fuel cap Lancia Voyager 2012 Owner handbook (in English)

CAUTION!
The TPMS has been optimized for
the original equipment tires and
wheels. TPMS pressures and warn-
ing have been established for the tire
size equipped on your vehicle. Un-
desirable system operation or sensor
damage may result when using re-
placement equipment that is not of
the same size, type, and/or style.
Aftermarket wheels can cause sensor
damage. Do not use tire sealant from
a can or balance beads if your ve-
hicle is equipped with a TPMS, as
damage to the sensors may result.
9. Malfunction Indicator Light
(MIL) The Malfunction Indicator
Light (MIL) is part of an on-
board diagnostic system,
called OBD, that monitors en-
gine and automatic transmission con-
trol systems. The light will illuminate
when the key is in the ON/RUN posi-
tion, before engine start. If the bulb
does not come on when turning the
key from OFF to ON/RUN, have the
condition checked promptly. Certain conditions, such as a loose or
missing gas cap, poor fuel quality,
etc., may illuminate the MIL after en-
gine start. The vehicle should be ser-
viced if the light stays on through
several of your typical driving cycles.
In most situations, the vehicle will
drive normally and will not require
towing.
CAUTION!
Prolonged driving with the MIL on
could cause damage to the engine
control system. It also could affect
fuel economy and drivability. If the
MIL is flashing, severe catalytic con-
verter damage and power loss will
soon occur. Immediate service is re-
quired.
WARNING!
A malfunctioning catalytic con-
verter, as referenced above, can
reach higher temperatures than in
normal operating conditions. This
can cause a fire if you drive slowly or
park over flammable substances
such as dry plants, wood, cardboard,
etc. This could result in death or
serious injury to the driver, occu-
pants or others.
10. Electronic Stability Control
(ESC) Activation/Malfunction
Indicator Light (for versions/
markets, where provided) The “ESC Activation/
Malfunction Indicator
Light” in the instrument
cluster will come on when
the ignition switch is turned to the
ON/RUN position. It should go out
with the engine running. If the “ESC
Activation/Malfunction Indicator
Light” comes on continuously with
the engine running, a malfunction has
been detected in the ESC system. If
this light remains on after several ig-
nition cycles, and the vehicle has been
driven several kilometers at speeds
166

 Electronic Speed Control ReadyThis light will turn on when
the electronic speed control
is ready. For further infor-
mation, refer to “Electronic
Speed Control” in “Understanding
The Features Of Your Vehicle.”
 Electronic Speed Control SET This light will turn on when
the electronic speed control
is SET. For further infor-
mation, refer to “Electronic
Speed Control” in “Understanding
The Features Of Your Vehicle.”
EVIC AMBER TELLTALE
LIGHTS
This area will show reconfigurable
amber caution telltales. These tell-
tales include:
 Low Fuel Light
When the fuel level reaches ap-
proximately 11.0 L this light
will turn on, and remain on until
fuel is added.  Loose Gascap Indicator
If the vehicle diagnostic sys-
tem determines that the fuel
filler cap is loose, improp-
erly installed, or damaged,
a loose gascap indicator will display in
the telltale display area. Tighten the
fuel filler cap properly and press the
SELECT button to turn off the mes-
sage. If the problem continues, the
message will appear the next time the
vehicle is started.
A loose, improperly installed, or dam-
aged fuel filler cap may also turn on
the Malfunction Indicator Light
(MIL).
 Windshield Washer Fluid Low Indicator This light will turn on to
indicate the windshield
washer fluid is low.  Wait To Start Light — Diesel
Engines Only The Wait To Start Light will
turn on when the ignition key is
first turned to the ON/RUN position.
Wait until the Wait To Start Light
turns OFF to start the engine. (Refer
to “Starting Procedures” in “Starting
And Operating” for further informa-
tion).
 Water In Fuel Indicator Light — Diesel Engines Only Indicates there is water de-
tected in the fuel filter. If
this light remains on, DO
NOT start the vehicle be-
fore you drain the water from the fuel
filter to prevent engine damage. Refer
to “Maintenance Procedures/ Drain-
ing Fuel/Water Separator Filter” in
“Maintaining Your Vehicle” for water
drain procedure.
EVIC RED TELLTALE
LIGHTS
This area will show reconfigurable red
telltales. These telltales include:176

 TREAD WEAR INDICATORS . . . . . . . . . . . . . 248
 LIFE OF TIRE . . . . . . . . . . . . . . . . . . . . . . . . 248
 REPLACEMENT TIRES . . . . . . . . . . . . . . . . . 249
 TIRE CHAINS . . . . . . . . . . . . . . . . . . . . . . . . . . 249
 TIRE ROTATION RECOMMENDATIONS . . . . . . 250
 TIRE PRESSURE MONITOR SYSTEM (TPMS) . . 250  BASE SYSTEM . . . . . . . . . . . . . . . . . . . . . . . . 252
 PREMIUM SYSTEM (for versions/markets,where provided) . . . . . . . . . . . . . . . . . . . . . . . 254
 TPMS DEACTIVATION AND REACTIVATION . . . . . . . . . . . . . . . . . . . . . . . 256
 FUEL REQUIREMENTS — GASOLINE ENGINE . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 256
 METHANOL . . . . . . . . . . . . . . . . . . . . . . . . . . 257
 ETHANOL . . . . . . . . . . . . . . . . . . . . . . . . . . . 257
 CLEAN AIR GASOLINE . . . . . . . . . . . . . . . . . 257
 MMT IN GASOLINE . . . . . . . . . . . . . . . . . . . . 257
 MATERIALS ADDED TO FUEL . . . . . . . . . . . 258
 FUEL REQUIREMENTS — DIESEL ENGINE . . . 258
 ADDING FUEL . . . . . . . . . . . . . . . . . . . . . . . . . . 258  LOCKING FUEL FILLER CAP (GAS CAP)(for versions/markets, where provided) . . . . . 258
 TRAILER TOWING . . . . . . . . . . . . . . . . . . . . . . 259  COMMON TOWING DEFINITIONS . . . . . . . . . 259
223

WARNING!(Continued)
 Unequal tire pressures can cause
steering problems. You could lose
control of your vehicle.
 Unequal tire pressures from one
side of the vehicle to the other can
cause the vehicle to drift to the
right or left.
 Always drive with each tire in-
flated to the recommended cold
tire inflation pressure.
Economy
Improper inflation pressures can
cause uneven wear patterns to de-
velop across the tire tread. These ab-
normal wear patterns will reduce
tread life resulting in a need for earlier
tire replacement. Under-inflation,
also increases tire rolling resistance
resulting in higher fuel consumption.
Ride Comfort And Vehicle
Stability
Proper tire inflation contributes to a
comfortable ride. Over-inflation pro-
duces a jarring and uncomfortable
ride. TIRE INFLATION
PRESSURES
The proper cold tire inflation pressure
is listed on the
driver's side “B” Pillar
or rear edge of the driver's side door.
The tire pressure should be checked
and adjusted, and the tires inspected
for signs of wear or visible damage, at
least once a month. Use a good quality
pocket-type gauge to check tire pres-
sure. Do not make a visual judgement
when determining proper inflation.
Radial tires may look properly in-
flated, even when they are under-
inflated.
CAUTION!
After inspecting or adjusting the tire
pressure, always reinstall the valve
stem cap. This will prevent moisture
and dirt from entering the valve
stem, which could damage the valve
stem.
Inflation pressures specified on the
placard are always “cold tire inflation
pressure.” Cold tire inflation pressure
is defined as the tire pressure after the
vehicle has not been driven for at least three hours, or driven less than
1.6 km after a three-hour period. The
cold tire inflation pressure must not
exceed the maximum inflation pres-
sure molded into the tire sidewall.
Check tire pressures more often if
subject to a wide range of outdoor
temperatures, as tire pressures vary
with temperature changes.
Tire pressures change by approxi-
mately 0.07 BAR per 7° C of air tem-
perature change. Keep this in mind
when checking tire pressure inside a
garage, especially in the Winter.
Example: If garage temperature is
20°C and the outside temperature is
0°C, then the cold tire inflation pres-
sure should be increased by 0.21
BAR, which equals 0.07 BAR for ev-
ery 7°C for this outside temperature
condition.
Tire pressure may increase from 0.13
to 0.4 BAR during operation. Do not
reduce this normal pressure buildup
or your tire pressure will be too low.
245

MATERIALS ADDED TO
FUEL
Besides using unleaded gasoline with
the proper octane rating, gasolines
that contain detergents, corrosion and
stability additives are recommended.
Using gasolines that have these addi-
tives will help improve fuel economy,
reduce emissions, and maintain ve-
hicle performance.
Indiscriminate use of fuel system
cleaning agents should be avoided.
Many of these materials intended for
gum and varnish removal may con-
tain active solvents or similar ingredi-
ents. These can harm fuel system gas-
ket and diaphragm materials.WARNING!
Carbon monoxide (CO) in exhaust
gases is deadly. Follow the precau-
tions below to prevent carbon mon-
oxide poisoning:(Continued)
WARNING!(Continued)
 Do not inhale exhaust gases. They
contain carbon monoxide, a color-
less and odorless gas which can
kill. Never run the engine in a
closed area, such as a garage, and
never sit in a parked vehicle with
the engine running for an ex-
tended period. If the vehicle is
stopped in an open area with the
engine running for more than a
short period, adjust the ventila-
tion system to force fresh, outside
air into the vehicle.
 Guard against carbon monoxide
with proper maintenance. Have
the exhaust system inspected ev-
ery time the vehicle is raised.
Have any abnormal conditions re-
paired promptly. Until repaired,
drive with all side windows fully
open.
 Keep the liftgate closed when
driving your vehicle to prevent
carbon monoxide and other poi-
sonous exhaust gases from enter-
ing the vehicle. FUEL REQUIREMENTS
— DIESEL ENGINE
Use Premium Quality Diesel fuels
with a Cetane rating of 50 or higher,
and meeting the EN590 standard are
highly recommended. See your autho-
rized dealer for further information
regarding fuels available in your area.
ADDING FUEL
LOCKING FUEL FILLER
CAP (GAS CAP) (for
versions/markets, where
provided)
The locking fuel filler cap is located
behind the fuel filler door, on the left
side of the vehicle. If the cap is lost or
damaged, be sure the replacement cap
has been designed for use with this
vehicle.
NOTE:
The driver's side sliding door can-
not be opened while the fuel door
is open. This feature operates only
when the sliding door is fully
closed prior to opening the fuel
door.
258

1. Insert the fuel cap key into the key
cylinder and turn the key to the right
to unlock.
2. Turn the gas cap knob to the left to
remove the cap.
3. When tightening the filler cap,
tighten until two or three clicks are
heard to ensure that the cap is prop-
erly seated.CAUTION!
 Damage to the fuel system oremission control system could re-
sult from using an improper fuel
tank filler tube cap (gas cap). A
poorly fitting cap could let impu-
rities into the fuel system and may
cause the “Malfunction Indicator
Light (MIL)” to turn on due to
fuel vapors escaping from the sys-
tem.
 To avoid fuel spillage and overfill-
ing, do not “top off” the fuel tank
after filling.
WARNING!
 Never have any smoking materi-als lit in or near the vehicle when
the gas cap is removed or the tank
is being filled.
 Never add fuel when the engine is
running. This is in violation of
most local laws and may cause the
MIL to turn on.
 A fire may result if gasoline is
pumped into a portable container
that is inside of a vehicle. You
could be burned. Always place gas
containers on the ground while
filling.
NOTE:
 When the fuel nozzle “clicks” or shuts off, the fuel tank is full.
 Tighten the fuel filler cap until you hear a “clicking” sound.
This is an indication that the
fuel filler cap is properly tight-
ened.
 If the gas cap is not tightened properly, the MIL may come on.
Be sure the gas cap is tightened
every time the vehicle is refu-
eled. TRAILER TOWING
In this section you will find safety tips
and information on limits to the type
of towing you can reasonably do with
your vehicle. Before towing a trailer
carefully review this information to
tow your load as efficiently and safely
as possible.
To maintain warranty coverage, fol-
low the requirements and recommen-
dations in this manual concerning ve-
hicles used for trailer towing.
COMMON TOWING
DEFINITIONS
The following trailer towing related
definitions will assist you in under-
standing the following information:
Gross Vehicle Weight Rating
(GVWR)
The GVWR is the total allowable
weight of your vehicle. This includes
driver, passengers, cargo and trailer
tongue weight. The total load must be
limited so that you do not exceed the
GVWR.
259

CENTER HIGH-MOUNTED
STOP LAMP (CHMSL)
The CHMSL uses LED lights are not
serviceable. The CHMSL must be re-
placed as an assembly, see your au-
thorized dealer.LICENSE LAMP
There are two license plate lamps, and
they are located under the tailgate
lamp bar and above the license plate.
1. Remove the two lens assembly
mounting screws.2. Remove the bulb from the socket.
Replace the bulb and reattach the lens
assembly.
FLUID CAPACITIES
Metric
Fuel (Approximate) 76 Liters
Engine Oil with Filter
3.6L Engine 5.6 Liters
2.8L Diesel Engine 6.5 Liters
Cooling System *
3.6L Engine 12.6 Liters
2.8L Diesel Engine 13.8 Liters
* Includes heater and coolant recovery bottle filled to MAX level. Add 2.8 Liters for versions/markets, where provided
with a rear heater.
311

Bulbs, Light . . . . . . . . . . . 65,308
Calibration, Compass . . . 172,181
Camera, Rear . . . . . . . . . . . . 135
Capacities, Fluid . . . . . . . . . . 311
Caps, FillerFuel . . . . . . . . . . . . . . . . . 258
Oil (Engine) . . . . . . . . . . . . 286
Power Steering . . . . . . . . . . 238
Radiator (Coolant
Pressure) . . . . . . . . . . . . . . 297
Car Washes . . . . . . . . . . . . . . 301
Carbon Monoxide Warning . . . . 63
Cargo (Vehicle Loading) . . . . . 148
Cargo Compartment Luggage Carrier . . . . . . . . . 153
Caution, Exhaust Gas . . . . . . . 33
Cellular Phone . . . . . . . . . 82,208
Center High Mounted Stop
Light . . . . . . . . . . . . . . . . . . 311
Chains, Tire . . . . . . . . . . . . . 249
Changing A Flat Tire . . . . . . . 269
Check Engine Light
(Malfunction Indicator
Light) . . . . . . . . . . . . . . . . . . 166
Checking Your Vehicle For
Safety . . . . . . . . . . . . . . . . . . . 63
Checks, Safety . . . . . . . . . . . . . 63
Child Restraint . . . . . . . . 53,56,57 Child Restraint Tether
Anchors . . . . . . . . . . . . . . . . . 58
Child Safety Locks . . . . . . . . . . 31
Child Seat . . . . . . . . . . . . . . . . 62
Clean Air Gasoline . . . . . . . . . 257
Cleaning
Wheels . . . . . . . . . . . . . . . 302
Climate Control . . . . . . . . . . . 209
Coat Hook . . . . . . . . . . . . . . 148
Coin Holder . . . . . . . . . . . . . 148
Cold Weather Operation . . . . . 227
Compact Disc (CD)
Maintenance . . . . . . . . . . . . . 208
Compact Spare Tire . . . . . . . . 247
Compass . . . . . . . . . 170,172,180
Compass Calibration . . . . 172,181
Compass Variance . . . . . . 170,181
Computer, Trip/Travel . . . . . . 179
Connector
UCI . . . . . . . . . . . . . . . . . . 187
Universal Consumer
Interface (UCI) . . . . . . . . . . 187
Conserving Fuel . . . . . . . . . . . 178
Console . . . . . . . . . . . . . . . . . 148
Console, Floor . . . . . . . . . . . . 148
Console, Overhead . . . . . . . . . 136
Console, Removable . . . . . . . . 150
Cool Down, Turbo . . . . . . . . . 229 Coolant Pressure Cap
(Radiator Cap) . . . . . . . . . . . 297
Cooling System . . . . . . . . . . . 295
Adding Coolant
(Antifreeze) . . . . . . . . . . . . 296
Coolant Capacity . . . . . . . . 311
Coolant Level . . . . . . . 295,297
Disposal of Used Coolant . . . 297
Drain, Flush, and Refill . . . . 296
Inspection . . . . . . . . . . . . . 297
Points to Remember . . . . . . 298
Pressure Cap . . . . . . . . . . . 297
Radiator Cap . . . . . . . . . . . 297
Selection of Coolant
(Antifreeze) . . . . . 296,311,312
Cupholders . . . . . . . . . . . 144,303
Data Recorder, Event . . . . . . . . 52
Defroster, Rear Window . . . . . 152
Defroster, Windshield . . . . 64,217
Diagnostic System, Onboard . . 287
Diesel Fuel . . . . . . . . . . . 258,312
Diesel Fuel Requirements . . . . 258
Dimmer Control . . . . . . . . . . 120
Dipsticks Automatic Transaxle . . . . . . 300
Oil (Engine) . . . . . . . . . . . . 288
Power Steering . . . . . . . . . . 238
Disabled Vehicle Towing . . . . . 281
327

DisposalAntifreeze (Engine
Coolant) . . . . . . . . . . . . . . 297
Engine Oil . . . . . . . . . . . . . 289
Domelight . . . . . . . . . . . . . . . 120
Door Locks . . . . . . . . . . . . . . . 22
Door Locks, Automatic . . . . . . 23
Driving On Slippery Surfaces . . . . . 236
Through Flowing, Rising, or
Shallow Standing Water . . . 236
Driving to Achieve Maximum
Fuel Economy . . . . . . . . . . . . 178
Electric Remote Mirrors . . . . . . 76
Electrical Power Outlets . . . . . 141
Electronic Brake Control
System . . . . . . . . . . . . . . . . . 241 Brake Assist System . . . . . . 242
Electronic Speed Control
(Cruise Control) . . . . . . . . . . 128
Electronic Stability Control
(ESC) . . . . . . . . . . . . . . . . . . 242
Electronic Vehicle Information
Center (EVIC) . . . . . . . . 135,172
Emergency, In Case of Hazard Warning Flasher . . . 268
Jacking . . . . . . . . . . . . 269,272
Jump Starting . . . . . . . . . . 277 Overheating . . . . . . . . . . . . 268
Engine . . . . . . . . . . . . . . . . . 286 Air Cleaner . . . . . . . . . . . . 289
Break-In Recommendations . . 62
Checking Oil Level . . . . . . . 288
Compartment . . . . . . . . . . . 285
Compartment
Identification . . . . . . . . . . . 285
Coolant (Antifreeze) . . . . . . 312
Cooling . . . . . . . . . . . . . . . 295
Exhaust Gas Caution . . . . 33,63
Fails to Start . . . . . . . . . . . 227
Flooded, Starting . . . . . . . . 227
Fuel Requirements . . . . . . . 311
Oil . . . . . . . . . . . . 288,311,312
Oil Change Interval . . . . . . 288
Oil Disposal . . . . . . . . . . . . 289
Oil Filler Cap . . . . . . . . . . . 286
Oil Filter Disposal . . . . . . . 289
Oil Selection . . . . . . . . 288,311
Oil Synthetic . . . . . . . . . . . 289
Overheating . . . . . . . . . . . . 268
Starting . . . . . . . . . . . . . . . 225
Temperature Gauge . . . . . . 169
Enhanced Accident Response
Feature . . . . . . . . . . . . . . . . . . 50
Entry System, Illuminated . . . . 18
Event Data Recorder . . . . . . . . 52
Exhaust Gas Caution . . 33,63,290 Exhaust System . . . . . . . . 63,290
Exterior Folding Mirrors . . . . . . 76
Exterior Lights . . . . . . . . . . . . 65
Fabric Care . . . . . . . . . . . . . . 302
Filler Location Fuel . . . . . . . . 167
Filters
Air Cleaner . . . . . . . . . . . . 289
Air Conditioning . . . . . 220,293
Engine Oil . . . . . . . . . . 289,312
Engine Oil Disposal . . . . . . 289
Flash-To-Pass . . . . . . . . . . . . 123
Flashers Hazard Warning . . . . . . . . . 268
Turn Signal . . . . . . . 65,164,309
Flooded Engine Starting . . . . . 227
Floor Console . . . . . . . . . . . . 148
Fluid Capacities . . . . . . . . . . . 311
Fluid Leaks . . . . . . . . . . . . . . 65
Fluid Level Checks Automatic Transaxle . . . . . . 300
Brake . . . . . . . . . . . . . 299,313
Power Steering . . . . . . 238,313
Fluid, Brake . . . . . . . . . . . . . 313
Fluids . . . . . . . . . . . . . . . . . . 312
Fluids, Lubricants and
Genuine Parts . . . . . . . . . . . . 312
Fog Light Service . . . . . . . . . . 310
Fog Lights . . . . . . . . 122,164,310
328

Fog Lights, Rear . . . . . . . . . . 169
Fold in Floor (Stow `n Go)
Seating . . . . . . . . . . . . . . . . . 108
Freeing A Stuck Vehicle . . . . . 279
Fuel . . . . . . . . . . . . . . . . 256,258Adding . . . . . . . . . . . . . . . 258
Additives . . . . . . . . . . . . . . 258
Conserving . . . . . . . . . . . . 178
Diesel . . . . . . . . . . . . . 258,312
Filler Cap (Gas Cap) . . 167,258
Filler Door (Gas Cap) . . . . . 167
Gasoline . . . . . . . . . . . . . . 256
Gauge . . . . . . . . . . . . . . . . 167
Light . . . . . . . . . . . . . . . . . 176
Octane Rating . . . . . . . 256,312
Requirements . . . . . . . . . . . 311
Saver Mode . . . . . . . . . . . . 178
Specifications . . . . . . . . . . . 312
Tank Capacity . . . . . . . . . . 311
Fuel Optimizer . . . . . . . . . . . 178
Fuel Saver . . . . . . . . . . . . . . . 178
Fueling . . . . . . . . . . . . . . . . . 258
Fuses . . . . . . . . . . . . . . . . . . 304
Gas Cap (Fuel Filler Cap) . . . . 258
Gasoline (Fuel) . . . . . . . . . . . 256 Conserving . . . . . . . . . . . . 178
Gasoline, Clean Air . . . . . . . . 257 Gauges
Coolant Temperature . . . . . 169
Fuel . . . . . . . . . . . . . . . . . 167
Speedometer . . . . . . . . . . . 167
Tachometer . . . . . . . . . . . . 164
Gear Ranges . . . . . . . . . . . . . 232
Gear Select Lever Override . . . 280
General Information . . . . . . 16,22
Glass Cleaning . . . . . . . . . . . . 303
Gross Axle Weight Rating . . . . 260
Gross Vehicle Weight Rating . . 259
Hands-Free Phone
(Uconnect™) . . . . . . . . . . . . . 82
Hazard
Driving Through Flowing,
Rising, or Shallow Standing
Water . . . . . . . . . . . . . . . . 236
Hazard Warning Flasher . . . . . 268
Head Restraints . . . . . . . . . . . 106
Headlight Washers . . . . . . . . . 126
Headlights . . . . . . . . . . . . . . 120 Cleaning . . . . . . . . . . . . . . 303
Leveling . . . . . . . . . . . . . . 124
Lights On Reminder . . . . . . 122
Passing . . . . . . . . . . . . . . . 123
Time Delay . . . . . . . . . . . . 121
Washers . . . . . . . . . . . 121,126
Heated Mirrors . . . . . . . . . . . . 76 Heated Seats . . . . . . . . . . . . . 104
Heater . . . . . . . . . . . . . . . . . 209
High Beam/Low Beam Select
(Dimmer) Switch . . . . . . . . . . 123
Hood Release . . . . . . . . . . . . 118
Hook, Coat . . . . . . . . . . . . . . 148
Ignition . . . . . . . . . . . . . . . . . 14
Key . . . . . . . . . . . . . . . . 13,14
Ignition Key Removal . . . . . . . . 14
Illuminated Entry . . . . . . . . . . 18
Immobilizer (Sentry Key) . . . . . 15
Infant Restraint . . . . . . . . . . . . 56
Information Center, Vehicle . . 172
Inside Rearview Mirror . . . . . . . 75
Instrument Cluster . . . . . 162,164
Instrument Panel and
Controls . . . . . . . . . . . . . . . . 161
Instrument Panel Cover . . . . . 302
Instrument Panel Lens
Cleaning . . . . . . . . . . . . . . . . 303
Integrated Power Module
(Fuses) . . . . . . . . . . . . . . . . . 304
Interior Appearance Care . . . . 302
Interior Lights . . . . . . . . 119,120
Intervention Regeneration
Strategy . . . . . . . . . . . . . . . . 290
Introduction . . . . . . . . . . . . . . . 4
329