gearbox PEUGEOT 107 2012 User Guide

9
65 Practical information
)As far as possible, immobilise the vehicle
on level, stable, non-slippery ground. )Apply the parking brake, switch off the
ignition and engage first gear or reverse
for the manual gearbox, position Nfor the2 Tronic gearbox. The followin
g tools are installed in a carrier,
located in the centre of the spare wheel:
1
. Wheelbrace 2.Jack with handle 3.Removable towing eye

Access to the spare wheel and
the jack in the boot
) Remove the carpet then the plastic cover using the handle.



Tyre pressures

These are indicated on the label positioned on the inner pillar of the left door, see
"Identification markings".



























Changing a wheel
)
If necessary, chock the wheel diagonally
opposite the wheel to be changed.) You must ensure that the occupants leave
the vehicle and wait in a safe location.

Parking the vehicle
To o l s

9
73 Practical information
* Fuses located behind the instrument panel. To change them, contact a PEUGEOT dealer or a qualified workshop.
FuseN°Rating(A)Functions
110Brake lamps - ABS - 2 Tronic gearbox
225Central locking/unlocking - Remote control
320Rear screen demisting
47.5Rear lamps - Number plate lamps - Instrument panel - Screen - headlamp adjustment - LED daytime runninglamps - Sidelamps
57.5Diagnostic socket
67.52 Tronic gearbox - Rear foglamp - ESP - LED daytime running lamps - Instrument panel - Rev counter
7-Not used
87.5
ABS/ESP - Power steering - Fan assembly
910Reversing lamps - Central locking/unlocking - Electric windows - Rear screen demisting - Speedometer - Air conditioning - Heating - Rev counter - Remote control
1020Front and rear wipers and screenwash
1115
Audio equipment - 12 V socket (120 W max)
127.5Heated rear screen - ABS - Fan assembly - Front and rear wipers and screenwash - Power steering - Central locking/
unlocking - Air conditioning - Heating - Electric windows - Speedometer - Rev counter - Remote control - Reversing lamp
1315
Airbag - Fuel injection system - 2 Tronic gearbox - Instrument panel - Rev counter - LED daytime running lamps
147.5 Air conditioning - Heating
15 *40
Audio system - 12 V socket - Front and rear wipers - Power steering - ABS/ESP - Cooling fan assembly
16 * 30Electric windows
17 *40
Air conditioning - Heating

9
75 Practical information
FuseN°Rating(A)Functions
15 LED daytime running lamps
220
Front foglamps
310
Left hand front lamp
410
Right hand front lamp
57.5 2 Tr o n i c gearbox - Fuel injection system
67.5
2 Tronic gearbox - Fuel injection system


730
LED daytime running lamps - Front foglamps
825
ABS
30
ABS/ESP (with VSC)
930
Starter motor - Heated rear screen - ABS -Cooling fan assembly - Front and rear wipers and screenwash - Power steering - Central locking/unlocking - Air conditioning - Heating - Electric windows - Speedometer -Rev counter - Remote control - Reversing lamp - Airbag - Fuel injection system - 2 Tronic gearbox - Instrument panel - LED daytime running lamps
FuseN°Rating(A)Functions
1010 Hazard warning lamps - Instrument panel - Rev counter - Direction indicators
1120
Left hand front lamp - Right hand front lamp
1215 Cour tesy lamp - Speedometer - Audiosystem- Instrument panel - Rev counter
1315
Fuel injection system - Cooling fan assembly
1410
Horn
157.5
Replacement fuse
1610
Replacement fuse
1715
Replacement fuse
1850 2 Tr o n i c gearbox
1930/40 Cooling fan assembly
20
40 ABS
50 ABS/ESP (with VSC)
2150
Power steering

9
77 Practical information









Charging the battery using
a battery charger
)Disconnect the battery from the vehicle.
)Follow the instructions for use provided by
the manufacturer of the charger.)Connect the battery star ting with thenegative terminal (-).)Check that the terminals and connectorsare clean. If they are covered with sulphate (whitish or greenish deposit), remove themand clean them.

The batteries contain harmful substances such as sulphuric acidand lead. They must be disposed of inaccordance with regulations and mustnot, in any circumstances, be discarded with household waste.
Take used remote control batteries andvehicle batteries to a special collection point.
Do not push the vehicle to star t the engine if you have a 2 Tronic gearbox.

It is advisable to disconnect the batteryif the vehicle is to be left unused for more than one month.


Do not reverse the polarity and use onlya 12 V charger.
Do not disconnect the terminals whilethe engine is running.
Do not charge the batteries withoutdisconnecting the terminals first.

80Practical information





Towing the vehicle
)
Install the towing bar. )
Put the gear lever into neutral (position Nfor the 2 Tronic gearbox).
)Take the removable towing eye stowed in
the spare wheel, under the boot carpet.
)Unclip the plastic cover. )Fully screw in the towing eye.

General
recommendations
Observe the legislation in force in your country.Ensure that the weight of the towing vehicle is higher than that of the towedvehicle.The driver must stay at the wheel of thetowed vehicle. Driving on motorways and fast roads is prohibited when towing.When towing a vehicle with all four wheels on the ground, always use an approved towing bar; rope and strapsare prohibited.When towing a vehicle with the engine off, there is no longer any power assistance for braking or steering.In the following cases, you must always call on a professional recovery service:- vehicle broken down on a motor way
or fast road,- when it is not possible to put the gearbox into neutral, unlock thesteering, or release the parkingbrake,- towing with only two wheels on theground, - where there is no approved towingbar available...

Your vehicle can only be towed at the front.
Never use the radiator crossmember.
To w i ng with fours wheels on theroad must be carried out at very low speed over a very shor t distance (in accordance with the legislation in force).
In all other cases, your vehicle must betranspor ted on a trailer.

Failure to obser ve this instruction maylead to damage to cer tain components (braking, transmission, ...) and the absence of braking assistance when theengine is started.
)
Unlock the steering by turning the key to
the first position and release the parkingbrake. ) Switch on the hazard warning lamps onboth vehicles.

88Checks






Checks






2 Tronic gearbox















Brake pads
Unless other wise indicated, check thesecomponents in accordance with the servicingbooklet and according to your engine.
Other wise, have them checked by a PEUGEOT
dealer or a qualified workshop.
12 V battery
Oil filter
Manual gearbox
Only use products recommended byPEUGEOT or products of equivalent quality and specification.
In order to optimise the operation of units as impor tant as the brakingsystem, PEUGEOT selects and offers very specific products. To avoid damaging the electrical units, the use of a high pressure washer in the engine compar tment is strictlyprohibited.
Air filter and passenger compartment filter

Brake disc wear
Parkin
g brake
The battery does not require any maintenance.
However, check that the terminals are clean
and correctl
y tightened, particularly in summer and winter.
When carrying out work on the battery, refer to the "Practical information" section for details of the precautions
to be taken before disconnecting the battery and following its reconnection.

Refer to the ser vicing booklet for
details of the replacement intervals
for these components.
Dependin
g on the environment (e.g.
dusty atmosphere) and the use of the vehicle (e.g. city driving), replace them twice as often if necessary.y A clogged passenger compar tment filter mayhave an adverse effect on the performance
of the air conditioning system and generate undesirable odours.
Replace the oil
filter each time theengine oil is changed.
Refer to the ser vicing booklet for
details of the replacement inter val for
this component.
The gearbox does not require any maintenance (no oil change).
Refer to the ser vicing booklet for the
details of the level checking intervalfor this component.
The
2 Tr o n i c gearbox does not require
any maintenance (no oil change).
Refer to the servicing booklet for
details of the checking inter val for
this unit.
Brake wear depends on the st
yle
of driving, par ticularly in the case
of vehicles used in town, over shor t
distances. It ma
y be necessary to
have the condition of the brakes checked
, even between vehicle services.
Unless there is a leak in the circuit, a drop in
the brake fluid level indicates that the brake pads are worn. For information on checkin
g brake
disc wear, contact a PEUGEOT
dealer or a qualified workshop.

I
f excessive travel or a loss of effectiveness of this system is
noticed, the parking brake must be checked, even between two services.
Checking this system must be done by a
PEUGEOT dealer or a qualified workshop.

11
89 Technical data








Engine
Engine
1.0 litre (≈ 68 hp)
Manual gearbox(5-speed)2 Tronic gearbox(5-speed)
Model codes PM, PNCFB0 / CFB4
CFB0/P

Cubic capacity (cc)
998

Bore x stroke (mm) 71 x 84

EU standard maximum power (kW)
50

Max power engine speed (rpm)
6 000


EU standard max torque (Nm)93

Max torque engine speed (rpm) 3 600


Fuel
Unleaded

Catalytic converter

Yes


Engine oil capacity (with filter replacement)
3.2

Technical data
90






Weights (in kg)
The design of your vehicle does not permit the fitting of a towbar.
Engine
1.0 litre
Manual gearbox(5-speed)2 Tr o n i c gearbox(5-speed)
Versions
3-door

5-door 3-door

5-door
Model codes

PMCFB0 / PMCFB4 PNCFB0 / PNCFB4

PMCFB0/PPNCFB0/P

Kerb weight 800805 830
840
Gross vehicle weight (GVW) 1 180


1 1901 180


1 190

130Visual search
Instruments and controls


Courtesy lamp 46


Rear view mirror 37


Electric windows 28


Front seats 38

Sun visors 40
Parking brake, handbrake 48


Audio system/Bluetooth 93-115
Vents, ventilation 33Heating, demist /defrost, air conditioning A/C 34-36Hazard warning lamps 48
Fittings, 12 volt socket 40


Mat 79


2 Tronic gearbox 42- 43
Manual gearbox 16
Seat belts 51-53

Audio system 11 6-127
Setting the time 25, 117Fitting audio equipment, speakers 79

.
133 Alphabetical index
2 Tronic gearbox .............16, 19, 22, 24, 42, 43,77,88Backup starting .............................................76Battery...............................................76-78, 88Battery, charging ...........................................77Bluetooth (hands-free)................................104Bonnet...........................................................84Boot...............................................................41Brake discs....................................................88Brake lamps ..................................................69Brake pads ....................................................88Brakes ...........................................................88
Capacity, fuel tank........................................30CD changer..........................................r124-127CD MP3.................................................98-100Central locking..............................................26Changing a bulb ......................................67,68Changing a fuse ............................................71Changing a wheel .........................................65Changing the remotecontrol battery.............................................27Changingthe time...............................................25, 117Checking levels.......................................86,87Checking the engineoil level ........................................................86Checks ..........................................................88Child lock.......................................................28Children...................................................28, 63Child seats.......................................57,59, 60Child seats,conventional................................................59Coolant level .................................................87Courtesy mirror.............................................r40Cup holder.....................................................r40
B
C
Deactivatingthe passenger airbag..................................55Defrosting ......................................................33Demisting......................................................33Dimensions...................................................91Dipped beam.....................................44, 67, 68Dipstick..........................................................86Direction indicators...........................44, 67-69Display screen..............................................23Doors.............................................................28Driver''s seat belt notfastened warning lamp.........................22, 52Driving mode.................................................42
Easy mode(automatic mode) ........................................42Eco-driving...................................................17Eco-driving (advice)......................................17Economicaldriving ........................................................17Electronic engineimmobiliser..................................................27Electronic stability control (ESP)...........................................................50Engine...............................................85, 89,90Engine, petrol ................................................31Engine compartmentfusebox.......................................................71Engine oil ................................................85,86Engine oil levelindicator......................................................r86Engines.........................................................89Environment ..................................................17ESP ...............................................................50
E
ABS...............................................................49Accessories..............................................4, 82Access to rear seats(3-door) .......................................................38Adjusting headlamps....................................46Adjusting the steering wheel.........................37Airbag fault..............................................54, 55Airbags ..............................................21, 54, 55Airbags, curtain .......................................55,56Airbags, front.................................................56Airbags, lateral........................................55,56Airbag warning lamp.....................................54Air conditioning.......................................12, 17Air conditioning, manual.........................13, 35Air conditioning on/off...................................f35Air distribution adjustment......................34, 35Air filter..........................................................r88Air flow..............................................17,34, 35Air flow adjustment .................................34, 35Air vents..................................................33-35Anti-lock braking system (ABS)....................49Anti-theft........................................................26ASR...............................................................50Assistance, emergency braking...................49Audible warning............................................48Audio equipment(general).......................................25, 117,118Audio streaming(Bluetooth)................................................103Audio system (CD/CD changer)..........124-127Audio system (radio)................... 119,120,122Auxiliary socket ..............................40, 117,118
A
D