gearbox PEUGEOT 108 2014 Owner's Manual

159
FuseN° Rating
(A) Functions
27 7. 5VSC system
28 60Passenger compartment fusebox
29** 125***Heated rear screen and door mirror heating - Heated seats
-
el

ectric fabric roof - ABS system - VSC system - Cooling fan -
Front foglamps - L
eD

daytime running lamps
30 50
ele

ctronic gearbox
40 Stop & Start
31 50Power steering
32 50*
Cooling fan
30
40
33 50ABS system - VSC system
34 10Spare fuse
* V
ti 8

2 engine.
** V
ti 6

8 engine.
***
t
h

is fuse must be replaced only by a
P
e

uge
Ot

dealer or a qualified workshop.
9
Practical information

161
12 V battery
the battery is located under the bonnet.
For access to the (+) terminal:
F
r
elease the bonnet using the interior lever,
then the exterior safety catch,
F

r
aise the bonnet and secure it with its stay,
F

l
ift the plastic cover for access to
the (+)


terminal.
Access to the battery
Procedure for starting the engine using another battery or charging a discharged battery.
Before doing any work
Immobilise the vehicle: apply the
parking brake, put the gearbox in
neutral, then switch off the ignition.
Check that all electrical equipment is
switched off.
th

e presence of this label, in particular
with the Stop & Start system, indicates
the use of a 12 V lead-acid battery with
special technology and specification;
the involvement of a P
e

uge
Ot

dealer
or a qualified workshop is essential
when replacing or disconnecting the
battery.
After refitting the battery, the Stop &
Start system will only be active after a
continuous period of immobilisation of the
vehicle, a period which depends on the
climatic conditions and the state of charge
of the battery (up to about 8 hours). Do not push the vehicle to start the
engine if you have an
etg electronic
gearbox.
9
Practical information

165
towing the vehicle
F take the removable towing eye stowed in the tool box, under the boot carpet.
F
u
n
clip the plastic cover, by pressing at the
bottom.
F

F
ully screw in the towing eye.
General recommendations
Observe the legislation in force in your
c o unt r y.
en
sure that the weight of the towing
vehicle is higher than that of the towed
vehicle.
th

e driver must remain at the wheel of
the towed vehicle and must have a valid
driving licence.
When towing a vehicle with all four
wheels on the ground, always use an
approved towing arm; rope and straps
are prohibited.
th

e towing vehicle must move off
g e nt l y.
When towing a vehicle with the engine
off, there is no longer any power
assistance for braking or steering.
In the following cases, you must always
call on a professional recovery service:
-

v
ehicle broken down on a motor way
or fast road,
-
f

our-wheel drive vehicle,
-

w
hen it is not possible to put the
gearbox into neutral, unlock the
steering, or release the parking
brake,
-

t
owing with only two wheels on the
ground,
-

w
here there is no approved towing
arm available...
Your vehicle can only be towed at the front.
F
I
nstall the towing bar.
F

P

ut the gear lever into neutral (position N
for the
etg
electronic gearbox).
F

ailure to observe this instruction may
lead to damage to certain components
(braking, transmission, ...) and the absence
of braking assistance when the engine is
started.
F
u
n

lock the steering and release the
parking brake.
F

S

witch on the hazard warning lamps on
both vehicles.
Never use the radiator crossmember.
9
Practical information

175
Checks
12 V battery
the battery does not require any maintenance.
However, check that the terminals are clean
and correctly tightened, particularly in summer
and winter.Refer to the warranty and
maintenance record for details of
the replacement intervals for these
components.
Air filter and passenger compartment filter
Replace the oil filter each time the
engine oil is changed.
Refer to the warranty and
maintenance record for details of
the replacement interval for this
component.
Oil filter
unless other wise indicated, check these components in accordance with the warranty and maintenance record and according to your engine.
Other wise, have them checked by a PeugeOt dealer or a qualified workshop.
Depending on the environment (e.g. dusty
atmosphere) and the use of the vehicle
(e.g.
city driving), replace them twice as often
if necessary .
A clogged passenger compartment filter may
have an adverse effect on the per formance
of the air conditioning system and generate
undesirable odours.
When carrying out work on the battery, refer
to the "12 V battery" section for details of the
precautions to be taken before disconnecting
the battery and following its reconnection.
Manual gearbox
the gearbox does not require any
maintenance (no oil change).
Refer to the warranty and
maintenance record for the checking
interval for this component.
Clutch
the clutch is operated mechanically and
requires regular adjustment.
Refer to the warranty and maintenance record
for information on when the adjustment should
be checked.
In the event of an operating fault
(difficulty moving off, for example),
contact a P
e

uge
Ot
dealer or a
qualified workshop.
10
Checks

176
ETG electronic gearbox
the etg gearbox does not require
any maintenance (no oil change).
Refer to the warranty and
maintenance record for information
on when this unit should be checked.
Brake wear depends on the style
of driving, particularly in the case
of vehicles used in town, over short
distances. It may be necessary to
Brake pads
For information on checking brake
disc wear, contact a Pe ugeOt
dealer or a qualified workshop.
Brake disc wearOnly use products recommended by
Pe ugeOt or products of equivalent
quality and specification.
In order to optimise the operation of
units as important as those in the
braking system, P
e

uge
Ot
selects and
offers very specific products.
After washing the vehicle, dampness,
or in wintry conditions, ice can form
on the brake discs and pads: braking
efficiency may be reduced. Make light
brake applications to dry and defrost
the brakes.
Parking brake
If excessive travel or a loss of
effectiveness of this system is
noticed, the parking brake must
be checked, even between two
services.
Checking this system must be done by a
P
e

uge
Ot
dealer or a qualified workshop.
have the condition of the brakes checked, even
between vehicle services.
un

less there is a leak in the circuit, a drop in
the brake fluid level indicates that the brake
pads are worn.
Checks

177
Petrol engineVTi 68
e-VTi 68VTi 82
Manual gearbox
(5 - speed) ETG electronic
gearbox
(5 - speed) Manual gearbox
(5 - speed) Manual gearbox
(5 - speed)
Model codes PM, PN PSCFBB - B1A000

PSCFBB-H1A000
PSCFBB-P1A000
PSCFBB-W1A000 PSCFBB-B1C000
PSCFBB-H1C000 PSCFBB-P1C000
PSCFBB-W1C000 PSCFB2-B1B000
PSCFB2-H1B000 PSCFB2-P1B000
PSCFB2-W1B000 PAHMTB - B1A000
PAHMTB-H1A000 PAHMTB-P1A000
PAHMTB-W1A000
Cubic capacity (cc) 9989989981 19 9
Bore x stroke (mm) 71 x 8471 x 8471 x 8477 x 85.8
e

u standard maximum power (kW)* 50505060
Max power engine speed (rpm) 6 0006 0006 000 5 750
e

u standard max torque (Nm) 95.595.595.5 11 6
Max torque engine speed (rpm) 4 8004 8004 800 2 750
Fuel
u

nleaded petrol
u
nleaded petrol
u
nleaded petrol
Catalytic converter Ye sYe sYe s
en

gine oil capacity (with filter replacement) 3.23.23.23.25
*
t
h
e maximum power corresponds to the value type-approved on a test bed, under conditions defined in e
u
ropean legislation (Directive 1999/99/
eC
).
engines
11
Technical data

178
EngineVTi 68
e-VTi 68VTi 82
Manual
gearbox
(5 - speed) ETG electronic
gearbox
(5 - speed) Manual gearbox

(5 - speed) Manual gearbox
(5 - speed)
Model codes PSCFBB - B1A000
PSCFBB-H1A000 PSCFBB-P1A000
PSCFBB-W1A000 PSCFBB-B1C000
PSCFBB-H1C000 PSCFBB-P1C000
PSCFBB-W1C000 PSCFB2-B1B000
PSCFB2-H1B000 PSCFB2-P1B000
PSCFB2-W1B000 PAHMTB - B1A000
PAHMTB-H1A000 PAHMTB-P1A000
PAHMTB-W1A000
Kerb weight 840860 860 865
gr

oss vehicle weight (
gV
W) 1 2401 2401 2401 240
gr

oss train weight (
g
t
W
) 1 2401 2401 2401 240
Weights (in kg)
the design of your vehicle does not permit the fitting of a towbar.
Technical data

239
Dashboard fuses 152-156
Instruments and controls
Opening the bonnet 1 70
Door mirrors
5
1
el

ectric windows
4
2
Courtesy lamp
1
01
Control for electric fabric roof
4
2
Rear view mirror
5
2
Sun visors
6
5
Manual parking brake
7
6Heating, ventilation
5

3-55
Manual air conditioning
5
6-57
Automatic air conditioning
5
8 - 61
Windscreen demist / defrost
6
2
Rear screen demist / defrost
6
3
7-inch touch screen
1
81-220
Setting the time
2
9
Radio

221-236
Setting the time
2
8
Manual gearbox
7
6
e

tg
el
ectronic gearbox
7
7-80
ge

ar shift indicator
8
1
Stop & Start

8
3 - 85
Hill start assist

8
2
12 V accessory socket
6 5uS
B port 6 6
Jack auxiliary socket

6
6
B3_en_Chap13_recherche-visuelle_ed01-2014
.
Visual search

243
Head restraints, rear .......................................50
H eating ............................................... 55, 56, 59
Hill start assist

................................................. 8

2
Hooks


.............................................................. 70
I
engine, petrol ................................ 13 5 , 171, 17 7en
gines ......................................................... 17 7
en

vironment
................. 8 , 5

4, 63, 103, 163, 174
Identification plates
....................................... 18

0
Indicators, direction


......................................102
Inflating accessories (using the kit)


..............13 9
Inflating tyres


............................................8, 180
Instrument panel
...............................

..............10
Instrument panel screen
................................. 11
I

nterior fittings

...........................................64, 65
Interior lamp


..................................................101
iPhone connection


........................................206
ISOFIX


..........................................................131
ISOFIX mountings ................................. 1 2 7, 1 3 1
L
Filling with fuel ...................................... 13 4, 13 5
Fitting a wheel ............................... ................14 4
Fittings, boot
................................................... 69
F

lashing indicators

................102, 148, 150, 151
Folding/unfolding the door mirrors


.................51
Frequency (radio)


.................................. 191, 2 25
Front foglamps


........................................ 9 5, 149
Front seats


...................................................... 47
Fuel ..............................................8, 25, 134, 135
Fuel gauge


.............................................. 25, 13 4
Fuel tank .................................................. 25, 13 4
Fusebox, dashboard


..................................... 15 4
Fuses


............................................................. 152
Jack
........

.......................................................142
Jack cable


.............................................19 4, 228
JACK socket


.............................64, 66, 194, 228
J
Keeping children safe .............11 2 , 114 , 118 -13 3
Key .................................................................. 30
Key, electronic


..................................... 33-35, 37
Key in ignition warning


....................................71
Keyless
e
n
try and Starting ................33, 34, 72
K
F
G
gearbox - etg .................................... 8, 77, 176ge
arbox, manual ..........................8, 76, 83, 175
gea

r lever
..............................
...........................8
ge

ar lever, etg gearbox ................................77
ge

ar lever, manual gearbox

...........................76
ge

ar shift indicator

......................................... 81
gl

ove box .................................................. 64, 65
H
Hands-free kit ....................................... 200, 231
Hazard warning lamps ..................................103
Headlamps


................................ 93, 98, 148, 149 Lamps, front


...........................................
148 -149
Lamps, rear

............................................
150 -151
Lamps, warning and indicator

..................
13 -23
Level, brake fluid
...........................................
17
3
Levels and checks .................................
171-174
Lighting
................
..........................................
148
Lighting bulbs (replacement)
................. 1
47-151
Lighting control stalk

.................................93, 94
Lighting dimmer
..............................
................
26
Lighting, guide-me home

................................
97
Lighting on reminder

.......................................
95
Loading

.............................................................
8
Locating your vehicle
...................................... 3
1
Locking/unlocking a door from the inside....... 38
M
Main beam .............................................. 93, 148
Maintenance ..................................................... 8
Manual mode


.................................................. 77
Mat


.................................................................. 67
Menu


............................. 186, 188, 198, 214, 216
Menus (
tou

ch screen)
.................................. 18

2
Mini fuel level
.......................................... 25, 13 4
Mirrorlink connection


.............................210 -212
Mirror, rear view
.............................................. 52
Mirrors, door .................................................... 51
Mountings for ISOFIX seats


.................1 2 7, 1 3 1
N
Number plate lamps ...................................... 1 51
.
Alphabetical index