wheel Hyundai Coupe 2003 Repair Manual

CONSUMER INFORMATION
8-2
To minimize tyre and chain wear, do not continue to use tyre chains when they are no longerneeded. WARNING:
o When driving on roads covered with snow
or ice, drive at less than 30 km/h (20 mph).
o Use a tyre chains less than 10mm to 16", 17" tyre.
o Avoid sudden stop and turn.
o Tighten firmly not to hear contact sound, if it still sounds, remove the chains for dam-age protection. I060A01GK-EAT TYRE ROTATION The tyre wear characteristics will vary between each tyre dependant upon the conditions of use.It is normal for the front tyres to wear more rapidlythan those fitted to the rear of the vehicle andtherefore tyre rotation will provide a means ofhelping to ensure an even wear rate across thetyre set. For vehicles fitted with radial ply tyres,rotation should be confined to front to rear tyrealternation. It is not recommended that radial plytyres be rotated from side to side. NOTE: Aluminium wheels which are not supplied asOriginal Equipment should not be mixed onthe same vehicle with the original steel wheels.
WARNING:When rotating the 215/45 R17 tyres, ensure tofollow the"ROTATION" direction marked onthe sidewall of tyres.When rotating the tyres of the left and right,separate the wheel from the tyre and then re-assemble them. However, it is acceptablethat the steel spare wheel be used in conjunc-tion with Original Equipment aluminiumwheels since the offset of both wheels iscompatible. Radial and cross ply tyres shouldnot be mixed on the same vehicle.
I050A01GK-EAT TYRE CHAINSTyre chains should be installed on the front wheels. Be sure that the chains are installed inaccordance with the manufacturer's instructions.Refer to the following information.
Tyre size
205/55 R 16 215/45 R 17
Snow Chain Thickness Max. 10 mm Max. 10 mm
I060A01GK
16" Tyre
17" Tyre
I060A02GK
Sidewall
Tyre rotation direction

CONSUMER INFORMATION 8-3
SI060A1-E TYRE BALANCINGIncorrect tyre balance will cause steering vibra- tion and uneven tyre wear. The vehicle tyres arebalanced during production but may need furtherbalancing throughout the life of the tyres.It is recommended that the tyres be balanced onthe car for best results and that the tyres arebalanced whenever they have been removedfrom the wheel for repair.
Wear indicator
0.06 in. (1.6 mm )
HGK248
SI060B1-E TYRE REPLACEMENT Tyres must be replaced when the wear indica- tors appear as a solid bar across the tyre tread.At this point, the remaining tread depth will beapproximately 1.6 mm. In addition to this, the tyremust be replaced if any portion of the tread hasbecome bald or if there are any lumps, bulges ordeep cuts in the sidewalls or tread. SI060D1-E WHEEL REPLACEMENT The original wheels may only be replaced with Hyundai Approved Wheels. WARNING: Driving on worn or defective tyres is danger-ous. Worn tyres may cause loss of steeringcontrol and a serious deterioration of brakingefficiency. Defective tyres may cause vibra-tion and loss of control through blow outs. Tyres of different size, construction or tread pattern should not be intermixed on the sameaxle. Radial and cross ply tyres should not beused on the same vehicle.The use of tyres and wheels of non approvedsizes can be dangerous.
Replacement tyres must be of the recommendedsize and rating and should be of the same manu-facture and tread pattern on each axle.

VEHICLE SPECIFICATIONS 9-1
1.6 & 2.0 L 205 / 55 R16
SJ000A1-F
9. VEHICLE SPECIFICATIONS
Litre55
in. (mm)
173(4395)
69.3(1760) 52.4(1330)99.6(2530)58.7(1490)58.7(1490)
Rack and pinion 0 ~ 1.18 in. (0 ~ 30 mm)5.20 in. (132 mm)Vane type
9
J010A01GK-AAT MEASUREMENT J020A01GK-AAT POWER STEERING SJ030A1-E FUEL SYSTEM J030A01GK-DATTYRE J040A02GK-GAT ELECTRICAL
Item BatteryAlternator
Overall lengthOverall widthOverall height (unladen)Wheel baseWheel tread
FrontRear
TypeWheel free playRack strokeOil pump type
Fuel tankcapacity US.gal
14.5 Imp.gal
12 2.7 V6
215 / 45 R17
1.6L
MF 60AH 90A2.0L
MF 68AH 90A2.7L
MF 68AH 95A
J035A01GK-DAT SPARE TYRE
T125/70R 16 (Temporary)
Standard
Dual hydraulic with brake booster Ventilated discSolid DiskCable
J050A01GK-GAT BRAKE
Type Front brake typeRear brake typeParking brake

INDEX
10-4 SEAT CUSHION HEIGHT ADJUSTMENT
........................................ 1-8
SEAT WARM ER ................................................................................. 1-9
SERVICE HI STORY ........................................................................... 5-1
SMOOTH CORNERING ................................................................... 2-11
SNOW TYRES ................................................................................... 8-1
SPARE TYRE ..................................................................................... 3-3
SPARKING PLUG REPLACEMENT .................................................. 6-8
SPECTACLE CASE ......................................................................... 1-41
SPEEDOMETER .............................................................................. 1-30
STARTING THE ENGINE ............... ................................................... 2-3
STEERING WHEEL FREEPLAY ..................................................... 6-15
STEERING WHEEL TILT LEVER .................................................... 1-48
STEREO SOUND SYSTEM ............................................................. 1-63
SUN VISOR ...................................................................................... 1-47
SUNROOF ........................................................................................ 1-39
SUPPLEMENTAL RESTRAINT (AIRBAG) SYSTEM ......................1-19
T TACHOMETER ................................................................................. 1-30
THEFT-ALARM SYSTEM ................................................................... 1-4
TOWING ATTACHMENTS ........... ....................................................2-12
TRACTION CONTROL SYSTEM ................... .................................... 2-9
TRAILER AND CARAVAN TOWING ............................................... 2-12
TRIP COMPUTER ............................................................................ 1-31
TRIP ODOMETER ............................................................................ 1-31TYRE PRESSURES
........................................................................... 8-1
TYRE BALANCING ............................................................................ 8-3
TYRE CHAINS ................................................................................... 8-2
TYRE REPLACEMEN T ...................................................................... 8-3
TYRE ROTATION .............................................................................. 8-2
V
VARIABLE INTERMITTENT WIPE FACILITY .................................1-35
VEHICLE IDENTIFICATION NUMBER .............................................. 8-1
VEHICLE TOWING OR RECOVERY ................................................ 3-7
WWHEEL REPLACEMENT ................................................................... 8-3
WINDSCREEN WASHER RESERVOIR REPLENISHMENT ..........6-10
WINDSCREEN WIPER BLADES ..................................................... 6-10
WINDSCREEN WASHER OPERATION ..........................................1-35
WINDSCREEN WIPER/WASHER SWITCH ....................................1-35
WINTER MOTORING ....................................................................... 2-11