steering INFINITI FX35 2005 Service Manual
[x] Cancel search | Manufacturer: INFINITI, Model Year: 2005, Model line: FX35, Model: INFINITI FX35 2005Pages: 4731, PDF Size: 60.13 MB
Page 3266 of 4731
TOW TRUCK TOWING GI-45
C
D E
F
G H
I
J
K L
M B
GI
Revision: 2005 July 2005 FX
AWD MODELS
INFINITI recommends that a dolly be used as illustrated when towing AWD models.
CAUTION:
Never tow AWD models with any of the wheels on the ground as this may cause serious and expen-
sive damage to the powertrain.
Vehicle Recovery (Freeing a Stuck Vehicle) AAS000EI
Securely install the vehicle recovery hook stored with jacking tools.
Make sure that the hook is properly secured in the stored place after
use.
WARNING:
Stand clear of a stuck vehicle.
Do not spin your tires at high speed. This could cause them
to explode and result in serious injury. Parts of your vehicle
could also overheat and be damaged.
CAUTION:
Tow chains or cables must be attached only to the vehicle
recovery hooks or main structural members of the vehicle.
Otherwise, the vehicle body will be damaged.
Do not use the vehicle tie downs to free a vehicle stuck in
sand, snow, mud, etc. Never tow the vehicle using the vehi-
cle tie downs or recovery hooks.
Always pull the cable straight out from the front of the vehi-
cle. Never pull on the hook at an angle.
Pulling devices should be routed so they do not touch any
part of the suspension, steering, brake or cooling systems.
Pulling devices such as ropes or canvas straps are not rec-
ommended for use in vehicle towing or recovery.
PAIA0098E
PAIA0099E
Page 3267 of 4731
GI-46
TOW TRUCK TOWING
Revision: 2005 July 2005 FX
AUTOMATIC TRANSMISSION
To tow a vehicle equipped with an automatic transmission, an appropriate vehicle dolly MUST be placed
under the towed vehicle's drive wheels. Always follow the dolly manufacture's recommendations when using
their product.
If the vehicle is stuck in sand, snow, mud, etc., use the following procedure:
1. Turn off the Vehicle Dynamic Control System.
2. Make sure the area in front and behind the vehicle is clear of obstructions.
3. Turn the steering wheel right and left to clear an area around the front tires.
4. Slowly rock the vehicle forward and backward. Shift back and forth between R (reverse) and D (drive).
Apply the accelerator as little as possible to maintain the rocking motion.
Release the accelerator pedal before shifting between R and D.
Do not spin the tires above 35 mph (55 km/h).
5. If the vehicle can not be freed after a few tries, contact a professional towing service to remove the vehi- cle.
Page 3399 of 4731
IDX-6
ALPHABETICAL INDEX
M
M/ANT - Wiring diagram .................................... AV-52
MAFS - Wiring diagram ..... EC-189, EC-197, EC-896,
EC-904
Magnet clutch ................................. ATC-84, ATC-144
MAIN - Wiring diagram ...................... EC-164, EC-855
Maintenance (engine)(VQ35DE) ...................... MA-14
Major overhaul (Final drive) .............. FFD-16, RFD-16
Major overhaul (Transfer) .................................. TF-45
Mass air flow sensor (MAFS) ............ EC-186, EC-195,
EC-893
, EC-902
Meter ..................................................................... DI-5
METER - Wiring diagram .................................... DI-10
MIL data link connectors circuit ....... EC-703, EC-1393
MIL/DL - Wiring diagram .................. EC-703, EC-1393
Mirror, door ..................................................... GW-114
Mirror, out side ................................................ GW-114
Misfire .............................................. EC-285, EC-1022
Mode door control linkage adjustment ............. ATC-72
Mode door motor ............................ ATC-70, ATC-131
Molding - See Exterior ................... EI-25, EI-29, EI-32
Multiport fuel injection (MFI) system .... EC-31, EC-722
Multiport fuel injection precautions ....................... GI-7
N
NATS - Wiring diagram .................................... BL-216
NAVI - Wiring diagram ..................................... AV-106
Navigation system ............................................. AV-87
NVH troubleshooting (EM) .............................. EM-170
NVH troubleshooting (EM)(VQ35DE) ............... EM-13
NVH troubleshooting (Final drive) ......... FFD-6, RFD-7
NVH troubleshooting (Propeller shaft) ................. PR-3
NVH troubleshooting (Transfer) ........................... TF-8
NVIS (Nissan vehicle immobilizer system) precautions
GI-3
O
O2H1B1 - Wiring diagram ................................ EC-879
O2H1B2 - Wiring diagram ................................ EC-881
O2H2B1 - Wiring diagram .................. EC-180, EC-887
O2H2B2 - Wiring diagram .................. EC-182, EC-889
O2S1B1 - Wiring diagram ... EC-937, EC-947, EC-959
O2S1B2 - Wiring diagram ... EC-939, EC-949, EC-961
O2S2B1 - Wiring diagram .. EC-230, EC-240, EC-445,
EC-456
, EC-968, EC-978, EC-1190, EC-1201
O2S2B2 - Wiring diagram .. EC-232, EC-242, EC-447,
EC-458
, EC-970, EC-980, EC-1192, EC-1203
Oil cooler (engine)(VQ35DE) ............................. LU-14
Oil filter(VK45DE) .............................................. LU-28
Oil filter(VQ35DE) .............................................. LU-10
Oil pan (engine)(VK45DE) .............................. EM-185
Oil pan (engine)(VQ35DE) ................................ EM-30
Oil pressure (engine)(VK45DE) ......................... LU-25
Oil pressure (engine)(VQ35DE) ........................... LU-8
Oil pressure relief valve (engine)(VQ35DE) ........ LU-6
Oil pump (A/T) ................................................. AT-308
Oil pump (engine)(VK45DE) .............................. LU-31
Oil pump (engine)(VQ35DE) .............................. LU-17
Oil pump regulator valve (engine)(VK45DE) ...... LU-31
Oil pump regulator valve (engine)(VQ35DE) ..... LU-17
Oil seal replacement (engine)(VK45DE) ......... EM-225
Oil seal replacement (engine)(VQ35DE) .......... EM-97
Oil seal replacement (front of final drive) .......... FFD-9,
RFD-10
Oil seal replacement (side of final drive) ......... FFD-11,
RFD-12
ORVR (On-board Refueling Vapor Recovery) .. EC-46,
EC-737
Out side mirror ............................................... GW-114
Overheat ........................................................ EC-1213
P
P/SCKT - Wiring diagram ................................ WW-57
Park/Neutral position switch ........... EC-609, EC-1283
Park/neutral position switch (A/T) .................... AT-114
Parking brake control ........................................... PB-3
PCV (positive crankcase ventilation) .. EC-51, EC-742
Personal lamp ..................................... LT-153, LT-187
PGC/V - Wiring diagram .. EC-338, EC-562, EC-1071,
EC-1235
PHASE - Wiring diagram ............................... EC-1045
PHSB1 - Wiring diagram .................................. EC-309
PHSB2 - Wiring diagram .................................. EC-311
Pilot bushing replacement - See Pilot
converter(VQ35DE) ........................................ EM-123
Piston assembly(VK45DE) ............................. EM-255
Piston assembly(VQ35DE) ............................. EM-135
Piston pin inspection(VK45DE) ....................... EM-262
Piston pin inspection(VQ35DE) ...................... EM-140
Piston ring inspection(VK45DE) ..................... EM-263
Piston ring inspection(VQ35DE) ..................... EM-141
Piston to bore clearance(VK45DE) ................. EM-266
Piston to bore clearance(VQ35DE) ................ EM-144
PNP/SW - Wiring diagram .............. EC-611, EC-1285
POS - Wiring diagram ..................... EC-302, EC-1038
POWER - Wiring diagram ................................... PG-4
Power door mirror .............................................. BL-21
Power seat ......................................................... SE-92
Power socket ................................................... WW-57
Power steering fluid level ........................ PS-8, MA-37
Power steering gear ........................................... PS-19
Power steering hydraulic pressure .................... PS-31
Power steering oil pump .................................... PS-31
Power steering system bleeding .......................... PS-8
Power supply routing .......................................... PG-3
Power window .................................................. GW-15
PRE/SE - Wiring diagram EC-355, EC-361, EC-1088,
EC-1094
Precations for Leak detection dye .................. ATC-16
Precautions (General) ........................................... GI-4
Pressure switch 1 .............................. AT-156, AT-175
Pressure switch 2 ............................................ AT-168
Pressure switch 3 .............................. AT-152, AT-177
Pressure switch 5 .............................. AT-160, AT-179
Page 3400 of 4731
IDX-7
A
C
D E
F
G H
I
J
K L
B
IDX
ALPHABETICAL INDEX
Pressure switch 6 ...............................
AT-164, AT-181
Pressure test (A/T) ............................................ AT-54
Propeller shaft ........................................... PR-4, PR-7
Propeller shaft on vehicle service .............. PR-4, PR-7
Propeller shaft vibration ............................. PR-4, PR-7
PS/SEN - Wiring diagram ................ EC-398, EC-1130
R
R/VIEW - Wiring diagram ................................. DI-117
Radiator(VK45DE) ............................................. CO-41
Radiator(VQ35DE) ............................................ CO-14
Rear axle ........................................................... RAX-5
Rear bumper ........................................................ EI-17
Rear combination lamp removal and installation ..........
LT-149
Rear door ............................................ BL-153, GW-80
Rear seat ......................................................... SE-106
Rear suspension ............................................... RSU-5
Rear view monitor ............................................. DI-114
Rear washer .................................................... WW-38
Rear window defogger ...................................... GW-86
Rear wiper ....................................................... WW-38
Refrigerant connection precaution ..................... ATC-8
Refrigerant discharging evacuating charging ATC-138
Refrigerant general precaution .......................... ATC-7
Refrigerant lines ............................................ ATC-138
Refrigerant pressure sensor ........... EC-674, EC-1364,
ATC-90
, ATC-156
Refrigeration cycle ........................................... ATC-21
Removal and installation (A/T) ........... AT-270, AT-273
Removal and installation (Transfer) .................... TF-44
Revolution sensor (A/T) ...................... AT-118, AT-263
Rocker cover(VK45DE) ................................... EM-197
Rocker cover(VQ35DE) ..................................... EM-51
Room lamp - See Interior lamp ......................... LT-159
ROOM/L - Wiring diagram ................................ LT-167
RP/SEN - Wiring diagram ................ EC-675, EC-1365
S
Seal - See Exterior .............................................. EI-27
SEAT - Wiring diagram ...................................... SE-93
Seat belt inspection ............................................. SB-6
Seat belt, front ..................................................... SB-3
Seat, rear ......................................................... SE-106
Self-diagnosis (Transfer) .................................... TF-22
SEN/PW - Wiring diagram ............... EC-484, EC-1230
SHIFT - Wiring diagram ................................... AT-237
Shift change signal ........................................ EC-1290
Shift lock system .............................................. AT-236
Shift schedule .................................................. AT-351
Shock absorber (rear) ....................................... RSU-9
Side air bag (satellite) sensor .......................... SRS-43
Side curtain air bag .......................................... SRS-40
Side trim .............................................................. EI-36
SMJ (super multiple junction) ............................ PG-78
SNOW MODE SW ......................................... EC-1388
SNOWSW - Wiring diagram .......................... EC-1389
Spark plug replacement .................................... MA-27
Spark plug replacement(VQ35DE) ................... MA-20
Spark plug(VK45DE) ...................................... EM-190
Spark plug(VQ35DE) ........................................ EM-43
Specification value ............................. EC-153, EC-844
Speedometer ........................................................ DI-5
Spiral cable ..................................................... SRS-37
Spot lamp .......................................................... LT-187
SROOF - Wiring diagram ..................... BL-172, RF-14
SRS - See Supplemental Restraint System ..... SRS-5
SRS - Wiring diagram ..................................... SRS-11
SRS Trouble diagnoses .................................... SRS-7
Stabilizer bar (rear) ......................................... RSU-16
Stall test (A/T) .................................................... AT-52
Standardized relay ............................................. PG-80
START - Wiring diagram .................................... SC-11
Starter ................................................................ SC-10
Starting system .................................................. SC-10
Steering gear and linkage inspection ................ MA-36
Steering linkage ................................................. PS-19
Steering wheel and column ................... PS-10, PS-12
Steering wheel turning force .............................. PS-10
Step lamp .......................................................... LT-126
Stop lamp .......................................................... LT-118
Stop lamp switch .............................. EC-614, EC-1297
STOP/L - Wiring diagram .................................. LT-120
Sun roof, electric ................................................ RF-10
Sunload sensor ............................. ATC-110, ATC-119
Sunroof .................................................. RF-10, RF-25
Supplemental Restraint System ....................... SRS-5
Supplemental restraint system - Wiring diagram ..........
SRS-11
Suspension ....................................................... MA-37
Symbols and abbreviations ...................... GI-10, GI-23
T
Tachometer ........................................................... DI-5
TCM circuit diagram ........................................... AT-51
TCM inspection table ......................................... AT-89
Thermostat(VK45DE) ....................................... CO-53
Thermostat(VQ35DE) ....................................... CO-26
Three way catalyst function (Bank 1) EC-316, EC-1050
Three way catalyst function (Bank 2) EC-316, EC-1050
Three way catalyst precautions ............................ GI-6
Three way catalyst(VK45DE) .......................... EM-182
Three way catalyst(VQ35DE) ........................... EM-26
Throttle control motor ....................... EC-437, EC-1161
Throttle control motor relay .............. EC-432, EC-1156
Throttle position sensor (TPS) .......... EC-213, EC-278,
EC-479
, EC-481, EC-633, EC-920, EC-1015, EC-1225,
EC-1227
, EC-1316
Throttle valve closed position learning ............. EC-786
Tie-rod ............................................................... PS-19
Timing chain(VK45DE) ................................... EM-200
Timing chain(VQ35DE) ..................................... EM-64
Tire rotation ............................................. WT-6, MA-35
Top tether strap child restraint ........................... SB-10
Torque converter installation AT-271, AT-272, AT-276
Page 3412 of 4731
INSTRUMENT PANEL ASSEMBLY IP-11
C
D E
F
G H
J
K L
M A
B
IP
Revision: 2005 July 2005 FX
Removal and InstallationAIS003CJ
WORK STEP
When removing instrument panel and pad, combination meter, display unit and audio unit, center console take
steps in the order shown by the numbers below.
CAUTION:
Disconnect both battery cables in advance.
Disconnect air bag system line in advance.
Never temper with air bag lid or force air bag lid to open, as this may adversely affect air bag per-
formance.
Be careful not to scratch pad and other parts.
1. Front defroster grille (RH) 2. Instrument panel and pad 3. Front defroster grille (LH)
4. Screw 5. Bolt 6. Combination meter assembly
7. Steering lock escutcheon 8. Side ventilation (LH) 9. Display unit and audio unit
10. Wiper and washer switch 11. Clip 12. Rubber
13. Lighting and turn signal switch 14. Combination meter bracket 15. Cluster lid C
16. Steering column upper cover 17. Steering column lower cover 18. Steering column front lower cover
19. Instrument side panel (LH) 20. Instrument clock finisher 21. A/T console finisher
22. Instrument driver lower panel 23. Console finisher (LH) 24. Center console
25. Console finisher (RH) 26. Instrument side panel (RH) 27. Instrument lower cover
28. Instrument passenger lower panel 29. Side ventilation (RH) 30. Front passenger air bag module mounting nut
Parts Reference
page Instrument
panel and pad Combination
meter Display unit and
audio unit Center console
(A) Front kicking plate (RH/LH) EI-38
[ 1 ] [ 1 ]
(B) Dash side finisher (RH/LH) EI-37
[ 2 ] [ 2 ]
(C) Front pillar garnish (RH/LH) EI-38
[ 3 ]
(D) A/T select lever knob AT- 2 3 3
[ 4 ] [ 1 ]
(E) Instrument clock finisher IP-12
[ 5 ] [ 2 ]
(F) A/T console finisher IP-12
[ 6 ] [ 3 ]
(G) Console finisher (RH/LH) IP-12
[ 7 ] [ 4 ]
(H) Center console IP-12
[ 8 ] [ 5 ]
(I) Instrument lower cover IP-13
[ 9 ]
(J) Instrument passenger lower panel IP-13
[10]
(K) Instrument driver lower panel IP-13
[11] [ 3 ]
(L) Steering column front lower cover IP-13
[12] [ 4 ]
(M) Steering column lower cover IP-13
[13] [ 5 ]
(N) Steering column upper cover IP-14
[14] [ 6 ]
(O) Wiper and washer switch IP-14
[15] [ 7 ]
(P) Lighting and turn signal switch IP-14
[16] [ 8 ]
(Q) Steering lock escutcheon IP-14
[17] [ 9 ]
(R) Combination meter assembly IP-14
[18] [10]
(S) Instrument side panel (RH/LH) IP-14
[19]
(T) Cluster lid C IP-15
[20] [ 1 ]
(U) Display unit and audio unit IP-15
[21] [ 2 ]
(V) Front defroster grille (RH/LH) IP-15
[22]
(W) Combination meter bracket IP-15
[23]
(X) Side ventilation (RH/LH) IP-16
[24]
(Y) Instrument panel and pad IP-16
[25]
Page 3414 of 4731
INSTRUMENT PANEL ASSEMBLY IP-13
C
D E
F
G H
J
K L
M A
B
IP
Revision: 2005 July 2005 FX
3. After removing, disassemble, each parts.
CAUTION:
When removing console, be careful not to pull the harness.
(I) Instrument Lower Cover
1. Pull down front instrument lower cover, and disconnect clips.
2. Pull it horizontally, and remove from lower cover pawls.
(J) Instrument Passenger Lower Panel
Remove screws with power tool, and disconnect harness connector,
and remove instrument passenger lower panel.
(K) Instrument Driver Lower Panel
1. Remove bolt and screws with power tool.
2. Remove data link connector.
3. Pull to disengage clip and pawl by removing panel in horizontal direction.
4. Disconnect in-vehicle sensor and each electrical parts.
5. Remove the grommet, and remove hood lock cable.
(L) Steering Column Front Lower Cover
1. Remove screw with power tool.
2. Disengage the tab, then remove steering column front lower cover.
NOTE:
Move the steering column telescopic to the rear most position
Move the steering column tilt to the top position.
(M) Steering Column Lower Cover
1. Remove screws with power tool.
2. Disengage the tab, then remove steering column lower cover.
PIIA5007E
PIIA4995E
PIIA4998E
Page 3415 of 4731
IP-14
INSTRUMENT PANEL ASSEMBLY
Revision: 2005 July 2005 FX
(N) Steering Column Upper Cover
Remove the steering column upper cover.
(O) Wiper and Washer Switch
Remove wiper and washer switch. Refer to WW-36, "Removal and Installation of Front Wiper and Washer
Switch" .
(P) Lighting and Turn Signal Switch
Remove lighting and turn signal switch. Refer to LT- 11 0 , "LIGHTING AND TURN SIGNAL SWITCH" .
(Q) Steering Lock Escutcheon
Pull back to your side, and remove steering lock escutcheon.
(R) Combination Meter Assembly
1. Remove bolts with power tool, and then remove connector
bracket.
2. Remove bolts with power tool and then disconnect harness con- nector.
CAUTION:
To prevent it from damaged by interference with the combina-
tion meter assembly, protect the combination meter assembly
with cloths.
(S) Instrument Side Panel (RH/LH)
1. Remove screws with power tool.
2. Pull to the side, disconnect clip and pawls and remove instru- ment side panel (RH/LH).
PIIA5002E
PIIA5003E
PIIA5004E
Page 3416 of 4731
INSTRUMENT PANEL ASSEMBLY IP-15
C
D E
F
G H
J
K L
M A
B
IP
Revision: 2005 July 2005 FX
(T) Cluster Lid C
1. Insert a remover into gap between instrument panel and pad,
pull back to your side, and disconnect metal clips below.
2. Disconnect harness connectors, and remove cluster lid C.
CAUTION:
Cover surroundings with cloth to avoid scratches or damages.
(U) Display Unit and Audio Unit
1. Remove screws with power tool.
2. Disconnect harness connector, and remove display unit and audio unit.
CAUTION:
Unit is heavy, so be careful not to pinch your fingers when
working.
(V) Front Defroster Grille (RH/LH)
Insert a remover into gaps between front defroster grille (RH/LH) and
instrument panel and pad, lift front defroster grille up, and remove
front defroster grille (RH/LH).
(W) Combination Meter Bracket
1. Remove bolts.
2. The installation bolts of the harness clip and steering column assembly is removed, steering column assembly is pulled back-
ward, and set combination meter bracket free from the instru-
ment panel and pad. Refer to PS-12, "
STEERING COLUMN" .
PIIA4994E
PIIB1335E
PIIA5009E
PIIA5010E
Page 3421 of 4731
LAN-2Revision: 2005 July 2005 FX
Display Unit Circuit Inspection .............................
... 74
Data Link Connector Circuit Inspection ............... ... 74
BCM Circuit Inspection ........................................ ... 75
Steering Angle Sensor Circuit Inspection ............ ... 75
Unified Meter and A/C Amp. Circuit Inspection ... ... 76
ABS Actuator and Electric Unit (Control Unit) Circuit
Inspection ............................................................ ... 76
Driver Seat Control Unit Circuit Inspection .......... ... 77
IPDM E/R Circuit Inspection ................................ ... 78
CAN Communication Circuit Inspection ............... ... 78
IPDM E/R Ignition Relay Circuit Inspection ......... ... 84
CAN SYSTEM (TYPE 2) ........................................ ... 85
Component Parts and Harness Connector Location ... 85
Schematic ............................................................ ... 86
Wiring Diagram - CAN - ....................................... ... 87
Check Sheet ........................................................ ... 90
CHECK SHEET RESULTS (EXAMPLE) .......... ... 93
Inspection Between TCM and Data Link Connector
Circuit .................................................................. .110
Inspection Between Data Link Connector and Uni-
fied Meter and A/C Amp. Circuit .......................... ..111
Inspection Between Unified Meter and A/C Amp.
and ABS Actuator and Electric Unit (Control Unit)
Circuit .................................................................. ..111
Inspection Between ABS Actuator and Electric Unit
(Control Unit) and Driver Seat Control Unit Circuit .112
ECM Circuit Inspection ........................................ .113
TCM Circuit Inspection ........................................ .113
Display Unit Circuit Inspection ............................. .114
Data Link Connector Circuit Inspection ............... .114
BCM Circuit Inspection ........................................ .115
Steering Angle Sensor Circuit Inspection ............ .115
LDW Camera Unit Circuit Inspection ................... .116
Unified Meter and A/C Amp. Circuit Inspection ... .117
ABS Actuator and Electric Unit (Control Unit) Circuit
Inspection ............................................................ .117
Driver Seat Control Unit Circuit Inspection .......... .118
IPDM E/R Circuit Inspection ................................ .118
CAN Communication Circuit Inspection ............... .119
IPDM E/R Ignition Relay Circuit Inspection ......... .125
CAN SYSTEM (TYPE 3) ........................................ .126
Component Parts and Harness Connector Location .126
Schematic ............................................................ .127
Wiring Diagram - CAN - ....................................... .128
Check Sheet ........................................................ .131
CHECK SHEET RESULTS (EXAMPLE) .......... .135
Inspection Between TCM and Data Link Connector
Circuit .................................................................. .154
Inspection Between Data Link Connector and Uni-
fied Meter and A/C Amp. Circuit .......................... .155
Inspection Between Unified Meter and A/C Amp.
and ABS Actuator and Electric Unit (Control Unit)
Circuit .................................................................. .155
Inspection Between ABS Actuator and Electric Unit
(Control Unit) and Driver Seat Control Unit Circuit .156
ECM Circuit Inspection ........................................ .157
TCM Circuit Inspection ........................................ .157
Display Control Unit Circuit Inspection ................ .158
ICC Unit Circuit Inspection .................................. .158 Intelligent Key Unit Circuit Inspection ..................
.159
Data Link Connector Circuit Inspection ................ .159
BCM Circuit Inspection ........................................ .160
Steering Angle Sensor Circuit Inspection ............. .160
Unified Meter and A/C Amp. Circuit Inspection .... .161
ICC Sensor Circuit Inspection .............................. .161
ABS Actuator and Electric Unit (Control Unit) Circuit
Inspection ............................................................. .162
Driver Seat Control Unit Circuit Inspection .......... .162
IPDM E/R Circuit Inspection ................................ .163
CAN Communication Circuit Inspection ............... .164
IPDM E/R Ignition Relay Circuit Inspection .......... .170
CAN SYSTEM (TYPE 4) ......................................... .171
Component Parts and Harness Connector Location .171
Schematic ............................................................ .172
Wiring Diagram - CAN - ....................................... .173
Check Sheet ........................................................ .176
CHECK SHEET RESULTS (EXAMPLE) ........... .180
Inspection Between TCM and Data Link Connector
Circuit ................................................................... .200
Inspection Between Data Link Connector and Uni-
fied Meter and A/C Amp. Circuit .......................... .201
Inspection Between Unified Meter and A/C Amp.
and ABS Actuator and Electric Unit (Control Unit)
Circuit ................................................................... .201
Inspection Between ABS Actuator and Electric Unit
(Control Unit) and Driver Seat Control Unit Circuit .202
ECM Circuit Inspection ........................................ .203
TCM Circuit Inspection ......................................... .203
Display Control Unit Circuit Inspection ................. .204
ICC Unit Circuit Inspection ................................... .204
Intelligent Key Unit Circuit Inspection .................. .205
Data Link Connector Circuit Inspection ................ .205
BCM Circuit Inspection ........................................ .206
Steering Angle Sensor Circuit Inspection ............. .206
LDW Camera Unit Circuit Inspection ................... .207
Unified Meter and A/C Amp. Circuit Inspection .... .208
ICC Sensor Circuit Inspection .............................. .208
ABS Actuator and Electric Unit (Control Unit) Circuit
Inspection ............................................................. .209
Driver Seat Control Unit Circuit Inspection .......... .209
IPDM E/R Circuit Inspection ................................ .210
CAN Communication Circuit Inspection ............... .211
IPDM E/R Ignition Relay Circuit Inspection .......... .218
CAN SYSTEM (TYPE 5) ......................................... .219
Component Parts and Harness Connector Location .219
Schematic ............................................................ .220
Wiring Diagram - CAN - ....................................... .221
Check Sheet ........................................................ .224
CHECK SHEET RESULTS (EXAMPLE) ........... .227
Inspection Between TCM and Data Link Connector
Circuit ................................................................... .244
Inspection Between Data Link Connector and Uni-
fied Meter and A/C Amp. Circuit .......................... .245
Inspection Between Unified Meter and A/C Amp.
and ABS Actuator and Electric Unit (Control Unit)
Circuit ................................................................... .245
Inspection Between ABS Actuator and Electric Unit
(Control Unit) and Driver Seat Control Unit Circuit .246
Page 3422 of 4731
LAN-3
C
D E
F
G H
I
J
L
M A
B
LAN
Revision: 2005 July 2005 FX
ECM Circuit Inspection ........................................
. 247
TCM Circuit Inspection ........................................ . 247
Display Unit Circuit Inspection ............................ . 248
AWD Control Unit Circuit Inspection ................... . 248
Data Link Connector Circuit Inspection ............... . 249
BCM Circuit Inspection ........................................ . 249
Steering Angle Sensor Circuit Inspection ............ . 250
Unified Meter and A/C Amp. Circuit Inspection ... . 250
ABS Actuator and Electric Unit (Control Unit) Circuit
Inspection ............................................................ . 251
Driver Seat Control Unit Circuit Inspection .......... . 251
IPDM E/R Circuit Inspection ................................ . 252
CAN Communication Circuit Inspection .............. . 253
IPDM E/R Ignition Relay Circuit Inspection ......... . 259
CAN SYSTEM (TYPE 6) ........................................ . 260
Component Parts and Harness Connector Location . 260
Schematic ........................................................... . 261
Wiring Diagram - CAN - ...................................... . 262
Check Sheet ........................................................ . 265
CHECK SHEET RESULTS (EXAMPLE) .......... . 269
Inspection Between TCM and Data Link Connector
Circuit .................................................................. . 287
Inspection Between Data Link Connector and Uni-
fied Meter and A/C Amp. Circuit .......................... . 288
Inspection Between Unified Meter and A/C Amp.
and ABS Actuator and Electric Unit (Control Unit)
Circuit .................................................................. . 288
Inspection Between ABS Actuator and Electric Unit
(Control Unit) and Driver Seat Control Unit Circuit . 289
ECM Circuit Inspection ........................................ . 290
TCM Circuit Inspection ........................................ . 290
Display Unit Circuit Inspection ............................ . 291
AWD Control Unit Circuit Inspection ................... . 291
Data Link Connector Circuit Inspection ............... . 292
BCM Circuit Inspection ........................................ . 292
Steering Angle Sensor Circuit Inspection ............ . 293
LDW Camera Unit Circuit Inspection .................. . 293
Unified Meter and A/C Amp. Circuit Inspection ... . 294
ABS Actuator and Electric Unit (Control Unit) Circuit
Inspection ............................................................ . 295
Driver Seat Control Unit Circuit Inspection .......... . 295
IPDM E/R Circuit Inspection ................................ . 296
CAN Communication Circuit Inspection .............. . 297
IPDM E/R Ignition Relay Circuit Inspection ......... . 303
CAN SYSTEM (TYPE 7) ........................................ . 304
Component Parts and Harness Connector Location . 304
Schematic ........................................................... . 305
Wiring Diagram - CAN - ...................................... . 306
Check Sheet ........................................................ . 309
CHECK SHEET RESULTS (EXAMPLE) .......... . 313
Inspection Between TCM and Data Link Connector
Circuit .................................................................. . 333
Inspection Between Data Link Connector and Uni-
fied Meter and A/C Amp. Circuit .......................... . 334
Inspection Between Unified Meter and A/C Amp.
and ABS Actuator and Electric Unit (Control Unit)
Circuit .................................................................. . 334
Inspection Between ABS Actuator and Electric Unit
(Control Unit) and Driver Seat Control Unit Circuit . 335 ECM Circuit Inspection ........................................
.336
TCM Circuit Inspection ........................................ .336
Display Control Unit Circuit Inspection ................ .337
AWD Control Unit Circuit Inspection .................... .337
ICC Unit Circuit Inspection .................................. .338
Intelligent Key Unit Circuit Inspection .................. .338
Data Link Connector Circuit Inspection ............... .339
BCM Circuit Inspection ........................................ .339
Steering Angle Sensor Circuit Inspection ............ .340
Unified Meter and A/C Amp. Circuit Inspection ... .340
ICC Sensor Circuit Inspection ............................. .341
ABS Actuator and Electric Unit (Control Unit) Circuit
Inspection ............................................................ .341
Driver Seat Control Unit Circuit Inspection .......... .342
IPDM E/R Circuit Inspection ................................ .343
CAN Communication Circuit Inspection .............. .344
IPDM E/R Ignition Relay Circuit Inspection ......... .350
CAN SYSTEM (TYPE 8) ........................................ .351
Component Parts and Harness Connector Location .351
Schematic ............................................................ .352
Wiring Diagram - CAN - ....................................... .353
Check Sheet ........................................................ .356
CHECK SHEET RESULTS (EXAMPLE) .......... .360
Inspection Between TCM and Data Link Connector
Circuit .................................................................. .381
Inspection Between Data Link Connector and Uni-
fied Meter and A/C Amp. Circuit .......................... .382
Inspection Between Unified Meter and A/C Amp.
and ABS Actuator and Electric Unit (Control Unit)
Circuit .................................................................. .382
Inspection Between ABS Actuator and Electric Unit
(Control Unit) and Driver Seat Control Unit Circuit .383
ECM Circuit Inspection ........................................ .384
TCM Circuit Inspection ........................................ .384
Display Control Unit Circuit Inspection ................ .385
AWD Control Unit Circuit Inspection .................... .385
ICC Unit Circuit Inspection .................................. .386
Intelligent Key Unit Circuit Inspection .................. .386
Data Link Connector Circuit Inspection ............... .387
BCM Circuit Inspection ........................................ .387
Steering Angle Sensor Circuit Inspection ............ .388
LDW Camera Unit Circuit Inspection ................... .388
Unified Meter and A/C Amp. Circuit Inspection ... .389
ICC Sensor Circuit Inspection ............................. .390
ABS Actuator and Electric Unit (Control Unit) Circuit
Inspection ............................................................ .390
Driver Seat Control Unit Circuit Inspection .......... .391
IPDM E/R Circuit Inspection ................................ .391
CAN Communication Circuit Inspection .............. .392
IPDM E/R Ignition Relay Circuit Inspection ......... .399
CAN SYSTEM (TYPE 9) ........................................ .400
Component Parts and Harness Connector Location .400
Schematic ............................................................ .401
Wiring Diagram - CAN - ....................................... .402
Check Sheet ........................................................ .405
CHECK SHEET RESULTS (EXAMPLE) .......... .407
Inspection Between TCM and Data Link Connector
Circuit .................................................................. .421
Inspection Between Data Link Connector and Uni-