engine MAZDA MODEL TRIBUTE 2002 (in English) Manual Online

TRANSMISSION FLUID
Checking automatic transmission fluid
Refer to your scheduled maintenance section for scheduled intervals for
fluid checks and changes. Your transaxle does not consume fluid.
However, the fluid level should be checked if the transaxle is not working
properly, i.e., if the transaxle slips or shifts slowly or if you notice some
sign of fluid leakage.
Automatic transmission fluid expands when warmed. To obtain an
accurate fluid check, drive the vehicle until it is warmed up
(approximately 30 km [20 miles]). If your vehicle has been
operated for an extended period at high speeds, in city traffic
during hot weather or pulling a trailer, the vehicle should be
turned off for about 30 minutes to allow fluid to cool before
checking.
1. Drive the vehicle 30 km (20 miles) or until it reaches normal
operating temperature.
2. Park the vehicle on a level surface and engage the parking brake.
3. With the parking brake engaged and your foot on the brake pedal,
start the engine and move the gearshift lever through all of the gear
ranges. Allow sufficient time for each gear to engage.
4. Latch the gearshift lever in P (Park) and leave the engine running.
5. Remove the dipstick, wiping it clean with a clean, dry lint free rag. If
necessary, refer toIdentifying components in the engine
compartmentin this chapter for the location of the dipstick.
6. Install the dipstick making sure it is fully seated in the filler tube.
7. Remove the dipstick and inspect the fluid level. The fluid should be
in the crosshatch zone for normal operating temperature.
Low fluid level
Do not drive the vehicle if the fluid
level is at the bottom of the dipstick
and the outside temperatures are
above 10ÉC (50ÉF).
Correct fluid level
The transmission fluid should be checked at normal operating
temperatures 66ÉC-77ÉC (150ÉF-170ÉF) on a level surface. The normal
operating temperature can be reached after approximately 30 km (20
miles) of driving.
Maintenance and Specifications
236

WARNING: Do not start your engine with the air cleaner
removed and do not remove it while the engine is running.
Changing the air filter element
1. Loosen the clamp that secures the air inlet tube to the engine air
filter cover and disconnect the tube from the cover.
2. Release the clamps that secure the air filter housing cover.
3. Carefully separate the two halves of the air filter housing.
4. Remove the air filter element from the air filter housing.
5. Wipe the air filter housing and cover clean to remove any dirt or
debris and to ensure good sealing.
6. Install a new air filter element.
Be careful not to crimp the filter
element edges between the air
filter housing and cover. This
could cause filter damage and
allow unfiltered air to enter the
engine if not properly seated.
7. Replace the air filter housing cover and secure the clamps.
8. Replace the air inlet tube and secure the clamp.
Note:Failure to use the correct air filter element may result in severe
engine damage. The customer warranty may be voided for any damage to
the engine if the correct air filter element is not used.
INFORMATION ABOUT UNIFORM TIRE QUALITY GRADING
New vehicles are fitted with tires
that have a rating on them called
Tire Quality Grades. The Quality
grades can be found where
applicable on the tire sidewall
between tread shoulder and
maximum section width. For
example:
²Treadwear 200 Traction AA Temperature A
Maintenance and Specifications
239

Drive cautiously. If you hear the chains rub or bang against the
vehicle, stop and retighten them. If this does not work, remove
the cables to prevent vehicle damage.
²Avoid overloading your vehicle.
²Remove the tire chains when they are no longer needed.
²Do not use chains on dry roads.
²The suspension insulation and bumpers will help prevent vehicle
damage. Do not remove these components from the vehicle when
using snow tires and traction devices.
²Do not exceed 48 km/h (30 mph) with tire chains on your vehicle.
REFILL CAPACITIES
Fluid Classification Application Capacity
Brake fluid High
Performance
DOT 3 Motor
Vehicle Brake
FluidAll Fill to line on
reservoir
Engine oil
(including filter
change)SAE 5W-20 2.0L I4 Zetec
engine4.25L (4.5
quarts)
3.0L V6 Duratec
engine5.2L (5.5
quarts)
Fuel tank N/A 2.0L I4 Zetec
engine57L (15 gallons)
3.0L V6 Duratec
engine61L (16 gallons)
Power steering
fluidMERCONtAll Fill to line on
reservoir
Maintenance and Specifications
244

Fluid Classification Application Capacity
Transmission
fluid
1API service GL-4
or GL-5, SAE
75W-90Manual transaxle
(2WD)2.7L (2.85
quarts)2
Manual transaxle
(4X4)2.2L (2.32
quarts)2
MERCONtATF 3.0L engine with
Automatic
transaxle and oil
cooler12.7L (13.4
quarts)3
Transfer Case SAE 75W-140
Synthetic
Lubricant4X4 (Automatic) 0.35L (12
ounces)
API service
GL-5, SAE
80W-904X4 (Manual) 0.35L (12
ounces)
Engine coolant
4Mazda
green-colored or
yellow-colored
Premium Engine
Coolant2.0L I4 Zetec
engine with
manual
transaxle5.0L (5.3
quarts)
3.0L V6 Duratec
engine with
automatic
transaxle10.0L (10.6
quarts)
Rear axle
lubricantSAE 80W-90
Premium Rear
Axle Lubricant4X4 1.4L (2.96 pints)
5
Windshield
washer fluidn/a All 2.6L (2.7
quarts)
1Ensure the correct automatic transmission fluid is used. Transmission
fluid requirements are indicated on the dipstick or on the dipstick
handle. MERCONtand MERCONtV are not interchangeable. DO NOT
mix MERCONtand MERCONtV. Refer to your scheduled maintenance
section to determine the correct service interval.
2Service refill capacity is determined by filling the transmission to the
bottom of the filler hole with the vehicle on a level surface.
Maintenance and Specifications
245

3Indicates only approximate dry-fill capacity. Some applications may vary
based on cooler size and if equipped with an in-tank cooler. The amount
of transmission fluid and fluid level should be set by the indication on
the dipstick's normal operating range.
4Add the coolant type originally equipped in your vehicle. DO NOT USE
Extended Life Engine Coolant (orange in color). Refer toAdding engine
coolantin this chapter.
5Fill to 6 mm to 14 mm (1/4 inch to 9/16 inch) below bottom of fill hole.
For further information on your lubrication specifications, see your
authorized Mazda dealer.
WHEEL AND TIRE SIZES
Vehicle
GradeWheel Tire Spare
WheelSpare Tire
DX/DX-V6 6.5JJx16 215/70R16 17x4T 135/90R17
LX-V6/ES-V6 7.0JJx16 235/70R16 17x4T 145/90R17
ENGINE SPECIFICATIONS
Engine 2.0L DOHC I4 Zetec
engine3.0L DOHC V6
Duratec engine
Cubic inches 121 181
Required fuel 87 octane 87 octane
Firing order 1-3-4-2 1-4-2-5-3-6
Spark plug gap 1.22-1.32 mm
(0.048-0.052 inch)1.32-1.42 mm
(0.052-00.056 inch)
Ignition system DIS Coil on plug
Compression ratio 9.6:1 10.0:1
Maintenance and Specifications
246

Vehicle identification number
The vehicle identification number is
attached to a metal tag and is
located on the driver side
instrument panel. (Please note that
in the graphic XXXX is
representative of your vehicle
identification number.)
Engine number
The engine number (the last eight numbers of the vehicle identification
number) is stamped on the engine block, transmission, frame and
transfer case (if equipped).
XXXXXXXXXXXXXXXXX
Maintenance and Specifications
249

A
ABS (see Brakes) .....................135
Air bag supplemental restraint
system ................................109, 114
and child safety seats ............111
description ......................109, 114
disposal ............................113, 117
driver air bag ..................111, 116
indicator light ...........12, 113, 117
operation .........................111, 116
passenger air bag ...........111, 116
side air bag ..............................114
Air cleaner filter ...............238±239
Air conditioning
manual heating and air
conditioning system .................50
All Wheel Drive (AWD),
driving off road .........................148
Antifreeze (see Engine
coolant) .....................................219
Anti-lock brake system
(see Brakes) ......................135±136
Anti-theft system ........................85
arming the system ....................85
disarming a triggered system ..86
warning light .............................13
Audio system (see Radio) ...19, 31
Automatic transaxle .................139
driving with .............................141
fluid, adding ............................236
fluid, checking ........................236
Automatic transmission
fluid, refill capacities ..............244
Auxiliary power point .................66
Axle
refill capacities ........................244
B
Battery .......................................217acid, treating emergencies .....217
charging system warning
light ............................................13
jumping a disabled battery ....180
maintenance-free ....................217
servicing ..................................217
Brakes ........................................134
anti-lock ...........................135±136
anti-lock brake system (ABS)
warning light .....................13, 136
brake warning light ..................12
fluid, checking and adding ....235
fluid, refill capacities ..............244
fluid, specifications .................246
lubricant specifications ..........246
parking ....................................136
shift interlock ..........................139
Break-in period .............................4
Bulbs ............................................57
C
Capacities for refilling fluids ....244
Cargo cover .................................74
CD-single .....................................19
Cell phone warning ...................250
Certification Label ....................248
Child safety restraints ..............118
child safety belts ....................118
Child safety seats ......................122
attaching with tether straps ..126
in front seat ............................123
in rear seat ..............................123
Cleaning your vehicle
engine compartment ..............199
instrument panel ....................201
interior .....................................201
plastic parts ............................200
washing ....................................198
Index
251

waxing .....................................198
wheels ......................................199
wiper blades ............................200
woodtone trim ........................201
Climate control (see Air
conditioning or Heating) ............50
Clock ......................................30, 45
Clutch
fluid ..........................................238
operation while driving ..........144
recommended shift speeds ....145
Console ........................................74
overhead ..............................65±66
Controls
power seat .................................89
Coolant
checking and adding ..............219
refill capacities ................223, 244
specifications ..........................246
Cruise control (see Speed
control) ........................................69
Customer
Assistance ..165±166, 188±189, 192
Ford accessories for your
vehicle .....................................202
D
Daytime running lamps
(see Lamps) ................................54
Defrost
rear window ..............................53
Dipstick
automatic transmission
fluid ..........................................236
engine oil .................................213
Doors
door ajar warning .....................14Driving under special
conditions ..........................150, 153
sand .........................................151
snow and ice ...........................154
through water .................152, 157
E
Emergencies, roadside
jump-starting ..........................180
Emission control system ..........232
Engine ........................................247
check engine/service engine
soon light ..................................10
cleaning ...................................199
coolant .....................................219
idle speed control ...................217
lubrication specifications .......246
refill capacities ........................244
service points ..................211±212
starting after a collision .........167
Engine block heater .................133
Engine oil ..................................213
checking and adding ..............213
dipstick ....................................213
filter, specifications ................216
recommendations ...................216
refill capacities ........................244
specifications ..........................246
Exhaust fumes ..........................133
F
Fluid capacities .........................244
Foglamps .....................................55
Four-Wheel Drive vehicles
description ..............................148
driving off road .......................149
indicator light ...................14, 149
Index
252

preparing to drive your
vehicle .....................................138
Fuel ............................................224
calculating fuel economy .......229
cap .....................................15, 227
capacity ...................................244
choosing the right fuel ...........226
comparisons with EPA fuel
economy estimates .................231
detergent in fuel .....................227
filling your vehicle with
fuel ...........................224, 227, 229
filter, specifications ................228
fuel filler door release ..............73
fuel pump shut-off switch .....167
gauge .........................................17
improving fuel economy ........229
low fuel warning light ..............12
octane rating ...................226, 247
quality ......................................226
running out of fuel .................227
safety information relating to
automotive fuels .....................224
Fuses ..................................168±169
G
Garage door opener ....................66
Gas cap (see Fuel cap) ......15, 227
Gas mileage (see Fuel
economy) ...................................229
Gauges .........................................16
engine coolant temperature
gauge .........................................16
fuel gauge ..................................17
odometer ...................................18
speedometer .............................17
tachometer ................................17
GAWR (Gross Axle Weight
Rating) .......................................157calculating ...............................159
definition .................................157
driving with a heavy load ......157
location ....................................157
GVWR (Gross Vehicle Weight
Rating) .......................................157
calculating .......................157, 159
definition .................................157
driving with a heavy load ......157
location ....................................157
H
Hazard flashers .........................167
Head restraints .....................87, 90
Headlamps ...................................54
aiming ........................................56
bulb specifications ....................58
daytime running lights .............54
flash to pass ..............................55
high beam ...........................13, 54
replacing bulbs .........................59
turning on and off ....................54
warning chime ..........................15
Heating
heating and air conditioning
system .......................................50
Hood ..........................................210
I
Ignition ...............................130, 247
Infant seats
(see Safety seats) .....................122
Inspection/maintenance (I/M)
testing ........................................233
Instrument panel
cleaning ...................................201
cluster ........................................10
Index
253

lighting up panel and
interior .......................................55
location of components ............10
J
Jump-starting your vehicle ......180
K
Keys .......................................82±84
key in ignition chime ...............15
positions of the ignition .........130
L
Lamps
bulb replacement
specifications chart ..................58
cargo lamps ...............................55
daytime running light ...............54
fog lamps ...................................55
headlamps .................................54
headlamps, flash to pass ..........55
instrument panel, dimming .....55
interior lamps .....................56, 58
replacing bulbs .............57, 59±61
Lane change indicator (see
Turn signal) .................................56
Liftgate ........................................75
Lights, warning and indicator ....10
air bag ........................................12
anti-lock brakes (ABS) ....13, 136
anti-theft ...................................13
brake ..........................................12
charging system ........................13
cruise indicator .........................13
door ajar ....................................14
fuel cap light .............................15
high beam .................................13
low coolant ................................14low fuel ......................................12
oil pressure ...............................14
overdrive off ..............................14
safety belt .................................12
service engine soon ..................10
turn signal indicator .................13
Load limits .................................157
GAWR ......................................157
GVWR ......................................157
trailer towing ..........................157
Loading instructions .................159
Locks
childproof ..................................78
doors ..........................................77
Lubricant specifications ...........246
Lumbar support, seats ...............89
M
Manual transaxle .......................144
fluid, checking and adding ....238
reverse .....................................146
Manual transmission
fluid capacities ........................244
Mirrors
fold away ...................................69
side view mirrors (power) .......68
Moon roof ....................................74
Motorcraft parts ........................228
O
Octane rating ............................226
Odometer .....................................18
Oil (see Engine oil) ..................213
Overdrive ...................................141
Index
254