engine oil GMC YUKON DENALI 2003 Owner's Guide

Part A: Scheduled Maintenance
Services
This part contains engine oil and chassis lubrication
scheduled maintenance which explains the engine oil life
system and how it indicates when
to change the
engine oil and filter. Lubricate chassis components with
each oil change.
Also, listed are scheduled maintenance
services which are to be performed at the mileage
intervals specified.
Using Your Maintenance Schedule
We at General Motors want to help you keep your
vehicle in good working condition. But we don’t know
exactly how you’ll drive it. You may drive very short
distances only a few times a week. Or you may drive
long distances all the time in very hot, dusty weather.
You may use your vehicle in making deliveries. Or
you may drive it to work,
to do errands or in many
other ways.
Because of all the different ways people use their
vehicles, maintenance needs vary. You may need more
frequent checks and replacements.
So please read
the following and note how you drive. If you have any
questions on how to keep your vehicle in good condition,
see your dealer. This part tells you
the maintenance services you should
have done and when you should schedule them.
When you go
to your dealer for your service needs,
you’ll know that GM-trained and supported service
people will perform the work using genuine GM parts.
The proper fluids and lubricants
to use are listed in
Part
D. Make sure whoever services your vehicle uses
these.
All parts should be replaced and all necessary
repairs done before you or anyone else drives the
vehicle.
This schedule is for vehicles that:
carry passengers and cargo within recommended
limits. You will find these limits on your vehicle’s
Certificationflire label. See Loading Your Vehicle
on
page 4-44.
are driven on reasonable road surfaces within legal
driving limits.
are driven off-road in the recommended manner.
See Operating Your All- Wheel-Drive Vehicle
Off
Paved Roads on page 4- 16.
use the recommended fuel. See Gasoline Octane
on page 5-5.
6-4

Scheduled Maintenance
The services shown in this schedule up to 100,000 miles
(1 66 000 km) should be repeated after 100,000 miles
(166
000 km) at the same intervals for the life of
this vehicle. The services shown at
150,000 miles
(240 000 km) should be repeated at the same interval
after 150,000 miles
(240 000 km) for the life of this
vehicle.
See Part B: Owner Checks and Services
on page 6- 10
and Part C: Periodic Maintenance Inspections on
page 6- 14.
Footnotes
t The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission warranty or limit recall liability prior to
the completion of the vehicle
s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the
maintenance be recorded.
+ A good time to check your brakes is during tire
rotation. See Brake System Inspection
on page 6-14.
Engine Oil and Chassis Lubrication
Scheduled Maintenance
Change engine oil and filter as indicated by the GM
Oil Life System (or every 12 months, whichever
occurs first). Reset the system.
Your vehicle has a computer system that lets you know
when
to change the engine oil and filter. This is
based on engine revolutions and engine temperature,
and not on mileage. Based on driving conditions,
the mileage at which an oil change will be indicated can
vary considerably. For the oil life system
to work
properly, you must reset the system every time the oil is
changed.
When the system has calculated that oil life has been
diminished, it will indicate that an oil change is
necessary. A CHANGE ENGINE
OIL message will
come on. Change your oil as soon as possible within
the next two times you stop for fuel.
It is possible that, if
you are driving under the best conditions, the oil life
system may not indicate that an oil change is necessary
for over a year. However, your engine oil and filter
must be changed at least once a year and at this time
the system must be reset.
It is also important to
check your oil regularly and keep it at the proper level.
6-5

If the system is ever reset accidentally, you must
change your oil at
3,000 miles (5 000 km) since your
last oil change. Remember
to reset the oil life system
whenever the oil is changed. See Engine Oil on
page
5-13 for information on resetting the system.
An Emission Control Service.
Lubricate chassis components with each engine oil
and filter change.
Lubricate the front suspension, ball joints, steering
linkage, transmission shift linkage and parking brake
cable guides. Ball joints should not be lubricated unless
their temperature is 10°F (-12°C) or higher, or they
could be damaged.
After the services are performed, record the date,
odometer reading and who performed the service on the
maintenance record pages in Part
E of this schedule.
7,500 Miles (12 500 km)
U Check rear/front axle fluid level and add fluid as
needed. Check constant velocity joints and axle seals
for leaking.
page
5-56 for proper rotation pattern and additional
information. (See footnote
+.)
0 Rotate tires. See Tire Inspection and Rotation on
15,000 Miles (25 000 km)
17 Check readfront axle fluid level and add fluid as
needed. Check constant velocity joints and axle seals
for leaking.
page
5-56 for proper rotation pattern and additional
information. (See footnote
+.)
0 Rotate tires. See Tire lnspection and Rotation on
22,500 Miles (37 500 km)
0 Check readfront axle fluid level and add fluid as
needed. Check constant velocity joints and axle seals
for leaking.
page
5-56 for proper rotation pattern and additional
information. (See footnote
+.)
CI Rotate tires. See Tire Inspection and Rotation on
30,000 Miles (50 000 km)
3 Check readfront axle fluid level and add fluid as
needed. Check constant velocity joints and axle seals
for leaking.
page
5-56 for proper rotation pattern and additional
information. (See footnote
+.)
(See footnote t.)
U Rotate tires. See Tire Inspection and Rotation on
U Replace fuel filter. An Emission Control Service.
6-6

Part B: Owner Checks and Services
Listed in this part are owner checks and services
which should be performed at the intervals specified
to
help ensure the safety, dependability and emission
control performance of your vehicle.
Be sure any necessary repairs are completed at once.
Whenever any fluids or lubricants are added
to your
vehicle, make sure they are the proper ones, as shown
in Part
D.
At Each Fuel Fill
It is important for you or a service station attendant to
perform these underhood checks at each fuel fill.
Engine Oil Level Check
Check the engine oil level and add the proper oil if
necessary. See Engine Oil on page 5-13 for further
details.
Engine Coolant Level Check
Check the engine coolant level and add DEX-COOL@
coolant mixture
if necessary. See Engine Coolant
on page 5-22 for further details.
Windshield Washer Fluid Level Check
Check the windshield washer fluid level in the windshield
washer tank and add the proper fluid
if necessary.
See Windshield Washer Fluid
on page 5-34 for further
details.
At Least Once a Month
Tire Inflation Check
Make sure tries are inflated to the correct pressures.
Don’t forget
to check your spare tire. See Tires on
page 5-55 for further details.
Cassette Tape Player Service
Clean cassette tape player. Cleaning should be done
every
50 hours of tape play. See Audio System(s)
on page 3-58 for further details.
At Least Twice a Year
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages
are working properly. Look for any other loose or
damaged safety belt system parts. If you see anything
that might keep a safety belt system from doing its
job, have it repaired. Have any torn or frayed safety belts
replaced.
6-1 0

Also look for any opened or broken air bag coverings,
and have them repaired or replaced. (The air bag
system does not need regular maintenance.)
Inspect wiper blades for wear or cracking. Replace
blade inserts that appear worn or damaged or that
streak or miss areas of the windshield.
Also see
Cleaning the Outside
of Your Vehicle on page 5-81.
Spare Tire Check
At least twice a year, after the monthly inflation check of
the spare tire determines that the spare is inflated
to
the correct tire inflation pressure, make sure that
the spare tire is stored securely. Push, pull, and then
try
to rotate or turn the tire. If it moves, use the wheel
wrenchhatchet
to tighten the cable. See Changing a Flat
Tire
on page 5-63.
Engine Air Cleaner Filter Restriction
Indicator Check
Your vehicle has an engine air cleaner filter restriction
indicator located on the air cleaner in the engine
compartment. The indicator lets you know when the air
cleaner filter is dirty and needs
to be changed. Check
the indicator at least twice a year or when your engine oil is changed,
whichever occurs first. See Engine Air
Cleaner/Filter
on page 5- 17 for more information. Inspect
your air cleaner filter restriction indicator more often
if
the vehicle is used in dusty areas or under off road
conditions.
Weatherstrip Lubrication
Silicone grease on weatherstrips will make them last
longer, seal better, and not stick or squeak. Apply
silicone grease with a clean cloth. During very cold,
damp weather more frequent application may be required. See
Part D: Recommended Fluids and
Lubricants
on page 6- 15.
Automatic Transmission Check
Check the transmission fluid level; add if needed. See
Automatic Transmission Fluid on page
5-20. A fluid loss
may indicate a problem. Check the system and repair
if needed.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
specified in Part D.

Part C: Periodic Maintenance
Inspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall).
You should let your dealer’s
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures
to perform these services may be
found in a service manual. See Service Publications
Ordering Information on page
7- IO.
Steering and Suspension Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system. Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections or other conditions which
could cause a heat build-up in the floor pan or could let
exhaust fumes into the vehicle. See Engine Exhaust
on page 2-29.
Fuel System Inspection
Engine Cooling System Inspection
Inspect the complete fuel system for damage or leaks.
Inspect the hoses and have them replaced
if they
are cracked, swollen or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed. Clean the
outside of the radiator and air conditioning condenser.
To help ensure proper operation, a pressure test of
the cooling system and pressure cap is recommended
at least once a year.
Transfer Case and Front Axle
(All-Wheel Drive) Inspection
Every 12 months, or at engine oil change intervals,
check front axle and transfer case and add lubricant
when necessary.
A fluid loss could indicate a problem.
Check and have it repaired,
if needed. Check vent
hose at transfer case for kinks and proper installation.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors
for surface condition. Inspect other brake parts,
including calipers, parking brake, etc. You may need
to
have your brakes inspected more often if your driving
habits or conditions result in frequent braking.
6-1 4

Part D: Recommended Fluids and
Lubricants
Flyids and lubricants identified below by mme,
part number or specification may be obtained from
your dealer.
Usage
Engine Oil
Engine Coolant
Hydraulic Brake
System
Windshield
Washer Solvent
Fluid/Lubricant
Engine oil with the American
Petroleum Institute Certified for
Gasoline Engines starburst symbol
of the proper viscosity. To determine
the preferred viscosity for your
vehicle's engine, see Engine
Oil on
page
5- 13.
50/50 mixture of clean, drinkable
water and use only
DEX-COOL@Coolant. See Engine
Coolant on page
5-22.
Delco Supreme 1 l@ Brake Fluid or
equivalent
DOT-3 brake fluid.
GM Optikleen@Washer Solvent or
equivalent.
Usage
Power Steering System
Automatic
Transmission
Key Lock
Cylinders
Chassis
Lubrication
Front and
Rear Axle
Transfer Case
Fluid/Lubricant
GM Power Steering Fluid (GM Part No.
U.S. 1052884, in Canada
993294, or equivalent).
DEXRON@-Ill Automatic
Transmission Fluid.
Mulit-Purpose Lubricant, Superlube
(GM Part No.
U.S. 12346241 , in
Canada 10953474, or equivalent).
Chassis Lubricant (GM Part No.
U.S. 12377985, in Canada
88901242, or equivalent) or lubricant
meeting requirements of NLGl
#2,
Category LB or GC-LB.
SAE 75W-90 Synthetic Axle Lubricant (GM Part
No. U.S.
12378261, in Canada 10953455) or
equivalent meeting GM Specification
99861
15.
DEXRON@-Ill Automatic
Transmission Fluid.
6-1 5

Care of Your (cont.)
CD Changer
............................................... 3-88
CDs and DVDs
........................................... 3-88
Cargo Cover
.................................................. 2-45
Cassette Tape Messages
................................. 3-69
Cassette Tape Player Service
........................... 6-10
CD Adapter Kits
............................................. 3-69
CD Changer
................................................... 3-83
CD Functions
................................................. 3-84
Center Console Storage Area
........................... 2-42
Center High-Mounted Stoplamp (CHMSL)
........... 5-52
Center Instrument Panel Fuse Block
.................. 5-90
Center Passenger Position, Safety Belts
............. 1-39
Chains, Tires
.................................................. 5-62
Charging System Light
................................. 3-33
Check
Check Engine Light
........... ........... 3-38
CHECK OIL LEVEL
.............. ............... 3-53
Checking Brake Fluid
...................................... 5-37
CHANGE ENGINE
OIL .................................... 3-52
Engine Light
......... ................... 3-38
CHECK WASHER FLUID
............................. 3-55
Checking Coolant
................................. .... 5-24
Checking Engine Oil
..................................... 5-1 3
Checking Things Under the Hood
...................... 5-10
Checking Your Restraint Systems
................... 1-86
Chemical Paint Spotting
........ ................... 5-84
Child Restraints Child Restraint Systems
............................... 1-54
Infants and Young Children
........................... 1-50 Child Restraints (cont.)
Lower Anchorages and Top Tethers for
Older Children
............................................. 1-48
Securing
a Child Restrairit Designed for the
Securing a Child Restraint in a Center Rear
Securing
a Child Restraint in a Rear Outside
Securing a Child Restraint in the Right Front
Children
(LATCH System)
.......................... 1-61
LATCH System
........................................ 1-63
Seat Position
........................................... 1-65
Seat Position
........................................... 1-63
Seat Position
........................................... 1-68
Top Strap
................................................... 1-57
Cigarette Lighter
......................................... 3-18
Top
Strap Anchor Location
............................ 1-59
Where to Put the Restraint
........................... 1-56
Cleaning Inside of Your Vehicle
.............. ......... 5-78
Outside
of Your Vehicle ........ ............. 5-81
Underbody Maintenance ............................ 5-84
Video Screen
........................................... 3-89
Weatherstrips
.................................. ..... 5-80
Cleaning Exterior Lamps/Lenses
....................... 5-81
Cleaning the Mirror
......................................... 2-33
Climate Control System, Automatic
............................................... 3-19
Climate Control System Climate Controls Personalization
.................... 3-27
Outlet Adjustment
........................................ 3-25
Rear
.......................................................... 3-25

Driving (cont.)
Freeway
....................... ............ 4-33
Hill and Mountain Roads
..., ................... 4-35
In Rain and on Wet Roads
....................... 4-29
winter ........................................................ 4-37
Driving On Grades .......................................... 4-54
Driving on Snow or Ice
.................................... 4-38
Driving Through Deep Standing Water
............... 4-31
Driving Through Flowing Water
......................... 4-31
DVD Driving with a Trailer
....................................... 4-53
Care
of Your ............................................... 3-88
Care
of Your DVD Player ............................. 3-89
Cleaning the Video Screen
........................... 3-89
Distortion .................................................... 3-86
Rear Seat Entertainment System
................... 3-72
DVD Player
.................................................... 3-72 Engine
Air Cleaner/Filter
......................................... 5-17
Battery
....................................................... 5-39
Check and Service Engine Soon Light
............ 3-38
Coolant ...................................................... 5-22
Coolant Heater
............................................ 2-21
Coolant Temperature Gage
........................... 3-36
Cooling System Inspection
............................ 6-14
Engine Compartment Overview
...................... 5-12
Exhaust
..................................................... 2-29
Fan Noise
.................................................. 5-33
Oil
............................................................. 5-13
Overheating
................................................ 5-25
Starting
...................................................... 2-19
Engine Air Cleaner Filter Restriction
Indicator Check
........................................... 6-11
ENGINE COOLANT HOT
................................. 3-53
Engine Coolant Level Check
............................. 6-10
Engine Oil Additives ........................................ 5-16
Engine Oil Level Check
................................... 6-10
Entering or Exiting the Third Row Seats
.............. 1-7
Engine
Oil and Chassis Lubrication Scheduled
Maintenance
................................................. 6-5
ENGINE OVERHEATED
.................................. 3-53
Entertainment System Cleaning the Video Screen
........................... 3-89
DVD Distortion
............................................ 3-86
Entry Lighting
................................................. 3-16
Erasing HomeLink@ Buttons
.............................. 2-41
E
Easy Exit Seat ............................................... 2-48
Electrical System
............................................ 5-87
Add-on Equipment
...................................... 5-87
Fuses and Circuit Breakers
........................... 5-87
Power Windows and Other Power Options
...... 5-87
Windshield Wiper Fuses
............................... 5-87
Electrochromic Mirror Operation
................ 2-32
Emissions Inspection and Maintenance
Programs
....................................... .... 3-40
5

Exit Lighting ........................................ 3-16
Extender, Safety Belt
....................................... 1-47
Exterior Lamps
......................... ~ ~ ................ 3-1 3
FabricKarpet
...
Engine Air Cleaner ..............................
Finding a P TY Station (RDS and XMTM) .....
Filter
Finding a Station
....................................
F
....
Finish Care
Finish Damage
................................
Fixed Mast Antenna .........................
Flash-to-Pass ...................................
Flat Tire .........................................
Flat Tire, Changing ..........................
Fluid
Automatic Transmission
.................
Power Steering ............................
Windshield Washer .......................
-
.....................................
..
.....
...
.... 5-78
.... 5-17
.... 3-63
.... 3-61
.... 5-81
.... 5-83
.... 3-89
...... 3-8
.... 5-63
............. 5-63
.......... 5-20
.......... 5-34
.......... 5-34
FM Stereo
..................................................... 3-87
Fog Lamps
.................................................... 3-1 5
Folding the Seatback ....................................... 1-17
Folding the Seatbacks
............................. 1-12, 1-22
Folding the Seatbacks (60/40 Split Bench Seat) .... 1-9
Following Distance
.......................................... 4-53
Footnotes
........................................ ......... 6-5
Front Axle
.................................... ... 5-47 Frontal
Air Bags
...................................... 1-77
Fuel
............................................................... 5-5
Additives ...................................................... 5-6
California Fuel
.............................................. 5-6
Filling Your Tank
........................................... 5-7
Fuels in Foreign Countries
.......................... 5-6
Gasoline Octane
....................................... 5-5
Gasoline Specifications .................................. 5-5
System Inspection ....................................... 6-14
Filling
a Portable Fuel Container
..................... 5-9
Gage
............................. .................... 3-42
Low Warning Light
....................................... 3-42
Fuel Information Button
.................................... 3-45
FUEL LEVEL LOW
......................................... 3-55
Fuses
Fuses and Circuit Breakers
........................... 5-87
Windshield Wiper
......................................... 5-87
G
Gage
Engine Coolant Temperature
............. .... 3-36
Fuel
...................................................... 3-42
Oil Pressure
........................................... 3-40
Speedometer
.......................................... 3-30
Tachometer
............................................. 3-30
Transmission Temperature
......................... 3-37
Voltmeter Gage ....................................... 3-34
Garage Door Opener
....................................... 2-38
6