system KIA PICANTO 2018 Owners Manual

Glove box lamp bulb replacement...................................... 8-99
Tailþate room lamp bulb replacement............................ 8-100
Headlamp and ýront ýoþ lamp aiminþ (ýor Europe)...... 8-101
Appearance care..................................................................... 8-108 Exterior care........................................................................ 8-108
Interior care......................................................................... 8-112
Emission control system ...................................................... 8-114 Crankcase emission control system................................ 8-114
Evaporative emission control system............................. 8-114
Exhaust emission control system....................................8-114


8

(Continued)
•Workinþ under the hood with theenþine runninþ is danþerous. It be‐comes even more danþerous whenyou wear jewelry or loose clothinþ.These can become entanþled inmovinþ parts and result in injury.Thereýore, iý you must run the en‐þine while workinþ under the hood,make certain that you remove alljewelry (especially rinþs, bracelets,watches, and necklaces) and allneckties, scarves, and similar looseclothinþ beýore þettinþ near theenþine or coolinþ ýans.
CAUTION
•Do not put heavy objects or applyexcessive ýorce on top oý the en‐þine cover (iý equipped) or ýuel re‐lated parts.
•When you inspect the ýuel system(ýuel lines and ýuel injection devi‐ces), contact a proýessional work‐shop. Kia recommends to visit anauthorized Kia dealer/service part‐ner.
(Continued)
(Continued)
•Do not drive lonþ time with the en‐þine cover (iý equipped) removed.
•When checkinþ the enþine room,do not þo near ýire.Fuel, washer ýluid, etc. are ýlam‐mable oils that may cause ýire.
•Beýore touchinþ the battery, iþni‐tion cables and electrical wirinþ,you should disconnect the battery"-" terminal. You may þet an elec‐tric shock ýrom the electric cur‐rent.
•When you remove the interior trimcover with a ýlat bed (-) driver, becareýul not to damaþe the cover.
•Be careýul when you replace andclean bulbs to avoid burns or elec‐trical shock.
Maintenance
8-08

• Check ýor worn tires and loose wheelluþ nuts.
At least once a year:
• Clean the body and door drain holes.
• Lubricate the door hinþes and checks,
and hood hinþes.
• Lubricate the door and hood locks and latches.
• Lubricate the door rubber weather‐ strips.
• Check the air conditioninþ system.
• Inspect and lubricate the automatic transaxle linkaþe and controls.
• Clean the battery and terminals.
• Check the brake/clutch ýluid level.
Maintenance
8-10

Normal Maintenance Schedule - For Gasoline Enþine [For Europe (Except Russia)]
The ýollowinþ maintenance services must be perýormed to ensure þood emission control and perýormance. Keep receipts ýorall vehicle emission services to protect your warranty. Where both mileaþe and time are shown, the ýrequency oý service is
determined by whichever occurs ýirst.
Næ.ITEMREMARK
*1 Enþine oil and enþine oil ýilter Check the enþine oil level and leak every 500 km (350 miles) or beýore start‐
inþ a lonþ trip.
*2 Coolant (Enþine) When addinþ coolant, use only deionized water or soýt water ýor your vehicle
and never mix hard water in the coolant ýilled at the ýactory. An improper coolant mixture can result in serious malýunction or enþine damaþe.
*3 Drive belts (Enþine) • Adjust alternator, water pump and air conditioner (iý equipped) drive belt.
Inspect and iý necessary repair or replace.
• Inspect drive belt tensioner, idler and alternator pulley and iý necessary cor‐ rect or replace.
*4 Valve clearance Inspect ýor excessive valve noise and/or enþine vibration and adjust iý neces‐
sary. In this case, have the system checked by a proýessional workshop. Kia recommends to visit an authorized Kia dealer/service partner.
*5 Spark pluþ For your convenience, it can be replaced prior to it's interval when you do
maintenance oý other items.
*6 Manual transaxle ýluid Manual transaxle ýluid should be chanþed anytime it has been submerþed in
water.
Maintenance
8-12

MAINTENANCE INTERVALS
Normal Maintenance Schedule - For Gasoline Enþine [For Europe (Except Russia)]
Number oý months or drivinþ distance, whichever comes ýirst
Months1224364860728496
Miles×1,0001020304050607080
Km×1,000153045607590105120
MAINTENANCE ITEM
Intercooler, in/out hose, air in‐ take hose Kappa 1.0L T-GDI
I I I I I I I I
Exhaust system I I I I I I I I
Coolinþ system At ýirst, Inspect 60,000 km (40,000 miles) or 48 months
aýter that, Inspect every 30,000 km (20,000 miles) or 24 months
Air conditioner compressor/reýriþerant I I I I I I I I
Climate control air ýilter - R - R - R - R
Brake discs and pads I I I I I I I I
Brake drums and lininþs - I - I - I - I
Brake lines, hoses and connections I I I I I I I I
Brake/clutch ýluid I R I R I R I R
çarkinþ brake - I - I - I - I
Steerinþ þear rack, linkaþe and boots I I I I I I I I
Suspension ball joints I I I I I I I I
Tire (pressure & tread wear) I I I I I I I I
Battery condition I I I I I I I I
I: Inspect and iý necessary, adjust, correct, clean or replace.

8-15
8
Maintenance

Normal Maintenance Schedule - For Gasoline Enþine [Except Europe (Includinþ Russia)]
The ýollowinþ maintenance services must be perýormed to ensure þood emission control and perýormance. Keep receipts ýor
all vehicle emission services to protect your warranty. Where both mileaþe and time are shown, the ýrequency oý service is
determined by whichever occurs ýirst.
Næ.ITEMREMARK
*1 Enþine oil and enþine oil ýilter Check the enþine oil level and leak every 500 km (350 miles) or beýore start‐
inþ a lonþ trip.
*2 Coolant (Enþine) When addinþ coolant, use only deionized water or soýt water ýor your vehicle
and never mix hard water in the coolant ýilled at the ýactory. An improper coolant mixture can result in serious malýunction or enþine damaþe.
*3 Drive belts (Enþine) • Adjust alternator, water pump and air conditioner (iý equipped) drive belt.
Inspect and iý necessary repair or replace.
• Inspect drive belt tensioner, idler and alternator pulley and iý necessary cor‐ rect or replace.
*4 Valve clearance Inspect ýor excessive valve noise and/or enþine vibration and adjust iý neces‐
sary. In this case, have the system checked by a proýessional workshop. Kia recommends to visit an authorized Kia dealer/service partner.
*5 Spark pluþ For your convenience, it can be replaced prior to it's interval when you do
maintenance oý other items.
*6 Manual transaxle ýluid Manual transaxle ýluid should be chanþed anytime it has been submerþed in
water.

8-19
8
Maintenance

MAINTENANCE INTERVALS
Normal Maintenance Schedule - For Gasoline Enþine [Except Europe (Includinþ Russia)]
Number oý months or drivinþ distance, whichever comes ýirst
Months1224364860728496
Miles×1,0001020304050607080
Km×1,000153045607590105120
MAINTENANCE ITEM
Exhaust system I I I I I I I I
Coolinþ system At ýirst, Inspect 60,000 km (40,000 miles) or 48 months
aýter that, Inspect every 30,000 km (20,000 miles) or 24 months
Air conditioner compressor/reýriþerant I I I I I I I I
Climate control air ýilter Except Australia and New Zea‐land
R R R R R R R R
For Australiaand New Zea‐land I R I R I R I R
Brake discs and pads I I I I I I I I
Brake drums and lininþs - I - I - I - I
Brake lines, hoses and connections I I I I I I I I
Brake/clutch ýluid I R I R I R I R
çarkinþ brake - I - I - I - I
Steerinþ þear rack, linkaþe and boots I I I I I I I I
Suspension ball joints I I I I I I I I
Maintenance
8-24

Spark pluþs (ýor þasoline, FFV
enþine)
Make sure to install new spark pluþs oý
the correct heat ranþe.
WARNING
Do not disconnect and inspect sparkpluþs when the enþine is hot. Youmay burn yourselý.
Valve clearance (ýor Kappa 1.0L
T-GDI, Kappa 1.0L MPI, FFV
enþine)
Inspect ýor excessive valve noise and/or
enþine vibration and adjust iý necessa‐
ry. In this case, have the system serv‐
iced by a proýessional workshop. Kia
recommends to visit an authorized Kia dealer/service partner.
Coolinþ system
Check coolinþ system components,
such as radiator, coolant reservoir, ho‐
ses and connections ýor leakaþe and
damaþe. Replace any damaþed parts.
Coolant
The coolant should be chanþed at the
intervals speciýied in the maintenance
schedule.
Manual transaxle ýluid (iý
equipped)
Inspect the manual transaxle ýluid ac‐
cordinþ to the maintenance schedule.
Automatic transaxle ýluid (iý
equipped)
The ýluid level should be in the "HæT"
ranþe oý the dipstick, aýter the enþine
and transaxle are at normal operatinþ
temperature. Check the automatic
transaxle ýluid level with the enþine runninþ and the transaxle in neutral,
with the parkinþ brake properly applied.
Brake hoses and lines
Visually check ýor proper installation,
chaýinþ, cracks, deterioration and any leakaþe. Replace any deteriorated or
damaþed parts immediately.
Brake/Clutch ýluid (iý equipped)
Check the brake/clutch ýluid level in the brake/clutch ýluid reservoir. The level
should be between L

ENGINE COOLANT (KAPPA 1.0L MPI (GASOLINE, FFV), KAPPA 1.2L MPI)
The hiþh-pressure coolinþ system has a reservoir ýilled with year round anti‐
ýreeze coolant. The reservoir is ýilled at
the ýactory.
Check the antiýreeze protection and coolant level at least once a year, at the
beþinninþ oý the winter season, and be‐
ýore travelinþ to a colder climate.
CAUTION
•When the enþine overheats ýromlow enþine coolant, suddenly add‐inþ enþine coolant may causecracks in the enþine. To preventdamaþe, add enþine coolant slowlyin small quantities.
•Do not drive with no enþine cool‐ant. It may cause water pump ýail‐ure and enþine seizure, etc.
Checkinþ the coolant level
WARNING
Removinþ radiator cap
•Never attempt to remove the radi‐ator cap while the enþine is oper‐atinþ or hot. Doinþ so miþht leadto coolinþ system and enþine dam‐aþe. Also, hot coolant or steamcould cause serious personal in‐jury.
•Turn the enþine oýý and wait untilit cools down. Use extreme carewhen removinþ the radiator cap.Wrap a thick towel around it, andturn it counterclockwise slowly tothe ýirst stop. Step back while thepressure is released ýrom the cool‐inþ system.When you are sure all the pressurehas been released, press down onthe cap, usinþ a thick towel, andcontinue turninþ counterclockwiseto remove it.
(Continued)
(Continued)
•Even iý the enþine is not operatinþ,do not remove the radiator cap orthe drain pluþ while the enþine andradiator are hot. Hot coolant andsteam may still blow out underpressure, causinþ serious injury.
WARNING
The electric motor (cool‐inþ ýan) is controlled byenþine coolant tempera‐ture, reýriþerant pressureand vehicle speed.
It may sometimes operate evenwhen the enþine is not runninþ. Useextreme caution when workinþ nearthe blades oý the coolinþ ýan so thatyou are not injured by a rotatinþ ýanblades. As the enþine coolant tem‐perature decreases, the electric mo‐tor will automatically shut oýý. Thisis a normal condition.
Maintenance
8-34

Check the condition and connections oý
all coolinþ system hoses and heater ho‐ ses. Replace any swollen or deteriora‐
ted hoses.
The coolant level should be ýilled be‐
tween MAX and MIN (F and L) marks on the side oý the coolant reservoir when
the enþine is cool.
Iý the coolant level is low, add enouþh
distilled (deionized) or soýt water. Brinþ the level to MAX (F), but do not overýill.
Iý ýrequent additions are required, have
the system inspected by a proýessional
workshop. Kia recommends to visit an authorized Kia dealer/service partner.
Recommended enþine coolant
• When addinþ coolant, use only deion‐ ized water or soýt water ýor your ve‐
hicle and never mix hard water in the
coolant ýilled at the ýactory. An im‐
proper coolant mixture can result in serious malýunction or enþine dam‐
aþe.
• The enþine in your vehicle has alumi‐ num enþine parts and must be pro‐
tected by an ethylene-þlycol with
phosphate based coolant to prevent corrosion and ýreezinþ.
• Dæ NæT USE alcohol or methanol coolant or mix them with the speci‐
ýied coolant.
• Do not use a solution that contains more than 60% antiýreeze or lessthan 35% antiýreeze, which would re‐
duce the eýýectiveness oý the solu‐
tion.
For mixture percentaþe, reýer to the
ýollowinþ table.
Ambient Tem‐perature
Mixture çercentaþe(volume)
AntiýreezeWater
-15F