engine control unit SSANGYONG KORANDO 1997 Service Service Manual

2-4 2-4 2-4 2-4
2-4
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
Engine Room FuseBox - W/H Main
Engine Room Fuse Box - W/H Engine Room
Engine Room Fuse Box - W/H Engine Room
Engine Room Fuse Box - W/H Engine Room
Engine Room Fuse Box - W/H Engine Room
W/H Engine Room - W/H Pre - Heating
W/H Engine Room - W/H Alternator
W/H Engine Room - W/H Alternator
W/H Engine Room - W/H Wheel G. sensor
W/H Engine Room - W/H Main
W/H Engine Room - W/H Main
W/H Engine Control - W/H ECM Main
W/H Engine Control - W/H ECM Main
W/H Main - W/H Fuel Cut Solenoid
W/H Main - W/H Roof
W/H Main - W/H Air Bag
W/H Main - W/H Air Bag
W/H Main - W/H SDM
W/H Main - W/H Air Conditioner
W/H Main - W/H ECM Main
W/H Main - W/H Transmission
W/H Main - W/H Transmission
W/H Main - W/H Transmission
W/H Main - W/H Fuel Pump
W/H Main - W/H Fuel Pump
W/H Main - W/H Fuel Pump
W/H Main - W/H Seat Heater
W/H Main - W/H Main
W/H Main - W/H FRT LH Door
W/H FRT LH Door - W/H Speaker
W/H Main - W/H FRT RH Door
W/H FRT RH Door - W/H Speaker
G201W/H Main Upper Front Left Leg Room
G202W/H Main Upper Front Left Leg Room
G203W/H Main Left Upper Center Facia
G204W/H Main Left Lower Center Facia
G205W/H Main Center "A" Pillar Front Right
G301W/H Main Below Front Left seat
G302W/H Main Below Center Console
G303W/H Main Below Front Right seat
G401W/H Main Inside Lower Trim Rear Left Quater
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Bhind Battery
Below Air Cleaner
Below Air Cleaner
Upper Front Right Control Arm
Next to Hydraulic Unit
Next to Hydraulic Unit
Behind Hydraulic Unit
Behind Hydraulic Unit
Next to Engine Room Fuse Box
Inside Left Cluster
Above FRT LH Seat Under Cover
Above FRT LH Seat Under Cover
Lower Rear Center Facia
Upper Evaporator
Lower "A" Piller(Upper ECM)
Upper Transfer Case
Upper Transfer Case
Upper Transfer Case
Upper Transfer Case
Upper Transfer Case
Upper Transfer Case
Below FRT LH Seat
Below Center Console
Upper Fuse Box
(Passenger Room)
Inside FRT LH Door Trim
Behind Front Right Panel
Inside FRT RH Door Trim
2. 2.2. 2.
2.
CONNECT CONNECTCONNECT CONNECT
CONNECT
OR, OR,OR, OR,
OR,
GR GR GR GR
GR
OUND AND SPLICE PA OUND AND SPLICE PAOUND AND SPLICE PA OUND AND SPLICE PA
OUND AND SPLICE PA
CK INFORMA CK INFORMACK INFORMA CK INFORMA
CK INFORMA
TION TIONTION TION
TION1) 1)1) 1)
1)
CONNECTOR CONNECTORCONNECTOR CONNECTOR
CONNECTORConnector Number Connector NumberConnector Number Connector Number
Connector Number
(Pin Number, Color) (Pin Number, Color)(Pin Number, Color) (Pin Number, Color)
(Pin Number, Color)Connecting Connecting Connecting Connecting
Connecting
Wiring Harness Wiring HarnessWiring Harness Wiring Harness
Wiring Harness
Connector Position Connector PositionConnector Position Connector Position
Connector Position
C101 (19Pin, White)
C102 (4Pin, Colorless)
C103 (22Pin, White)
C104 (8Pin, Colorless)
C105 (10Pin, White)
C106 (3Pin, Black)
C107 (20Pin, White)
C108 (6Pin, Colorless)
C109 (1Pin, Black)
C110 (2Pin, Black)
C110 (4Pin, Black)
C111 (3Pin, Black)
C112 (6Pin, Black)
C113 (12Pin, Black)
C114 (6Pin, Gray)
C115 (40Pin, Black)
C116 (3Pin, Black)
C201 (8Pin, White)
C202 (4Pin, White)
C203 (2Pin, Black)
C204 (4Pin, Colorless)
C205 (17Pin, White)
C206 (6Pin, Black)
C301 (2Pin, Black)
C301 (16Pin, Black)
C302 (10Pin, Black)
C303 (3Pin, Black)
C303 (4Pin, Black)
C303 (6Pin, Black)
C304 (10Pin, White)
C305 (14Pin, White)
C351 (22Pin, White)
C352 (2Pin, Black)
C361 (22Pin, Blue)
C362 (2Pin, Black)
2) 2)2) 2)
2)
SPLICE PACK SPLICE PACKSPLICE PACK SPLICE PACK
SPLICE PACK
S201
S202
S203
S204
S205Splice Pack Position Splice Pack PositionSplice Pack Position Splice Pack Position
Splice Pack Position Wiring WiringWiring Wiring
Wiring
Harness HarnessHarness Harness
Harness Color ColorColor Color
Color Splice Pack Splice PackSplice Pack Splice Pack
Splice Pack
Number NumberNumber Number
Number
Colorless
Black
Colorless
Colorless
ColorlessW/H Main
W/H Main
W/H Main
W/H Main
W/H MainUpper Fuse Box(Passenger Room)
Behind Cluster
Behind 4WD Switch
Behind Audio
Behind Front Right Kick Panel
Remark RemarkRemark Remark
Remark
Diesel only
Gasoline
Diesel
Gasoline
Gasoline
Diesel
Gasoline
Manual T/M
Automatic T/M
Diesel
Diesel
Gasoline
GSL : EURO IIIBehind Left Tail Lamp
Behind Left Tail Lamp
Inside Rear Bumper
Inside Tail Gate
Connector Number Connector NumberConnector Number Connector Number
Connector Number
(Pin Number, Color) (Pin Number, Color)(Pin Number, Color) (Pin Number, Color)
(Pin Number, Color)Connecting Connecting Connecting Connecting
Connecting
Wiring Harness Wiring HarnessWiring Harness Wiring Harness
Wiring Harness
Connector Position Connector PositionConnector Position Connector Position
Connector Position
C401 (2Pin, Black)
C402 (12Pin, Black)
C403 (3Pin, Black)
C404 (2Pin, Black)W/H Tail Gate - W/H Main
W/H Tail Gate - W/H Main
W/H Rear Bumper - W/H Main
W/H Tail Gate - W/H HMSL
Remark RemarkRemark Remark
Remark
3) 3)3) 3)
3)
GROUND GROUNDGROUND GROUND
GROUND
G101
G102
G103Ground Position Ground PositionGround Position Ground Position
Ground Position
Wiring Harness Wiring HarnessWiring Harness Wiring Harness
Wiring Harness Number NumberNumber Number
Number
Ground GroundGround Ground
Ground
W/H Engine Room
Battery
W/H Engine RoomLeft Fender Next to Battery
Center Engine Block
Right Fender Engine Room
Pin PinPin Pin
Pin
Number NumberNumber Number
Number
8
20
14
14
8

ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
2-5 2-5 2-5 2-5
2-5
W/H Main
W/H Main
W/H Main
W/H Main
W/H Main
W/H Main
W/H Main
W/H Main J203
J204
J205
J301
J302
J303
J304
J401 J101
J102
J103
J104
J105
J106
J107
J108
J201
J202W/H Engine Room
W/H Engine Room
W/H Engine Room
W/H Engine Room
W/H Main
W/H Engine Control
W/H Engine Control
W/H Engine Control
W/H Main
W/H Main
4) 4)4) 4)
4)
JOINT JOINTJOINT JOINT
JOINT
Joint Position Joint PositionJoint Position Joint Position
Joint Position
Wiring Harness Wiring HarnessWiring Harness Wiring Harness
Wiring Harness Joint JointJoint Joint
Joint
Number NumberNumber Number
Number
Remark RemarkRemark Remark
RemarkGasoline
Gasoline
Gasoline
Gasoline
Gasoline
Gasoline Next to BTSI Unit
Upper Blower Unit
Behind Front Right Kick Panel
Below Rear Left Seat
Below Rear Left Seat
Below Rear Right Seat
Below Rear Right Seat
Below Luggage Lamp Behind Battery
Behind Battery
Below Air Cleaner
Below Air Cleaner
Next to Hydraulic Unit
Behind Hydraulic Unit
Next to Yellow Label
Upper Injector #4 (4CYL) or #6 (6CYL)
Above FRT LH Seat Under Cover
Behind Cluster
*CYL : Cylinder

2-6 2-6 2-6 2-6
2-6
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS3. 3.3. 3.
3.
WIRING HARNESS & CONNECT WIRING HARNESS & CONNECTWIRING HARNESS & CONNECT WIRING HARNESS & CONNECT
WIRING HARNESS & CONNECT
OR & GR OR & GROR & GR OR & GR
OR & GR
OUND LOCA OUND LOCAOUND LOCA OUND LOCA
OUND LOCA
TION TIONTION TION
TION1) 1)1) 1)
1)
W/H ENGINE ROOM W/H ENGINE ROOMW/H ENGINE ROOM W/H ENGINE ROOM
W/H ENGINE ROOM
1. Starting motor
2. G102
3. -
4. Compressor
5. Wheel speed sensor(FRT LH)
6. Starting motor "ST" terminal connector
7. Canister purge valve (Gasoline E/G)
8. Pre-heating time control unit (Diesel E/G)
9. C109 (Diesel E/G)
10. J102
11. J101
12. G101
13. Turn signal & position lamp(FRT LH)
14. Fog lamp(FRT LH)
15. Head lamp(FRT LH)
16. HLLD (FRT LH)
17. Hood switch
18. Thermo switch (Diesel E/G)
19. LH horn
20. Condenser fan motor-Non A/conditioner
21. Condenser fan motor(LH)
22. Resistor
23. RH horn
24. Fog lamp(FRT RH)
25. Condenser fan motor(RH)
26. Head lamp(FRT RH)
27. HLLD (FRT RH)
28. Turn signal & position lamp(FRT RH)
29. G103
30. C110 (Diesel E/G)
31. Alternator B+ (Diesel E/G)
32. J104
33. J103
34. C110 (Gasoline E/G)
35. Alternator B+ (Gasoline E/G)
36. -
37. C111
38. Wheel speed sensor(FRT RH)
39. Dual pressure switch
40. Washer motor
41. ADD (FRT RH)
42. C112
43. C113
FUSE &RELAY BOX
42
43
41
40
393435
37303138
2928
25
26
24
23
2221201918
17
1516
13
12111089
7
6
5
4321
14
27
3233

5-16 5-16 5-16 5-16
5-16
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
a. a.a. a.
a.
CONNECTOR INFORMATION CONNECTOR INFORMATIONCONNECTOR INFORMATION CONNECTOR INFORMATION
CONNECTOR INFORMATION
b. b.b. b.
b.
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONCONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
3. 3.3. 3.
3.
PRE-HEA PRE-HEAPRE-HEA PRE-HEA
PRE-HEA
TING SYSTEM TING SYSTEMTING SYSTEM TING SYSTEM
TING SYSTEM
PRE-HEATING TIME CONTROL UNIT
CLUSTER "B" CLUSTER "A"
CLUSTER "C" CLUSTER "D"
C110 (BLACK)
C103 (22Pin, White)
C107 (20Pin, White)
C110 (4Pin, Black)
J202
G102
G201CONNECTOR(NUMBER) CONNECTOR(NUMBER)CONNECTOR(NUMBER) CONNECTOR(NUMBER)
CONNECTOR(NUMBER)
CONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESSCONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESS
CONNECTING. WIRING HARNESS
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Engine Room
W/H Engine Room - W/H Alternator
W/H Main
Battery
W/H Main
CONNECTOR POSITION CONNECTOR POSITIONCONNECTOR POSITION CONNECTOR POSITION
CONNECTOR POSITION
Engine Room Fuse Box
Engine Room Fuse Box
Below Air Cleaner
Behind Cluster
Center Engine Block
Upper Front Left Leg Room

5-22 5-22 5-22 5-22
5-22
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
b. b.b. b.
b.
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONCONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONTHROTTILE
MOTOR &
SENSOR
ECM
123
456
2167
5348
OVPR CRANK SHAFT
POSITION
SENSORACCELERATION
PEDAL SENSOR
5. 5.5. 5.
5.
ECM (ELECTRONIC CONTROL MODULE) : E23 MSE ECM (ELECTRONIC CONTROL MODULE) : E23 MSEECM (ELECTRONIC CONTROL MODULE) : E23 MSE ECM (ELECTRONIC CONTROL MODULE) : E23 MSE
ECM (ELECTRONIC CONTROL MODULE) : E23 MSE1) 1)1) 1)
1)
SENSOR (CRANK SHAFT POSITION, ACCELERATION PEDAL), THROTTLE SENSOR (CRANK SHAFT POSITION, ACCELERATION PEDAL), THROTTLESENSOR (CRANK SHAFT POSITION, ACCELERATION PEDAL), THROTTLE SENSOR (CRANK SHAFT POSITION, ACCELERATION PEDAL), THROTTLE
SENSOR (CRANK SHAFT POSITION, ACCELERATION PEDAL), THROTTLE
MOTOR & SENSOR, IGNITION COIL & SPARK PLUG MOTOR & SENSOR, IGNITION COIL & SPARK PLUGMOTOR & SENSOR, IGNITION COIL & SPARK PLUG MOTOR & SENSOR, IGNITION COIL & SPARK PLUG
MOTOR & SENSOR, IGNITION COIL & SPARK PLUG
a. a.a. a.
a.
CONNECTOR INFORMATION CONNECTOR INFORMATIONCONNECTOR INFORMATION CONNECTOR INFORMATION
CONNECTOR INFORMATION
C114 (GRAY) IGNITION COIL
C206 (BLACK)
C115 (BLACK)
C102 (4Pin, Colorless)
C104 (8Pin, Colorless)
C114 (6Pin, Gray)
C115 (2Pin, Black)
C206 (6Pin, Black)
J108
G302CONNECTOR(NUMBER) CONNECTOR(NUMBER)CONNECTOR(NUMBER) CONNECTOR(NUMBER)
CONNECTOR(NUMBER)
CONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESSCONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESS
CONNECTING. WIRING HARNESS
CONNECTOR POSITION CONNECTOR POSITIONCONNECTOR POSITION CONNECTOR POSITION
CONNECTOR POSITION
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
W/H Engine Control - W/H ECM Main
W/H Engine Control - W/H ECM Main
W/H Main - W/H ECM Main
W/H Engine Control
W/H MainEngine Room Fuse Box
Engine Room Fuse Box
Behind Hydraulic Unit
Behind Hydraulic Unit
Lower "A" Piller (Upper ECM)
Upper Injecter #4 (4CYL) or #6 (6CYL)
Below Center Console

5-24 5-24 5-24 5-24
5-24
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS2) 2)2) 2)
2)
INJECTOR, FUEL PUMP RELAY, FUEL PUMP, IMMOBILIZER INJECTOR, FUEL PUMP RELAY, FUEL PUMP, IMMOBILIZERINJECTOR, FUEL PUMP RELAY, FUEL PUMP, IMMOBILIZER INJECTOR, FUEL PUMP RELAY, FUEL PUMP, IMMOBILIZER
INJECTOR, FUEL PUMP RELAY, FUEL PUMP, IMMOBILIZER
(1) W/O EURO III (1) W/O EURO III(1) W/O EURO III (1) W/O EURO III
(1) W/O EURO III
b. b.b. b.
b.
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONCONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
IMMOBILIZER
ANTENNA
ECM
OVPR
INJECTOR
a. a.a. a.
a.
CONNECTOR INFORMATION CONNECTOR INFORMATIONCONNECTOR INFORMATION CONNECTOR INFORMATION
CONNECTOR INFORMATION
C114 (GRAY) FUEL PUMP
C206 (BLACK)
C115 (BLACK)
C303 (BLACK)
C102 (4Pin, Colorless)
C104 (8Pin, Colorless)
C114 (6Pin, Gray)
C115 (40Pin, Black)
C206 (6Pin, Black)
C303 (4Pin, Black)
J107
J205
G201
G205
G302CONNECTOR(NUMBER) CONNECTOR(NUMBER)CONNECTOR(NUMBER) CONNECTOR(NUMBER)
CONNECTOR(NUMBER)
CONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESSCONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESS
CONNECTING. WIRING HARNESS
CONNECTOR POSITION CONNECTOR POSITIONCONNECTOR POSITION CONNECTOR POSITION
CONNECTOR POSITION
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
W/H Engine Control - W/H ECM Main
W/H Engine Control - W/H ECM Main
W/H Main - W/H ECM Main
W/H Main - W/H Fuel Pump
W/H Engine Control
W/H Main
W/H Main
W/H Main
W/H MainEngine Room Fuse Box
Engine Room Fuse Box
Behind Hydraulic Unit
Behind Hydraulic Unit
Lower "A" Piller (Upper ECM)
Upper Transfer Case
Next to Yellow Label
Behind Front Right Kick Panel
Upper Front Left Leg Room
Center "A" Piller Front Right
Below Center Console

5-26 5-26 5-26 5-26
5-26
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
(2) W/ EURO III (2) W/ EURO III(2) W/ EURO III (2) W/ EURO III
(2) W/ EURO III
b. b.b. b.
b.
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONCONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
IMMOBILIZER
ANTENNA
ECM
2167
5348
OVPR
INJECTOR
a. a.a. a.
a.
CONNECTOR INFORMATION CONNECTOR INFORMATIONCONNECTOR INFORMATION CONNECTOR INFORMATION
CONNECTOR INFORMATION
C114 (GRAY) FUEL PUMP
C206 (BLACK)
C115 (BLACK)
C303 (BLACK)
C102 (4Pin, Colorless)
C104 (8Pin, Colorless)
C114 (6Pin, Gray)
C115 (40Pin, Black)
C206 (6Pin, Black)
C303 (6Pin, Black)
J107
J205
G201
G205
G302CONNECTOR(NUMBER) CONNECTOR(NUMBER)CONNECTOR(NUMBER) CONNECTOR(NUMBER)
CONNECTOR(NUMBER)
CONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESSCONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESS
CONNECTING. WIRING HARNESS
CONNECTOR POSITION CONNECTOR POSITIONCONNECTOR POSITION CONNECTOR POSITION
CONNECTOR POSITION
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
W/H Engine Control - W/H ECM Main
W/H Engine Control - W/H ECM Main
W/H Main - W/H ECM Main
W/H Main - W/H Fuel Pump
W/H Engine Control
W/H Main
W/H Main
W/H Main
W/H MainEngine Room Fuse Box
Engine Room Fuse Box
Behind Hydraulic Unit
Behind Hydraulic Unit
Lower "A" Piller (Upper ECM)
Upper Transfer Case
Next to Yellow Label
Behind Front Right Kick Panel
Upper Front Left Leg Room
Center "A" Piller Front Right
Below Center Console

5-28 5-28 5-28 5-28
5-28
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
a. a.a. a.
a.
CONNECTOR INFORMATION CONNECTOR INFORMATIONCONNECTOR INFORMATION CONNECTOR INFORMATION
CONNECTOR INFORMATION
b. b.b. b.
b.
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONCONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
3) 3)3) 3)
3)
SENSOR (CAM SHAFT POSITION, AIR FLOW, O SENSOR (CAM SHAFT POSITION, AIR FLOW, OSENSOR (CAM SHAFT POSITION, AIR FLOW, O SENSOR (CAM SHAFT POSITION, AIR FLOW, O
SENSOR (CAM SHAFT POSITION, AIR FLOW, O
2 22 2
2), CAM SHAFT ACTUATOR ), CAM SHAFT ACTUATOR), CAM SHAFT ACTUATOR ), CAM SHAFT ACTUATOR
), CAM SHAFT ACTUATOR
(1) W/O EURO III (1) W/O EURO III(1) W/O EURO III (1) W/O EURO III
(1) W/O EURO III
AIR FLOW
SENSOR
ECM
OVPRCAM SHAFT
POSITION
C114 (GRAY) CAM SHAFT
ACTUATOR
C206 (BLACK)
C115 (BLACK)
O2 SENSOR
C102 (4Pin, Colorless)
C104 (8Pin, Colorless)
C114 (6Pin, Gray)
C115 (40Pin, Black)
C206 (6Pin, Black)
J106
J204
G302CONNECTOR(NUMBER) CONNECTOR(NUMBER)CONNECTOR(NUMBER) CONNECTOR(NUMBER)
CONNECTOR(NUMBER)
CONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESSCONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESS
CONNECTING. WIRING HARNESS
CONNECTOR POSITION CONNECTOR POSITIONCONNECTOR POSITION CONNECTOR POSITION
CONNECTOR POSITION
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
W/H Engine Control - W/H ECM Main
W/H Engine Control - W/H ECM Main
W/H Main - W/H ECM Main
W/H Engine Control
W/H Main
W/H MainEngine Room Fuse Box
Engine Room Fuse Box
Behind Hydraulic Unit
Behind Hydraulic Unit
Lower "A" Piller (Upper ECM)
Behind Hydrauilc Unit
Upper Blower Unit
Below Center Console

5-30 5-30 5-30 5-30
5-30
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
a. a.a. a.
a.
CONNECTOR INFORMATION CONNECTOR INFORMATIONCONNECTOR INFORMATION CONNECTOR INFORMATION
CONNECTOR INFORMATION
b. b.b. b.
b.
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONCONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
(2) W/ EURO III (2) W/ EURO III(2) W/ EURO III (2) W/ EURO III
(2) W/ EURO III
AIR FLOW
SENSOR
ECM
2167
5348
OVPRCAM SHAFT
POSITION
C114 (GRAY) CAM SHAFT
ACTUATOR
C206 (BLACK)
C115 (BLACK)
O2 SENSOR
C102 (4Pin, Colorless)
C104 (8Pin, Colorless)
C114 (6Pin, Gray)
C115 (40Pin, Black)
C206 (6Pin, Black)
J106
J204
G302CONNECTOR(NUMBER) CONNECTOR(NUMBER)CONNECTOR(NUMBER) CONNECTOR(NUMBER)
CONNECTOR(NUMBER)
CONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESSCONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESS
CONNECTING. WIRING HARNESS
CONNECTOR POSITION CONNECTOR POSITIONCONNECTOR POSITION CONNECTOR POSITION
CONNECTOR POSITION
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
W/H Engine Control - W/H ECM Main
W/H Engine Control - W/H ECM Main
W/H Main - W/H ECM Main
W/H Engine Control
W/H Main
W/H MainEngine Room Fuse Box
Engine Room Fuse Box
Behind Hydraulic Unit
Behind Hydraulic Unit
Lower "A" Piller (Upper ECM)
Behind Hydrauilc Unit
Upper Blower Unit
Below Center Console
MAP SENSOR

5-32 5-32 5-32 5-32
5-32
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
a. a.a. a.
a.
CONNECTOR INFORMATION CONNECTOR INFORMATIONCONNECTOR INFORMATION CONNECTOR INFORMATION
CONNECTOR INFORMATION
b. b.b. b.
b.
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONCONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
4) 4)4) 4)
4)
SENSOR (ENGINE TEMPERATURE, KNOCK), CANISTER PURGE VALVE, SENSOR (ENGINE TEMPERATURE, KNOCK), CANISTER PURGE VALVE,SENSOR (ENGINE TEMPERATURE, KNOCK), CANISTER PURGE VALVE, SENSOR (ENGINE TEMPERATURE, KNOCK), CANISTER PURGE VALVE,
SENSOR (ENGINE TEMPERATURE, KNOCK), CANISTER PURGE VALVE,
DIAGNOSIS DIAGNOSISDIAGNOSIS DIAGNOSIS
DIAGNOSIS
(1) W/O EURO III (1) W/O EURO III(1) W/O EURO III (1) W/O EURO III
(1) W/O EURO III
ECM
OVPR
CANISTOR
PURGE VALVE
KNOCK SENSOR DIAGNOSIS
CONNECTOR
C113 (BLACK)
C115 (BLACK)
ENGINE TEMP'
SENSOR
C101 (19Pin, White)
C102 (4Pin, Colorless)
C103 (22Pin, White)
C104 (8Pin, Colorless)
C113 (12Pin, Black)
C115 (40Pin, Black)
J205
G302CONNECTOR(NUMBER) CONNECTOR(NUMBER)CONNECTOR(NUMBER) CONNECTOR(NUMBER)
CONNECTOR(NUMBER)
CONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESSCONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESS
CONNECTING. WIRING HARNESS
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
W/H Engine Room - W/H Main
W/H Engine Control - W/H ECM Main
W/H Main
W/H Main
CONNECTOR POSITION CONNECTOR POSITIONCONNECTOR POSITION CONNECTOR POSITION
CONNECTOR POSITION
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Next to Hydraulic Unit
Behind Hydraulic Unit
Below Center Console