stop start OPEL KARL 2015 Owner's Guide

OPEL Karl Owner Manual (GMK-Localizing-EU RHD-9231168) - 2016 - crc -
5/7/15
160 Vehicle Care
checked and have the cause of the
coolant loss remedied by a
workshop.
Washer Fluid
Fill with clean water mixed with a
suitable quantity of washer fluid
which contains antifreeze.
Caution
Only washer fluid with a sufficient
antifreeze concentration provides
protection at low temperatures or
a sudden drop in temperature.(Continued)
Caution (Continued)
Use of washer fluid containing
isopropanol can damage exterior
lamps.
Brakes
In the event of minimum thickness
of the brake lining, a squealing
noise sounds during braking.
Continued driving is possible but
have the brake lining replaced as
soon as possible.
Once new brake linings are
installed, do not brake
unnecessarily hard for the first few
journeys.
Brake Fluid
{Warning
Brake fluid is poisonous and
corrosive. Avoid contact with
eyes, skin, fabrics and painted
surfaces.
The brake fluid level must be
between theMINand the MAX
marks.
If fluid level is below the MINmark,
seek the assistance of a workshop.
Brake and clutch fluid
0
Recommended Fluids and
Lubricants 0195.
Battery
Vehicles without stop-start system
will be equipped with a lead acid
battery. Vehicles with stop-start
system will be equipped with an
AGM battery which is not a lead
acid battery.

OPEL Karl Owner Manual (GMK-Localizing-EU RHD-9231168) - 2016 - crc -
5/7/15
Vehicle Care 161
The vehicle battery is
maintenance-free provided that the
driving profile allows sufficient
charging of the battery.
Short-distance-driving and frequent
engine starts can discharge the
battery. Avoid the use of
unnecessary electrical consumers.
Batteries do not belong in
household waste. They must be
disposed of at an appropriate
recycling collection point.
Laying up the vehicle for more than
4 weeks can lead to battery
discharge. Disconnect the clamp
from the negative terminal of the
vehicle battery.
Ensure the ignition is switched off
before connecting or disconnecting
the vehicle battery.
Replacing the vehicle battery
Note
Any deviation from the instructions
given in this paragraph may lead to
a temporary deactivation of the
stop-start system.
When the vehicle battery is being
replaced, please ensure that there
are no open ventilation holes in the
vicinity of the positive terminal. If a
ventilation hole is open in this area,
it must be closed off with a dummy
cap, and the ventilation in the
vicinity of the negative terminal must
be opened.
Only use vehicle batteries that allow
the fuse box to be mounted above
the vehicle battery.
In vehicles with stop-start system,
ensure to have the AGM (Absorptive
Glass Mat) battery replaced with an
AGM battery again.
An AGM battery can be identified by
the label on the battery. We
recommend the use of an original
Opel vehicle battery.
Note
Using an AGM vehicle battery
different from the original Opel
vehicle battery may result in a lower
performance of the stop-start
system.
We recommend that you have the
vehicle battery replaced by a
workshop. Stop-start system
0
Automatic Engine Start/Stop
Feature0137.

OPEL Karl Owner Manual (GMK-Localizing-EU RHD-9231168) - 2016 - crc -
5/7/15
162 Vehicle Care
Charging the vehicle battery
{Warning
On vehicles with stop-start
system, ensure that the charging
potential does not exceed
14.6 volts when using a battery
charger. Otherwise the vehicle
battery might be damaged.
Jump starting
0Jump
Starting 0188.
Warning label
Meaning of symbols:
.
No sparks, naked flames or
smoking.
. Always shield eyes. Explosive
gases can cause blindness or
injury.
. Keep the vehicle battery out of
reach of children.
. The vehicle battery contains
sulphuric acid which could cause
blindness or serious burn
injuries.
. See the Owner's Manual for
further information.
. Explosive gas may be present in
the vicinity of the vehicle battery.Wiper Blade Replacement
Wiper blades on the
windscreen
Lift wiper arm. Press release lever
and detach wiper blade.
Attach the wiper blade slightly
angled to the wiper arm and push
until it engages.
Lower wiper arm carefully.

OPEL Karl Owner Manual (GMK-Localizing-EU RHD-9231168) - 2016 - crc -
5/7/15
172 Vehicle Care
Instrument Panel Fuse
Block
In left-hand drive vehicles, the fuse
box is behind the storage
compartment in the instrument
panel.
Open compartment, compress the
locking tabs, fold compartment
down and remove.
No. Circuit1 Onstar
2 HVAC module 3 Instrument panel cluster
4 Continuously Variable
transmission control module
5 Radio
6 Body control module 1 (CVT Stop & Start)
7 Side blind spot alert/Rear parking assist
8 Data link connection
9 Electric steering column lock
10 Sensing and Diagnostic module
11 DC-DC converter
12 -
13 Electronic toll collection system
14 Linear power module
15 Passive entry & passive start
16 Discrete logic ignition switch (Non CVT
stop&start)
17 Front collision avoidance

OPEL Karl Owner Manual (GMK-Localizing-EU RHD-9231168) - 2016 - crc -
5/7/15
Vehicle Care 173
18 Instrument panel cluster
19 Reflected LED Alert Display
20 Headlight levelling switch
21 Front power window
22 Rear power window
23 -
24 Automated manual gearboxmodule
25 Auxiliary power socket
26 Sunroof
27 -
28 Body control module 8
29 Body control module 7
30 Body control module 6
31 Body control module 5
32 Body control module 4
33 Body control module 3
34 Body control module 2 (Non CVT Stop & Start)
35 Body control module 1 (Non CVT Stop & Start) 36 Discrete logic ignition
switch (CVT stop&start)
37 Steering wheel controls backlighting
38 -
39 Logistic/DC-DC converter
40 Driver express power window
41 Blower motor
42 Front heated seat
43 HVAC module
44 Heated steering wheel
45 Body control module 2 (CVT Stop & Start)Vehicle Tools
Tools
Vehicles with tyre repair kit
The vehicle tools are in the
compartment under the floor cover
in the load compartment, together
with the tyre repair kit.

OPEL Karl Owner Manual (GMK-Localizing-EU RHD-9231168) - 2016 - crc -
5/7/15
178 Vehicle Care
The menu Tyre Load only appears if
the vehicle is in a standstill and the
parking brake is applied.
Select :
.Lofor comfort pressure up to
3 people
. Eco for Eco pressure up to
3 people
. Hifor full loading
TPMS Sensor Matching
Process
Each TPMS sensor has a unique
identification code. The identification
code must be matched to a new tyre/ wheel position after rotating the
tyres or exchanging the complete
wheel set and if one or more TPMS
sensors were replaced. The TPMS
sensor matching process should
also be performed after replacing a
spare tyre with a road tyre
containing the TPMS sensor.
The malfunction light and the
warning message or code should go
off at the next ignition cycle. The
sensors are matched to the tyre/
wheel positions, using a TPMS
relearn tool, in the following order :
Left side front tyre, right side front
tyre, right side rear tyre and left side
rear tyre. The turn light at the
current active position is illuminated
until sensor is matched.
Consult your workshop for service
or to purchase a relearn tool. You
have two minutes to match the first
tyre/ wheel position, and
five minutes overall to match all four
tyre/wheel positions. If it takes
longer, the matching process stops
and must be restarted.
The TPMS sensor matching process
is outlined below:
1. Apply the parking brake.
2. Turn the ignition on.
3. Move selector lever to neutral.
4. Use MENUon the indicator
lever to select the Vehicle
Information Men u in the
Driver Information
Centre (DIC).
5. Turn the adjuster wheel to scroll to the tyre
pressure menu.
6. Press SET/CLR to begin the
sensor matching process.
A message requesting
acceptance of the process
should display.
7. Press SET/CLR again to
confirm the selection. The horn
sounds twice to signal the
receiver is in relearn mode.
8. Start with the left side front tyre.
9. Place the relearn tool against the tyre sidewall, near the
valve stem. Then press the

OPEL Karl Owner Manual (GMK-Localizing-EU RHD-9231168) - 2016 - crc -
5/7/15
208 Index
IndexA
Accessories andModifications . . . . . . . . . . . . . . . . . . 156
Accessory Power . . . . . . . . . . . . . . . 137
Adjustable Air Vents . . . . . . . . . . . . 131
Adjustments Seat, Initial Drive . . . . . . . . . . . . . . . 33
Air Conditioning . . . . . . . . . . . . . . . . 126
Air Conditioning Regular Operation . . . . . . . . . . . . . . . . . . . . . 132
Air Filter, Passenger Compartment . . . . . . . . . . . . . . . . . 132
Air Intake . . . . . . . . . . . . . . . . . . . . . . . 132
Airbags Curtain . . . . . . . . . . . . . . . . . . . . . . . . . 43
Front . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
Light On-Off . . . . . . . . . . . . . . . . . . . . 70
On-Off Light . . . . . . . . . . . . . . . . . . . . 70
On-Off Switch . . . . . . . . . . . . . . . . . . 43
Safety Belt Tensioner Light . . . . . 70
Side . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42
System Check . . . . . . . . . . . . . . . . . . 38
Alarm System Anti-theft . . . . . . . . . . . . . . . . . . . . . . . . 26
AM-FM Radio . . . . . . . . . . . . . . . . . . . 102
Anti-theft Alarm System . . . . . . . . . . . . . . . . . . 26
Antilock Brake System (ABS) . . . 142 Antilock Brake System
(ABS) (cont'd)
Warning Light . . . . . . . . . . . . . . . . . . . 71
Appearance Care
Exterior . . . . . . . . . . . . . . . . . . . . . . . 191
Interior . . . . . . . . . . . . . . . . . . . . . . . . 192
Audio System Theft-Deterrent Feature . . . . . . . . . 92
Auto Stop Mode . . . . . . . . . . . . . . . . . 74
Automatic
Engine Start/Stop Feature . . . . 137
Auxiliary Devices . . . . . . . . . . . . . . . . . . . . . . . 108
B
Battery . . . . . . . . . . . . . . . . . . . . . . . . . 160
Jump Starting . . . . . . . . . . . . . . . . . 188
Power Protection . . . . . . . . . . . . . . . 91
Blade Replacement, Wiper . . . . . 162
Bluetooth
Overview . . . . . . . . . . . . . . . . . . . . . .116
Bonnet . . . . . . . . . . . . . . . . . . . . . . . . . 157
Bonnet Ajar Light . . . . . . . . . . . . . . . . 74
Brakes . . . . . . . . . . . . . . . . . . . . . 141, 160 Antilock . . . . . . . . . . . . . . . . . . . . . . . 142
Assist . . . . . . . . . . . . . . . . . . . . . . . . . 143
Brake and Clutch SystemWarning Light . . . . . . . . . . . . . . . . . 71
Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 160

OPEL Karl Owner Manual (GMK-Localizing-EU RHD-9231168) - 2016 - crc -
5/7/15
210 Index
D
Danger, Warning, and Caution . . . . 4
Data Recorders, Event . . . . . . . . . 206
Daytime RunningLamps (DRL) . . . . . . . . . . . . . . . . . . . 86
Declaration of Conformity . . . . . . . 205
Devices Auxiliary . . . . . . . . . . . . . . . . . . . . . . 108
Dimensions Vehicle . . . . . . . . . . . . . . . . . . . . . . . 203
Displays Service . . . . . . . . . . . . . . . . . . . . . . . . . 68
Door Ajar Light . . . . . . . . . . . . . . . . . . . . . . . 74
Central Locking System . . . . . . . . 22
Driver Assistance Systems . . . . . 148
Driver Information Centre (DIC) . . . . . . . . . . . . . . . . . . . 75
E
Electrical SystemEngine Compartment FuseBlock . . . . . . . . . . . . . . . . . . . . . . . . 170
Fuses . . . . . . . . . . . . . . . . . . . . . . . . 169 Electrical System (cont'd)
Instrument Panel Fuse
Block . . . . . . . . . . . . . . . . . . . . . . . . 172
Electronic Climate Control
System . . . . . . . . . . . . . . . . . . . . . . . . 128
Electronic Stability Control . . . . . . 144
Electronic Stability Control (ESC) Off Light . . . . . . . . . . . . . . . . . 72
Electronic Stability Control
Indicator Light . . . . . . . . . . . . . . . . . . 72
Emissions - CO2 Fuel Consumption . . . . . . . . . . . . 154
End-of-Life Vehicle Recovery . . . 157
Engine Automatic Start/StopFeature . . . . . . . . . . . . . . . . . . . . . 137
Check and Service Engine Soon Light . . . . . . . . . . . . . . . . . . . . 70
Coolant . . . . . . . . . . . . . . . . . . . . . . . 159
Coolant Temperature Gauge . . . . 68
Coolant Temperature Warning Light . . . . . . . . . . . . . . . . . 72
Exhaust . . . . . . . . . . . . . . . . . . . . . . 140
Oil Pressure Light . . . . . . . . . . . . . . 73
Reduced Power Light . . . . . . . . . . . 74
Starting . . . . . . . . . . . . . . . . . . . .18, 136
Engine Data . . . . . . . . . . . . . . . . . . . . 202
Engine Identification . . . . . . . . . . . . 200 Entry Lighting . . . . . . . . . . . . . . . . . . . . 90
Event Data Recorders . . . . . . . . . . 206
Exit Lighting . . . . . . . . . . . . . . . . . . . . . 91
Exterior Lamp Controls . . . . . . . . . . 85
F
First Aid Kit . . . . . . . . . . . . . . . . . . . . . . 57
Fixed Air Vents . . . . . . . . . . . . . . . . . 132
Flat Tyre
Changing . . . . . . . . . . . . . . . . . . . . . 184
Fluid Brakes . . . . . . . . . . . . . . . . . . . . . . . . 160
Washer . . . . . . . . . . . . . . . . . . . . . . . 160
Fog Lamp Light, Rear . . . . . . . . . . . 74
Fog Lamps Bulb Replacement . . . . . . . . . . . . 165
Front . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Rear . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88
Folding Mirrors . . . . . . . . . . . . . . . . . . 28
Front Airbag System . . . . . . . . . . . . . 42
Front Fog Lamp Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 74
Front Indicator Lamps . . . . . . . . . . 165
Front Seat Position Seats Adjustment . . . . . . . . . . . . . . . . . . . . . 33
Front Seats
Adjustment . . . . . . . . . . . . . . . . . . . . . 34
Heated . . . . . . . . . . . . . . . . . . . . . . . . . 35
Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . 152