charging ISUZU TROOPER 1998 Service Repair Manual

ISUZU TROOPER 1998 Service Repair Manual TROOPER 1998 ISUZU ISUZU https://www.carmanualsonline.info/img/61/57184/w960_57184-0.png ISUZU TROOPER 1998 Service Repair Manual

Page 9 of 3573

ISUZU TROOPER 1998  Service Repair Manual PAGE BACK                                                                           PAGE NEXT
THIS MALUAL INCLUDES THE FOLLOWING SECTIONS:
6VD1 / 6VE1
SECTION No. CONTRNTS
6A ENGINE MECHANICAL
6B ENGI

Page 16 of 3573

ISUZU TROOPER 1998  Service Repair Manual GENERAL REPAIR INSTRUCTIONS
1. Park the vehicle on level ground and chock the
front or rear wheels before lifting the vehicle.
2. Use covers on the vehicle body, seats, and
floor to prevent damage and

Page 62 of 3573

ISUZU TROOPER 1998  Service Repair Manual SERVICE INFORMATION  00 Ð 23
AIR CONDITIONING CYCLE TROUBLESHOOTING
No cooling or insuffi-
cient cooling
Insufficient velocity
of cooling air1. Magnetic clutch does not run
2. Compressor is not rotat

Page 64 of 3573

ISUZU TROOPER 1998  Service Repair Manual RESULT SYMPTOM TROUBLE CAUSE CORRECTION
SERVICE INFORMATION  00 Ð 25
Reduced or no air flow through
the condenser
No bubbles in sight glass when
condenser is cooled by water
(Insufficient cooling)
Af

Page 91 of 3573

ISUZU TROOPER 1998  Service Repair Manual 00 Ð 52 SERVICE INFORMATION
HFC-134a
SPECIAL TOOLS
ILLUSTRATION PARTS NO. PARTS NAME
5-8840-0629-0
ACR
4(115V  60Hz)
(J-39500-A)
5-8840-0630-0
ACR
4(220-240V  50/60Hz)
(J-39500-220A)
5-8840-0631-0 AC

Page 133 of 3573

ISUZU TROOPER 1998  Service Repair Manual AIR CONDITIONING  1B Ð 7
EVAPORATOR
The evaporator cools and dehumidifies the air
before the air enters the vehicle. High-pressure
liquid refrigerant flows through the expansion valve
(1) into the lo

Page 139 of 3573

ISUZU TROOPER 1998  Service Repair Manual AIR CONDITIONING  1B Ð 13
ACR41) Using the ACR4(HFC-134a Refrigerant Recovery/
Recycling/ Recharging/ System) or equivalent to
thoroughly discharge and recover the refrigerant.
ACR
4(115V  60Hz) : 5-

Page 141 of 3573

ISUZU TROOPER 1998  Service Repair Manual AIR CONDITIONING  1B Ð 15
COMPRESSOR LEAKS
If leaks are located around the compressor shaft seal or
shell, replace or repair the compressor.
RECOVERY, RECYCLING, EVACUATION AND
CHARGING
Handling Refr

Page 142 of 3573

ISUZU TROOPER 1998  Service Repair Manual 1B Ð 16 AIR CONDITIONING
WARNING
·SHOULD HFC-134a CONTACT YOUR EYE(S),
CONSULT A DOCTOR IMMEDIATELY.
·DO NOT RUB THE AFFECTED EYE(S). INSTEAD,
SPLASH QUANTITIES OF FRESH COLD WATER
OVER THE AFFECTE

Page 143 of 3573

ISUZU TROOPER 1998  Service Repair Manual AIR CONDITIONING  1B Ð 17
7) Check to ensure that the pressure does not change
after 10 minutes or more.
·If the pressure changes, check the system for leaks.
·If leaks occur, retighten the refrige
Page:   1-10 11-20 21-30 31-40 41-50 ... 90 next >