fuse box diagram SSANGYONG KORANDO 1997 Service Repair Manual
[x] Cancel search | Manufacturer: SSANGYONG, Model Year: 1997, Model line: KORANDO, Model: SSANGYONG KORANDO 1997Pages: 2053, PDF Size: 88.33 MB
Page 1652 of 2053
SECTION 9A
BODY WIRING SYSTEM
CAUTION: Disconnect the negative battery cable before removing or installing any electrical unit or when a
tool or equipment could easily come in contact with exposed electrical terminals. Disconnecting this cable
will help prevent personal injury and damage to the vehicle. The ignition must also be in LOCK unless
otherwise noted.
TABLE OF CONTENTS
General Description.............................................9A-2
Wire Color Chart..................................................9A-2
Engine Room Fuse & Relay Box......................... 9A-3
Usage of Fuse in Engine Room Fuse Box.............9A-5
Passenger Room Fuse Box..................................9A-6
Usage of Fuse in Engine Room Fuse Box.............9A-7
Schematic and Routing Diagrams.......................9A-8
Engine Room Fuse & Relay Circuit.......................9A-8
Wiring Harness & Connector &
Ground Location................................................. 9A-11
W/H Engine Room.............................................9A-11W/H Main..........................................................9A-12
W/H Main (Floor)............................................... 9A-14
W/H Roof..........................................................9A-15
W/H Seat Heater................................................9A-16
W/H Door..........................................................9A-17
W/H Tail Gate....................................................9A-18
W/H Air-Conditioner...........................................9A-19
W/H Engine Control (Gasoline)...........................9A-20
W/H Pre-Heating (Diesel)...................................9A-21
W/H Transmission..............................................9A-22
Page 1864 of 2053
HOW TO USE ELECTRICAL WIRING DIAGRAM HOW TO USE ELECTRICAL WIRING DIAGRAM HOW TO USE ELECTRICAL WIRING DIAGRAM HOW TO USE ELECTRICAL WIRING DIAGRAM
HOW TO USE ELECTRICAL WIRING DIAGRAM
1-3 1-31-3 1-3
1-3
Connector
Diode
Fuse in engine room fuse & relay box
Fuse in passenger room fuse box
GroundJoint - Inline wire connected pointSplice pack(Junction connector) C CC C
C
D DD D
D
Ef EfEf Ef
Ef
F FF F
F
G GG G
G
J JJ J
J
S SS S
S
2. 2.2. 2.
2.
CIRCUIT IDENTIFICA CIRCUIT IDENTIFICACIRCUIT IDENTIFICA CIRCUIT IDENTIFICA
CIRCUIT IDENTIFICA
TION SYMBOL TION SYMBOLTION SYMBOL TION SYMBOL
TION SYMBOL
3. 3.3. 3.
3.
FUNCTION OF PO FUNCTION OF POFUNCTION OF PO FUNCTION OF PO
FUNCTION OF PO
WER SUPPL WER SUPPLWER SUPPL WER SUPPL
WER SUPPL
Y LINE (NUMBER) Y LINE (NUMBER)Y LINE (NUMBER) Y LINE (NUMBER)
Y LINE (NUMBER)
IDENTIFICATION IDENTIFICATIONIDENTIFICATION IDENTIFICATION
IDENTIFICATION
SYMBOL SYMBOLSYMBOL SYMBOL
SYMBOLMEANING MEANINGMEANING MEANING
MEANINGPower supply No Power supply NoPower supply No Power supply No
Power supply No
Power supply condition Power supply conditionPower supply condition Power supply condition
Power supply condition
Battery Voltage(B+) supply in Ignition Switch "ON" and "ST" (IGN 1)Battery Voltage(B+) supply in Ignition Switch "ON" (IGN 2)
Battery Voltage(B+) supply in Ignition Switch "ON" and "ACC"
Battery Voltage(B+) supply directly regardless of Ignition Switch
Ground connected to battery(–)Battery Voltage(B+) supply in Head Lamp Switch 1st and 2nd step(Illumination circuit) 15 1515 15
15
15A 15A15A 15A
15A
15C 15C15C 15C
15C
30 3030 30
30
31 3131 31
31
58 5858 58
58
Abbreviation AbbreviationAbbreviation Abbreviation
Abbreviation
Color ColorColor Color
Color
Brown
Green
Violet
Pink
White
Orange
Light Green Br BrBr Br
Br
G GG G
G
V VV V
V
P PP P
P
W WW W
W
Or OrOr Or
Or
Lg LgLg Lg
Lg
Abbreviation AbbreviationAbbreviation Abbreviation
Abbreviation
Color ColorColor Color
Color
Sky Blue
Red
Blue
Yellow
Gray
Black Sb SbSb Sb
Sb
R RR R
R
L LL L
L
Y YY Y
Y
Gr GrGr Gr
Gr
B BB B
B
4. 4.4. 4.
4.
WIRING HARNESS COLOR IDENTIFICA WIRING HARNESS COLOR IDENTIFICAWIRING HARNESS COLOR IDENTIFICA WIRING HARNESS COLOR IDENTIFICA
WIRING HARNESS COLOR IDENTIFICA
TION TIONTION TION
TION5. 5.5. 5.
5.
HO HOHO HO
HO
W W W W
W
T TT T
T
O CHECK O CHECK O CHECK O CHECK
O CHECK
TERMINAL NUMBER OF CONNECT TERMINAL NUMBER OF CONNECTTERMINAL NUMBER OF CONNECT TERMINAL NUMBER OF CONNECT
TERMINAL NUMBER OF CONNECT
OR OROR OR
OR
- Terminal number is given based on Female Terminal Connector
ex) Terminal Number 4 of C901 connection
LockingTerminal Number 4
of total 6 pins
Male Connector
(W/H Fuel Tank)
4
C901
Female Connector
(W/H Floor) C901
W/H Floor132
465
Page 1865 of 2053
HOW TO USE ELECTRICAL WIRING DIAGRAM HOW TO USE ELECTRICAL WIRING DIAGRAM HOW TO USE ELECTRICAL WIRING DIAGRAM HOW TO USE ELECTRICAL WIRING DIAGRAM
HOW TO USE ELECTRICAL WIRING DIAGRAM
1-3 1-31-3 1-3
1-3
Connector
Diode
Fuse in engine room fuse & relay box
Fuse in passenger room fuse box
GroundJoint - Inline wire connected pointSplice pack(Junction connector) C CC C
C
D DD D
D
Ef EfEf Ef
Ef
F FF F
F
G GG G
G
J JJ J
J
S SS S
S
2. 2.2. 2.
2.
CIRCUIT IDENTIFICA CIRCUIT IDENTIFICACIRCUIT IDENTIFICA CIRCUIT IDENTIFICA
CIRCUIT IDENTIFICA
TION SYMBOL TION SYMBOLTION SYMBOL TION SYMBOL
TION SYMBOL
3. 3.3. 3.
3.
FUNCTION OF PO FUNCTION OF POFUNCTION OF PO FUNCTION OF PO
FUNCTION OF PO
WER SUPPL WER SUPPLWER SUPPL WER SUPPL
WER SUPPL
Y LINE (NUMBER) Y LINE (NUMBER)Y LINE (NUMBER) Y LINE (NUMBER)
Y LINE (NUMBER)
IDENTIFICATION IDENTIFICATIONIDENTIFICATION IDENTIFICATION
IDENTIFICATION
SYMBOL SYMBOLSYMBOL SYMBOL
SYMBOLMEANING MEANINGMEANING MEANING
MEANINGPower supply No Power supply NoPower supply No Power supply No
Power supply No
Power supply condition Power supply conditionPower supply condition Power supply condition
Power supply condition
Battery Voltage(B+) supply in Ignition Switch "ON" and "ST" (IGN 1)Battery Voltage(B+) supply in Ignition Switch "ON" (IGN 2)
Battery Voltage(B+) supply in Ignition Switch "ON" and "ACC"
Battery Voltage(B+) supply directly regardless of Ignition Switch
Ground connected to battery(–)Battery Voltage(B+) supply in Head Lamp Switch 1st and 2nd step(Illumination circuit) 15 1515 15
15
15A 15A15A 15A
15A
15C 15C15C 15C
15C
30 3030 30
30
31 3131 31
31
58 5858 58
58
Abbreviation AbbreviationAbbreviation Abbreviation
Abbreviation
Color ColorColor Color
Color
Brown
Green
Violet
Pink
White
Orange
Light Green Br BrBr Br
Br
G GG G
G
V VV V
V
P PP P
P
W WW W
W
Or OrOr Or
Or
Lg LgLg Lg
Lg
Abbreviation AbbreviationAbbreviation Abbreviation
Abbreviation
Color ColorColor Color
Color
Sky Blue
Red
Blue
Yellow
Gray
Black Sb SbSb Sb
Sb
R RR R
R
L LL L
L
Y YY Y
Y
Gr GrGr Gr
Gr
B BB B
B
4. 4.4. 4.
4.
WIRING HARNESS COLOR IDENTIFICA WIRING HARNESS COLOR IDENTIFICAWIRING HARNESS COLOR IDENTIFICA WIRING HARNESS COLOR IDENTIFICA
WIRING HARNESS COLOR IDENTIFICA
TION TIONTION TION
TION5. 5.5. 5.
5.
HO HOHO HO
HO
W W W W
W
T TT T
T
O CHECK O CHECK O CHECK O CHECK
O CHECK
TERMINAL NUMBER OF CONNECT TERMINAL NUMBER OF CONNECTTERMINAL NUMBER OF CONNECT TERMINAL NUMBER OF CONNECT
TERMINAL NUMBER OF CONNECT
OR OROR OR
OR
- Terminal number is given based on Female Terminal Connector
ex) Terminal Number 4 of C901 connection
LockingTerminal Number 4
of total 6 pins
Male Connector
(W/H Fuel Tank)
4
C901
Female Connector
(W/H Floor) C901
W/H Floor132
465
Page 1868 of 2053
2-4 2-4 2-4 2-4
2-4
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
Engine Room FuseBox - W/H Main
Engine Room Fuse Box - W/H Engine Room
Engine Room Fuse Box - W/H Engine Room
Engine Room Fuse Box - W/H Engine Room
Engine Room Fuse Box - W/H Engine Room
W/H Engine Room - W/H Pre - Heating
W/H Engine Room - W/H Alternator
W/H Engine Room - W/H Alternator
W/H Engine Room - W/H Wheel G. sensor
W/H Engine Room - W/H Main
W/H Engine Room - W/H Main
W/H Engine Control - W/H ECM Main
W/H Engine Control - W/H ECM Main
W/H Main - W/H Fuel Cut Solenoid
W/H Main - W/H Roof
W/H Main - W/H Air Bag
W/H Main - W/H Air Bag
W/H Main - W/H SDM
W/H Main - W/H Air Conditioner
W/H Main - W/H ECM Main
W/H Main - W/H Transmission
W/H Main - W/H Transmission
W/H Main - W/H Transmission
W/H Main - W/H Fuel Pump
W/H Main - W/H Fuel Pump
W/H Main - W/H Fuel Pump
W/H Main - W/H Seat Heater
W/H Main - W/H Main
W/H Main - W/H FRT LH Door
W/H FRT LH Door - W/H Speaker
W/H Main - W/H FRT RH Door
W/H FRT RH Door - W/H Speaker
G201W/H Main Upper Front Left Leg Room
G202W/H Main Upper Front Left Leg Room
G203W/H Main Left Upper Center Facia
G204W/H Main Left Lower Center Facia
G205W/H Main Center "A" Pillar Front Right
G301W/H Main Below Front Left seat
G302W/H Main Below Center Console
G303W/H Main Below Front Right seat
G401W/H Main Inside Lower Trim Rear Left Quater
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Bhind Battery
Below Air Cleaner
Below Air Cleaner
Upper Front Right Control Arm
Next to Hydraulic Unit
Next to Hydraulic Unit
Behind Hydraulic Unit
Behind Hydraulic Unit
Next to Engine Room Fuse Box
Inside Left Cluster
Above FRT LH Seat Under Cover
Above FRT LH Seat Under Cover
Lower Rear Center Facia
Upper Evaporator
Lower "A" Piller(Upper ECM)
Upper Transfer Case
Upper Transfer Case
Upper Transfer Case
Upper Transfer Case
Upper Transfer Case
Upper Transfer Case
Below FRT LH Seat
Below Center Console
Upper Fuse Box
(Passenger Room)
Inside FRT LH Door Trim
Behind Front Right Panel
Inside FRT RH Door Trim
2. 2.2. 2.
2.
CONNECT CONNECTCONNECT CONNECT
CONNECT
OR, OR,OR, OR,
OR,
GR GR GR GR
GR
OUND AND SPLICE PA OUND AND SPLICE PAOUND AND SPLICE PA OUND AND SPLICE PA
OUND AND SPLICE PA
CK INFORMA CK INFORMACK INFORMA CK INFORMA
CK INFORMA
TION TIONTION TION
TION1) 1)1) 1)
1)
CONNECTOR CONNECTORCONNECTOR CONNECTOR
CONNECTORConnector Number Connector NumberConnector Number Connector Number
Connector Number
(Pin Number, Color) (Pin Number, Color)(Pin Number, Color) (Pin Number, Color)
(Pin Number, Color)Connecting Connecting Connecting Connecting
Connecting
Wiring Harness Wiring HarnessWiring Harness Wiring Harness
Wiring Harness
Connector Position Connector PositionConnector Position Connector Position
Connector Position
C101 (19Pin, White)
C102 (4Pin, Colorless)
C103 (22Pin, White)
C104 (8Pin, Colorless)
C105 (10Pin, White)
C106 (3Pin, Black)
C107 (20Pin, White)
C108 (6Pin, Colorless)
C109 (1Pin, Black)
C110 (2Pin, Black)
C110 (4Pin, Black)
C111 (3Pin, Black)
C112 (6Pin, Black)
C113 (12Pin, Black)
C114 (6Pin, Gray)
C115 (40Pin, Black)
C116 (3Pin, Black)
C201 (8Pin, White)
C202 (4Pin, White)
C203 (2Pin, Black)
C204 (4Pin, Colorless)
C205 (17Pin, White)
C206 (6Pin, Black)
C301 (2Pin, Black)
C301 (16Pin, Black)
C302 (10Pin, Black)
C303 (3Pin, Black)
C303 (4Pin, Black)
C303 (6Pin, Black)
C304 (10Pin, White)
C305 (14Pin, White)
C351 (22Pin, White)
C352 (2Pin, Black)
C361 (22Pin, Blue)
C362 (2Pin, Black)
2) 2)2) 2)
2)
SPLICE PACK SPLICE PACKSPLICE PACK SPLICE PACK
SPLICE PACK
S201
S202
S203
S204
S205Splice Pack Position Splice Pack PositionSplice Pack Position Splice Pack Position
Splice Pack Position Wiring WiringWiring Wiring
Wiring
Harness HarnessHarness Harness
Harness Color ColorColor Color
Color Splice Pack Splice PackSplice Pack Splice Pack
Splice Pack
Number NumberNumber Number
Number
Colorless
Black
Colorless
Colorless
ColorlessW/H Main
W/H Main
W/H Main
W/H Main
W/H MainUpper Fuse Box(Passenger Room)
Behind Cluster
Behind 4WD Switch
Behind Audio
Behind Front Right Kick Panel
Remark RemarkRemark Remark
Remark
Diesel only
Gasoline
Diesel
Gasoline
Gasoline
Diesel
Gasoline
Manual T/M
Automatic T/M
Diesel
Diesel
Gasoline
GSL : EURO IIIBehind Left Tail Lamp
Behind Left Tail Lamp
Inside Rear Bumper
Inside Tail Gate
Connector Number Connector NumberConnector Number Connector Number
Connector Number
(Pin Number, Color) (Pin Number, Color)(Pin Number, Color) (Pin Number, Color)
(Pin Number, Color)Connecting Connecting Connecting Connecting
Connecting
Wiring Harness Wiring HarnessWiring Harness Wiring Harness
Wiring Harness
Connector Position Connector PositionConnector Position Connector Position
Connector Position
C401 (2Pin, Black)
C402 (12Pin, Black)
C403 (3Pin, Black)
C404 (2Pin, Black)W/H Tail Gate - W/H Main
W/H Tail Gate - W/H Main
W/H Rear Bumper - W/H Main
W/H Tail Gate - W/H HMSL
Remark RemarkRemark Remark
Remark
3) 3)3) 3)
3)
GROUND GROUNDGROUND GROUND
GROUND
G101
G102
G103Ground Position Ground PositionGround Position Ground Position
Ground Position
Wiring Harness Wiring HarnessWiring Harness Wiring Harness
Wiring Harness Number NumberNumber Number
Number
Ground GroundGround Ground
Ground
W/H Engine Room
Battery
W/H Engine RoomLeft Fender Next to Battery
Center Engine Block
Right Fender Engine Room
Pin PinPin Pin
Pin
Number NumberNumber Number
Number
8
20
14
14
8
Page 1870 of 2053
2-6 2-6 2-6 2-6
2-6
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS3. 3.3. 3.
3.
WIRING HARNESS & CONNECT WIRING HARNESS & CONNECTWIRING HARNESS & CONNECT WIRING HARNESS & CONNECT
WIRING HARNESS & CONNECT
OR & GR OR & GROR & GR OR & GR
OR & GR
OUND LOCA OUND LOCAOUND LOCA OUND LOCA
OUND LOCA
TION TIONTION TION
TION1) 1)1) 1)
1)
W/H ENGINE ROOM W/H ENGINE ROOMW/H ENGINE ROOM W/H ENGINE ROOM
W/H ENGINE ROOM
1. Starting motor
2. G102
3. -
4. Compressor
5. Wheel speed sensor(FRT LH)
6. Starting motor "ST" terminal connector
7. Canister purge valve (Gasoline E/G)
8. Pre-heating time control unit (Diesel E/G)
9. C109 (Diesel E/G)
10. J102
11. J101
12. G101
13. Turn signal & position lamp(FRT LH)
14. Fog lamp(FRT LH)
15. Head lamp(FRT LH)
16. HLLD (FRT LH)
17. Hood switch
18. Thermo switch (Diesel E/G)
19. LH horn
20. Condenser fan motor-Non A/conditioner
21. Condenser fan motor(LH)
22. Resistor
23. RH horn
24. Fog lamp(FRT RH)
25. Condenser fan motor(RH)
26. Head lamp(FRT RH)
27. HLLD (FRT RH)
28. Turn signal & position lamp(FRT RH)
29. G103
30. C110 (Diesel E/G)
31. Alternator B+ (Diesel E/G)
32. J104
33. J103
34. C110 (Gasoline E/G)
35. Alternator B+ (Gasoline E/G)
36. -
37. C111
38. Wheel speed sensor(FRT RH)
39. Dual pressure switch
40. Washer motor
41. ADD (FRT RH)
42. C112
43. C113
FUSE &RELAY BOX
42
43
41
40
393435
37303138
2928
25
26
24
23
2221201918
17
1516
13
12111089
7
6
5
4321
14
27
3233
Page 1871 of 2053
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
2-7 2-7 2-7 2-7
2-7
2) 2)2) 2)
2)
W/H MAIN W/H MAINW/H MAIN W/H MAIN
W/H MAIN• W/H MAIN
1. C351
2. S201
3. G201
4. G202
5. Auto down unit
6. HLLD switch
7. OSRV switch
8. Rear wiper & washer switch
8-1. DLC9. C201
10. Clutch switch "A"
11. Clutch switch "B" (Gasoline E/G)
12. Stop lamp switch
13. Dimmer & passing switch
14. Turn signal,FRT fog lamp & Light switch
15. Wiper switch
16. J201
17. C20218. Immobilizer antenna
19. Ignition switch
20. Cruise control switch
21. Key reminder switch
22. C203
23. Acceleration pedal sensor
24. Kick down switch
25. REKES
26. ADD' (LH)
27. Diagnosis connector
28. Brake fluid switch
29. Locking hud solenoid (TCCU)
30. C116
31. Cluster "D"
32. Cluster "C"
33. Cluster "B"
34. Cluster "A"
35. J202
36. J202
37. J203
38. S203
39. 4WD switch
40. Hazard switch
41. Defroster switch
42. -
43. Antenna feeder cable
44. S204
45. Audio
46. -
47. SDM
48. G204
49. C204
50. Chime Bell
51. Buzzer
52. Acceleration sensor
53. G203
54. Cigar lighter
55. Central door lock relay
56. BTSI solenoid
57. A/Tsocket
58. BTSI "P" position sw
59. Mode switch
60. Shift motor
61. Speed sensor & clutch coil
62. VSS
63. C301
64. C302
65. C30366. C304
67. TCM
68. TOD Resistor (Gasoline E/G)
69. G301
70. TOD or TCCU
71. FRT LH seat belt sw
72. Parking brake sw
73. W/D Burglar connector
74. Seat heater switch
75. STICS
76. G303
77. -
78. OVPR (Gasoline E/G)
79. C305
80. Seat belt sw (FRT RH)
81. EBCM (ADD)
82. G303
83. C205
84. Thermo amp
85. Passenger inflator
86. -
87. -
88. Front wiper motor
89. Siren
90. O2 sensor 1 / (Gasoline E/G)
91. EBCM (ABS) & Modulator (ABD)
92. J105
93. C113
94. C112
95. EGR solenoid (Diesel E/G)
96. C114 (Gasoline E/G)
97. C115 (Gasoline E/G)
98. J204 (Gasoline E/G)
99. S205
100.J205 (Gasoline E/G)
101.Antenna feeder cable
102.Auto antenna
103.C206
104.ECM (GSL) or Immobilizer unit (DSL)
105.EGR control unit (Diesel E/G)
106. G205
107.C361
108. O2 sensor 2 (Gasoline E/G)
FUSE
BOX
RELAY
BOX
FUSE &
RELAY BOX
A
1011
12131415171618192021222829
30
26
27
31323334
35
3637
38
394041
43
83888990
91
93
9495
9296
979899102
101100
106107
104105
103
108
84
85
44
8-1
4748
49
50
51
52
53
45
55
54565758
60616263
6465
66
67
68
71
72
73
74
7576
78
7980
8182
69
70
59
232425
13
4259678
Page 1883 of 2053
CONTENTS CONTENTSCONTENTS CONTENTS
CONTENTS
1. 1.1. 1.
1.
IGNITION SWITCH CIRCUIT IGNITION SWITCH CIRCUITIGNITION SWITCH CIRCUIT IGNITION SWITCH CIRCUIT
IGNITION SWITCH CIRCUIT
............................................................. .......................................................................................................................... .............................................................
.............................................................
3-2 3-2 3-2 3-2
3-2
2. 2.2. 2.
2.
30 30 30 30
30
TER B TER BTER B TER B
TER B
A AA A
A
T+ PO T+ POT+ PO T+ PO
T+ PO
WER SUPPL WER SUPPLWER SUPPL WER SUPPL
WER SUPPL
Y CIRCUIT Y CIRCUITY CIRCUIT Y CIRCUIT
Y CIRCUIT
(PASSENGER ROOM FUSE BOX) (PASSENGER ROOM FUSE BOX)(PASSENGER ROOM FUSE BOX) (PASSENGER ROOM FUSE BOX)
(PASSENGER ROOM FUSE BOX)
................................................... ...................................................................................................... ...................................................
...................................................
3-2 3-23-2 3-2
3-2
3. 3.3. 3.
3.
15A IGN 2 , 15A IGN 2 ,15A IGN 2 , 15A IGN 2 ,
15A IGN 2 ,
15C A 15C A 15C A 15C A
15C A
CC PO CC POCC PO CC PO
CC PO
WER SUPPL WER SUPPLWER SUPPL WER SUPPL
WER SUPPL
Y CIRCUIT Y CIRCUITY CIRCUIT Y CIRCUIT
Y CIRCUIT
(PASSENGER ROOM FUSE BOX) (PASSENGER ROOM FUSE BOX)(PASSENGER ROOM FUSE BOX) (PASSENGER ROOM FUSE BOX)
(PASSENGER ROOM FUSE BOX)
................................................... ...................................................................................................... ...................................................
...................................................
3-4 3-43-4 3-4
3-4
4. 4.4. 4.
4.
15 15 15 15
15
TER IGN 1 PO TER IGN 1 POTER IGN 1 PO TER IGN 1 PO
TER IGN 1 PO
WER SUPPL WER SUPPLWER SUPPL WER SUPPL
WER SUPPL
Y CIRCUIT Y CIRCUITY CIRCUIT Y CIRCUIT
Y CIRCUIT
(PASSENGER ROOM FUSE BOX) (PASSENGER ROOM FUSE BOX)(PASSENGER ROOM FUSE BOX) (PASSENGER ROOM FUSE BOX)
(PASSENGER ROOM FUSE BOX)
................................................... ...................................................................................................... ...................................................
...................................................
3-4 3-43-4 3-4
3-4
5. 5.5. 5.
5.
ENGINE R ENGINE RENGINE R ENGINE R
ENGINE R
OOM FUSE & RELA OOM FUSE & RELAOOM FUSE & RELA OOM FUSE & RELA
OOM FUSE & RELA
Y CIRCUIT Y CIRCUITY CIRCUIT Y CIRCUIT
Y CIRCUIT
...................................... ............................................................................ ......................................
......................................
3-5 3-53-5 3-5
3-5
SECTION 3 SECTION 3SECTION 3 SECTION 3
SECTION 3
WIRING DIAGRAM FOR POWER SUPPLIES WIRING DIAGRAM FOR POWER SUPPLIESWIRING DIAGRAM FOR POWER SUPPLIES WIRING DIAGRAM FOR POWER SUPPLIES
WIRING DIAGRAM FOR POWER SUPPLIES
Page 1886 of 2053
3-4 3-4 3-4 3-4
3-4
WIRING DIAGRAM FOR POWER SUPPLIES WIRING DIAGRAM FOR POWER SUPPLIESWIRING DIAGRAM FOR POWER SUPPLIES WIRING DIAGRAM FOR POWER SUPPLIES
WIRING DIAGRAM FOR POWER SUPPLIES
4. 4.4. 4.
4.
15T 15T15T 15T
15T
er erer er
er
IGN 1 PO IGN 1 PO IGN 1 PO IGN 1 PO
IGN 1 PO
WER SUPPL WER SUPPLWER SUPPL WER SUPPL
WER SUPPL
Y CIRCUIT Y CIRCUITY CIRCUIT Y CIRCUIT
Y CIRCUIT
(PASSENGER ROOM FUSE BOX) (PASSENGER ROOM FUSE BOX)(PASSENGER ROOM FUSE BOX) (PASSENGER ROOM FUSE BOX)
(PASSENGER ROOM FUSE BOX) 3. 3.3. 3.
3.
15A IGN 2 , 15A IGN 2 ,15A IGN 2 , 15A IGN 2 ,
15A IGN 2 ,
15C A 15C A 15C A 15C A
15C A
CC PO CC POCC PO CC PO
CC PO
WER SUPPL WER SUPPLWER SUPPL WER SUPPL
WER SUPPL
Y CIRCUIT Y CIRCUITY CIRCUIT Y CIRCUIT
Y CIRCUIT
(PASSENGER ROOM FUSE BOX) (PASSENGER ROOM FUSE BOX)(PASSENGER ROOM FUSE BOX) (PASSENGER ROOM FUSE BOX)
(PASSENGER ROOM FUSE BOX)
Page 1900 of 2053
5-6 5-6 5-6 5-6
5-6
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
C103 (22Pin, White)
C104 (8Pin, Colorless)
C107 (20Pin, White)
C108 (6Pin, Colorless)
C110 (4Pin, Black)
C113 (12Pin,Black)
C301 (16Pin, Black)
S202 (20Pin,Black)
G102
G201
1. 1.1. 1.
1.
ST STST ST
ST
AR ARAR AR
AR
TING & CHARGING SYSTEM TING & CHARGING SYSTEMTING & CHARGING SYSTEM TING & CHARGING SYSTEM
TING & CHARGING SYSTEM1) 1)1) 1)
1)
DIESEL DIESELDIESEL DIESEL
DIESEL
b. b.b. b.
b.
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONCONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION a. a.a. a.
a.
CONNECTOR INFORMATION CONNECTOR INFORMATIONCONNECTOR INFORMATION CONNECTOR INFORMATION
CONNECTOR INFORMATION
CLUTCH SW "A"
CLUSTER "B" IGNITION SW
INHIBITOR SWC110 (BLACK)
S202 (BLACK) CLUSTER "A"
CLUSTER "C" CLUSTER "D"
ALTERNATOR
C301 (BLACK)
C113 (BLACK)
CONNECTOR(NUMBER) CONNECTOR(NUMBER)CONNECTOR(NUMBER) CONNECTOR(NUMBER)
CONNECTOR(NUMBER)
CONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESSCONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESS
CONNECTING. WIRING HARNESS
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Engine Room
Engine Room Fuse Box - W/H Engine Room
W/H Engine Room - W/H Alternator
W/H Engine Room - W/H Main
W/H Main - W/H Transmission
W/H Main
Battery
W/H Main
CONNECTOR POSITION CONNECTOR POSITIONCONNECTOR POSITION CONNECTOR POSITION
CONNECTOR POSITION
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Below Air Cleaner
Next to Hydraulic Unit
Upper Transfer Case
Behind Cluster
Center Engine Block
Upper Front Left Leg Room
Page 1902 of 2053
5-8 5-8 5-8 5-8
5-8
ELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMSELECTRICAL WIRING DIAGRAMS ELECTRICAL WIRING DIAGRAMS
ELECTRICAL WIRING DIAGRAMS
a. a.a. a.
a.
CONNECTOR INFORMATION CONNECTOR INFORMATIONCONNECTOR INFORMATION CONNECTOR INFORMATION
CONNECTOR INFORMATION
b. b.b. b.
b.
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITIONCONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
2) 2)2) 2)
2)
GASOLINE GASOLINEGASOLINE GASOLINE
GASOLINE
CLUTCH SW "A"
CLUSTER "B" IGNITION SWINHIBITOR SW
S202 (BLACK) CLUSTER "A"
CLUSTER "C" CLUSTER "D"
C301 (BLACK)
C110 (BLACK)
C103 (22Pin, White)
C104 (8Pin, Colorless)
C107 (20Pin, White)
C108 (6Pin, Colorless)
C110 (2Pin, Black)
C301 (16Pin, Black)
S202 (20Pin,Black)
G102
G201CONNECTOR(NUMBER) CONNECTOR(NUMBER)CONNECTOR(NUMBER) CONNECTOR(NUMBER)
CONNECTOR(NUMBER)
CONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESSCONNECTING. WIRING HARNESS CONNECTING. WIRING HARNESS
CONNECTING. WIRING HARNESS
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Main
Engine Room Fuse Box - W/H Engine Room
Engine Room Fuse Box - W/H Engine Room
W/H Engine Room - W/H Alternator
W/H Main - W/H Transmission
W/H Main
Battery
W/H Main
CONNECTOR POSITION CONNECTOR POSITIONCONNECTOR POSITION CONNECTOR POSITION
CONNECTOR POSITION
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Engine Room Fuse Box
Below Air Cleaner
Upper Transfer Case
Behind Cluster
Center Engine Block
Upper Front Left Leg Room