SEAT BELTS MAZDA MX-5 1994 Workshop Manual

PRE-DELIVERY INSPECTION PRE-DELIVERY INSPECTION PRE-DELIVERY INSPECTION TABLE The following items may be done at any time prior to delivery to your customer. INSPECT and ADJUST, if necessary, the following items to specification: 0 Glass, exterior bright metal and paint for damage 0 Convertible top and detachable hardtop (if equipped) for damage 0 Wheel lug nuts and locks 89-117 N.m (9-1 2 kgf.m, 66-86 ft4bf) 0 All weatherstrips for damage or detachment Operation of hood release and lock Operation of fuel lid 0 Door operation and alignment Headlight aiming INSTALL the following parts: Wheel caps (if equipped) 0 Outside mirror(s) 0 Mast antenna (if equipped) UNDER HOOD-ENGINE OFF INSPECT and ADJUST, if necessary, the following items to specification : Fuel, coolant, and hydraulic lines, fittings, connections, and components for leaks Engine oil level 0 Power steering fluid level (if equipped) Brake and clutch master cylinder fluid level 0 Windshield washer reservoir fluid level 0 Radiator coolant level and specific gravity 0 Tightness of battery terminals pKiq INSTALL the following parts: CHECK operation of the following items: 0 Seat controls (sliding and reclining) 0 Door locks 0 Seat belts and warning system 0 Air bag system using indicator light (Refer to section T) Ignition switch and steering lock 0 Starter interlock switch (clutch pedal) All lights, including warning, and indicator lights 0 Audible warning system 0 Horn, wipers, and washers Audio system 0 Cigarette lighter Power windows (if equipped) 0 Power outside mirrors (if equipped) 0 Heater, defroster, and air conditioner at all mode selections (if equipped) CHECK the following items: Presence of spare fuses 0 Upholstery and interior finish CHECK and ADJUST, if necessary, the following items: 0 Pedal height and free play of brake and clutch pedals I Pedal height mm {in} I Ft: $iy I Clutch pedal {6.89--7.28) (with carpet) Parking brake 7-9 notchesil96 N (20 kgf, 44 Ibf) 0.63.1 (0.024. 12) Brake pedal RUNNING AT OPERATING TEMPERATURE CHECK the following items: 0 Automatic transmission oil level 171-181 (6.73--7.13) (with carpet) I ON HOIST I 4--7 {0.16-0.28} CHECK the following items: 0 Underside fuel, coolant, and hydraulic lines, fittings, con- nections, and components for leaks 4 Tires for cuts or bruises 0 Steering linkage, suspension, exhaust system, and all underside hardware for looseness or damage Manual transmission oil level Differential oil level I ROAD TEST I CHECK the following items: Brake operation Clutch operation 0 Steering control 0 Operation of meters and gauges Squeaks, rattles and unusual noises 0 Overall engine performance Seat belt emergency locking retractors 0 Cruise control system (if equipped) I AFTER ROAD TEST I CHECK for necessary owner information materials, tools and spare tire in vehicle The following items must be done just before the delivery to your customer. 0 Load test battery and charge if necessary -1 Install fuses for accessories Adjust tire pressure to specification Load test fesuk 0 Remove seat and floor mat protective covers (Refer to Door Label) 0 Vacuum and clean interior of vehicle Clean outside of vehicle Inspect installation of option parts with invoice 45UOAX-002 Gartner Banana

FLOOR COVERING FLOOR COVERING COMPONENTS Removal / Installation 1. To remove the cabin carpet, first remove the following: a Seats (Refer to page S-65.) b Dashboard (Refer to page S-56.) c Heater unit (Refer to Section U) d Front side trim, scuff plates, quarter trim, and rear package trim (Refer to page S-59.) e Front seat belts and buckles (Refer to page S-63.) 2. Remove the remaining parts in the order shown in the figure. 3. Install in the reverse order of removal. 1. Rear end mat 2. Foot rest 3. Bracket 4. Cabin carpet Gartner Banana

1790 -2 * SEAT BELTS 1A3 NA9 NA4 BLACK $ELTI A' (1) ,FRT SEAT dA3 NA5 1484 BLACK ;OVER , HQLE Gartner Banana

2-C06 2-C07 2-E07 2-F07 2-60 7 2-107 2-LO7 2-CO8 2-EOB 2-E09 2-GO9 2- JOY 2-H09 2-El0 ncAn LunDlnmIAun ~~nra LICENSE LAHPS ORNAMENTS REAR FINISHER BONNET TRUNK LID FRONT PANELS FENDER 6 WHEEL APRON PANELS DASH 6 COWL PANELS SIDE PANELS FLOOR PANELS FLOOR ATTACHMENTS (HOLE COVERS ) FLOOR ATTACHHENTS DASHBOARD EOUIPUENTS METtK HOOD SPEEDOMETER CABLE METER COMPONENTS DASHBOARD L RELATED PARTS CONSOLE VENTILATUR SEATS SEAT BELTS AIR BAG FRONT DOORS FRONT DOOR MECHANISMS FRONT DOOR TRIMS L RELAIED PAR T S SUNROOF SWITCHES 6 RELAYS (ENGINE) DASHBOARD SWITCHES COMB l !?AT1 ON SWITCH RELAYS 6 UNIT (BODY) DOOR SWITCH & HORNS AUTO CRUISE CONTROL SYSTEM AUDIO SYSTEMS (RADIO & TAPE DE CK 1 AUDIO SYSTEMS (ANTENNA & SPEAK ER) WIRING HARNESSES(FR0NT & REAR 1 WIRING HARNESSES(ENG1NE 6 T/HI SSION) WIRING HARNESSES(DASuYGARD> WIRING HARNESSES(DOOR,FLOOR/CE ILING) WIRING HARNESS CLAMPS WINDSHIELD WASHER (W/O ANTI LOCK BRAKE SYSTEM) WINDSHIELD WASHER (ANTI LOCK BRAKE SYSTEM) WINDSHIELD WIPERS WIPER MOTOR COMPOHENTS(FR0NT) FRONT HEADER TRIK 6 PILLAR TRI ns TRIMS b SCUFF PLATES FLOOR MATS X PhDS SERVICE TOOLS VISORS,ASSiST HAHOCES 8 HIRROK S DATE. 1995-04 PAGE. 3 Gartner Banana

VEWICLE IDENTIFICATION SYSTEM FOR MX-5 MIATA SERIES (.i994) VIN (= Vehicle Identification Number) for MX-5 MIATA series (1994 Year Model) consists of WMI(= World N,anuf:lcturer Identifier), VDS(= VehlCle Description Section) and VIS(= Vehicls lderitification Section). VDS consisting of six alphanumeric characters denotes the 'MODEL SERIES". VIS consisting of ell%lt alphanumeric characters denotes the serial unit number of vehicle and is sequentially numbered within each VUS. ~iscellaneous ibnllficalbn code (1 =All seats manual belts + Driver's seat air bag, 3=All seats manual bolt.. + Front wts ah b8g) .- Body style code (35=2 door) Car line code (NA=MX.5 MIATA wries ) ---- World manufacturer tdentifier (Al! Mazda passenger cars undw 1J.S.A. h Canada spe?ciflcations are idenUfied by JM1) * Chock dtg11 is tncludod ao a VIN secmry foarure to permit law o:,forcom~nf vonficatlon of tho aulhentrc~ty of a suspected tllegal VIN pota. This S~ngle dlyit nurrlbor 1 abtmined. bawd l~pon a cotnplor rnalht,matrcal formula whrch 16 applied lo etch votdc10'~ VI!N ,. -+nr LOCA'IION OF VIN PLATE The plate is a:lached to the top Mge of the dash pand under the bonnet(englrte hood), refer to the IUuntratlon shown light (Notel If Lhe VIN(Chassis) reference nunibor In the PCM{Parts Catalog Mc~oticho) appeal od as: NA3 a r r - 5OOOOl , ... th.9 vehicle's VIN wccrkl be e.g. JMlNA351 * HOWUOOl Gartner Banana