Transmission Hyundai Kona 2018 Repair Manual
[x] Cancel search | Manufacturer: HYUNDAI, Model Year: 2018, Model line: Kona, Model: Hyundai Kona 2018Pages: 523, PDF Size: 33.6 MB
Page 428 of 523

Maintenance
7-16
Normal Maintenance Schedule (Gasoline Engine, except Europe) (Cont.)
Months1224364860728496
Miles x 1,0001020304050607080
Km x 1,000153045607590105120
Climate control air filter RRRRRRRR
Manual transmission fluid *7II
Dual clutch transmission fluid * 7II
Valve clearance (1.6 T-GDI) *8I
Exhaust systemIIII
Trasnfer case oil (4WD) *8II
Rear differential oil (4WD) * 8II
Propeller shaft (4WD)IIIIIIII
I : Inspect and if necessary, adjust, correct, clean or replace.
R : Replace or change.*7
: Manual transaxle/dual clutch transmission fluid, transfer case oil and differential oil should be changed anytime they have be en
submerged in water.
* 8
: Inspect for excessive valve noise and/or engine vibration and adjust if necessary.We recommend that the system be checked
by an authorized HYUNDAI dealer.
MAINTENANCE INTERVALS
MAINTENANCEITEM
Page 430 of 523

Maintenance
7-18
Maintenance itemMaintenance operationMaintenance intervalsDriving
condition
Climate control air filterRReplace more frequently
depending on the conditionC, E, G
Manual transmission fluidREvery 120,000 km (80,000 miles)C, D, E, F, G, H, I, J
Dual clutch transmission fluidREvery 120,000 km (80,000 miles)C, D, E, F, G, H, I, J
Rear differential oil (4WD)REvery 120,000 km (80,000 miles)C, D, E, G, I, K, H
Transfer case oil (4WD)REvery 120,000 km (80,000 miles)C, D, E, G, I, K, H
Propeller shaft (4WD)IEvery 20,000 km (12,500 miles) or 12 monthsC, E
Severe driving conditions
A : Repeatedly driving short distance of less than 8 km (5 miles)in normal temperature or less than 16 km (10 miles) in freez-
ing temperature
B : Extensive engine idling or low speed driving for long distances
C : Driving on rough, dusty, muddy, unpaved, graveled or salt spread roads
D : Driving in areas using salt or other corrosive materials or in very cold weather E : Driving in the heavy dust condition
F : Driving in heavy traffic area
G : Driving on uphill, downhill, or mountain roads repeatedly
H : Towing a trailer, or using a camper or roof rack
I : Driving as patrol car, taxi, commercial car or vehicle towing
J : Driving over 170 km/h (106 mile/h)
K : Frequently driving in stop-and-go conditions
Page 432 of 523

7-20
Maintenance
Air cleaner filter
We recommend that the air cleaner
filter be replaced by an authorized
HYUNDAI dealer.
Spark plugs
(for Gasoline Engine)
Make sure to install new spark plugs
of the correct heat range.
Valve clearance
(for Gasoline Engine)
Inspect excessive valve noise and/or
engine vibration and adjust if neces-
sary. We recommend that the system
be serviced by an authorized HYUNDAI
dealer.
Cooling system
Check the cooling system parts,
such as radiator, coolant reservoir,
hoses and connections for leakage
and damage. Replace any damaged
parts.
Engine coolant
The coolant should be changed at
the intervals specified in the mainte-
nance schedule.
Manual transmission fluid (if equipped)
Inspect the manual transmission fluid according to the maintenance
schedule.
Dual clutch transmission fluid (if equipped)
Inspect the dual clutch transmission fluid according to the maintenance
schedule.
Brake hoses and lines
Visually check for proper installation,
chafing, cracks, deterioration and
any leakage. Replace any deteriorat-
ed or damaged parts immediately.
Brake/Clutch fluid (if equipped)
Check the brake/clutch fluid level in
the brake fluid reservoir. The level
should be between “MIN” and “MAX”
marks on the side of the reservoir.
Use only hydraulic brake fluid con-
forming to DOT 3 or DOT 4 specifi-cation.
Parking brake
Inspect the parking brake system
including the parking brake lever and
cables.
Do not disconnect and inspectspark plugs when the engine is
hot. You may burn yourself.
WARNING
Page 505 of 523

8-6
Specifications & Consumer information
ItemGasoline Engine
1.0 T-GDI 1.6 T-GDI
2WD 4WDM/T DCT
Gross vehicle weight kg (lbs.)1775 (3913) 1910 (4210)
Luggage volume (VDA) l(cu ft.) MIN : 361 (12.74)
MAX : 1143 (40.36)
VV EEHH IICC LLEE WW EEIIGG HH TT AA NN DD LL UU GGGGAAGG EE VV OO LLUU MM EE
M/T : Manual transmission
DCT : Dual clutch transmission
Min : Behind rear seat to upper edge of the seat back.
Max : Behind front seat to roof.
Page 506 of 523

8
Specifications & Consumer information
RREECCOO MM MMEENN DDEEDD LL UU BBRRIICC AA NN TTSS AA NN DD CC AA PPAA CCIITT IIEE SS
To help achieve proper engine and powertrain performance and durability, use only lubricants of the proper quality.
The correct lubricants also help promote engine efficiency that results in improved fuel economy.
These lubricants and fluids are recommended for use in your vehicle.
Lubricant Volume Classification
Engine oil * 1
*2
(drain and refill) Recommends Gasoline1.0 T-GDI
3.6
l(3.8 US qt.)
API SN & ACEA C2
1.6 T-GDI 4.5
l(4.75 US qt.)
ACEA A5/B5
Manual transmission fluid 1.0 T-GDI 1.6 ~ 1.7
l
(1.7 ~ 1.8 US qt.) HK SYN MTF 70W (SK) SPIRAX S6 GHME 70W MTF (H.K.SHELL)
GS MTF HD 70W (GS CALTEX)
API GL-4, SAE 70W, TGO-9
Dual clutch transmission fluid 1.6 T-GDI 1.9 ~ 2.0
l
(2.0 ~ 2.1 US qt.) HK SYN DCTF 70W (SK)SPIRAX S6 GHME 70W DCTF (H.K.SHELL)
GS DCTF HD 70W (GS CALTEX)API GL-4, SAE 70W
Coolant 1.0 T-GDI
6.8
l(7.1 US qt.) Mixture of antifreeze and distilled water
(Ethylene-glycol with phosphate based coolant
for aluminum radiator)
1.6 T-GDI
7.1
l(7.5 US qt.)
Rear differential oil (4WD) 0.47~0.52
l
(0.49~0.55 US qt.) HYPOID GEAR OIL API GL-5, SAE75W/90
(SHELL HD AXLE OIL 75W90 or equivalent)
*
1
: Refer to the recommended SAE viscosity numbers on page 9.
* 2
: Engine oils labeled Energy Conserving Oil are now available. Along with other additional benefits, they contribute to fuel economy by reducing
the amount of fuel necessary to overcome engine friction. Often, these improvements are difficult to measure in everyday driving, but in a year’s
time, they can offer significant cost and energy savings. 8-7
Page 515 of 523

I-4Compact spare tire replacement ...................................7-41
Coolant..........................................................................7-23
Cooling fluid, see engine coolant .................................7-23
Crankcase emission control system..............................7-85
Cruise control system ...................................................5-90
Cup holder ..................................................................3-131
Curtain air bags.............................................................2-52
Dashboard illumination, see instrument panel illumination.................................................................3-38
Dashboard, see instrument cluster ................................3-37
Day/night rearview mirror ............................................3-19
Daytime running light (DRL) .......................................3-91
Declaration of conformity ............................................8-12
Defogging (Windshield) .............................................3-124
Defroster .....................................................................3-107 Rear window defroster ...........................................3-107
Defrosting (Windshield) .............................................3-124
Dimensions .....................................................................8-2
Display illumination, see instrument panel
illumination.................................................................3-38
Displays, see instrument cluster ...................................3-37
Distance to empty ........................................................3-41
Door locks.....................................................................3-11
Central door lock switch ..........................................3-13
Child-protector rear door lock .................................3-15
Auto door lock/unlock features................................3-15 Downhill Brake Control (DBC) ...................................5-38
Drinks holders, see cup holders..................................3-131
Drive mode integrated control system .........................5-53
Driver assist system ......................................................3-96
Rear view monitor....................................................3-99
Parking Distance Warning (Reverse) system.........3-100
Parking Distance Warning (Reverse/Forward) system ..................................................................3-104
Driver Attention Warning (DAW) system ....................5-84
Driver's air bag .............................................................2-48
Driving at night.............................................................5-97
Driving in flooded areas ...............................................5-98
Driving in the rain ........................................................5-97
Dual Clutch transmission (DCT)..................................5-19 DCT warning messages ...........................................5-21
Paddle shifter............................................................5-24
Good driving practices .............................................5-26
Electric chromic mirror (ECM) ....................................3-20
Electric power steering (EPS) ......................................3-17
Electronic stability control (ESC) ................................5-33
Emergency Stop Signal (ESS) ......................................5-37
Emergency towing ........................................................6-43
Emission control system ...............................................7-85 Crankcase emission control system .........................7-85
Evaporative emission control System ......................7-85
Exhaust emission control system .............................7-86
Index
D
E
Page 517 of 523

I-6Hazard warning flasher...................................................6-3
Hazardous driving conditions .......................................5-96
Head up display (HUD)................................................3-80
Headlamp delay function..............................................3-90
Headlamp leveling device ............................................3-91
Headlamp position ........................................................3-84
Headlight bulb replacement..........................................7-64
Headrest ........................................................................2-15
Front seat headrests ..................................................2-16
Rear seat headrests ...................................................2-18
Heated steering wheel...................................................3-18
Height adjustment .........................................................2-26
High beam assist (HBA)...............................................3-85
High beam operation ....................................................3-84
Highway driving ...........................................................5-98
Hill-start assist control (HAC) .....................................5-37
Hood .............................................................................3-31
Horn ..............................................................................3-19
How to use this manual ..................................................F-5
If the engine doesn't turn over or turns over slowly ......6-4
If the engine overheats ...................................................6-8
If the engine stalls at a crossroad or crossing ................6-3
If the engine stalls while driving ....................................6-3
If the engine turns over normally but doesn't start.........6-5 If the engine will not start ..............................................6-4
If you have a flat tire (with spare tire) .........................6-20
Jack and tools ...........................................................6-20
Changing tires ..........................................................6-21
Jack label ..................................................................6-26
If you have a flat tire (with TMK) - Type A ................6-28
If you have a flat tire (with TMK) - Type B ................6-35
Ignition switch ................................................................5-6
Key ignition switch ....................................................5-6
Engine Start/Stop button ............................................5-9
Immobilizer system ......................................................3-10
Impact sensing door unlock..........................................3-15
Improtant safety precautions ..........................................2-2 Always wear your seat belt ........................................2-2
Restrain all children ...................................................2-2
Air bag hazards ..........................................................2-2
Driver distraction .......................................................2-2
Control your speed .....................................................2-3
Keep your vehicle in safe condition ..........................2-3
In case of emergency while driving ...............................6-3
Indicator light ...............................................................3-44
Inside rearview mirror ..................................................3-19
Instrument cluster .........................................................3-37 Instrument panel illumination ..................................3-38
Gauges and meters ...................................................3-38
Warning and indicator lights ....................................3-44
LCD display messages .............................................3-57
LCD display control.................................................3-64
Manual transmission shift indicator.........................3-42
Index
H
I
Page 519 of 523

I-8Light bulbs ....................................................................7-64
Lighting.........................................................................3-83
Auto light position ...................................................3-83
Position lamp position..............................................3-84
Headlamp position ...................................................3-84
High beam operation ................................................3-84
High beam assist (HBA) ..........................................3-85
Turn signals ..............................................................3-88
Lane change signals .................................................3-88
Rear fog lamp...........................................................3-89
Battery saver function ..............................................3-90
Headlamp delay function .........................................3-90
Daytime running light (DRL) ..................................3-91
Headlamp leveling device ........................................3-91
Low Beam Assist-Static light...................................3-92
Low Beam Assist-Static light .......................................3-92
Lubricants and capacities ...............................................8-7
Luggage compartment lamp .........................................3-94
Luggage net (holder) ..................................................3-136
Luggage tray ...............................................................3-130
Main fuse ......................................................................7-49
Maintenance services......................................................7-4 Maintenance services .................................................7-4
Owner maintenance....................................................7-5
Scheduled maintenance services ................................7-7
Normal maintenance schedule ............................7-8, 13 Maintenance under severe usage conditions......7-11, 17
Explanation of scheduled maintenance items ..........7-19
Tire maintenance ......................................................7-41
Maintenance under severe usage conditions (for Europe) ................................................................7-11
Maintenance under severe usage conditions (except Europe) ..........................................................7-17
Manual climate control system...................................3-108
Manual transmission .....................................................5-16 Using the clutch .......................................................5-16
Downshifting ............................................................5-17
Good driving practices .............................................5-18
Manual transmission shift indicator .............................3-42
Mirrors ..........................................................................3-19 Day/night rearview mirror .......................................3-19
Electric chromic mirror (ECM) ...............................3-20
Inside rearview mirror..............................................3-19
Outside rearview mirror ...........................................3-20
Adjusting the outside rearview mirrors ...................3-21
Folding/Unfolding the outside rearview mirror.......3-22
Moonroof, see sunroof..................................................3-27
Multi box ....................................................................3-129
Multi fuse......................................................................7-49
Multimedia system .........................................................4-2 Aux, USB and iPod....................................................4-2
Antenna ......................................................................4-2
Steering wheel audio control .....................................4-3
Audio / Video / Navigation system............................4-4
Bluetooth ®
Wireless Technology hands-free .............4-4
Index
M