manual transmission Ram 2500 2011 Owner's manual (Gas and Diesel)
[x] Cancel search | Manufacturer: RAM, Model Year: 2011, Model line: 2500, Model: Ram 2500 2011Pages: 117, PDF Size: 0.28 MB
Page 9 of 117
JOBNAME: 288987 2011 Maint-Wa PAGE: 8 SESS: 55 OUTPUT: Wed May 26 09:12:27 2010
/chrysler/chry-intl/warr-maint/288987-ram-gasdsl-en/warranty
5/100 POWERTRAIN WARRANTY
The following powertrain components are covered for5 years or 100,000
kilometres,whichever occurs first, measured from the vehicle’s original
warranty start date.
Vehicles placed in taxi, limousine, postal or ambulance service and all SRT
vehicles are excluded from the5-year or 100,000-kilometrePowertrain
Warranty, and are covered only under the3-year or 60,000-kilometreBasic
Warranty.
•Engine –Cylinder block and all internal parts; cylinder head assem-
blies; timing case, timing chain, timing belt, gears and sprockets;
vibration damper; oil pump; water pump and housing; intake and
exhaust manifolds; flywheel with starter ring gear; core plugs; valve
covers; oil pan; turbocharger housing and internal parts; turbocharger
wastegate actuator; supercharger; serpentine belt tensioner; seals and
gaskets for listed components only.
•Transmission –Transmission case and all internal parts; torque con-
verter; drive/flex plate; transmission range switch; transmission control
module; bell housing; oil pan; seals and gaskets for listed components
only.
Note: Manual transmission clutch parts are not covered at any time.•Rear-Wheel Drive (If equipped) –Rear axle housing and all internal
parts; axle shafts; axle shaft bearings; driveshaft assemblies; driveshaft
centre bearings; universal joints and yokes; seals and gaskets for listed
components only.
•4-Wheel Drive (4x4) (If equipped)–Transfer case and all internal parts;
transfer case control module and shift mode motor assembly; axle
housing and all internal parts; axle shafts; axle shaft bearings; drive-
shaft assemblies (front and rear); driveshaft centre bearings; universal
joints and yokes; disconnect housing assembly; seals and gaskets for
the listed components.
•All-Wheel Drive (AWD) (If equipped) –Power transfer unit and all
internal parts; driveshaft and axle shaft assemblies; constant velocity
joints and boots; axle housing and all internal parts; differential carrier
assembly and all internal parts; output ball bearing; output flange; end
cover; viscous converter clutch; overrunning clutch; vacuum motor;
torque tube; pinion spacer and shim; seals and gaskets for these parts
only.
8
5/100 POWERTRAIN WARRANTY
Page 33 of 117
JOBNAME: 288987 2011 Maint-Wa PAGE: 2 SESS: 22 OUTPUT: Wed May 26 09:12:27 2010
/chrysler/chry-intl/warr-maint/288987-ram-gasdsl-en/01aintervals-gas
INTRODUCTIONThe oil change indicator system will remind you that
it is time to take your vehicle in for scheduled
maintenance. Based on engine operation condition
the oil change indicator message will illuminate, this
means that service is required for your vehicle. Have
your vehicle serviced as soon as possible, within the
next 800 km. The oil change indicator message will
not monitor the time since the last oil change. Change
your vehicles oil if it has been 6 months since your
last oil change even if the oil change indicator
message is NOT illuminated. Change your engine oil
more often if you drive your vehicle off-road for an
extended period of time.Under no circumstances
should oil change intervals exceed 13,000 km or
6 months, whichever comes first.Your dealer will
reset the oil change indicator message after complet-
ing the scheduled oil change. If this scheduled oil
change is performed by someone other than yourdealer the message can be reset by referring to the
steps described in the Owner’s Manual.
The performance of all scheduled service work is
required to maintain your vehicle in good operat-
ing condition. Chrysler Canada Inc. reserves the
right to deny warranty coverage if the vehicle has
not been properly maintained. While we do not
insist that such work be performed by factory
authorized retailers, we strongly recommend that
an authorized Chrysler, Jeepor Dodge Retailer
perform this work.
AT EACH STOP FOR FUEL
•Check the engine oil level about 5 minutes
after a fully warmed engine is shut off. Check-
ing the oil level while the vehicle is on level
ground will improve the accuracy of the oil
level reading. Add oil only when the level is at
or below the ADD or MIN mark.
•Check the windshield washer solvent and add
if required.ONCE A MONTH
•Check tire pressure and look for unusual wear
or damage.
•Inspect the battery and clean and tighten the
terminals as required.
•Check the fluid levels of coolant reservoir,
brake master cylinder, power steering and
transmission and add as needed.
•Check all lights and other electrical items for
correct operation.
•Check and clean wiper blades. Replace if
required.
AT EACH OIL CHANGE
•Change the engine oil filter.
•Inspect the brake hoses and lines.
VISUAL INSPECTIONS —
INSPECT FOR SIGNS OF COMPONENT
DETERIORATION AND PHYSICAL DAMAGE.
MAINTENANCEScheduled maintenance must be completed to provide the best vehicle performance and reliability. The limited warranties in the
warranty booklet DO NOT COVER repairs required due to improper maintenance. We strongly suggest you keep track of scheduled maintenance and keep receipts
or other documents. Use only recommended MoparLubricants and genuine MoparParts. In the event that a condition arises between maintenance intervals,
please contact your retailer. AVOID PROLONGED PERIODS OF IDLING.
NOTE: WHERE TIME (MONTHS) AND METRAGE ARE INDICATED, FOLLOW THE INTERVAL THAT OCCURS FIRST.
Page 73 of 117
JOBNAME: 288987 2011 Maint-Wa PAGE: 2 SESS: 26 OUTPUT: Wed May 26 09:12:27 2010
/chrysler/chry-intl/warr-maint/288987-ram-gasdsl-en/02aintervals-diesel
INTRODUCTIONYour vehicle is equipped with an engine oil change
indicator system. This system will alert you when it is
time to change your engine oil by displaying the words
“Oil Change Required” on your Electronic Vehicle Infor-
mation Center (EVIC). The engine oil change indicator
system is duty cycle based, which means the engine oil
change interval may fluctuate depending on your per-
sonal driving style. Driving styles such as frequent stop
and go type driving can increase the frequency of the
engine oil change. This is the result of more frequent
regeneration of the exhaust aftertreatment system, which
can decrease the life of the engine oil. Failure to change
the engine oil per the maintenance schedule can result in
internal engine damage.
Under no circumstances should the oil change interval
exceed 12,000 km or six months whichever occurs first.
For information on resetting the Oil Change Indicator
message, refer to “Oil Change Required If
Equipped,” under “System Status (EVIC Displays)”
in the “Electronic Vehicle Information Center
(EVIC)” Section of the Owner’s Manual.The performance of all scheduled service work is
required to maintain your vehicle in good operating
condition. Chrysler Canada Inc. reserves the right to
deny warranty coverage if the vehicle has not been
properly maintained. While we do not insist that such
work be performed by factory authorized retailers,
we strongly recommend that an authorized Chrysler,
Jeepor Dodge Retailer perform this work.
AT EACH STOP FOR FUEL
•Check the engine oil level about 5 minutes after a
fully warmed engine is shut off. Checking the oil
level while the vehicle is on level ground will
improve the accuracy of the oil level reading. Add
oil only when the level is at or below the ADD or
MIN mark.
•Check the windshield washer solvent and add if
required.
ONCE A MONTH
•Check tire pressure and look for unusual wear or
damage.
•Inspect the batteries, clean and tighten the termi-
nals as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, and transmission and transfer
case (if equipped) add as needed.
•Drain water from the fuel filter.•Check and clean wiper blades. Replace if required.
AT EACH OIL CHANGE
•
Change the engine oil filter.•Inspect the exhaust system.•Inspect the brake hoses and lines.•Check the automatic transmission fluid level.•Check the manual transmission fluid level.•Check the engine coolant level, hoses, and clamps.•Lubricate outer tie rod ends.
Inspection and service should also be performed any-
time a malfunction is observed or suspected. Retain all
receipts.
VISUAL INSPECTIONS —
INSPECT FOR SIGNS OF COMPONENT
DETERIORATION AND PHYSICAL DAMAGE.
MAINTENANCEScheduled maintenance must be completed to provide the best vehicle performance and reliability. The limited warranties in the
warranty booklet DO NOT COVER repairs required due to improper maintenance. We strongly suggest you keep track of scheduled maintenance and keep receipts
or other documents. Use only recommended MoparLubricants and genuine MoparParts. In the event that a condition arises between maintenance intervals,
please contact your retailer. AVOID PROLONGED PERIODS OF IDLING.
NOTE: WHERE TIME (MONTHS) AND METRAGE ARE INDICATED, FOLLOW THE INTERVAL THAT OCCURS FIRST.
Page 88 of 117
JOBNAME: 288987 2011 Maint-Wa PAGE: 15 SESS: 68 OUTPUT: Wed May 26 09:12:27 2010
/chrysler/chry-intl/warr-maint/288987-ram-gasdsl-en/02bintervals-diesel
Perform Maintenance At
96,000 km or 48 Months
❏Change the engine oil and oil filter.Under no circumstances should the oil change
interval exceed 12,000 km or 6 months whichever occurs first.*
❏Rotate tires.
❏Check the diesel exhaust fluid (DEF) tank, refill if necessary.
❏Lubricate the front drive shaft fitting. (4x4)
❏Lubricate the outer tie rod ends. (Chassis Cab only)
❏Inspect the front suspension components, tie rod ends and boot seals; replace if
necessary.
❏Change the transfer case fluid.(4x4)
❏Inspect the front (4x4) and rear axle fluid; change if using your vehicle for any of
the following: police, fleet, off-road or frequent trailer towing.
❏Replace the fuel filter element.
❏Inspect the front wheel bearings.
❏Inspect the manual transmission fluid; add if necessary.
❏Change the automatic transmission fluid and filter. (Chassis Cab only)
❏Change the automatic transmission fluid and filter if using your vehicle for any of
the following: police, fleet or frequent trailer towing. (Ram Truck only)
* Oil changes that are prompted by the oil change indicator system prior to this schedule maintenance interval can
be recorded in the oil change log section.
Perform Maintenance
At
48 Months or
96,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................
Page 89 of 117
JOBNAME: 288987 2011 Maint-Wa PAGE: 16 SESS: 68 OUTPUT: Wed May 26 09:12:27 2010
/chrysler/chry-intl/warr-maint/288987-ram-gasdsl-en/02bintervals-diesel
❏Change the engine oil and oil filter.Under no circumstances
should the oil change interval exceed 12,000 km or
6 months whichever occurs first.*
❏Rotate tires.
❏Check the diesel exhaust fluid (DEF) tank, refill if necessary.
❏Lubricate the front drive shaft fitting. (4x4)
❏Lubricate the outer tie rod ends. (Chassis Cab only)
❏Inspect the front suspension components, tie rod ends and boot
seals; replace if necessary.
❏Change the transfer case fluid.(4x4)
❏Inspect the front (4x4) and rear axle fluid; change if using your
vehicle for any of the following: police, fleet, off-road or fre-
quent trailer towing.
❏Replace the fuel filter element.
❏Inspect the front wheel bearings.
❏Inspect the manual transmission fluid; add if necessary.
❏Change the automatic transmission fluid and filter. (Chassis
Cab only)
❏Change the automatic transmission fluid and filter if using your
vehicle for any of the following: police, fleet or frequent trailer
towing. (Ram Truck only)
* Oil changes that are prompted by the oil change indicator system prior to this
schedule maintenance interval can be recorded in the oil change log section.
Perform Maintenance At
96,000 km or 48 Months
Odometer Reading
Date
Repair Order No.
CHRYSLER
RETAILERSTAMP
Signature of authorized Chrysler Canada Retailer
................................................................................................
Page 104 of 117
JOBNAME: 288987 2011 Maint-Wa PAGE: 31 SESS: 68 OUTPUT: Wed May 26 09:12:27 2010
/chrysler/chry-intl/warr-maint/288987-ram-gasdsl-en/02bintervals-diesel
Perform Maintenance At
192,000 km or 96 Months
❏Change the engine oil and oil filter.Under no circumstances should the oil change
interval exceed 12,000 km or 6 months whichever occurs first.*
❏Rotate tires.
❏Check the diesel exhaust fluid (DEF) tank, refill if necessary.
❏Lubricate the front drive shaft fitting. (4x4)
❏Lubricate the outer tie rod ends. (Chassis Cab only)
❏Inspect the front suspension components, tie rod ends and boot seals; replace if
necessary.
❏Change the transfer case fluid.(4x4)
❏Inspect the front (4x4) and rear axle fluid; change if using your vehicle for any of
the following: police, fleet, off-road or frequent trailer towing.
❏Replace the fuel filter element.
❏Inspect the front wheel bearings.
❏Change the manual transmission fluid if using your vehicle for any of the following
police, fleet or frequent trailer towing.
❏Change the automatic transmission fluid and filter(s).
* Oil changes that are prompted by the oil change indicator system prior to this schedule maintenance interval can
be recorded in the oil change log section.
Perform Maintenance
At
96 Months or
192,000 km
Odometer Reading
DateRetailer Copy
Remove and attach to Repair Order
................................................................................................
Page 105 of 117
JOBNAME: 288987 2011 Maint-Wa PAGE: 32 SESS: 68 OUTPUT: Wed May 26 09:12:27 2010
/chrysler/chry-intl/warr-maint/288987-ram-gasdsl-en/02bintervals-diesel
❏Change the engine oil and oil filter.Under no circum-
stances should the oil change interval exceed 12,000 km
or 6 months whichever occurs first.*
❏Rotate tires.
❏Check the diesel exhaust fluid (DEF) tank, refill if
necessary.
❏Lubricate the front drive shaft fitting. (4x4)
❏Lubricate the outer tie rod ends. (Chassis Cab only)
❏Inspect the front suspension components, tie rod ends and
boot seals; replace if necessary.
❏Change the transfer case fluid.(4x4)
❏Inspect the front (4x4) and rear axle fluid; change if using
your vehicle for any of the following: police, fleet, off-
road or frequent trailer towing.
❏Replace the fuel filter element.
❏Inspect the front wheel bearings.
❏Change the manual transmission fluid if using your vehicle
for any of the following police, fleet or frequent trailer
towing.
❏Change the automatic transmission fluid and filter(s).
* Oil changes that are prompted by the oil change indicator system prior to this
schedule maintenance interval can be recorded in the oil change log section.
Perform Maintenance At
192,000 km or 96 Months
Odometer Reading
Date
Repair Order No.
CHRYSLER
RETAILERSTAMP
Signature of authorized Chrysler Canada Retailer
................................................................................................