I I I
I PARTNUMBER I SIZE DESCRIPTION USAGE
I050004
Removes soil and black marks
White Sidewall Tire Cleaner
16
oz. (0.473 L) 1050 I 74 Removes rust and
corrosion
Chrome
Cleaner and Polish
16 oz. (0.473 L) 1050 173 Also removes
old waxes and polishes
Tar and Road Oil Remover
16
oz. (0.473
Lj
IO501 72 Shines vehicle without scratching Chamois
2.75
sq. ft.
I05020
I
6 Ibs. (2.72 kg)
1050429 23
oz. (0.680 L) 1 OS0427 32
02. (0.946
Lj
10502 14
16 oz,. (0.473 L)
I 1051515 I 32 oz. (0.946 L)
I052870
8
oz. (0.237 L) 105291 8**
I6 oz. (0.473 L)
Magic Mirror Cleaner Polish
Spot and stain removal
Vinyl and
Leather Cleaner Exterior cleaner
and polish I
Glass Cleaner Cleans grease, grime and smoke film
Multi-Purpose Powdered Cleaner
Spot Lifter Cleans
vinyl, cloth, tires
and mats
Windshield washer solvent and antifreeze
Optikleen For cloth
Wash and Wax Concentrate
1~
-~ ~~ ~ ~~
Exterior wash I
Armor All Protector I I I
1052929 I 16 oz. (0.473 L) I Wheel Cleaner I Spray on wheel cleaner
I052930
Cleans
vinyl, leather and rubber
Armor All Cleaner 16 oz. (0.473 L) 12345002**’ Attracts and absorbs soils
Capture
Dry Spot Remover
8
0%. (0.237 L)
I 12345725 I 12 oz. (0.354 L) I Silicone Tire Shine .. . Shines tires - ., - -~ <- - - - ._
I
See your General Motors Parts Department for these products.
See “Fluids and Lubricants’’
in the Index.
* Not recomrr.,..ded for pigskin suede leather.
**Not recommended for use on instrument panel vinyl. I
6-59
ProCarManuals.com

Capacities and Specifications
Normal Maintenance Replacement Parts
Replacement part numbers listed in this section are based on the latest information available at the time of printing,
and are subject
to change. If a part listed in this manual is not the same as the part used in your vehicle when it was
built, or if you have any questions, please contact your GM truck dealer.
These specifications are for information only.
If you have any questions, see the service manual for the chassis or
refer to the body manufacturer’s publications.
Engine Identification -- Gasoline Engines
Type V6 V8
Engine “VORTEC” 4300 ”VORTEC” 5000
VIN Code W M
Fuel System SFI 1 SFI 1
‘Sequential Central Port Fuel Injection
Wheel Nut Torque
MODEL TORQUE
All 122 ft-lb (165 Nem)
“VORTEC” 5700 “VORTEC” 7400
V8
V8
R J
SF1 I SFI’
? -Sequential Multi-Port Fuel Injection
ProCarManuals.com

Maintenance Schedule
Short TripKity Definition -- Gasoline Engines i
Follow the Short Trip/City Maintenance Schedule if any
one of these conditions is true for your vehicle:
0
0
0
0
0
e
Most trips are less than 5 to 10 miles (8 to 16 km).
This is particularly important when outside
temperatures are below freezing.
Most trips include extensive idling (such as frequent
driving
in stop-and-go traffic j.
Most trips are through dusty areas.
You frequently tow
a trailer or use a carrier on top of
your vehicle.
You frequently tow
a trailer or us-e a carrier on top of
your vehicle. (With some models, you should never
tow
a trailer. See “Towing a Trailer” in the Index.)
If the vehicle is used for delivery service, police, taxi
or other commercial application.
Short Trip/City Intervals -- Gasoline Engines
Every 3,000 Miles (5 000 km): Engine Oil and Filter
Change (or
3 months, whichever occurs first). Chassis
Lubrication (or
3 months, whichever occurs first).
Drive Axle Service (or
3 months, whichever
occurs first).
At 6,000 Miles (10 000 km) -- Then Every
12,000 Miles (20
000 km): Tire Rotation.
Every 15,000 Miles (25 000 km): Air Cleaner Filter
Inspection,
if driving in dusty conditions. Shields and
Underhood Insulation Inspection (GVWR above
8,500 Ibs. only). Thermostatically Controlled Engine
Cooling Fan Check (or every
12 months, whichever
occurs first). Front Wheel Bearing Repack (or at each
brake relining, whichever occurs first).
Every 30,000 Miles (50 000 km): Air Cleaner Filter
Replacement. Fuel Filter Replacement.
Every 50,000 Miles (83 000 km): Automatic
Transmission Service (vehicles over
8600 GVWR
or driven under severe conditions only).
7-4
ProCarManuals.com

Maintenance Schedule
Every 7,500 Miles (12 500 km): Engine Oil and Filter
Change (or every 12 months, whichever occurs first).
Chassis Lubrication (or every 12 months, whichever
occurs first). Drive Axle Service.
At 7,500 Miles (12 500 km) -- Then Every
15,000 Miles
(25 000 km): Tire Rotation.
Every 15,000 Miles (25 000 km): Shields and
Underhood Insulation Inspection (GVWR above
8,500 lbs. only). Thermostatically Controlled Engine
Cooling Fan Check
(or every 12 months, whichever
occurs first).
Every 30,000 Miles (50 000 km): Fuel Filter
Replacement. Air Cleaner Filter Replacement.
Front Wheel Bearing Repack (or at each brake
relining, whichever occurs first).
Every 50,000 Miles (83 000 km): Automatic
Transmission Service (vehicles over
8600 GVWR or
driven under severe conditions only).
Every 60,000 Miles (100 000 km): Engine Accessory
Drive Belt Inspection. Fuel
Tank, Cap and Lines
Inspection. Exhaust Gas Recirculation System
Inspection. Evaporative Control System Inspection.
Every 100,000 Miles (166 000 km): Cooling System
Service (or every
60 months, whichever occurs fist).
Spark Plug Wire Inspection. Spark
Plug Replacement.
Positive Crankcase Ventilation (PCV) Valve Inspection.
These intervals only sumnarize maintenance services.
Be sure to follow the complete maintenance schedule on
the.following pnges.
7-6
ProCarManuals.com

Short TripKity Maintenance Schedule -- Gasoline Engines A
15,000 Miles (25 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
0 Lubricate chassis components; see
Arz Emission Cotltr-ol Senlice.
footnote ## (or every 3 months, whichever
occurs first).
El Inspect air cleaner filter if you are driving
in dusty conditions. Replace filter if
necessary. AFI Emission Contd Stjt-vic’o.
0 Check axle tluid level and add fluid
as needed.
**
Clean and repack the front wheel bearings
(or at each brake relining, whichever
occurs first).
0 Vehicles With GVWR Above 8,500 lbs.
Only: Inspect shields and underhood
insulation for damage or looseness. Adjust
or replace
as required. This is Noise Emission
Control Ser\*icc_. Applicnble only to vehicles sold irz
the United Stl1te.s.
0 If your engine has a thermostatically
controlled cooling fan, inspect all hoses
and ducts for proper hook-up (or every
12 months, whichever occurs first). Be sure
the valve works properly. 7his is CI Noise
Emission Corltrol Service. Applicddr onl~ to
\~cl~ic.lcs sold in the United Stcrtes.
DArE SERVICED BY ACTUAL MILEAGE
7-10
ProCarManuals.com

I Short TripKity Maintenance Schedule -- Gasoline Engines 1
30,000 Miles (50 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emissiol~ Control Service.
0 Lubricate chassis components; see footnote #
(or every 3 months, whichever occurs first).
0 Check axle fluid level and add fluid
as needed. **
0 Clean and repack the front wheel bearings (or at
each brake relining, whichever occurs first).
0 Replace fuel filter.
Replace air cleaner filter.
0 Vehicles With GVWR Above 8,500 lbs. Only:
Inspect shields and underhood insulation for
damage or looseness. Adjust or replace
as
required. This is a Noise Emission Control Service.
Applicable only
to vehicles sold in the United Stutes.
An Emission Control Service. 3-
An Etnissiorz Control Service.
0 If your engine has a thermostatically
controlled cooling fan, inspect all hoses
and ducts for proper
hook-up (or every
12 months, whichever occurs first). Be sure
the valve works properly.
This is u Noise
Etnissiou Coutrol Service. Applicable
o~d~ to
whic.les
sold in the United States.
Rotation” in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers for
freedom
of movement. Refer to the
appropriate
GM service manual for proper
caliper service procedures.
0 Rotate tires. See “Tire Inspection and
7-13
ProCarManuals.com

Short Trip/City Maintenance Schedule -- Gasoline Engines
45,000 Miles (75 000 km)
Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components; see
footnote
## (or every 3 months, whichever
occurs first).
17 Check axle fluid level and add fluid
as needed. **
0 Clean and repack the fron
(or at each brake relining,
occurs first).
Cl Inspect air cleaner filter if
t wheel bearings
whichever
’ you are driving
in dusty conditions. Replace filter if
necessary. An Emission Control Service.
0 Vehicles With GVWR Above 8,500 Ibs.
Only: Inspect shields and underhood
insulation for damage or looseness. Adjust
or replace
as required. This is u Noise Emission
Cmr-d Service. Applicable only to vehicles sold irz
the United States.
0 If your engine has a thermostatically
controlled cooling fan, inspect all hoses
and ducts for proper hook-up (or every
12 months, whichever occurs first). Be sure
the valve works properly.
This is N Noise
Emi-sion Control Service. Applicable
only to
vehicles .sold in the United StLttes.
1 DATE I ACTUAL MILEAGE ISERVICED BY: I
7-16
ProCarManuals.com

I Short Trip/City Maintenance Schedule -- Gasoline Engines I
57,000 Miles (95 000 km)
Cl Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Lubricate chassis components; see
footnote
## (or every 3 months, whichever
occurs first).
as needed.
**
0 Check axle fluid level and add fluid
I
ACTUAL MILEAGE SERVICED BY.
60,000 Miles (100 000 km)
0 Change engine oil and filter (or e J
3 months, whichever occurs first).
An En.zission Control Service.
0 Lubricate chassis components; see footnote #
(or every 3 months, whichever occurs first).
0 Check axle fluid level and add fluid
as needed. **
0 Clean and repack the front wheel bearings
(or
at each brake relining, whichever
occurs first).
0 Vehicles With GVWR Above 8,500 lbs.
Only: Inspect shields and underhood
insulation for damage or looseness. Adjust
or replace as required.
This i.s a Noise E/7zis.sion
Control Service. Appliccrble
only to vehicles sold in
the United States.
(Continued)
7-19
ProCarManuals.com