maintenance KIA OPTIMA 2020 Owners Manual

Maintenance
100
7
Canister
Fuel vapors generated inside the fuel
tank are absorbed and stored in the
onboard canister. When the engine is
running, the fuel vapors absorbed in
the canister are drawn into the surge
tank through the purge control sole-
noid valve.
Purge Control Solenoid Valve
(PCSV)
The purge control solenoid valve is
controlled by the Engine Control
Module (ECM); when the engine
coolant temperature is low during
idling, the PCSV closes so that evap-
orated fuel is not taken into the
engine. After the engine warms up
during ordinary driving, the PCSV
opens to introduce evaporated fuel to
the engine.
3. Exhaust emission control system
The Exhaust Emission Control
System is a highly effective system
which controls exhaust emissions
while maintaining good vehicle per-
formance.
Engine exhaust gas precautions
(carbon monoxide)
Carbon monoxide can be present with other exhaust fumes.
Therefore, if you smell exhaust
fumes of any kind inside your vehi-
cle, have it inspected and repaired
immediately. If you ever suspect
exhaust fumes are coming into
your vehicle, drive it only with all
the windows fully open. Have your
vehicle checked and repaired
immediately.
WARNING - Exhaust
Engine exhaust gases contain
carbon monoxide (CO). Though
colorless and odorless, it is
dangerous and could be lethal if
inhaled. Follow the instructions
on this page to avoid CO poi-
soning.

7101
Maintenance
Do not operate the engine in con-fined or closed areas (such as
garages) any more than what is
necessary to move the vehicle in or
out of the area.
When the vehicle is stopped in an open area for more than a short
time with the engine running,
adjust the ventilation system (as
needed) to draw outside air into the
vehicle.
Never sit in a parked or stopped vehicle for any extended time with
the engine running.
When the engine stalls or fails to start, excessive attempts to restart
the engine may cause damage to
the emission control system.Operating precautions for catalyt-
ic converters (if equipped)
WARNING- Catalytic converter
Keep away from the catalytic
converter and exhaust system
while the vehicle is running or
immediately thereafter. The
exhaust and catalytic systems
are very hot and may burn you.
WARNING- Fire
Do not park, idle or drive the vehicle over or near flamma-
ble objects, such as grass,
vegetation, paper, leaves, etc.
A hot exhaust system can
ignite flammable items under
your vehicle.
Also, do not remove the heat sink around the exhaust sys-
tem, do not seal the bottom of
the vehicle or do not coat the
vehicle for corrosion control.
It may present a fire risk under
certain conditions.

Your vehicle is equipped with a cat-
alytic converter emission control
device.
Therefore, the following precautions
must be observed:
Use only UNLEADED FUEL forgasoline engines.
Do not operate the vehicle when there are signs of engine malfunc-
tion, such as misfire or a noticeable
loss of performance.
Do not misuse or abuse the engine. Examples of misuse are
coasting with the ignition off and
descending steep grades in gear
with the ignition off.
Do not operate the engine at high idle speed for extended periods (5
minutes or more).
Do not modify or tamper with any part of the engine or emission con-
trol system. All inspections and
adjustments must be made by an
authorized Kia dealer.
Avoid driving with an extremely low fuel level. Running out of fuel could
cause the engine to misfire, dam-
aging the catalytic converter. Failure to observe these precautions
could result in damage to the catalyt-
ic converter and to your vehicle.
Additionally, such actions could void
your warranties.
7 102
Maintenance

Index
4I
Limitation of ECO operation ......................................5-97
When ECO is activated ..............................................5-97
Driver Attention Warning (DAW)................................5-125 Resetting the system ................................................5-127
System disabled ........................................................5-127
System malfunction ..................................................5-128
System setting and activation ..................................5-125
ECO system ..................................................................5-98 Limitation of ECO operation ......................................5-99
Plug-in hybrid vehicle ................................................5-98
When ECO is activated ..............................................5-99
Economical operation ..................................................5-130
Emergency starting ..........................................................6-5 Jump starting ................................................................6-5
Push-starting ................................................................6-6
Emission control system ................................................7-99 Crankcase emission control system ............................7-99
Evaporative emission control (including ORVR : Onboard Refueling Vapor Recovery) system ..........7-99
Exhaust emission control system ..............................7-100
Engine ........................................................................\
......8-2
Engine compartment ................................................2-6, 7-3 Engine maintenance mode (for plug-in Hybrid) ..........7-20
Starting Engine Maintenance Mode ..........................7-20
Stopping Engine Maintenance Mode..........................7-20
Engine number ................................................................8-9
Engine oil ......................................................................7-\
18 Changing the engine oil and filter ..............................7-19
Checking the engine oil level ....................................7-18
Engine start/stop button ..................................................5-7 Engine start/stop button position ..................................5-7
Illuminated engine start/stop button ............................5-7
Starting the hybrid system ............................................5-9
Explanation of scheduled maintenance items ..............7-14
Exterior overview ............................................................2-2
Forward Collision-avoidance Assist (FCA) system ......5-43 Brake operation ..........................................................5-47
FCA sensor (Front view camera)................................5-48
FCA warning message and system control ................5-45
Limitation of the system ............................................5-51
System malfunction ....................................................5-49
System setting and activation ....................................5-43
Forward Collision-avoidance Assist (FCA) system - sensor fusion type (front radar+front view camera) ..5-57Brake operation ..........................................................5-61
E
F

I7
Index
Front fog lamp (Bulb and LED type) bulb replacement ..............................................................7-81
Front turn signal lamp (Bulb type) bulb replacement (Headlamp Type A) ..................................................7-80
Front turn signal lamp (Bulb type) bulb replacement (Headlamp Type B) ..................................................7-80
Glove box lamp (Bulb type) bulb replacement ..........7-88
Headlamp (High beam) bulb replacement (Headlamp Type A) ..................................................7-78
Headlamp (Low beam) bulb replacement (Headlamp Type A) ..................................................7-77
Headlamp (Low/High beam) (LED type) bulb replacement (Headlamp Type B) ..............................7-79
High mounted stop lamp (LED type) bulb replacement ..............................................................7-86
License plate lamp (Bulb type) bulb replacement ......7-85
Light bulb position (Front) ........................................7-75
Light bulb position (Rear) ..........................................7-76
Light bulb position (Side) ..........................................7-76
Map lamp (LED type) bulb replacement ..................7-86
Personal lamp (LED type) bulb replacement ............7-88
Position lamp + DRL (LED type) bulb replacement..7-81
Rear turn signal lamp bulb replacement ....................7-82
Room lamp (Bulb type) bulb replacement ................7-87
Side repeater lamp (LED type) bulb replacement ......7-82
Stop lamp (LED type) bulb replacement (Sedan) ......7-84
Tail lamp (LED type) bulb replacement (Sedan)........7-84 Trunk lamp (LED type) bulb replacement..................7-89
Vanity mirror lamp (Bulb type) bulb replacement ....7-87
Lighting........................................................................\
4-103 Battery saver function ..............................................4-103
Check headlight ......................................................4-110
Daytime running light ..............................................4-103
Dynamic Bending Light ..........................................4-111
Front fog light ..........................................................4-110
Headlight leveling device..........................................4-110
High Beam Assist ....................................................4-106
High beam operation ................................................4-105
Lighting control ........................................................4-103
Turn signals and lane change signals........................4-109
Luggage volume ..............................................................8-5
Maintenance services ......................................................7-4 Owner maintenance precautions ..................................7-5
Owner’s responsibility ..................................................7-4
Mirrors ........................................................................\
..4-48 Inside rearview mirror ................................................4-48
Outside rearview mirror ..............................................4-50
M

Index
8I
Owner maintenance ........................................................7-6Owner maintenance schedule ......................................7-6
Panoramic sunroof ........................................................4-38 Closing the sunroof ....................................................4-43
Resetting the sunroof ..................................................4-43
Sliding the sunroof ......................................................4-41
Sunroof open warning ................................................4-39
Sunshade ....................................................................4-40\
Tilting the sunroof ......................................................4-42
Parking brake ................................................................7-27 Checking the parking brake ........................................7-27
Parking distance warning - reverse ................................4-98 Non-operational conditions of the parking distance warning-reverse system ............................................4-99
Operation of the parking distance warning-reverse ....4-98
Parking distance warning-reverse system precautions ..............................................................4-100
Self-diagnosis............................................................4-100 Rearview monitor ........................................................4-101
Recommended lubricants and capacities ........................8-6
Recommended SAE viscosity number ........................8-7
Road warning ..................................................................6-2 Hazard warning flasher ................................................6-2
Scheduled maintenance service ......................................7-8
Seat ........................................................................\
..........3-4 Driver position memory system (for power seat) ......3-11
Front seat adjustment - manual ....................................3-7
Front seat adjustment - power ......................................3-8
Headrest (for front seat) ..............................................3-12
Rear seat adjustment ..................................................3-15
Seatback pocket ..........................................................3-15
Seat belts ........................................................................\
3-21 Care of seat belts ........................................................3-32
Pre-tensioner seat belt ................................................3-28
Seat belt precautions ..................................................3-30
Seat belt restraint system ............................................3-21
Smart cruise control with Stop & Go system ................5-76 Limitations of the system............................................5-9\
0
Smart Cruise Control speed ........................................5-78
R
S
O
P

Index
10I
Tire care ......................................................................7-\
39
Tire maintenance ........................................................7-44
Tire pressure................................................................7-40
Tire replacement ........................................................7-43
Tire rotation ................................................................7-41
Tire sidewall labeling ..................................................7-44
Tire traction ................................................................7-44
Wheel alignment and tire balance ..............................7-42
Wheel replacement ....................................................7-43
Towing ........................................................................\
..6-24 Emergency towing ......................................................6-26
Removable towing hook ............................................6-25
Towing service ............................................................6-24
Trailer Towing..............................................................5-139
Vehicle break-in process ..................................................1-5
Vehicle certification label ................................................8-8
Vehicle data collection and event data recorders ............1-6
Vehicle Identification Number (VIN) ..............................8-8
Vehicle load limit ........................................................5-140 Certification label......................................................5-143
Tire and loading information label ..........................5-140
Vehicle modifications ......................................................1-5 Vehicle weight ............................................................5-144
Base curb weight ......................................................5-144
Cargo weight ............................................................5-144
GAW (Gross Axle Weight) ......................................5-144
GAWR (Gross Axle Weight Rating) ........................5-144
GVW (Gross Vehicle Weight) ..................................5-144
GVWR (Gross Vehicle Weight Rating) ....................5-144
Vehicle curb weight ..................................................5-144
Warning and indicator lights..........................................4-84 Indicator lights ............................................................4-92
Warning lights ............................................................4-84
Washer fluid ..................................................................7-26 Checking the washer fluid level..................................7-26
Welcome system ..........................................................4-119 Headlight (Headlamp) escort function......................4-119
Interior light ..............................................................4-119
Pocket lamp ..............................................................4-119
Windows ........................................................................\
4-24 Power windows ..........................................................4-25
Windshield defrosting and defogging..........................4-136 Automatic climate control system ............................4-136
Defogging logic ........................................................4-137
V
W