climate control KIA RIO 2021 Owner's Manual
[x] Cancel search | Manufacturer: KIA, Model Year: 2021, Model line: RIO, Model: KIA RIO 2021Pages: 534, PDF Size: 13.49 MB
Page 406 of 534

Maintenance
14
7
Severe driving conditions
A - Repeatedly driving short distance of less than 5 miles (8 km)
in normal temperature or less than 10 miles (16 km) in freez-
ing temperature
B - Extensive engine idling or low speed driving for long dis- tances
C - Driving on rough, dusty, muddy, unpaved, graveled or salt- spread roads
D - Driving in areas using salt or other corrosive materials or in very cold weather
E - Driving in heavy dust condition F - Driving in heavy traffic area
G- Driving on uphill, downhill, or mountain road repeatedly
H - Using for towing or camping, and driving with loading on the
roof.
I - Driving as a patrol car, taxi, other commercial use or vehicle towing
J - Frequently driving under high speed or rapid acceleration.
K - Frequently driving in stop-and-go conditions
L - Engine oil usage which is not recommended (Mineral type, Semi-synthetic, Lower grade etc.)
MAINTENANCE ITEMMAINTENANCEOPERATIONMAINTENANCE INTERVALSDRIVING
CONDITION
Drive shafts and bootsIMore frequentlyC, D, E, F, G, H, I, J
Climate control air filter
(for evaporator and blower unit)RMore frequentlyC, E, G
SC PE USA 7.qxp 10/23/2020 6:05 PM Page 14
Page 421 of 534

729
Maintenance
WASHER FLUID
Checking the washer fluid
level
The reservoir is translucent so that
you can check the level with a quick
visual inspection.
Check the fluid level in the washer
fluid reservoir and add fluid if neces-
sary. In warm climates, plain water
may be used if washer fluid is not
available. However, use washer sol-
vent with antifreeze characteristics in
cold climates to prevent freezing.
WARNING- Flammablefluid
Do not allow the washer fluid to
come in contact with open
flames or sparks. The windshield
washer fluid reservoir is flamma-
ble under certain circumstances.
This can result in a fire.WARNING- Windshield fluid
Do not drink the windshield
washer fluid. The windshield
washer fluid is poisonous to
humans and animals.
WARNING- Coolant
Do not use radiator coolant or antifreeze in the washer fluid
reservoir.
Radiator coolant can severely obscure visibility when sprayed
on the windshield and may
cause loss of vehicle control.
OSC077019N
SC PE USA 7.qxp 10/23/2020 6:05 PM Page 29
Page 425 of 534

733
Maintenance
CLIMATE CONTROL AIR FILTER
Filter inspection
The climate control air filter should
be replaced according to the
Maintenance Schedule. If the vehicle
is operated in severely air-polluted
cities or on dusty rough roads for a
long period, it should be inspected
more frequently and replaced earlier.
When you replace the climate control
air filter, replace it performing the fol-
lowing procedure, and be careful to
avoid damaging other components.1. Open the glove box and removethe stoppers on both sides. 2. With the glove box open, pull the
support strap (1).
OYB076023OYB076022
SC PE USA 7.qxp 10/23/2020 6:06 PM Page 33
Page 426 of 534

Maintenance
34
7
3. Remove the climate control air fil-
ter cover while pressing the lock
on both sides of the cover. 4. Replace the climate control air fil-
ter.
5. Reassemble in the reverse order of disassembly.
When replacing the climate control
air filter, install it properly. Otherwise,
the system may produce noise, and
the effectiveness of the filter may be
reduced.
OSC076007OQL075021
SC PE USA 7.qxp 10/23/2020 6:06 PM Page 34
Page 433 of 534

741
Maintenance
When recharging the battery,
observe the following precautions:
The battery must be removed fromthe vehicle and placed in an area
with good ventilation.
Do not allow cigarettes, sparks, or flame near the battery.
Watch the battery during charging, and stop or reduce the charging
rate if the battery cells begin
gassing (boiling) violently or if the
temperature of the electrolyte of
any cell exceeds 120°F (49°C).
Wear eye protection when check- ing the battery during charging.
Disconnect the battery charger in the following order.
1. Turn off the battery charger main switch.
2. Unhook the negative clamp from the negative battery terminal.
3. Unhook the positive clamp from the positive battery terminal. Before performing maintenance or
recharging the battery, turn off all
accessories and stop the engine.
The negative battery cable must be removed first and installed last
when the battery is disconnected.Reset items
The following items should be reset
after the battery has been dis-
charged or the battery has been dis-
connected.
Auto up/down window
Sunroof
Trip computer
Climate control system
SC PE USA 7.qxp 10/23/2020 6:06 PM Page 41
Page 442 of 534

Maintenance
50
7
Tread wear
The tread wear grade is a compara-
tive rating based on the wear rate of
the tire when tested under controlled
conditions on a specified govern-
ment test course. For example, a tire
graded 150 would wear one-and-a-
half times (1½) as well on the gov-
ernment course as a tire graded 100.
The relative performance of tires
depends upon the actual conditions
of their use, however, and may
depart significantly from the norm
due to variations in driving habits,
service practices and differences in
road characteristics and climate. Tires degrade over time, even when
they are not being used. Regardless
of the remaining tread, we recom-
mend that tires be replaced after
approximately six (6) years of normal
service. Heat caused by hot climates
or frequent high loading conditions
can accelerate the aging process.
These grades are molded on the
side-walls of passenger vehicle tires.
The tires available as standard or
optional equipment on your vehicles
may vary with respect to grade.
Traction - AA, A, B & C
The traction grades, from highest to
lowest, are AA, A, B and C. Those
grades represent the tires ability to
stop on wet pavement as measured
under controlled conditions on spec-
ified government test surfaces of
asphalt and concrete. A tire marked
C may have poor traction perform-
ance.
The traction grade assigned to this
tire is based on straight-ahead brak-
ing traction tests, and does not
include acceleration, cornering,
hydroplaning, or peak traction char-
acteristics.
SC PE USA 7.qxp 10/23/2020 6:06 PM Page 50
Page 524 of 534

Index
2I
Air bag - advanced supplemental restraint system ........3-34Adding equipment to or modifying yourair bag-equipped vehicle ..........................................3-62
Air bag warning label ................................................3-62
Air bag warning light ..................................................3-38
Curtain air bag ............................................................3-54
Driver's and passenger's front air bag ........................3-49
How does the air bag system operate ........................3-35
Occupant detection system ........................................3-41
Side air bag ................................................................3-52
SRS Care ....................................................................3-61\
SRS components and functions ..................................3-38
Why didn’t my air bag go off in a collision? (Inflation and non-inflation conditions of the
air bag) ......................................................................3-\
56
Air cleaner ....................................................................7-31\
Filter replacement ......................................................7-31
Air conditioning system ..................................................8-6
Appearance care ..........................................................7-102 Exterior care ..............................................................7-102
Interior care ..............................................................7-108
Automatic climate control system ..............................4-123 Activate upon washer fluid use ..............................4-134
Air Conditioning refrigerant label ............................4-134
Automatic heating and air conditioning ..................4-124 Checking the amount of air conditioner refrigerant
and compressor lubricant ........................................4-132
Climate control air filter ..........................................4-132
Manual heating and air conditioning ........................4-125
System operation ......................................................4-130
Battery........................................................................\
....7-39 For best battery service ..............................................7-39
Recharging the battery ................................................7-40
Reset items ..................................................................7-41
Before driving ..................................................................5-5 Before entering vehicle ................................................5-5
Before starting ............................................................5-5
Necessary inspections ................................................5-5
Blind-Spot Collision Warning (BCW) ..........................5-68 Detecting sensor ..........................................................5-69
Function malfunction and limitations ........................5-73
Function operation ......................................................5-72
Function settings ........................................................5-70
Brake system..................................................................5-29 Anti-lock Brake System (ABS) ..................................5-34
Electronic Stability Control (ESC) ............................5-35
Good braking practices ..............................................5-42
Hill-start Assist Control (HAC) ..................................5-39
Parking brake ..............................................................5-31
Power brakes ............................................................5-29
A
B
SC PE USA Index.qxp 10/23/2020 6:23 PM Page 2
Page 525 of 534

I3
Index
Vehicle Stability Management (VSM)........................5-40
Brake/clutch fluid ..........................................................7-27 Checking the brake/clutch fluid level ........................7-27
Bulb wattage ....................................................................8-3
California perchlorate notice ......................................7-114
Checking fluid levels ....................................................7-20
Child Restraint System (CRS) ......................................3-27 Using a child restraint system ....................................3-28
Climate control air filter ................................................7-33 Filter inspection ..........................................................7-33
Consumer assistance (U.S. only) ..................................8-12
Cruise Control (CC) ......................................................5-87 Function operation ......................................................5-87
To decrease speed ......................................................5-88
To increase set speed ..................................................5-88
To resume the function ..............................................5-89
To temporarily pause the function ..............................5-89
FCC ....................................................................\
......4-155
The radio frequency components (Rear Corner Radar) complies ..................................................................5-104 Declaration of conformity ..........................................4-155
Defroster ......................................................................4-\
110
Rear window defroster ..............................................4-110
Dimensions ......................................................................8-\
2
Door locks......................................................................4-\
18 Auto door lock/unlock feature ....................................4-21
Child-protector rear door lock ....................................4-22
Impact sensing door unlock system ............................4-21
Operating door locks from inside the vehicle ............4-19
Operating door locks from outside the vehicle ........4-18
Rear Occupant Alert (ROA) system ..........................4-22
Speed sensing door lock system ................................4-21
Driver Attention Warning (DAW) ................................5-78 Basic function ............................................................5-78
Detecting sensor ..........................................................5-78
Function malfunction and limitations ........................5-84
Function operation ......................................................5-81
Function settings ........................................................5-79
Leading Vehicle Departure Alert function ..................5-78
Economical operation ..................................................5-105
Electrical Equipment (U.S. only) ..................................8-15
Emergency starting ..........................................................6-5 Jump starting ................................................................6-5
C
D
E
SC PE USA Index.qxp 10/23/2020 6:23 PM Page 3
Page 530 of 534

Index
8I
Manual climate control system ....................................4-111Activate upon washer fluid use ..............................4-122
Air Conditioning refrigerant label ............................4-121
Checking the amount of air conditioner refrigerant and compressor lubricant ........................................4-120
Climate control air filter ..........................................4-119
Heating and air conditioning ....................................4-112
System operation ......................................................4-117
Manual Transmission ....................................................5-17 Good driving practices ................................................5-20
Manual transmission operation ..................................5-17
Mirrors ........................................................................\
..4-48 Inside rearview mirror ................................................4-48
Outside rearview mirror ..............................................4-49
Online factory authorized manuals (U.S. only) ............8-16
Owner maintenance ........................................................7-7 Owner maintenance schedule ......................................7-7
Parking brake ................................................................7-30 Checking the parking brake ........................................7-30 Rear Cross-Traffic Collision Warning (RCCW) ..........5-96
Detecting sensor ..........................................................5-97
Function malfunction and limitations ........................5-99
Function operation ......................................................5-98
Functions settings ......................................................5-97
Rear View Monitor (RVM)............................................4-91
Recommended lubricants and capacities ........................8-7 Recommended SAE viscosity number ........................8-9
Refrigerant label ............................................................8-11
Reporting Safety Defects (U.S. only)............................8-16
Road warning ..................................................................6-2 Hazard warning flasher ................................................6-2
Scheduled maintenance service ......................................7-9 Scheduled maintenance service precaution ..................7-9
Seat ........................................................................\
..........3-4 Driver’s seat ..................................................................3-4
Front passenger’s seat ..................................................3-4
Front seat adjustment ....................................................3-7
Headrest (for front seat) ................................................3-8
Rear seat ........................................................................\
3-4
Rear seat adjustment ..................................................3-11
Seatback pocket ..........................................................3-10
S
R
P
O
SC PE USA Index.qxp 10/23/2020 6:23 PM Page 8
Page 532 of 534

Index
10I
Tire care ......................................................................7-\
42
Tire chains ..................................................................7-55
Tire maintenance ........................................................7-47
Tire pressure................................................................7-43
Tire replacement ........................................................7-46
Tire rotation ..............................................................7-44
Tire sidewall labeling..................................................7-47
Tire traction ................................................................7-47
Wheel alignment and tire balance ..............................7-45
Wheel replacement ....................................................7-47
Tires and wheels ..............................................................8-5
Towing ........................................................................\
..6-29 Emergency towing ......................................................6-31
Removable towing hook (front)..................................6-30
Towing service ............................................................6-29
Trailer towing ..............................................................5-116
Trip computer ................................................................4-59 Service Mode (for type A cluster) ..............................4-64
Trip information (Trip computer) ..............................4-59
Trunk (for 4 door) ..........................................................4-24 Opening the trunk ......................................................4-24
Closing the trunk ........................................................4-24
Emergency trunk safety release ..................................4-25
Vehicle break-in process ..................................................1-6
Vehicle certification label ..............................................8-10 Vehicle data collection and event data recorders ............1-7
Vehicle Identification Number (VIN)............................8-10
Vehicle load limit ........................................................5-117
Certification label ....................................................5-120
Tire and loading information label ..........................5-117
Vehicle modifications ......................................................1-6
Vehicle weight ............................................................5-122 Base curb weight ......................................................5\
-122
Cargo weight ............................................................5-122
GAW (Gross axle weight) ........................................5-122
GAWR (Gross axle weight rating) ..........................5-122
GVW (Gross vehicle weight) ..................................5-122
GVWR (Gross vehicle weight rating) ......................5-122
Vehicle curb weight ..................................................5-122
Warning and indicator lights..........................................4-79 Indicator Lights ..........................................................4-87
Warning lights ............................................................4-79
Washer fluid ..................................................................7-29 Checking the washer fluid level ................................7-29
Weight/volume ................................................................8-6
Windows ........................................................................\
4-33 Manual windows ........................................................4-38
Power windows ..........................................................4-34
Windshield defrosting and defogging..........................4-136 Automatic climate control system ............................4-137
W
V
SC PE USA Index.qxp 10/23/2020 6:23 PM Page 10