Peugeot Partner VU Dag 2004 Owner's Guide

PEUGEOT SERVICING
24
22-12-2003
Intermediate top-up visit included in the Fixed Services.
THE MAINTENANCE CYCLE FOR YOUR PARTNER INDIRECT INJECTION DIESEL
Service every 10,000 miles (15,000 km) or 2 years.
1st Service at
10,000 km or 6 months*.
This is necessary in order to benefit from the warranty.
These fixed services are carried out with synthetic based oil; Fuel Economy oil orsynthetic oil may also be used.
Arduous conditions of use (see corresponding section).
* Whichever comes first. MILES (KM)
10,000/90,000 (15,000/135,000) 20,000/100,000 (30,000/150,000) 30,000/110,000 (45,000/165,000)
40,000/120,000 (60,000/180,000) 50,000/130,000 (75,000/195 000) 60,000/140,000 (90,000/210,000) 70,000/150,000 (105,000/225,000) 80,000/160,000 (120,000/240,00)

PEUGEOT SERVICING25
22-12-2003
A AND C SERVICE LEVELS AND THE INTERMEDIATE VISIT
Level
Operations Description of operation 1st service
A C Intermediate
DRAIN/REFILLÐ Engine oilÐ Bleed fuel filter (diesel)Ð Oil filterÐ Petrol filter (according to engine)REPLACEÐ Diesel filter or element (according to engine)Ð Air filter elementÐ Spark plugs (petrol)Ð Engine oil (check + top-up) Ð Manual gearbox oil (check + top-up) Ð Battery (check + top-up) if cap is removableLEVELÐ Screen wash (check + top-up)Ð Coolant (check + top-up)Ð Brake fluid (check + top-up)Ð Power steering fluid (check + top up according to specification)Ð Operation of lights and indicatorsÐ Condition of glass, headlamp and light lenses and mirrorsÐ HornÐ Windscreen washer jetsÐ Condition of wiper bladesÐ Condition and tension of the ancillary drive beltsÐ HandbrakeÐ Condition of hydraulic circuits (hoses and covers)CHECKÐ Condition of rubber boots and gaitersÐ Brake pads Ð Play in hubs, link rods, ball joints, flexible mountingsÐ Shock absorbersÐ Rear drum brake lining wearÐ Condition and pressure of tyres (including spare wheel)Ð Emission control check as per current legislation (petrol)Ð Smoke opacity (diesel)Ð Passenger compartment filter (according to specification) Ð Visual check of the whole vehicle
SERVICE*Ð Courtesy vehicle
ROAD TEST
: All driving conditions. : Arduous conditions. * According to destination.

(1) Minimum quality standard: Petrol engines: ACEA A3 and API SH/SJ; Diesel engines: ACEA B3 and API CF/CD.
ACEA = Association des Constructeurs EuropŽens Automobiles (Association of European Automobile Manufacturers) -
API =American Petroleum Institute.
If oil is used which does not conform to the ACEA A3-B3 standards, this requires the "Arduous Conditions" servicing schedule to be followed, which involves shorter intervals between services.* This Fuel Economy oil can only be used in engines designed for its use.
TRADE NAMES OF RECOMMENDED ENGINE LUBRICANTS IN EUROPE (1)
PETROL DIESEL
DIESEL PETROL
26
22-12-2003

27
PEUGEOT SERVICING
22-12-2003
Recommendations for recommended lubricants The oils which appear in the table opposite are suitable for mostpurposes. The diagram opposite states the optimum range of viscosity depen-ding on the temperatures at whichthe oils are to be used. It is also possible to use "superior quality" synthetic oils. In the absence of semi-synthetic or
synthetic oils, oils of ACEA A1/A2
and API SH/SJ/SL quality (for petrol
engines), or ACEA B1/B2 and APICD/CF quality (for diesel engines)may be used by following the"Arduous Conditions" servicingschedule which specifies shorterintervals. Do not hesitate to ask for advice
from a PEUGEOT dealer to maintaindriving pleasure and to minimise themaintenance cost of your vehicle. For countries outside Europe, please
contact a local PEUGEOT dealer.
ONLY ONLY
Manual Gearbox ESSO GEAR OIL BVTOTAL TRANSMISSION BV75W80 PR 9736.41 75W80 PR 9730.A2
Power steering ESSO ATF D TOTAL Fluide AT42 PR 9730.94 PR 9730.A3
Other recommended products
Brake fluid PEUGEOT DOT4 Coolant
PROCOR TM 108/GLYSANTIN G33 or REVKOGEL 2000
ONLY protection to Ð35 ¼C

INSTRUMENTS AND CONTROLS
28
22-12-2003
1.
Seat belt not fastened warning light*
2. Passenger air bag disarmingwarning light*
3. Front and side air bags warninglight
4. Front fog lamps indicator light
5. Anti-lock braking system (ABS)warning light
6. Rear fog lamp indicator light
7. Diesel pre-heat warning light
8. Left hand direction indicator
9. Total distance recorder, serviceindicator and engine oil levelindicator 10.
Right hand direction indicator
11 . Engine diagnostics warning light
12. Main beam headlamps indicator light
13. Handbrake, low brake fluid leveland electronic brake forcedistribution warning light
14. Dipped beam headlampsindicator light
15. Battery charge warning light
16. Engine oil pressure andtemperature warning light
17. Water in diesel filter warning light
18. Low coolant level warning light 19.
Coolant temperature indicator
20. Total distance recorder button
21. Central (STOP) warning light
22. Speedometer
23. Rev counter
24. Lighting rheostat button
25. Fuel level indicator
26. Low fuel level warning light
* According to destination.
INSTRUMENT PANEL: PETROL-DIESEL MANUAL GEARBOX

INSTRUMENTS AND CONTROLS29
22-12-2003
Handbrake, low brake
fluid level and Electronic BrakeForce Distribution
system faultwarning light
Linked to the central (STOP) warninglight. This indicates one of the following:
Ð that the handbrake is applied or not fully released,
Ð an excessive drop in brake fluid level (if the warning light remains on even when the handbrake isreleased),
Ð a fault in the Electronic Brake Force Distribution system, if lit at
the same time as the ABS warninglight.
You must stop.
Consult a PEUGEOT dealer.
INSTRUMENTS AND CONTROLS
A permanently lit warning light or one flashing
,with the engine
running, indicates an operatingfault of the unit concerned. Theillumination of certain warninglights may be accompanied byan audible signal and a message
on the multifunction display. Donot ignore this warning: consulta PEUGEOT dealer as soon aspossible.
If the central STOP warning light comes on when you are driving,
stop your vehicle immediately,where it is safe to do so.
Anti-lock braking system (ABS)warning light
This comes on for 3 seconds each time the ignition is switched on. If the warning light remains on or comes on above 8 mph (12 km/h),
this indicates an ABS malfunction.
However, the vehicle retains conven- tional servo-assisted braking. Lighting of this warning light, accompanied by an audible signal,
indicates an ABS fault.
Consult a PEUGEOT dealer.
Diesel engine low coolant levelwarning light
Linked to the central (STOP) warn-ing light.
You must stop.
Wait for the engine to cool before topping up the level. The cooling circuit is pressurised.In the event of breakdown and to prevent any risk of burns , unscrew
the cap by two turns to allow thepressure to drop. When the pressure has dropped, remove the cap and top up the level.
Consult a PEUGEOT dealer.
Central (STOP) warning light
Linked to the warning lights:
Ð "engine oil pressure and tempera- ture",
Ð "low coolant level",
Ð "handbrake",
Ð "low brake fluid level",
Ð "electronic brake force distribution system fault".
Linked with the "coolant tempera-
ture" indicator.
You must stop if the light flashes with the engine running.
Consult a PEUGEOT dealer. Engine oil pressure and temperaturewarning light
Linked to the central (STOP) warn-ing light.
You must stop. This warning light indicates one of the following:
Ð insufficient oil pressure,
Ð a lack of oil in the lubrication cir- cuit. Top up the level.
Ð an oil temperature which is too high. The warning light is acom-
panied by an audible signal. Tolower the oil temperature, reduceyour speed.
Consult a PEUGEOT dealer.

INSTRUMENTS AND CONTROLS
30
22-12-2003
Seat belt not fastened warning light*
When the ignition is switchedon, this indicator light comes on
if the driver has not fastened his seat belt. Above 12 mph (20 km/h), the warning light flashes for two minutes accompa-nied by an audible signal which
becomes progressively louder. Oncethe two minutes have elapsed, thewarning light remains on until the driverfastens his seat belt.
Front and side airbags warning light
The light will come on for a few sec-onds when the ignition is switched on. With the engine running, illumination of this warning light indicates a faultin the air bags.
Consult a PEUGEOT dealer.
Battery charge warning light
This indicates one of the following:
Ð faulty operation of the charging circuit,
Ð slack battery or starter terminals,
Ð a cut or slack alternator belt,
Ð an alternator failure.
Consult a PEUGEOT dealer.
Engine diagnostics warning light
This comes on each time the ignitionis switched on. If it comes on with the engine running, this indicates incorrectoperation of the injection, ignition or
emission control system. There is arisk of damage to the catalyticconverter (petrol engine only).
Consult a PEUGEOT dealer.
* According to destination.
Water in diesel filter indicator*
There is a risk of damage to theinjection system.
Consult a PEUGEOT dealer as soon as possible.
Passenger air bag disarmedwarning light*
If the passenger air bag is disarmed, the warning light comes on when the ignitionis switched on and it remains on.
Always consult a PEUGEOT dealerif the warning light flashes. Low fuel levelwarning light
When this light first comes on, you haveenough fuel to drive
approximately
30 miles (50 km) . (The tank capacity is
approximately 55 litres for petrol engines
and 60 litres for Diesel engines.)
Diesel engine pre-heatwarning light
Wait until the warning light goes out before starting the engine. If the temperature is high enough, the warning light comes on for less
than one second. You can start theengine without waiting.
Coolant temperature indicator
Ð needle in zone (A), the tempera-
ture is correct,
Ð needle in zone (B), the tempera-
ture is too high. The central STOP
warning light flashes.
You must stop.
Consult a PEUGEOT dealer.

INSTRUMENTS AND CONTROLS
30
22-12-2003
Seat belt not fastened warning light*
When the ignition is switchedon, this indicator light comes on
if the driver has not fastened his seat belt. Above 12 mph (20 km/h), the warning light flashes for two minutes accompa-nied by an audible signal which
becomes progressively louder. Oncethe two minutes have elapsed, thewarning light remains on until the driverfastens his seat belt.
Front and side airbags warning light
The light will come on for a few sec-onds when the ignition is switched on. With the engine running, illumination of this warning light indicates a faultin the air bags.
Consult a PEUGEOT dealer.
Battery charge warning light
This indicates one of the following:
Ð faulty operation of the charging circuit,
Ð slack battery or starter terminals,
Ð a cut or slack alternator belt,
Ð an alternator failure.
Consult a PEUGEOT dealer.
Engine diagnostics warning light
This comes on each time the ignitionis switched on. If it comes on with the engine running, this indicates incorrectoperation of the injection, ignition or
emission control system. There is arisk of damage to the catalyticconverter (petrol engine only).
Consult a PEUGEOT dealer.
* According to destination.
Water in diesel filter indicator*
There is a risk of damage to theinjection system.
Consult a PEUGEOT dealer as soon as possible.
Passenger air bag disarmedwarning light*
If the passenger air bag is disarmed, the warning light comes on when the ignitionis switched on and it remains on.
Always consult a PEUGEOT dealerif the warning light flashes. Low fuel levelwarning light
When this light first comes on, you haveenough fuel to drive
approximately
30 miles (50 km) . (The tank capacity is
approximately 55 litres for petrol engines
and 60 litres for Diesel engines.)
Diesel engine pre-heatwarning light
Wait until the warning light goes out before starting the engine. If the temperature is high enough, the warning light comes on for less
than one second. You can start theengine without waiting.
Coolant temperature indicator
Ð needle in zone (A), the tempera-
ture is correct,
Ð needle in zone (B), the tempera-
ture is too high. The central STOP
warning light flashes.
You must stop.
Consult a PEUGEOT dealer.

INSTRUMENTS AND CONTROLS
31
22-12-2003
Instrument panel display After switching on the ignition, three functions are shown in succession:
Ð service indicator (see corresponding section),
Ð engine oil level indicator (Diesel),
Ð total distance recorder/total and trip distances.Note:the total and trip distances are displayed for 30 seconds when the ignition is switched off, on opening the driver's door,
as well as on locking and unlocking the vehicle. Engine oil level (Diesel) When the ignition is switched on, the engine oil level is indicated for approximately 10 seconds, after the servicing information.
Maximum Note: a surplus of oil can cause damage to the engine.
Minimum
Check the level with the dipstick and top it up. The level indicated is only correct if the vehi- cle has been on stable, level ground, with the engine stopped, for 10 minutes. Oil level gauge fault
The 6 segments flash to indicate a fault in the oil level gauge.There is a risk the engine will be damaged.
Consult a PEUGEOT dealer.

Lighting rheostat With the lights on, press the button to vary the intensity of the lighting ofthe instruments and controls. Whenthe lighting reaches the minimum (ormaximum) setting, release the but-ton then press it again to increase(or reduce) the brightness. As soon as the lighting is of the required brightness, release thebutton.
Total distance recorder Briefly pressing button
1alternates
between the total and trip distance displays.
To reset the trip recorder to zero, when it is displayed press button 1
until zeros appear.
INSTRUMENTS AND CONTROLS
32
22-12-2003