ECU MAZDA MODEL CX-5 2015 (in English) Workshop Manual

Black plate (431,1)
3. Turn the spare tire hold-down boltcounterclockwise.
Spare tire hold-down bolt
To secure the spare tire
Store the spare tire in the reverse order of
removal. After storing, verify that the
spare tire is stored securely.
Changing a Flat Tire
NOTE
If the following occurs while driving, it could
indicate a flat tire.
lSteering becomes difficult.lThe vehicle begins to vibrate excessively.lThe vehicle pulls in one direction.
If you have a flat tire, drive slowly to a
level spot that is well off the road and out
of the way of traffic to change the tire.
Stopping in traffic or on the shoulder of a
busy road is dangerous.
WARNING
Be sure to follow the directions for
changing a tire: Changing a tire is dangerous if not
done properly. The vehicle can slip off
the jack and seriously injure
someone.
No person should place any portion
of their body under a vehicle that is
supported by a jack.
Never allow anyone inside a vehicle
supported by a jack: Allowing someone to remain in a
vehicle supported by a jack is
dangerous. The occupant could cause
the vehicle to fall resulting in serious
injury.
NOTE
Make sure the jack is well lubricated before
using it.
1. Park on a level surface off the right-of- way and firmly set the parking brake.
2. Put a vehicle with an automatic transaxle in Park (P), a manual
transaxle in Reverse (R) or 1, and turn
off the engine.
If Trouble Arises
Flat Tire
7-7
CX-5_8DR2-EA-14A_Edition1 Page431
Thursday, November 21 2013 8:50 AM
Form No.8DR2-EA-14A

Black plate (437,1)
4. Turn the lug wrench counterclockwiseand lower the vehicle. Use the lug
wrench to tighten the nuts in the order
shown.
If you are unsure of how tight the nuts
should be, have them inspected at an
Authorized Mazda Dealer.
Nut tightening torque
N·m (kgf·m, ft·lbf) 108
―147
(12 ―14, 80 ―108)
WARNING
Always securely and correctly tighten
the lug nuts:
Improperly or loosely tightened lug
nuts are dangerous. The wheel could
wobble or come off. This could result
in loss of vehicle control and cause a
serious accident.
Be sure to reinstall the same nuts you
removed or replace them with metric
nuts of the same configuration: Because the wheel studs and lug nuts
on your Mazda have metric threads,
using a non-metric nut is dangerous.
On a metric stud, it would not secure
the wheel and would damage the
stud, which could cause the wheel to
slip off and cause an accident. 5.
(Aluminum wheel equipped vehicle)
Remove the center cap by tapping it
with the lug wrench.
6. Store the damaged tire, using the tire hold-down bolt to hold it in place.
Tire hold-down bolt
7. Remove the tire blocks and store thetools and jack.
8. Check the inflation pressure. Refer to Tires on page 9-8.
9. Have the flat tire repaired or replaced as soon as possible.
WARNING
Do not drive with any tires that have
incorrect air pressure: Driving on tires with incorrect air
pressure is dangerous. Tires with
incorrect pressure could affect
handling and result in an accident.
When you check the regular tires' air
pressure, check the spare tire, too.
NOTE
To prevent the jack and tool from rattling, store
them properly.
If Trouble Arises
Flat Tire
7-13
CX-5_8DR2-EA-14A_Edition1 Page437
Thursday, November 21 2013 8:50 AM
Form No.8DR2-EA-14A

Black plate (440,1)
5. Start the engine of the booster vehicleand run it a few minutes. Then start the
engine of the other vehicle.
6. When finished, carefully disconnect the cables in the reverse order described in
the illustration.
7. If the battery cover has been removed, install it in the reverse order of
removal.
NOTE
Verify that the covers are securely installed.
7-16
If Trouble Arises
Battery Runs Out
CX-5_8DR2-EA-14A_Edition1 Page440
Thursday, November 21 2013 8:50 AM
Form No.8DR2-EA-14A

Black plate (445,1)
CAUTION
ØDo not tow the vehicle pointed
backward with driving wheels on
the ground. This may cause
internal damage to the transaxle.
ØDo not tow with sling-type
equipment. This could damage
your vehicle. Use wheel-lift or
flatbed equipment.
Tiedown Hooks
CAUTION
Do not use the front and rear
tiedown eyelets for towing the
vehicle.
They have been designed only for
securing the vehicle to a transport
vessel during shipping.
Using the eyelets for any other
purpose could result in the vehicle
being damaged.
qTiedown Hooks
1. Remove the tiedown eyelet and the lug
wrench from the luggage compartment
(page 7-3).
2. Wrap a flathead screwdriver or similar tool with a soft cloth to prevent
damage to a painted bumper, and open
the cap located on the front or rear
bumper.
Front
If Trouble Arises
Emergency Towing
7-21
CX-5_8DR2-EA-14A_Edition1 Page445
Thursday, November 21 2013 8:50 AM
Form No.8DR2-EA-14A

Black plate (446,1)
Rear
CAUTION
Do not use excessive force as it may
damage the cap or scratch the
painted bumper surface.
NOTE
Remove the cap completely and store it so as
not to lose it.
3. Securely install the tiedown eyelet using the lug wrench.
Front
Tiedown eyelet
(Long type)
Lug wrench
Rear
Tiedown eyelet
(Short type)
Lug wrench
4. Hook the tying rope to the tiedown eyelet.
CAUTION
If the tiedown eyelet is not securely
tightened, it may loosen or disengage
from the bumper when tying the
vehicle. Make sure that the tiedown
eyelet is securely tightened to the
bumper.
7-22
If Trouble Arises
Emergency Towing
CX-5_8DR2-EA-14A_Edition1 Page446
Thursday, November 21 2013 8:50 AM
Form No.8DR2-EA-14A

Black plate (450,1)
The check engine light may illuminate in
the following cases:
lThe fuel tank level being very low or
approaching empty.
lThe engine's electrical system has a
problem.
lThe emission control system has a
problem.
l(U.S.A. and Canada)
The fuel-filler cap is missing or not
tightened securely.
If the check engine light remains on, or it
flashes continuously, do not drive at high
speeds and consult an Authorized Mazda
Dealer as soon as possible.
q If the high engine coolant
temperature warning light (red)
illuminates or flashes
The light flashes when the engine coolant
temperature is extremely high, and
illuminates when the engine coolant
temperature increases further.
Handling Procedure
Flashing light
Drive slowly to reduce engine load until
you can find a safe place to stop the
vehicle and wait for the engine to cool
down. Illuminated light
This indicates the possibility of
overheating. Park the vehicle in a safe
place immediately and stop the engine.
Refer to Overheating (page 7-18).
CAUTION
Do not drive the vehicle with the high
engine coolant temperature warning
light illuminated. Otherwise, it could
result in damage to the engine.
q
If the AWD warning indication/
warning light is indicated
Type A
The warning indication will display under
the following conditions;
lThere is an abnormality with the AWD
system.
lThere is too much difference in tire
radius between the front and rear
wheels.
lThe differential oil temperature is
abnormally high.
lThere is a continuous large difference
between front and rear wheel rotation,
such as when trying to pull away from
an icy surface or when trying to
remove the vehicle from mud, sand or
similar conditions.
When “4WD system inspection
required ”is indicated
Contact an Authorized Mazda Dealer.
7-26
If Trouble Arises
Warning/Indicator Lights and Warning Sounds
CX-5_8DR2-EA-14A_Edition1 Page450
Thursday, November 21 2013 8:50 AM
Form No.8DR2-EA-14A

Black plate (455,1)
qIf the low engine coolant
temperature indicator light (blue)
does not turn off
If the low engine coolant temperature
indicator light remains illuminated after
the engine has been sufficiently warmed
up, the temperature sensor could have a
malfunction. Consult an Authorized
Mazda Dealer.
qIf the turn signal/hazard warning
indicator light illuminates or flashes
at an abnormally high speed
If an indicator light remains illuminated
(does not flash) or if it flashes abnormally,
one of the turn signal bulbs may be
burned out. Consult an Authorized Mazda
Dealer.
qIf the security indicator light
illuminates or flashes
If the engine does not start with the
correct key, and the security indicator
light keeps illuminating or flashing, the
system may have a malfunction. Consult
an Authorized Mazda Dealer.
qIf the blind spot monitoring (BSM)
system OFF indicator light flashesí
The indicator light flashes if the BSM
system has a malfunction. Consult an
Authorized Mazda Dealer.
NOTE
If the vehicle is driven on a road with less
traffic and few vehicles that the radar sensors
can detect, the system may pause (The BSM
OFF indicator light in the instrument panel
flashes). However, it does not indicate a
malfunction.
If Trouble Arises
Warning/Indicator Lights and Warning Sounds
7-31íSome models.
CX-5_8DR2-EA-14A_Edition1 Page455
Thursday, November 21 2013 8:50 AM
Form No.8DR2-EA-14A

Black plate (527,1)
C
Capacities ............................................ 9-5
Carbon Monoxide ............................. 3-23
Cargo Securing Loops ..................... 5-119
Cell Phones ....................................... 8-20
Center Console ................................ 5-119
Child RestraintChild-restraint system
installation .................................. 2-28
Installing child-restraint
systems ....................................... 2-29
LATCH child-restraint
systems ....................................... 2-36
Child Safety Locks for Rear Doors ... 3-18
Climate Control System ...................... 5-2 Fully Automatic Type .................. 5-9
Gas specifications ........................ 9-7
Manual Type ................................ 5-5
Operating Tips .............................. 5-2
Vent Operation ............................. 5-3
Clock ............................................... 5-113
Cruise Control ................................... 4-89
Cruise Control Set Vehicle Speed ..... 4-15
Cup Holder ...................................... 5-116
Customer Assistance ........................... 8-2
D
Dashboard Illumination .................... 4-13
Daytime Running Lights ................... 4-59
Defogger Mirror ......................................... 4-66
Rear window .............................. 4-66
Dimensions ......................................... 9-5
Door Locks ....................................... 3-10
Driving In Flooded Area ................... 3-43
Driving on Uneven Road .................. 3-44
D
Driving Tips ...................................... 3-39 Automatic transaxle ................... 4-53
Break-in period .......................... 3-39
Driving in flooded area .............. 3-43
Driving on uneven road ............. 3-44
Floor mat .................................... 3-40
Hazardous driving ...................... 3-40
Money-saving suggestions ......... 3-39
Overloading ............................... 3-43
Rocking the vehicle .................... 3-41
Winter driving ............................ 3-41
Dynamic Stability Control (DSC) ..... 4-84
E
Emergency Starting Push-Starting .............................. 7-17
Starting a Flooded Engine .......... 7-17
Emergency Towing Tiedown Hooks .......................... 7-21
Towing Description .................... 7-20
Emission Control System .................. 3-22
Engine Coolant ....................................... 6-23
Engine Compartment
Overview .................................... 6-20
Exhaust gas ................................ 3-23
Hood release .............................. 6-18
Oil .............................................. 6-21
Starting ......................................... 4-3
Essential information .......................... 6-2
Event Data Recorder ......................... 8-21
Exhaust Gas ...................................... 3-23
Index
10-3
CX-5_8DR2-EA-14A_Edition1 Page527
Thursday, November 21 2013 8:50 AM
Form No.8DR2-EA-14A

Black plate (528,1)
E
Exterior Care ..................................... 6-56Aluminum Wheel
Maintenance ............................... 6-60
Bright-Metal Maintenance ......... 6-59
Maintaining the Finish ............... 6-57
Plastic Part Maintenance ............ 6-61
F
FlasherHazard warning .......................... 4-67
Headlights .................................. 4-55
Flat Tire ............................................... 7-3 Mounting the Spare Tire ............ 7-12
Floor Mat .......................................... 3-40
Fluid Brake/Clutch .............................. 6-25
Washer ........................................ 6-25
Fluids Classification ................................ 9-4
Fog Lights ......................................... 4-60
Foot Brake ........................................ 4-71
Front Seat ............................................ 2-5
Fuel Filler lid and cap ........................ 3-24
Gauge ......................................... 4-13
Requirements ............................. 3-21
Tank capacity ............................... 9-5
G
Gauges .............................................. 4-10
Glove Compartment ........................ 5-118
H
Hazard Warning Flasher .................... 4-67
Hazardous Driving ............................ 3-40
H
Head Restraint .................................. 2-12
Headlights
Control ....................................... 4-55
Flashing ...................................... 4-58
High-low beam .......................... 4-58
Leveling ..................................... 4-59
Hill Launch Assist (HLA) ................. 4-74
HomeLink Wireless Control
System .............................................. 4-68
Hood Release .................................... 6-18
Horn .................................................. 4-67
I
Ignition
Switch .......................................... 4-2
Illuminated Entry System ................ 5-112
Immobilizer System .......................... 3-35
Indicator Lights
AFS OFF .................................... 4-40
BSM OFF ................................... 4-43
Cruise ......................................... 4-42
Hazard warning .......................... 4-42
Headlight high-beam .................. 4-42
KEY ............................................ 4-38
Lights-on .................................... 4-43
Low engine coolant
temperature ................................ 4-41
Power steering malfunction ........ 4-33
Security ...................................... 4-42
Shift position .............................. 4-41
Smart City Brake Support
(SCBS) OFF ............................... 4-41
TCS OFF .................................... 4-40
TCS/DSC ................................... 4-40
Turn signal ................................. 4-42
Wrench ....................................... 4-40
10-4
Index
CX-5_8DR2-EA-14A_Edition1 Page528
Thursday, November 21 2013 8:50 AM
Form No.8DR2-EA-14A

Black plate (530,1)
O
Owner MaintenanceClosing the Hood ....................... 6-19
Engine Compartment
Overview .................................... 6-20
Opening the Hood ...................... 6-18
Owner Maintenance
Precautions ................................. 6-16
Replace Electrical Battery .......... 6-33
P
Parking Brake ................................... 4-72
Personalization Features ................... 9-10
Power Steering .................................. 4-88
Power Windows ................................ 3-30
R
Rear Coat Hooks ............................. 5-119
Rear Door Child Safety Locks .......... 3-18
Rear Seat ............................................. 2-8
Rear View Monitor ......................... 4-101
Rear Window Defogger .................... 4-66
Rear Window Washer ....................... 4-65
Rear Window Wiper .......................... 4-65
Rearview Mirror ................................ 3-28
Recommended Oil ............................ 6-21
Recreational Towing ......................... 3-53
Registering Your Vehicle in A Foreign
Country ............................................. 8-18
ReplacementElectrical battery ......................... 6-33
Fuse ............................................ 6-49
Light Bulbs ................................ 6-40
Tires ........................................... 6-37
Wheel ......................................... 6-38
Wiper .......................................... 6-27
Rocking the Vehicle .......................... 3-41
S
Safety Defects, Reporting ................. 8-14
Satellite Radio ................................... 5-44
Scheduled Maintenance ...................... 6-4
Seat Belt System 3-point type ................................ 2-17
Automatic locking ...................... 2-16
Emergency locking .................... 2-16
Extender ..................................... 2-21
Pregnant women ........................ 2-16
Seats Front seat ...................................... 2-5
Head restraint ............................. 2-12
Rear seat ....................................... 2-8
Seat warmer .................................. 2-7
Security System Immobilizer system .................... 3-35
Theft-deterrent system ............... 3-37
Service Publications .......................... 8-48
Smart City Brake Support (SCBS) .... 4-76 Laser Sensor Handling ............... 4-79
Stopping The Smart City Brake
Support
(SCBS) System Operation ......... 4-81
Spare Tire ............................................ 7-5
Specifications ...................................... 9-4
Speedometer ...................................... 4-11
SRS Air Bags Front passenger occupant
classification system .................. 2-56
How the SRS air bags work ....... 2-49
Limitations to SRS air bag ......... 2-54
Monitoring ................................. 2-62
SRS air bag deployment
criteria ........................................ 2-53
Supplemental restraint system
components ................................ 2-47
Starting the Engine .............................. 4-3
10-6
Index
CX-5_8DR2-EA-14A_Edition1 Page530
Thursday, November 21 2013 8:50 AM
Form No.8DR2-EA-14A