Peugeot Partner VU Dag 2004 Workshop Manual

1. Air conditioning
The air conditioning is designed to operate in all seasons. In summer, it enables
the temperature to be lowered and in winter, above 0 ¡C, it increases the effec-tiveness of the demisting.Press the switch to activate the air conditioning. The indicator light comes on. 2. Air flow adjustment and air
intake control
Turn the control from posi-tion 1to position 4to obtain
an air flow sufficient toensure your comfort.
YOUR PARTNER IN DETAIL
50
22-12-2003
AIR CONDITIONING
The air conditioning does not operate while the air flow adjustment control is in the minimum position. Note: It is quite normal that the condensation created by the air conditioning
results in a flow of water under the vehicle when it is stationary.

4. Air distribution adjustmentWindscreen and side win- dows (de-icing/demisting).
To quickly de-ice or demist the wind-screen and side windows:
Ð turn the temperature and air flow controls to maximum,
Ð close the centre vents,
Ð position the air intake control in the "Outside Air" position,
Ð start the air conditioning.
Windscreen, side windows and footwells. Footwells.
These settings are recommended for cold climates. Centre and side vents.
This setting is recommended forhigh temperatures.
Intake of exterior air.
This is the normal operating posi-tion.
Recirculation of interior air.
This position prevents exteriorodours and smoke entering the pas-senger compartment. Used simultaneously with the air conditioning, recirculation enablesboth heating and cooling perform-ance to be improved. Used without the air conditioning, recirculation may result in misting ofthe windows. As soon as possible, position the control in the exterior air intake posi-tion.
YOUR PARTNER IN DETAIL 51
22-12-2003
3. Temperature adjustment
To be adjusted to your requirements.From blue (cold when the air condi- tioning is on) to red (hot).
Important precaution Operate the air conditioning system for 5 to 10 minutes, once or twice amonth, to keep it in perfect working
order.
If the system does not produce cold air, do not use it and contact a PEUGEOT
dealer. Note:
to optimise the operation of
the air conditioning, leave the vents open.

YOUR PARTNER IN DETAIL
52
22-12-2003
To remove the head restraint, place it in the top position, pressthe tabs and pull it upwards.
To put it back in position, locate the stems of the restraint in theholes, taking care to keep themin line with the seat back.
2- Seat back angle adjustment Turn the knob.
3- Forwards-backwards adjustment (driver) Lift the control and slide the seat forwards or backwards.
SEATS
1- Head restraint height
adjustment
To raise or lower the restraint, slide it.
The adjustment is correct when the upper edge of thehead restraint is level withthe top of the head.

YOUR PARTNER IN DETAIL53
22-12-2003
Never drive with the head restraints removed;they must be in placeand correctly adjusted.
Do not place heavyobjects in the drawers.
4- Storage drawer (version with passenger air bag) There is a storage drawer under the driver's or passenger seat.
To open it, lift it and pull.
5- Heated seats switch Press the switch. The tempera-
ture is controlled automatically. Pressing the switch again stops operation. Note: the command for activation
of heating of the seat(s) remains memorised for two minutes after
the ignition has been switched off.

YOUR PARTNER IN DETAIL
54
22-12-2003
MULTIFUNCTION PASSENGER SEAT*
To fold the seat back: Pull the control
1upwards and tilt the seat back.
This provides a flat surface, recesses for drinks and a strap for retaining documents.
To fold the seat fully: Pull the control 2upwards and tilt the whole seat.
It is not necessary to remove the head restraint.This provides access to a box which enables you to store objects so that they cannot be seen from outside the vehicle or to wedge long objects passed through the roof flap. If your vehicle is not fitted with a load blocking partition, it can accommodate long objects (up to 2.10 m). These must be placed on the front edge of the instrument panel and secured using the rear bar of the boot or using the lashing rings.
* According to destination.

YOUR PARTNER IN DETAIL55
22-12-2003
LASHING RINGS Use the 6 lashing rings on the lug- gage compartment floor to secureyour loads.
You can use suitable load retainers (half-height partitions, grille, etc.)
supplied by your PEUGEOT dealer.
For greater safety, always
ensure that the
loads transported are
stowed securely.

YOUR PARTNER IN DETAIL
56
22-12-2003
GENERAL POINTS RELATING TO CHILD SEATS Although one of PEUGEOT's main criteria when designing your vehicle, the safety of your children also depends on you.
For maximum safety, please follow these precautions:
Ð Since 1992,
all children under the age of 10 must travel in approved child
seats* suited to their weight , on seats fitted with a seat belt.
Ð A child weighing less than 9 kg must travel in the rearwards facing position both in the front and in the rear. PEUGEOT recommends that children should travel in the "rearwards facing" position up to the age of two.
Ð Statistically, the safest seats in your vehicle for the transportation of chil- dren are the rear seats. PEUGEOT recommends that children travel in the rear even when a "rearwards facing" child seat is used.
Ð If a child is travelling on a booster seat, check that the lap section of the seat belt passes over the child's thighs correctly. The chest section of the seat beltmust be positioned on the child's shoulder without touching the neck. PEUGEOTrecommends that you use a booster seat with a back, fitted with a seat beltguide at shoulder level.
Ð Remember to fasten the seat belt or the child seat harness keeping the slack
in relation to the child's body to a minimum , even for short journeys.
* According to current legislation in the country.
** Consult the relevant administration in your country for information regarding the rules for transporting children on the front passenger seat.Rules for transporting children on the front passenger seat** Children under the age of 10 must not travel in the forwards facing position, unless the rear seats arealready occupied by other childrenor the rear seats cannot be used(absent or folded). In this case,adjust the front passenger seat tothe intermediate position and leavethe passenger air bag armed. The transportation of children in the rearwards facing position is permit-
ted. In this position, it is essential to
disarm the passenger air bag.Otherwise, the child would risk beingkilled or seriously injured if the airbag were to inflate.

YOUR PARTNER IN DETAIL57
CHILD SEATS RECOMMENDED BY PEUGEOT
PEUGEOT offers a complete range of child seats which are secured using the seat belt:
Group 0+: from birth to 13 kg L1 - "Britax Babysure": installed in the rear-facing position in the front and in the rear using a three-point seat belt. In the front, it is compulsory to disarm the passenger air bag and the vehicle's seat must be adjusted to the intermediate longitudinal position.
Group 1: from 9 to 18 kg L2 - "Ršmer Prince": installed in the rear using a two or three-point seat belt. For the safety of your child, it is imperative that the restraining cushion is used.
Group 2: from 15 to 25 kg L3 - "Ršmer Vario'': installed in the rear using a two or three-point seat belt.
22-12-2003

YOUR PARTNER IN DETAIL
58
22-12-2003
Groups 2 and 3: from 15 to 36 kg
L4 - "Recaro Start'': installed in the rear using a three-point seat belt. The height and width at the shoulders and length of the seat cushion must be adjusted according to the age and build of your child. L5 - "Klippan Optima": installed in the rear using a three-point seat belt. From the age of 6 years (approximately 22 kg), the booster is used on its own.
Groups 1, 2 and 3: from 9 to 36 kg L6 - "Kiddy Life": installed in the rear using a three-point seat belt.The height and width at the shoulders and the length of the seat cushion must be adjusted according to the age and build of your child.
For the safety of young children (from 9 to 18 kg), PEUGEOT recommends use of the restraining cushion.
Never leave one or more children alone and unsu-pervised in a vehicle. Never leave a child or an
animal in a vehicle which is exposed to the sun and has thewindows closed.
To protect your young children from the sun, fit blinds on the rearwindows. Never leave the keys within reach of children inside the vehi-cle. Observe strictly the recommen- dations for assembling andsecuring the child seat as shownin the child seat instructions.
To prevent the doors from opening
accidentally, use the child lock*. Also, do not open the rear windows more than a third*.
* According to model.
Disarm the passenger air bag when installing a "rearwards facing" child seat on the front passenger seat. Otherwise, the child would risk beingkilled or seriously injured were the air bag to inflate.

YOUR PARTNER IN DETAIL59
SUMMARY TABLE FOR THE INSTALLATION OF CHILD SEATS In accordance with European regulations (Directive 2000/3), the table below indicates the options for the installation of child seats secured using the seat belt and universally approved (child seats which can be installed in all vehicles using a seatbelt), in accordance with the weight of the child and the seat in the vehicle:
U : seat suitable for the installation of a child seat secured using the seat belt and "universally" approved. "Rear facing" and "forward facing" child seats.
(a) Group 0 : from birth to 10 kg.
(b) The rules for transporting children on the front passenger seat are specific to each country. Consult the legislation in for ce
in your country. Regulation weight group
Seat
Weight below 13 kg Weight from 9 to 18 kg Weight from 15 to 25 kg Weight from 22 to 36 kg
(groups 0 (a) and 0+) (group 1) (group 2) (group 3) From birth to 1 year From 1 to 3 years From 3 to 6 years From 6 to 10 years approx. approx. approx. approx.
Front passenger seat (b) UU UU
22-12-2003