switch MITSUBISHI 3000GT 1995 2.G Workshop Manual

Downloaded from www.Manualslib.com manuals search engine L
L
CHASSIS ELECTRICAL - Column Switch54-113
Front of vehicles
219FOlZ:
Mating mark-! !kU19FOOE
-
16FO237
16FO1:900002398
+B,COLUMN COVER, LOWER / COLUMN COVER, UP-
PER REMOVAL
After the screws have been removed, remove the covers,while making sure not to break the grippers.
INSTALLATION SERVICE POINT
.A(STEERING WHEEL INSTALLATION
To center the clock spring, line up the “NEUTRAL” markof the clock spring with the mating mark.
CautionIf the clock spring’s mating mark is not properly
aligned, the steering wheel may not be completely
rotational during a turn, or the flat cable within the
clock spring may be severed, obstructing normal op-eration of the SRS and possibly leading to serious
injury to the vehicle’s driver.
INSPECTION
(1) Remove the knee protector and the column cover. (Refer
(2)
to GROUP 52A - Instrument Panel.)
Disconnect the column switch left connector (16 terminals)
and check the continuity between the terminals for each
switch.
LIGHTING SWITCH CHECK
Operate the switch and check the continuity between the termi-
nals.
TSB Revision

Downloaded from www.Manualslib.com manuals search engine 54-114CHASSIS ELECTRICAL - Column Switch
TURN SIGNAL SWITCH CHECK
Operate the switch and check the continuity between the termi-
nals.J
~
DIMMER/PASSING SWITCH CHECK
Operate the switch and check the continuity between the termi-
WIPER AND WASHER SWITCH
Refer to GROUP 51 - Windshield Wiper and Washer.
TSB Revision

Downloaded from www.Manualslib.com manuals search engine CHASSIS ELECTRICAL - Horn54-115
HORN
SPECIFICATIONS
GENERAL SPECIFICATIONS
Horn (Except for theft-alarm horn)
ItemsI Specifications
Type
Effective sounding voltage V
Power consumption A
Sound level dB
Fundamental frequency Hz
“low” sound
“high” sound
“low” sound
“high” sound
Fiat type
11.5-15
3.0
100-112
100-112350-390395-435
Theft-alarm horn
1 ItemsI Specifications
1 Type1 Flat typeI
Effective sounding voltage V
Power consumption A
Sound level dB
Fundamental frequency Hz
11-14.5
Max. 3.5
105-120I
I 405-435
TROUBLESHOOTING
COMPONENT LOCATION
OPERATIONl
The horn switch always receives battery voltagevia the dedicated fuse (6) and the coil of the
horn relay.
l
When the horn switch is set to ON, the contactsof the horn relay close.
Then current flows through the dedicated fuse
(6) to the contacts of the horn relay, the hornand ground, causing the horn to sound.1. One of the horn does not sound.
TROUBLESHOOTING HINTSl Check the horn.
2. Horns do not sound.
l Check the horn switch.
l Check the dedicated fuse (6).
NOTE
(1) For vehicles equipped with the theft-alarm sys-tem, refer to
P.54-205.
(2) For information concerning the horn relay and
theft-alarm horn relay, refer to
P.54-?18.
TSB Revision

Downloaded from www.Manualslib.com manuals search engine 54-I 18CHASSIS ELECTRICAL - HornHORN SWITCH
REMOVAL AND INSTALLATION(UP TO 1993 MODELS)
~
Y16FO207Removal steps
1. Air bag module (Refer to GROUP 528
(FROM 1994 MODELS)
- Air Bag Module and Clock Spring.)2. Horn contact switch3. Horn contact plate and wire4. Horn switchThe
horn switch is not supplied
If it is faulty, replace the steeringby itself.wheel assembly.i-.
-L 16FOO61200002400
RELAY
INSPECTION
HORN RELAY CHECK
Connect battery to terminal 1 and check continuity between
terminals with terminal 3 grounded.
~1
THEFT-ALARM HORN RELAY CHECK
Connect battery to terminal 2 and check continuity between
terminals with terminal 4 grounded.TSB Revision

Downloaded from www.Manualslib.com manuals search engine CHASSIS ELECTRICAL - Radio and Tape Player54-125 ~
,IGHTKHUIU REMOTECONTROL SWITCH
*LA‘1REL/
1.25R-\I
-l
DEDICATEDFUSE
c
-------
G-h
J/BrS(c-69)
1
50
G-W
a(D-36)(D-34)
RADIO AND TAPE PLAYER
I;
I1II:--_---- ______2- ---
r
J2
1---7
(T)GR-(T>GR-
B-k
(T>GR-
:T>GR-I
103,l (c-15)
(LH)(RH)
RHEOSTAT
REAR
SPEAKER
HRl4MOOAB
TSB Revision

Downloaded from www.Manualslib.com manuals search engine 54-128CHASSIS ELECTRICAL - Radio and Tape Player
CIRCUIT DIAGRAM
(1993 models)
’ I
d
FUSIBLE LINK@
J-
IGNITIONSWITCH(ACC)IGNITIONSWITCH(IG1)
1B4------------__J/B/T\
r
3
1
I
SPARE
CONNECTOR
(CD CHANGER
(F-40)I
3r
IOD ORSTORAGE
CONNECTOR
(A-11x)
(R-B
0----------------
R-E
.------ ---------.
jm(c-78:
0.85
R-E
IMOTOR
I#$@E;'ti IRELAY
/
(F-31);
L
.o (c-81
L
I
11
I
\/V-------_02"3 CmTg
2LI2L-wB-W,,4,,3\
IOD OR STORAGE
CONNECTOR
IA-11X)I
\/\/\I,
L-;(,\\6\A MOTOR
l(D-47)B--@3- ANTENNAP
2B2
n3SaL
EEP
(D-34)22
RADIO AND TAPE PLAYER
f
2‘-1
30
30
d
(A-1Ix) (c-ss)Crn) (c-77)(c-78)(c-80)(c-81)(c-82)-
\
(D-34) o(D-47)(F-31)0
HR14MOlAA
TSB Revision1

Downloaded from www.Manualslib.com manuals search engine 54-132CHASSIS ELECTRICAL - Radio and Tape Player
CIRCUIT DIAGRAM
(1994 models-Radio and Tape Player with Amplifier)
FUSIBLE LINK@IGNITIONSWITCH(ACC)IGNI:SWIT(
5W-B2L,.1 (c-68)2B-h,4
J/B----------____
I rI
IIOD OR STORAGECONNECTOR
(A-11x)
R-B (R-E
1
'DA
UT0'HAMGER
(F-40)
"2
B2z
0
E 2B13n
3
I
\/v--------.o 4“3 (c-70)
2LI2L-w
B-W
,,4,,3
1IOD OR STORAGE
CONNECTOR
(A-13X)MOTOR
IANTENNA jCONTROL- I
L-35/\,\6fi MOTOR
B-+@+ ANTENNA
0
2Btr:z1
n&
GE
!2g
[ON1(IGl)I
3
RADIO AND TAPE PLAYER
HR14M02AA
TSB Revision1

Downloaded from www.Manualslib.com manuals search engine 54-136CHASSIS ELECTRICAL - Radio and Tape Player
CIRCUIT DIAGRAM

d
I
FUSIBLE LINK@IGNITIONSWITCH(ACC)IGNIlSWITC
2W-B
1
B-W2B-w
2LIHORN5W-B
,,l (c-68)
CHARGING 2B-W
,,4------___----_cl\I
IN(IGl)
‘(c-82,
I
i(c-80)
J/B
@10A
tII
IOD OR STORAGE B-WCONNECTOR
(A-11X)
IIIOD OR STORAGE
CONNECTOR
(A-11X)
L
1R-B
W4igfUISE
ID,UTO:HAMGERr
3m(c-78:
0.85
R-B
10 (c-81
L
1.------
B-W
.BUZZER.@;&ALARM
dR-E
2E
RADIO AND TAPE PLAYER
HR14M03AA
1 TSB Revision

Downloaded from www.Manualslib.com manuals search engine CHASSIS ELECTRICAL - Radio and Tape Player
54-137 ~
L;
(c-(c-34)(c-57)00(D-36),(D-47)(F-06) FTC9
i
~~l~~[~!~~l~ -1
(F-33)(1czD2
Bfzi%$pJ q
HR14M03AB
J/BRADIO REMOTE
CONTROL SWITCHJ/B
3Y
_------
!
(Y-W)
3(1
I
CLOCK
SPRING
I
*m
(UP TO 1995Y
(Fgyiiz/g~-
MODELS).FULL AUTO A/C4----1I
I
RADIO REMOTE
CONTROL SWITCH'T;Tk\IGHT
-T-2R-W
IRADIO AND TAPE PLAYERIIII
------1
(T)Y-
;-----.
@$* -=.------)E
(T>Y-L 2(T>GR-1
(c-34),>3E-----_
(T)Y-L(T>GR-'L
------11
(T)GR-I(T>Y-IR (T>GR-R22
+-
(LH)
- ------- ----------------------‘i1
r 1
7
r
12
i%A'CPR (T)GR-R.FULL AUB-Y.MANUAL I.ELC-4A/i
-;t_310_----_,,21> B-Y
B-Y
lhll (c-15)
B-YjE;EW&AND
.FOG LIGHT
B-Y12
4m7+-RHEOSTAT(RH)\Y/
REAR
SPEAKER
1 TSB Revision

Downloaded from www.Manualslib.com manuals search engine 54-140CHASSIS ELECTRICAL - Radio and Tape Player
CIRCUIT DIAGRAM

J,
IGNITIONSWITCH(ACC)IGNITIONSWITCH(IG1)FUSIBLE LINK@
B-W 2B-\i
2L1HORN5W-BCHARGING2B-y
,,I(c-68),4--J/B1-----------_
I1
010A
T
1I----4------I
MOTOR
I#&#L" IUNIT
I
(F-31):
(D-47)
1
B-W
IIIOD OR STORAGE
CONNECTOR+'BUZZERTW&ALARMIOD OR STORAGE B-wCONNECTOR
5(A-11X)I----__-------__-------
-1
rc
---
v
DOW'tT0jHAMGER(F-40)!
2B
*\/4,4,\,L-35,\,\6
B
0
2BY
2F
n
ii&
Ei
_-i2
RADIO AND TAPE PLAYER
HR14M04AATSB Revision